transmission VOLKSWAGEN PASSAT 2004 Owner's Manual

Trailer towing tips
when to­
wing a
weight and weig ht distribution. per­
formance and economy depend
on
how your and
operate your rig.
Before you
tow your
you the
unit.
Backing up is
and requires practice.
Steering
wi­
thout a
you need
a
than turn ing radius.
When passing, remember that you cannot
be­
cause
of the added Make sure you ha­ve enough room to pass. After passing. of room for your
changes.
AND
After parking , the and
on a it cannot be avoided. do
so
foot brake .
Have someone chocks under both
With chocks in bra­
kes
Turn to curb.
parking brake.
and
transmission in first or reverse gear.
you move the
the
to
move the position.
When restarting after parking on a
the engine.
the parking brake and
and have someone retrieve the
Notes
your may require more frequent maintenance
due to the extra
page 31.
DRIVING AND ENVIRONMENT---------21

Engine compartment
bris from entering the interior
through the heating
and ventil ation ducts
The engine compartment and transmission
have been corrosion protected
at the
mation given on page 22.
Good anti-corrosion treatment is very the
is frequently driven on salted roads. the
entire engine compartment and plenum
or if
you have the engine
the anti­
corrosion treatment is almost always
is therefore essential to ask
for a long-last ing corrosion protection of
If you must rinse off gasoline, oil residue or grease while your are cleaning your engine, then the dirty
water should be run through an oil separator filter. We recommend
that you have your engine cleaned at a qualified workshop or service

AND
General notes
We recommend that you have the engi­
ne compartment and th e underside of your
Also. whenever the lower body transmission or engi ne assemblies have
be en repaired. any anti-corros io n
coating
lost on the affec ted surfaces shou ld be app lied .
salt spray deposits
and oily subst ances must be removed.
Your authorize d dealer
stocks the cleaning and preservation solu­
tions recommended by the factory for this
purpose and has the equi pment necessary
to apply them . Therefore, any additio nal
corrosion protection work shoul d be perfor­
med by a
dealer. Using
-----------------CAR E AND CLEANING

Maintenance
Your has been designed to
mum.
However, a certain amount of
By regularly maintaining your vehicle, you help make sure that emission standards are maintained,
thus minimizing adverse effects on the environment.
For
maintenance your Maintenance see Booklet
1.1.
Under difficult operating
when towing a very
some service work be performe
between the specified.
This
th
air
injection and emission r
increasing technr
very strict
the nature of repairs and adjustments to en[ and transmission parts which an owne1 can perform.
Maintenance. adjustments and repairs
require testing
maintenance, adjustments and
repairs can impair the ope ration and
warranty. Therefore, proof of servicing in
accordance with the maintenance
made within the warranty
period .
Above
in doubt about any servicing, have it done by your or any other
workshop.
We urge you to give your
ties. to keep your
Performing
the need arise and trained
of
the the
instructions given.
serve the provided .

Emergency towing with commercial tow truck
The following inform at ion must be used by commercial tow truck operators who know
how to operate their equipment safely.
General hints
Whenever tow with the front
wheels
off g round.
The
a
cau­
se bumper and body panel damage .
is not safe for pas­
sengers. Never
mph km
the vehicle cannot be towed w ith wheel
lift equipment in combination with self-loa­
ding it must be transported on a flat
bed
to avoid damage to the transmission
caused by the lack of lubrication. 4 -
Towing
6 -12 inch es (15-

rpm
Ma xi
mum torque SAE net 166 ft. rpm
(225
Nm at
(1.781cm 3)
Stroke
in (
86.4 mm)
Bore 3.19 in ( mm)
ratio 9.5: 1
Premium 1
Capacities
tank in gal. 62
Reserve in gal.
in
washer container in quarts. 6.2
E ng ine
in quarts.
Automatic Manual
transmission transmission
w ithout brakes in lbs.
with brakes in lbs. kg) (91
in lbs. 165 (75 kg)
Note For maximum engine performance.
The engine be checked topping up.
The spark ignition system meets
-see AND
chapter

Always keep this information with your other vehicle literature. you
have questio ns, contact your authorized Volkswage n dealer.
This supp lement describes updates since
the las t printing of Safety
Sedan
Tire inflation pressure sticker for
Wheel Drive)
Engine co
mpartment: Gasoline engines hp (1.8L) an d 275 hp (4.0L)
Technical Data
Technical Data for Sedan Wagon W8 with manual transmission

You must depress the clutch pedal
the way before you can start the engine.
Always depress the clutch pedal ful­ly when changing gears. Do not hold
the vehicle on a hill with the clutch pedal partially depressed. This may cause premature clutch wear or da­mage.
Resting your hand on the gearshift lever knob while driving will cause
premature wear in the transmission.
Drive in 6th gear for optimum fuel economy
when cruising. However,
if more accelera­
tion is required (when passing, for exam ­
ple). shift down .
Gearshift pattern
press down and push forward. after driving forward. stop the ve­
I .
-
B45-667K
High beam
The headlights work only when the ignition
is switched on.
The headlights stay on when you switch on
the high beam.
high beam with
high beam with reduced brightness.
High beam with brightness
Switching on:
With the headlights on. push the lever for­
ward ( 4 ).
The blue indicator ligh t in the instrument
the lever (3 ) towards you.
High beam with reduced bright-
ness
With the headlights
will come on.
the switch (A ) qut to the second detent.
Switching off: