load capacity VOLKSWAGEN GOLF 1993 1H / 3.G Owners Manual

Downloaded from www.Manualslib.com manuals search engine CONTROLS AND EQUIPMENT

Cigarette lighter
The cigarette lighter is switched on by
pushing in the element. When the heating
element glows, the lighter springs out auto­
matically -pull it out immediately and use it.
The
cigarette lighter socket can be
used for other electrical accessories with a
capacity of up to 120 watts. However, when the engine is not running this will discharge
the battery. For further information see
chapter Accessories on page
111 .
•
Attention • Be careful when using the cigarette lighter! Careless or uncontrolled use of the cigarette lighter can cause burns. The cigarette lighter and the socket also work when the igni­tion is switched off and the key removed. For this reason children should never be left in the vehicle on their own.
Ashtray
Front
To empty: Open ashtray, press but­
ton
on ashtray and pull
ashtray out.
To replace Push ashtray into the
guides.
Attention Never use the ashtrays as paper containers. Danger of fire!
Rear
To empty
To replace: O
pen ashtra y and pull it
out ver ticall y u
pwards
P re ss ashtray
down ve rti ­cally and close flap.
Attention Never use the ashtrays as pape r containers. Danger of fire!
68

Downloaded from www.Manualslib.com manuals search engine GENERAL MAINTENANCE

• When disconnecting the bat­
tery from th e vehic le e lectrical
system first disconnect the nega­
tive cable and then the positive
cable.
The battery must not b e discon­
nected with th e engine ru nning,
as this will damage t he e lectrica l
system (e lectro n ic components).

• When reconnecting t h e bat­
tery connect the positive cable
first and then the negative cable.
The connect ing cables must on
no account interchang ed -can
cause wiring to burn out.

In order to protect the c asing from UV radiation, do not expose battery to direct sunlight.
Checking acid level
In norma l operating conditions the ba ttery re quires hardly any maintenance . At 111(;)11 am bient tem peratu res Ilowever It I S advIs­
a b le to check th e acid le ve l a t r egula r inter ­als. It shou ld always be between the M IN
a nd MAX marks on th e batter y I
f th e ac
id leve l drops below the MIN mark, the aff ecte d c ells must be topped -up to the
MAX mark W ith dis tille d wa ter.
It
is recommen ded that the acid level is checked and correcte d by a Volkswag en dea ler.
Winter driving
W inte r wea ther is part icu larly hard on the
battery. Furt h er more at low temperatures it has only a par t of th e capacity it has at nor ­
ma l temperatures . We reco mmend there­
for e th at
the bat te ry sho uld be c h ecked pre­
f erably by a Volkswage1l dea le r before the onset of cold weat her an d charge d if
necessary
I f the vehicle is not driven for sev­e ral weeks when te m peratures are very low, the battery should be taken out and stored in a frost-free room, s o tha t it cannot freeze up and become damaged.
To ake battery out, first d isconnect the two cables an d th en remov e retainer.
Charging battery
W hen charg ing with a lo w curren t (e.g. with a smal l char ger) the battery cables need not
no rmally b e taken off. The instructions from the charger manufactu re r must however be
noted.
Bef ore
Quick charging, that is charging
wi th a high current, both battery cables
must b e disconnec ted .
T
he f o llowin g inf ormation must be noted:
• Whe n charging the
battery do not re­
move caps.
• A discha rged battery
can freeze at -10°e. It is essential to thaw out a frozen battery before it is given a quick charge otherwise it may ex­plode!
• The mains cable of the charger should
n ot be connec ted unti l afte r the clips of the charger have been prop erly secured to th e
battery terminals Red =pos itive
Black = negative
•
Recon nect cables correct ly after ch arg­ing battery.
101

