lights VOLKSWAGEN GOLF PLUS 2012 Service Manual

Charging, replacing, disconnecting and connecting the
first rea d and no te the introductory
o n p age 257.
the vehicle batte ry
Vehicl e batteries should be c harged by your rized Volk swagen deale r or an authorize d
Replacing the ve hicle battery
Th e batt ery in
your vehicl e is s pecially deve loped
f o r it s locati o n, w ith sp eci al dim ensio ns and safe ty
featu res. Befo re buy in g a new battery, ask an th ori ze d Volkswage n deale r o r authorize d swagen Facility w ha t batt eries are suit abl e
w ith r egard to e lectro-m agnetic compatibility, mension s, requir ed m aintenan ce, perfor man ce,
and safety sp ec ifications. H ave th e battery place d by an auth ori ze d Volkswage n deale r o r an authori zed Volk swage n Facility.
use m aint ena nce-free vehicl e ba tt eries m ee tin g standards T L 825
hicle's elec tri cal sys te m , note the following:
off all electrical syste ms and dev ices
and th e ign ition.
Fir st di sconnec t the negative cabl e and th en the positive
the vehicl e battery
to reconnecting the ba tt ery , switch off all elec trical sys te m s and dev ices and the ig niti on .
Con nec t th e positive cable fir st a n d then th e
n ega tive
ta n ce at mph (15-20 km /h).lf the in dica to r ligh ts do not go out, contact an auth orized swage n dealer or a n au th orize d Volkswagen v ice Facility and have the vehicle c hec ked.
If th e battery was discon necte d f or a long tim e, the
n ext scheduled se rvice may no t be correct ly la te d and page 16 The maximum per-
an d nance booklet.
Vehicles with
h icle battery, lock an d unloc k th e ve hicl e from th e outs id e. Th en try to sta rt the ig niti on again. If th e
ig niti on canno t b e switch ed on , ge t expe rt ta n ce.
Automatic electrical
load deactivation
I f t
he ve hicle battery drain is hig h, t he intelligent
o n board electrical sys te m m anage ment cally takes steps to help p reve nt b attery d rain.
The id le speed i s in creased so that the n ato r provides more powe r.
The power to dev ices that co nsume lot of e lec tricity is cut bac k or switched off com ple te ly.
W hen the en gine is s ta rt ed , p owe r supply oft h e
1 2-vo lt socke ts and t he c igare tte lighter is ra ril y int errupted.
T he on
board elec trica l sys tem man age men t
canno t always keep th e battery fro m being drained. For example, th e battery will drain if th e
e n g in e is not running, but th e ig ni tio n i s switc he d
o n for a lo ng tim e or th e parkin g lights a re left o n for a lo ng time.
What drain s th e battery?
Long period s w hen th e engine is no t running, especially w hen th e ig niti on is on.
Fa ilur e to use the proper batte ry with prop er mounting and connecti ons may ca use short seriou s personal injurie s.
Always use only mainten ance- free or leak-pro of batteries with the same
ment battery. Specification s are liste d on the
b attery ho using.
Wh en th e battery is charged, it produces hi ghly explosive hydroge n gas.
Charge ve hicl e batte ries only in w ell-ve nti-
l a te d areas.

Engine
Introduction
In this sec tio n yo u'll fin d infor matio n on th e lowing:
Indicator lights . ......... , . . . . . . . . .. . . . 315
Catalytic converter ............. , . . . . . .
.......... , . . . . . . . . . . . . . 317
More informatio n:
179
234
pa ge 239
Engi ne page 247
Notice about data r eco rded by vehicle control page
Towing a nd
The vehicle exhaust sys te m and the catalyt ic
co nve rter or di ese l parti cu la te filter very hot
a n d can cause a fir e a nd serious perso na l in jury.
Neve r park where parts oft h e hot exhaust syste m and catal ytic con ver te r co uld ignite
O ammabl e m ate ri als, su c h as bru sh , lea ves, dry fu el, e tc.
Neve r appl y addition al undercoatin g o r rust
proofi ng on or near th e exhaust manifold, pipes , catalyti c converter, d ies el pa rti cu-
l a te or heat shi eld s.
Califo rni a Propo sition 65 Warnin g
E ngine exha ust, some of it s constitu ents, and ce rtain v ehi cle component s cont ain or emit ch em ica ls kno wn to th e Sta te o f California to
ca use cance r and birth defec ts and reproduc tive h arm. In additio n, cert ain flu ids contain ed in
ve hicles and ce rtain products of compone nt
wea r contain or emit ch emicals know n t o the Sta te o f Ca lifornia to cause cancer and birtJ1
firs t read and note the int rod uctory in formati on an d heed th e WARN INGS on page 315.
Light s
th orized dea le r o r a uth orized Serv ice Facility .
Diesel e ng in e preheating before eng in e 172 sta rt -up .

Lights up Possi ble cause
Cata ly tic converte r malfunction.
Diese l particulate
gin e).
Misfir e, whi ch can th e ca talytic
co nve ner.
W he n th e ignit io n is swit ched o n , seve ral warning and indicator lights come o n b riefly for functio n
check. They go out after a few seconds.
a ll applicable legal requirements when cleaning the d iese l p articulate filter .
diesel particula te filt er mended only when v isib ility, we ather, road, and traffic conditions permit.
converter
firs t rea d and not e the introductory inform ati o n and heed the on page315.
The cata lytic con ve rter prov ides exha ust gas treatment to help red uce pollutan ts in the exhaus t
g a s. To help ensure lo ng serv ice life of the exhaus t
sys te m and gaso lin e engine catalytic conv en er:
Neve r comple te ly empty th e fu el tank.
Do not exceed the correct page 247.
mainte nan ce
Prop er response
Ease off the accelerator.
minutes in 4th gear (m anual
transmission) or in D Dri ve (automat ic trans-
m ission) a speed of about45 mph km /h ).
speed
an authorized Volk swage n dealer or au-thorized
deale r or authorized F ac ility.
Ease off the acce lerator. dri ve to the
n earest authorized d ea le r or thori zed Facili ty. Have en-gin e c hecked.
D o not put others at risk.
Note
Failure to heed warning lights or text can result in ve hicl e damage.
As long as the in dicator ligh ts are on , ex pect engin e malfunctio ns, cre ased fuel co nsumption a nd loss of en g in e
efficie ncy.
Do not tow-start the vehicle; jump-start stead page 353.
yo u ex perie nce mi sfires, loss of p ower or th e gin e is not running smoothl y w hile driving. reduce
speed immediately and have the ve hicl e checked by an authorized

Do it yourself
con sid era tions" or may help.
De
scription causes amon g oth ers remed y
Vehicl e ba tt ery dead. jump page 353.
page 257. Engine does no t start. The wrong ve hicle key is used. a valid ve hicl e page 34.
Fuel leve l too low. Hefue l 234.
Batt ery in ve hicl e key dead. page 34.
Vehicle cannot be locke d Too far away from vehicle . Sy nchroni ze veh icle page 34. key. Lock or unlo ck vehicl e manually
crat ing range. page322.
en gine, braking assis t sys-th e entry in the ke yword noises. te rns, e lectro nic steering index.
co lumn lock.
the "Assis tance e ntry in the keywo rd in dex .
Exterior mirro rs move convenience settings
w he n unl ocke d . stored. 65.
F ront seats can not be ad -Vehicle battery dead. veh icle page 257.
jus ted with power con-Fuse b lown.
a n authoriz e d Volkswage n
m obilit y se t in vehicle. on ve h icl e. dealer or an authori zed Volk swagen Ser-
v ice Facility for page 326.
Func tions diff
er from th e Settin gs were adju ste d in th e and reset to fac tory settings if
descript ion in the oper-Volkswagen Information page 2 ating manual. Syste m.
T he road
is not illumi-H ea dlights a djusted too hig h . !>A dju st headlig ht page
n a ted correctly. Light b ulb s burned out. ligh t page 344.
Low beams no t swi tched on . Switch on low page
Vehicle battery ch a rge too low. page 257.
E lect rica l a p plian ces do Remaining fuel le vel too low. Refu el page 234. not functi on.
page341.
Do it yourself

