lights VOLKSWAGEN GOLF PLUS 2012 Owner's Guide

At the gas station
Refueling
In this section yo u'll fin d information on the lowing:
Indicator lights and gouge . . . . . . . . . . . . . . . . 235
Refueling . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . 237
Refueling checklist . . . . . . . . . . . . . . . . . . . . . . . . . 238
The fue l filler flap is located on the rear ri ght side of th e ve hicle.
More info rmation:
Fuel page 239
Preparations for work ing in the engine page 242
Improp er refuel in g or ha ndl in g of fue l can ca use fire, explosion, an d severe burns.
Always m ake sure that the fuel tank cap is
screwed on all the way. This help s keep fu el from spillin g out or evapora ting.
Fuel is highly flammable and explosive ; it can cause severe burns and other seve re ries.
Failure to shut the e ngine off while refueling and/or to in se rt the pump nozz le into the vehicl e's filler n eck can cause fu e l overflow and fue l spray. Fuel spray and overflowing fuel are dangerous beca use they can ca use fire or seriou s
injury.
Durin g refuelin g, the e ngine, an d th e ti on must be swi tc hed off for safety reasons.
Never use a cell ular te leph one, radio, or other radio eq uipment while refueli ng. The
fire.
While driving
Neve r get back into your veh icle while eling . If in exce ptiona l circumstan ces you must
ge t back in your ve hicl e while refue ling, make cert ain that you close th e door and touch metal
to disc harge static electricity before touching the filler nozzle again. This helps avoid the buildup of stati c elec tricity , w hich can cause sparks that can ig nit e fuel vapors re leased during refueling .
Never smoke or have an open flam e (or
sparks, ciga re tt es, or oth er sm old erin g obj ects)
anywhere in or your vehicle when refueling
o r
Avoid elec trostatic discharge and
safety instructions and procedures that apply a t th e service statio n whe re yo u fuel.
Never spill fuel in the ve hicl e or the luggage compartment.
For safety
or empty, may leak and could cause a fire,
under exce ption al cir cumstances, yo u must tmnspo rt a po rt able fuel contain er, please observe the following:
- Neve r
fill a portable fuel container while it
i s anywhere in or o n the ve hicl e (for example,
i n the luggage compartment). tri city ca n build up while filling and can

information and heed the WAHNINGS on page 234.
Lights
up Indicator pos itio n response 235, fig. 147
Hunning on reserve-
Fu el tank cap not pro perly closed. properly.
When the ignition is switched
a few seconds.
Fuel tank cap not properly
indicator ligh t comes on or if yo u see a tex t m essage to the same effec t in the in stru­ment clu ste r d is play , stop the ve hicl e in a safe
p lace and switch ofT the en g ine and the ig n ition.
might remain even tho ugh the fu el t ank cap is properl y closed. This is no rm al and n o re ason to take your vehicl e in for se rvic e.
however, th e m alfun ctio n indicator light driv e to yo ur neares t authorized swagen dealer or authorize d Volkswage n Serv ice Facility and have fuel sys tem and the engine checked.
While driving
Driving with a fu el tank that is almost empty can
lead t o s tallin g in traffic, a co llisio n, and seriou s
p ersonal injuries.
W hen the fu el t ank is almost empty, fuel
supply to the engine can b e interrupted, espe­ciall y w he n driving up and d ow n hill s.
Steerin g and braking assist ance a s we ll as and re lated syste ms w ill not work if the en ­
gine or s talls due to lack of fuel.
Always refuel w hen the tank is 1/4 full to re ­duce the risk of sta ll in g in traffic due to lack of fuel.
Note
----------------------~ Failure to heed warning lights or t ext WARN-can result in veh icle damage.
Never drive until the fuel tank i s com ple te ly
empty. The irregula r fu el supply can cause the e n­gine to misfire. This allows unburned fuel t o ge t into the exhau st syste m and damage the cata lyti c
co nverter or the diesel p arti culate filt er.
The small next to the gas pump symbol in the fuel page fig. shows
th e sid e of the ve hicl e w ith the fuel filler flap.