Downloaded from www.Manualslib.com manuals search engine GENERAL MAINTENANCE
Spark plugs V-belts
Renewing a battery
If the battery has to be renewed , the new battery must have the same capacity, volt­
age (12 V olts). current strength and shape
and a cap sealing arrangement. Volkswagen
dealers have a range of suitable batteries .
&-. Because of the problem of dis­~posing of the old battery the re­newal ofa battery should preferably be done by a Vo/kswagen dealer. Batteries contain, amongst other things, sulphuric acid and lead and must on no account be put with nor­mal household waste.
The spark plugs are rene w ed during the
Volkswagen Inspection Service
If the spark plugs have to be rene w
ed be­
t w een the Inspection Services, the fOllow­
ing should be noted :
• Spark plugs and ignition system are
matched to the engine and
as such contrib­
ute to reducing the levels of exhaust pollu­
tants. To avoid faulty operation, engine
damage and even the w ithdrawal of the
type approval due
to ex cessive emissions
v alues or non -suppressed spark plugs, only
the Genuine Volks wagen spark plugs for the
engine concerned should be used. Import­
ant, am ong other
thing
'S, are the number of
electrodes , the heat value and if necessary
the radio suppression .
• The plugs may
be, for technical reasons,
changed at short notice. It is therefore ad­visable to obtain plugs only from Volks­
w agen dealers -they have the latest in­
formation •
The V-belts are among the most s
e­verely stressed parts of a vehicle. The belts
must therefore be subjected to very high
quality requirements.
• When renewing a belt it
is not sufficient to use just any belt of the same size. For
safety reasons only the special Genuine
V olkswagen belt for the vehicle concerned
should be used .
• The V-belts may
be, for technical rea­
sons, changed at short notice . It is therefore
advisable to obtain V-belts only from Volks­
wagen dealers and to
hav e them changed
there -they have the latest information .
•
On some engines durable ribbed belts are used, which are checked and if necess­
ary tensioned during an Inspection Service
(every 60, 000 km/40,OOO miles).
102

Downloaded from www.Manualslib.com manuals search engine ----DO-lT-YOURSELF
Emergency starting
A -Flat battery
B - Boosting battery

The battery
is located in the engine com­

partment.

I f the engine will not start because the bat­
tery is flat.
jumper cables can be con­
nected to the battery of another vehicle to
start the engine . The follow ing points
should be noted
• Both batteries
must be of the 12 Volt var­
iety and the capacity (Ah) of the booster bat­
tery must be app roximately the same as that of the flat battery .
• The jumper cables must be heavy
enough to carry the load. Note cable manu­
facture r's data. •
Only use Jumper cabl
es with insulated
clips.
• A flat battery
can freeze at -1 Ooe and if
a battery is frozen it must be thawed out be­
fore connecting Jumper cables, o th erwise it
could explode.
• There
must be no contact between the
vehic les, other wise current can flo w as soon as the plus terminal s are connected .
• The flat battery
must be properly con­
nected to the electrical system.
• The engine of the boosting vehicle
must be running.
•
The jumper cables must only be con­
nected as follo w s: 1. One end of (+) cable (usually red) to the (+) term inal of the flat battery.
2 . Other end of the red cable to the (+l ter­
minal
of boosting battery.
3. One end of H cable (usually black) to the
H terminal of boosting battery.
4. Other end of blac k cable (X) to a solid
metal part bolted to th e block or to cylinder
block itself.
Do not connect the cable to the flat battery
m in us terminal. The sparks could Ignite the
exp losive gas flowing out of the battery
Attention • The non-insulated parts of the cable clips must not touch one another on any account. Further­more the jumper cable attached to the battery positive terminal must not come into contact with electrically conductive vehicle parts -Short circuit danger! • Route the jumper cables so that they cannot come into con­tact with rotating parts in the en­gine compartment. • Do not stand with your face over the battery -danger of acid burns! • Keep sources of igni~ion(naked flames, burning cIga­rettes etc.) well away from the battery -Explosion danger!
• Start the engine as described in the
"Starting engine" section.
• If the engine does not start at once, stop
using starter after
10 seconds, wait about
half a minute and then try aga in.
• With engine running, disconnect cables in reverse sequence .
1 28

Downloaded from www.Manualslib.com manuals search engine ALPHABETICAL INDEX

A Acceleration figu res . . .... . . .