Fuses
Introduction
thi s section yo u'll find information on the lowing:
342
343
Due to ongoing development of the ve hicl e, ment -d ependent allocation of fuse s an d th e bin ed fuse prote ction of multiple load s us ing one fuse, an up-to-date overview of th e fuse location per lo ad is no t pos sible at the time of printing. taile d info rma tion regarding fuse bo x layout is
availabl e from authori zed dea ler s Faciliti es.
In gen eral , one fuse ca n prot ect severa l l oad s. load can a ls o be protected by s evera l fuses.
R eplac e
fuses only if the ca use of th e malfuncti on
wa s corr ected. a newly re pla ced fuse blow s aga in
aft er a short time, th e ele ctri cal sys te m should be
c he cke d b y
an authorized deale r or an au thorize d Facility .
More information:
page 242
High voltage systems in the engine
Never touch ignition cables. Never touch other components of the hi gh voltag e elec tronic
ignition syste m.
Practi cal tips
Avoid short circuits in the electrical system.
tion in tJ1e circuit can cause fires and serious
Neve r replace a fuse with one that has a
higher amp ratin g. Replace a blown fuse only
with a fus e of the same amperage (same color and same imprint) and same overall size.
Never repair fuses.
Never
Note ---To help prevent damage to ele ctr ica l
system, swit ch off all lights and accessories,
switch off the ignition , and remove the key from the ign ition switch befo re replacing a fuse.
If a fuse is replaced with a fuse with higher
electrical system.
A sin gle load (a s ingle electr ical componen t) ma y be prot ected several fuses.
fuse m ay prote ct sev era l loads (several e le ctri ca l compone nts).
341

Introduction
In thi s section you'll find informat io n on the
low ing:
Indicator light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 345
Information on light bulb replacement . . . . . . . . . . 346
Rep lacing light bulbs in the headlight . . . . . . . . . . . 347
Changing the light bulb in the front bumper . . . . . 348
Rep lacing light bulbs in taillight in th e rear hatch . 349
Replacing taillight bulbs in th e body aft he vehicle
Changing the light bulb in the license plate lamp . 351
Changin g a ligh t b ulb requ ires a certain amount of
s kill. If you are uncertain about how to proceed, Volkswagen r ecommends havi ng the ligh t bulb
c h anged by
Facility. training and know le d ge are ge nerally required
w he n other ve hicl e part s mu st be disasse mbled to
replace a bul b, or when d ischarge lamps mu st
b e re p la ced.
sh ould always keep a box in t he ve hicle wit h all the re p lacement bulbs requi re d for traffic safety. R eplacement bulbs are avai lable from your autho­rized Volkswagen dealer or Authorize d Facility. The laws of some
Additional light bulb s p ecifi cations
fac tory-in stalled lig ht bulb s in th e light s or th e taillig h ts may have differe nt sp ecifi ca­
t io ns th an conven tio nal light bulbs. are on th e g lass bulb or o n the m eta l b ase.
More info rmation:
Lights and page
for worki ng in the engi ne page 242
Vehicle tool page 326
Fu ses p age 341
D o it yoursel f
and other accidents ca n happen when yo u cannot see the road ah ea d and when yo u
cannot b e seen by o th er m oto ri sts.
Impr op er r epla cement of burn ed ou t headlig ht s
and o th er light bulbs ca n ca use serious perso nal
injury .
Always read and hee d the before doing any work in the engine compart­242. The engin e co mpartment of any mot or ve hicl e is a potentially dangerous
area, and work in t11is area can lead to seriou s personal injury.
Gas disc harge lamps (Xenon ) ge t power from
a hi gh vo ltag e source that can cause seve re
H7 bulb s and gas disc harge la m ps arc under
high pressure and can e xplode if handle d pro perly.
Always le t a burne d o ut light bulb cool down before re pl acing it.
Neve r replac e a light bulb unless you arc fa miliar with all of th e necessary procedures. In
parti cul ar, n eve r remo ve a hea dlight unless you
know exactly how to carry o
ut the job and have the co rrect tools and light bulb s.
ge n dea le r, a n authorize d Volkswagen
personal inju ry may result fro m improp erly
performed wo rk.
strongly recommend th at you alwa ys hnvc gns discha rge lamps {Xeno n) a nd bulb s replace d by a qualifi ed tec hni cian.
Do not touch th e glass of l ig ht bulb s with your bare hands. Fing erp rint s left on the bulb
eva porate due to the heat when th e bul b is
swit c hed on and cause the reflec to r t o
There arc sh a rp edges on an d around th e
h eadlamp housin g in the en gin e com partment and th e ta illi ght hou sing. h and prote ction if you repla ce bulbs.