Refueling checklist
first rea d an d note the introductory information and heed the on page 234.
The engi ne compartment of moto r vehicle is a haza rdous engine or in the engin e compartment unless yo u -know exac tl y how to carry o ut the job,
-have the correct technical in formation and the proper too ls and supplies, and -ar e familiar with the necessary safety precautions page 242, Preparation s for working
have the work done by an authorized Volkswagen dealer or authorized Volkswag e n Serv ice Facility. Ser ious personal injury may result from improperly perform ed work. Make
s ure that y ou check the followin g item s re gu larly. The bes t thin g is to check them every time you refue l:
Wind sh ie ld was her fluid leve l page 128
E ng in e oil leve l page 247
Engin e coolant leve l page 252
Brake fluid level page 188
Tire pressure page 276
Vehicle lighting necessary for drivin g safe ty:
-Turn signal s
-
li ghts, low beams and high beams
- Taillights
- Brak e light s
Inf
ormat ion regard ing changing light bul bs page 344.
While dri ving

Always disconnect the batt ery (or teries, where appli cable). Make sure the hicle is unlocked when you disconnect the battery, or th e alarm w ill go off. Never touch the electrica l w irin g of the ign ition sys te m .
Neve r smoke.
Never work near heaters, water heaters, or other open flames.
Always have a functional, approved fire tinguisher nearby.
Warning
Note
W hen c
hangin g or topping off fluid s, make sure that you pour the fluids into the correct voirs. Addin g incorrect fluids will cause serious
malfunc tions and engine damage!
Fluid leaks are harmfu l to the environm ent.
thori zed Volkswagen dealer or authori zed swagen Serv ice Faci lity. Dispose of le aked at ing fluid s
first read and note the in tr o du ctory informat io n and heed th e on p age 242.
Lights ca use up
Engine hood not proper ly closed.
When the ignition is sw
itched on, several warning
a nd in dicator light s co me on bri efly fo r a functio n
c h eck. They go out after a few seconds.
If th e engi ne hood is open or not clos
ed properly,
the following warning light comes on in the ment cluster:
tions , a sy mbol showing th at the hood is not erly clo sed may appea r in th e in stru ment clu ste r
di splay instead of the warnin g light . Th e light or sy mbo l will als o com e o n whe n th e ig nition is swit ched off. T he di splay goe s out about
Core,
response
Close the eng ine hood.
I S seconds
after the vehicle has been locked with
the doors closed.
Failure to heed warning lights and instrument cluster text messages can cause the vehicle to
break down in traffic and res ult in a co llision and se riou s personal injury.
Never ignore warning lights or text
Always stop the vehicle as soo n as it is safe to do

Engine oil
Introduction
In thi s sect io n you'll find inform ation on the fol­
lowing:
Warning and indicator lights . . . . . . . . . . . . . . . . . . . 247
Engine
=>Boo klet Warranty
fo r wor king in the engine com­partment=> page 242
accessories, repairs and modifications page303
Im
proper h andling of engin e oil can cause se­vere burns and other seriou s injurie s.
Always wear eye protection.
Warning and indicator light s
Engine oil is poisonous and must be stor ed out of the rea ch of children.
To reduce
Engine oil becomes ex tremely hot when the engine is running and can ca use severe burns. Alway s le t the engine cool down to the tou ch.
all othe r operat in g flui ds, engine oil can pollut e the envir o nment. leak ing op­
erat ing fluid s and dispose of them properly in ac­
co rdance with appl icable environmental laws and regu latio ns.
on page 247.
Light s response up
Engine oil level too low. th e engine. th e eng ine oil leve l --=>page 249.
Flashes cause respon se
Switc h off the eng ine.
Engine oil press ure too low.
-If the warning light flashes although the oil level is normal , do continue driving or let the en gine idle. as damage may result. Get ex -pert assis ta n ce.
Take the veh icle to an auth orized Volkswagen Engine oil leve l sensor malfunction. dealer or authorized Volkswagen Service Fa-cility. Have the engine oil sensor checked .