Accessories

Adjusting washer jets

A ir conditioner
.. ....... .

Airbag

Alloy w heels

Analog clock
..
Anti-freeze.

Anti-dazzle inside mirror

Anti-knock properties of the fuel

Anti-locking brake system
(ABS)
Anti-theft warning system

Aq uaplaning .... ..... .

Ashtray .......... . .
ATF.
Automatic gearbox.

Automatic tra ns mission fluid

Automati c was h plants .... . . . .

Axle weights. . ....... .

B Battery . . . ....... . . . . .

Belt height adjustment ... .. . . .

Blower ...
Bonnet.
B rake fluid.
Brake pad wear indicat or

Brake servo .

Brake system

Brake warni
ng I'amp .

B rakes

B ulb changing.

Burglar alarm .
1
36

111
103
59
18
88
41
97

12

82
76
8
106
68

96
32

96

85

143

100
15

56, 59
90

99

48
75
99
48
75

121
8

C Capacities .. . . .... . 146
Care 85
Care of body . . . . . . . . . . . . . 85
Care of vehicle 85

Cavity preservation 89

Central locking system 7

Cetane Number . . . . . . . . . . 84

Changing bulb s . . . . . . . . . . 1
21
Changing wheels 116
Chassis number 147
Child safety . 21
Child seats ........ . . . . . . . 21
Chi ld-proo f catch ......... 9

Cigarette lig hter 68

Cigarette lig h ter socket. 68
Cleaning and anti -corrosion treatment of

engine compartment . . . . . . . . 88

Clean ing veh ic le . . . . . . . . . . 85

C limat ronic 62
Clock .. 41
Cockpit . . . . . . . . . . 4

Cold starting aid 37
Compression rat io 134

Cons umption figures. . 137

Coolant additive 97
Coolant level 46, 97
Coolant tempera ture gauge 45

Cool ing system . . . . . . . . . . 97
Cruise control system 54

Cubic capacity 134

D Dash panel 4
Defrosting windows 57,60,62
Diesel fuel 84
Dimensions. 145

Dip lever 53

Direction indicators 48, 53
Do-it-yourself ......... .
112

Door locks . ..... . . 9
Doors . .. 9
Driver's seat
25

Driving abroad .... . 110
Driving economically 72
Driving tips ...... . ... ..... ..... . 71
Driving with four-wheel drive 79
Dust and pollen filter ...... . .. . . 104