Note
After replacing a headlight bulb or other light bulb, always make sure that the rubber covers or plastic ca ps have been properly and securely rein­
s talled to help prevent water from gettin g into the
e lec trica l connection s and headlight hou sin g and damaging th e e lectrical system_
Please first read and note the introductory information and heed the o n page 344.
Lights up Possible cau se
Light bulb of th e exterio r ve hicle lighting . not working .
W
hen the ignit ion is swi tc h ed on, severa l wa rnin g
and indi cator lights come on briefl y for a fun ction
check. They go out after a few seconds.
Failure to heed warning lights and instrument cluste r text messages can cause the ve hicle to break down in traffic and result in a co llision and serious personal injury.
Never ignore warning lights or tex t WARN­INGS.
tips
Proper response
R
epl ace the ligh t bu lb.
WARNING
A lways sto p th e ve hicl e as soon as it is safe to
do so .
Note
Failure to heed warning lights or tex t WARNINGS can result in vehicl e damage.
344 345

in th e rear hatch
Fig. 195 the rear hatch: Removing the bulb holder.
first read and note the introducto ry info rm ation and heed the on page 344.
Revie w and follow the page 346.
2. page 45.
3. With the fla t blad e of the scre wdri ver from the ve hicl e too l kit 326 ) ca refull y pry off
the cove r a t the fig.
4. and re move th e bulb h ol der.
5. R e place th e burned out light bulb with a new bulb of the sam e type.
6. Heplace th e bulb hold er. The lo ckin g lu g must latc h audib ly.
7. A nac h the cover. The cover must l atc h tig htly.
Taillights w ith have a light bulb f or the back up light. This bul b can b e rep laced .
Practical tips 348 349

Optical Parking Sys tem . . . . . . . . . . . . . .
. . . . . . . . . . . . . . .
Rear Assis t. .................. ........
Audio warnin gs
Warning and
indicator lights ........... 13
Automat ic headlight control ............. 124
Automa ti c load deactivation. . . . . . . . . . . .
Automatic transmission ................. 179
Direct
th e selector lever
l
ock .............................. 325
Ignition key saf e ty interlock ........... 175
Kick-down feature ................... 186
Launch
control program .............. L86
Ma lfun cti on ......................... 186
Axle weights ............................
B
mount ............................. 157
see Braking assistance syste ms .. ...... 194
Battery Replac e
ment in remote co ntrol key. . . . 36
Belt warning light. . . . . . . . . . . . . . . . . . . . . . . 68
Bottle
holders
Bottles . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 166
Brake
Brak e booste r.
...........
.......................... 196
Brake l eve l. ...... ..... .......... 197 Brake pads .......................... 192
Brak ing
assistance sy s tems ........... 194
b rake ............. .... 197
Emerge ncy brake display
during hard brak-ing ................................ 321 Indicato r light ................... .... 189
Alphab etical index
Parking brake ........................ 19 1
Warning
light ....................... . 189
Brak e Assist ............................ 194
Brake Assist . . . . . . . . . . . . . . . . . . . . . . 194
B rake booste r ...................... 193, 194
Brake
............................. 196
Specifica tions
....................... 196
Brake sys
tem ........................... 194
Malfun ction ......................... 192
Brakes
Eme r
gency when full braking .. 321
Braking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Braking assistance systems. . . . . . . . . . . . . . 194
Breakdown Protect in g th e ve hicl e . . . . . . . . . . . . . . .
Break-in period
E ngin e .............................
Brakes ......... .................. 192
c
phone ....... ..... ..................
changer ........................... .
phone
w ithout outside antenna. . . . . . . . .
con so le . . . . . . . . . . . . . . . . . . . . . . .
a light bulb
Indicator light . . . . . . . . . . . . . . . . . . . . . . 345
th e wheel change ... ............ 335
ve hicl e ....................... 333
W heel bolt s ..................... ..... 332 W hee l change ....................... 335