Failure to heed warning lights and instrument cluster text messages can cause ve hicl e to break down in traffi c and result in a collision and serious perso nal injury .
Never ignore warning lights or text WARN­INGS.
Eng ine
first read and not e the introductory information and h eed the on page 247.
The engine oil used must conform to exact specifi­cations.
U sin g
the prop er engin e oil is import an t for th e
fun ctionality and serv ice life of th e engine. Your engin e was factory-filled with a hi gh-qualit y
multi -gr ad e oil which can usuall y be used
t h roughout the entire ye ar.
Your engine was factory
-fille d with a hi gh -quality, all-season e ng in e oil that meets stric t Volkswagen oil quality standards and has a vis­grad e ofSAE You can use this oil for normal d riv in g in temperatures.
D iesel engin es with diesel
diesel particulat e filt er
At the tim e thi s Manual was printed, the engine oils available in the U.S. that m eet these swage n standards oils. This does
not mean, however, that any engin e oil
will meet Volkswagen standard s. Always use an ap­proved oil that exp ress ly complies w ith the
Core,
Always stop the veh icle as soon as it is safe to
d o so.
No te
Failure to heed warning lights or tex t WARNINGS can result in ve hicle
swagen oil qualit y standard th at applies to your ve­
hicle's e ngin e.
General recommendations:
If oi l th a t meets the applicab le swagcn oil quality standard w ith viscosity grade SAE or is no t availab le in your area,
b e sure to use viscosity g rad e suitabl e for the cl i­mate, sea so n, a nd operati ng conditions th at exi st where the vehicle is used. Make sure the oil meets
th e quality standard listed table on page 248.
Engine oils arc consta ntl y being improved. swa gen dea lers and Service Facilities are alway s regarding new deve lopments and chan ges. Volk s wagen therefore recommends that
yo u have the e ngin e oil changed by an authorized Volk swagen dealer or an author ized Volk swagen
Service Facility.
Note
If yo u need to add oil and there is none avail­
a bl e that meets th e Volkswagen oil quality stan­dard your en gi ne requires, you may add a to ta l of no more than 1/2 quart of a high-quality
or SAE
Us e only a high quality engine oil that ex­pressly complies with the Volkswagen oil standard specified fo r your ve hicle's engine. U si ng any o ther oil can cause serious engin e damage that will not be cove re d b y any swagen Limited Warranty.
Do not mix any lubricants or other additives
into the motor oil. Doing so can cause engine damage! Damage caused by these types of addi­tives are not covered by any Volkswagen Limited

Temperature
Lights up gauge needle response page252,
fig . 153
off the road and s top as soon as you can do so safely.
the engin e
coolant l eve l and add e ngine coolant if page 255. th e e ngin e coo lant E ng in e coolant tempera-
leve l is correc t o r the p roble m continues Warning zone l
u re too high. afte r addin g coo la nt and driv ing a sh ort tance, do not drive an y farther.
sary 341.
th e engin e coo la nt level after the en-
gine has coole d d own and add en gine
coolant i f page 255. the engine coo la nt leve l is correc t or tl1e problem continues after adding coolant, do
En gin e coolant leve l too not drive a ny farther.
Facility.
These in struction s apply only when the coolant temperature stays in the normal
rang e. immediately if the needle goes
in to
the red warning zone
Eng ine coo lant system the nearest authorized Volk swagen .. malfunction. dealer or authorized Volkswage n
Do not drive at hi gh en g in e s peeds or with heavy en g in e loads until the engine warm s
cause
Engi ne coo lant syste m malfun ction .
the engine compartment 252 253

Failure to heed warnin g light s and instrument cluster text message s can cause the ve hicl e to break down in traffic and result in a and seriou s personal injury .
Never ignore warning light s or text I NGS.
Engine coolant specifications
introdu ctory information and heed th e on pag e 252.
The engi ne c ooling sys tem is fille d
p erce nt of Volk s wa gen engi ne coo lant additi ve G 12 plu s-plu s (TL-VW 774 G) o r G 12 plus (TL -VW F). Both of these engin e coola nt ti ve s are purple.
This mixtur e pro vides antif r eeze pro te ction down
to -13 a ls o he lps to pro tec t th e light
allo y pan s in th e eng in e coolin g sys te m against
corro sio n. In addit ion, the mi xture help s preve nt
c alcium dep os its and in creases the bo ilin g point of the e ng in e coola nt.
T o
protec t th e e ng in e, the mi xture must a lway s co nt ain nt le a st
mate conditions , th e perc entage of coola nt ti ve can be in cre ased. Howe ver, the coo la nt ti ve pe rc e n ta ge mu st never be m ore than oth erw ise , ant ifreeze prot ection is reduce d a nd
th e ability of the mi xture to coo l th e e ngine is als o
r educed.
Whe n addin g e ngine coolant, use a mixture of till ed water and at l ea st c o o la nt addit ive G 12 plu s- plu s for optimum co rro sion protection
Core, maintenanc e
Always stop the vehicl e as soon as it is saf e to do so.
Note
Failure to heed warning lights o r text can re s ult in veh icle damage.
Too little antifreeze protection in the en gin e coolin g syste m can cause eng in e failure and vere injuri es.
be used.
At extremely cold temperatures, the coolant could freeze, cau sin g the v ehicl e to brea k down. The heater would als o no t work, and ve hicl e cupants could be without protection at free zing temperatures.
Note
N eve r mix original Volkswagen engine coo lant additives with other additi ve s no t approved by
Volkswagen. Mixing Volkswage n coo la nt
facturers can serio usly damage th e engine and th e engi ne coolin g sys te m .
Eng in e coolant additive G 12 plus-plus can b e
m ixed with G 12 plus and G
If the fluid in th e e ngine coo lant res ervoir is any color but purple (s u ch
this is th e case, the gin e coolant mus t b e r epla ced immedi ate ly . envi se serious m alfun ction s or engine damage can occ ur!
E ng in e coolan t a nd engine c oo lant additi ves can pollute th e environm ent. le akin g opera ting a nd disp ose of th em in
acco rdance with appli cable e nvir o nm ent al la ws
a nd