1 48

Downloaded from www.Manualslib.com manuals search engine ALPHABETICAL INDEX

E F H Electri
c windows 10.52 Fan . . .. 98 Hand brake 31 Emergency li ght s 51 Filling the tank ...... . . 81 Head restraints .. ............... 24
E me rgency startin g 128
Filter preheating .......... . . 84 Headlight flasher ........ .. . 53 Engine First
aid kit ........... . . . 112 Headlight range control ........... 51 -Code letters 147
Folding/sliding cover 30 Headlig ht washer system
55
- Data 134 Foot mats ............ . 31 Heated rear window 52 -Number 147 Four wheel drive 79 Heating
56 -Oil .. 92 Fresh air filte r ........ . 104 Height adjustable seat. 26
- Oil capacity. 146 Fresh air venti lation
58, 61 Height adjustable steering wheel
35
- Oil change intervals 2.95 Front fogligh ts ........... . .
50 High beams. ........... 48
- Oil consumption
94 Front
seats
25 Horn
4
- Oil level
..... . . .. . . 94 Fuel ........... . . . 82
- Oil pressure 47 -Additives. 83, 84
- Starting/stopping 36 -
Consumption ........ . 72,137 Engine compartment. 91 -Filter preh eating . 84 Identification
data
147
E ngine number. 147 -Gauge
45 Idling speed boost ......... 37 ~Environment -Saving
72 Ignition lock. . . . . . . . . 35
-Battery. . . . . . . . . . . . .
. . . . . . . .. 102 Fuel gauge Fuses. 45
119 Increasing
luggage space
I nertia reel belts ......... 27 14 -Brake fluid. . . . . . . . . . . . . . . . . . .. 99 InSide mirror . . . . . . . . . . . . 12 -Care ofcar. . . . . . . . . . . . . . . . . . .. -Coolant ...................... 85 98 G Inspection intervals
Instruments 95
39
-Driving with low emissions and n
oise......... ............... 72 Gear change marks
Gear stick ....... . . 39, 71 31 Interior
lights 67
-Engine oil .................... -En vironmentally conscious drivin g . . . . . . . . . . . . . . . . . . . . . .. - Exhaust gas system .... . .. . ...
95
72
74
Glove box light .......... .
Glow plugs
Gross vehicle
weight
67,126 37
143
- Filling th e tank ................ 81 -~~.......................... ~ -Maintenance. . . . . . . . . . . . . . . . . .. 2 - Old oil . ....................... 95 - Old tyres .................... 107 - Tyre pressure ................ 105 - Tvres .... . .. . . ............... 107 - Unfeade d fuel. . . . . . . . . . . . . . . .. 83 - Washing th e vehicle ........... 86 Exha..JS. gas system 74
149

Downloaded from www.Manualslib.com manuals search engine ALPHABETICAL INDEX
J Jack 11 4, 117 Jack sockets . 117
Jumper cable 128
K Keys. 6 Kick-down
33
L Lap belt 16
Leather care ....... .
87
L ifting vehicle . . .......... .
13 1
Lighting ....... .
50
Lighting sw itch .
50
Locks . .
... 9 Lubricant add iti ves .
96
Lubricants .
92
Luggage boot
light
.. 67, 126
Luggage compartment 28
Luggage compartment cover . 30
Luggage compartment light 67, 126
Lumbar support 26
M M + S tyres 109,
139
Maintenance .. 2 M ake-up mirror . . 66 M anual gearbo x 31 Masking headlights 110 Max
imu m speed ..... .. .. . 136 Mesh partition 29
Mileage recorder 39
Mirror heating
..... ... . . . 12
Mirrors . 12
Mobile
telephones. ... . . .. .. 111 Modifications 111 Multi function indicator ......... .
42
150
N Number plate lighting
125
o Octane number .. ... .. . .
82
Oil capacity ...... .. . .
146 011 change intervals
95
Oil change intervals 2 Oil consumption .
94
Oil dipstick
- Automatic gearbox
..... ... . 96 -Engine . . .. ..... . 94 Oil pressure ......... .
47
O il spec ifications
92
O il
s. . .. .... . .
92 Output. . ... . . . .... .. .... .
134
Outside mirrors
12
P Paint care ..... . . .
86
Paint number 147
Par
king. 74 Par . ing lights 53 Par ing lock .. . 32
Pedals 31 Performance .... . ... .... ........ . 136
Petro l,
- Quality .
82
Petrol additives . .
...... .
. 83
Pollen filter . . . . 104
Power assisted steering 96
R Radio ..... 127
Reading light . . . . . . . . . . . . . . . . . . . . 67
Rear foglight . . . . . . . . . . . 50
Rear lights. . . . . . . . . . . . . . . . . . 1 25
Rear seat . 27
Rear
window w ash/wipe 55 Releas ing tank flap . 82
Renewa l of parts ........ .. . ... 111 Restraint systems 13, 21
Rev counter . .... ...... 41 Reverse gear . . . . . . . . . . 32 Reversing lights . . .. 3 1
Roof load . . . . . . . . . . . . .. 70 , 143
Roof load carrying system 70
Roof rack . 70
Roof
ra i ling 70
Running in . . . . . . . . . . . . . . . .. 71