light bulb
License plate lamp .. ................. 35 1
light bulbs . . . . . . . . . . . . . . . . . . . 344 In front bumper ......... ............ 348
In
the body ............. ............
In the h ea d light ..................... 347
In th e r
ear hatch ....•................ 34 9
Tai
llights ....................... 349,
o il leve l ...................... 249
Driving safely ...... ............... 28, 29
Gell ing read y
..................... 28, 29
In an emergency ................
Lifting vehicle with jack . . . . . . . . . . 333, 334
Ligh t bulb re pla cement . . . . . . . . . . . . . . 346
Preparation s for changin g a wheel . . . . 331
Sa fe ty belts . . . . . . . . . . . . . . . . . . . . . . . . . . 72
Ti re mobility set. . . . . . . . . . . . . . . . . . . . . 338
Uphol stery ........................... 271
and th e Advanced Airbag System. . . . . .
anchorages..... 116
Sec urin g wi
th the Top Tether strap. . . . liB
safe ty lo ck . . . . . . . . . . . . . . . . . . . . . . . . 44
safety seat. . . . . . . . . . . . . . . . . . . . . . . .
the rear seat . . . . . . . . . . . . . . . . . . . . . lOB
seat
Booster
seat. . . . . . . .. . . . . . .. . . . . . .. . . 1L2
seat mounting................. 112
Infant carrier ........................
Securing wit h lo ckab le safet y belt . . . . . 114
Secu ring w ith safety b elt . . . . . . . . . . . . . 114
seats s eat mounting. . . . . . . . . . . . .
care. . . . . . . . . . . . . . . . . . . . . . . . . . . 267
lig h ter. . . . . . . . . . . . . . . . . . . . . . . . 169
Als o see: A ir co nd itio ning . . . . . . . . . . . . 226
sunroof . . . . . . . . . . . . . . . . . . . . . . . 51
Rear hatch . . . . . . . . . . . . . . . . . . . . . . . . . . . 47
Vehicle . . . . . . . . . . . . . . . . . . . . . . . . . . . 39,
hooks . . . . . . . . . . . . . . . . . . . . . . . . . . . . 165
.................................. 6
number . . . . . . . . . . . . . . . . . . . . . . . . . . 327
we ight
Determination (North America) .......
spare wheel
Dr iving style
........................ 288
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
information . . . . . . . . . . . . . . . . . 3ll
units . . . . . . . . . . . . . . . . . . . . . . . . . .
Engine coolant . . . . . . . . . . . . . . . . . . 252
Co
unter-steering assista nce. . . . . . . . . . . . .
h o ld er
Front center co nsole. . . . . . . . . . . . . . . . . 166
Rear center co nsole ................. . 167
weight . . . . . . . . . . . . . . . . . . . . . . . . . . .
D
Data recorded b y control units . . . . . . . . . .
Data recorded whil e driving. . . . . . . . . . . . .
Data recorde r . . . . . . . . . . . . . . . . . . . . . . . . . .
Dayt ime running lights. . . . . . . . . . . . . . . . . 124
Dynamic