read and note the introductory
on page 252.
If th e coolant level drops too low, the engin e
coo lant level/ tempe ratur e warni ng ligh t lights up.
Park the ve hicl e on level ground.
Always let the engin e cool
th e engine hood
There is a fig.
When the eng in e is co ld, check the e ngine
coolant leve l relat ive to th e marking on th e sid e of th e expa nsio n tank fig. 154.
Always protec t face, hands and arms from h ot
escaping coo lant o r steam by cover ing the cap with a larg e, thi ck rag.
Carefully unsc rew the
Add new engine co olant ac co rding to Volkswagen specifications page 254)
Th e engi ne coo lant leve l must b e in sid e the mark s on the sid e of the 154. Do
not above top edge of the
the engine compartment
Fig. 155 Coolan t e xpans ion tank cap in the eng in e
compartment.
Screw the lid tightly.
Even in a n em erge ncy, do not use any other kind of coolant addi tive if eng ine coolant meeting
Volkswagen pa ge 254) is una v ail­
able! Instead, add distilled water
page 254.
H
ot steam and hot engin e coo lant can cause se­
rio us burns.
Never open the hood if yo u sec steam o r coolant esca ping from the engine compartment. Always wait until you no longer see or hear steam or coolant escapin g from the engine.
Always let the e ngin e cool down compl etel y
before carefully opening th e hood.
When the engin e has coo le d down and you are ready to open hood:
- F
irmly apply the parking brake and shift (automatic) o r Neutral (manual only).
- Hemov e
the vehicl e key from the ignition.
- Always keep c
hildren and others away from the en gin e compartment and never
leave them unsupervise d.
The engine coolant system is under pressure
w hen the engine is hot. Neve r unscrew the coolant expansion tank cap whe n the engine is hot. Hot coolant can spray out and ca use severe burns and other serious injuri es.
254 255

Never use or attempt to ch arge a damaged or frozen battery, or a battery was frozen but has thawed. a frozen or thawed battery could cause explosion s and ch emi cal burns! place damaged or froze n ba tt eri es m ediat ely. A disc harge d battery can freeze at
temperatures around +32 Alway s
the battery has a ve nt lin e or tube, make sure thi s is connec te d.
Always make sure that the vent line is curely attached to a cated in the
If you battery acid in your eyes or on your
eral minutes. The n medical attention
ical attention immedia te ly.
Warning
Battery posts, termin als and related rie s contain lead and lea d compon ent s, cals known to the of to cau se
cancer or other h arm . Wash your hand s after
handlin g.
Note
Never di scon nect a ba tt ery or connec t
two b atte ries to each other when th e
Do not expose the battery to dire ct light for an extend ed p eriod of tim e as ultraviolet rays may damage th e battery housing.
is lef t s tanding in the cold for a
lon g tim e, prote ct th e battery from
fr ee zin g. A battery will be permanentl y damaged by fr eez ing.
infunnatiun on pa ge 257 .
Light s cause up
Alternator malfunctio ning.
W he n th e ig niti on i s s witched on. several warning
a nd in dica tor lights come on briefly for a funct ion ch eck. T hey go out aft er a few seco nds.
Failure to hee d warning lights and instrument
Never ignore warning light s or tex t
cleaning, maintenance
to an authorized dea le r or authorized Volksw agen Fa-cilit y. Have e lectrical syste m ch ec ke d . off unnecessary elec trica l load s. Th e ve-battery will not be c ha rged by the alt er-nato r whil e th e is in moti on.
Always stop tl1e
Note
Failure to heed warning lights or te xt