FLUID VOLVO 850 1996 User Guide

1996 Volvo 850
pg. 8:13 Automatic transmission fluid

Check the oil level as follows:

Park the car on a level surface with the engine idling . Slowly move the\
gear selector lever through all
the shift positions and then to position P. Wait 3 minutes before checki\
ng the oil level.
As the illustration shows, the dipstick has a COLD and a HOT side. The o\
il level should between the
MIN and MAX marks. Wipe the dipstick with a clean cloth.
WARNING! The oil may be very
hot.

Do not use rags that could leave lint on the dipstick. The transmission \
is topped up via the dipstick tube.
The space between the MIN and MAX marks on the dipstick corresponds to 0\
.5 US qt. (0.5 liter). Do
not fill the transmission with too much oil, since this can result in oi\
l being ejected from the
transmission. Too little oil, on the other hand, can negatively affect t\
ransmission operation, particularly
in very cold weather.

A Cold transmission: oil temperature 105° F (40° C). This is a n\
ormal temperature for the transmission
after idling for about 10 minutes. At oil temperatures below 105° F (\
40° C), the level may be below the
MIN mark.
B Warm transmission: oil temperature 169° F (80° C). This temper\
ature after driving for about 30
minutes. At oil temperatures above 190° F (90° C), the level may\
be above the MAX mark.

Fluid type: ATF Dexron IIE/III and Mercon.
file:///K|/ownersdocs/1996/1996_850/96850_813.htm (1 of 7)12/30/2006 9\
:59:53 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850

Air pump system (B5254S)

When the engine is being started from cold, an electrical air pump which\
draws air to the exhaust system
is activated. This starts an afterburning process which leads to reduced\
hydrocarbon and carbon
monoxide (HC and CO) emissions and reduces the warm-up period for the \
catalytic converter.
The pump starts when the car has been started and is moving. It continue\
s to work until the catalytic
converter has reached normal working temperature, although it can also s\
tart when the engine is idling.
If the air pump is running and the engine is switched off, the pump cont\
inues working in order to protect
the pump motor.
Note! A soft whining noise can be heard from the pump, and when it perfo\
rms a self-diagnosis, the high/
low beam and the instrument lighting will flash briefly. This is complet\
ely normal. pg. 8:15 Windshield washer nozzles, Washer fluid reservoir

Adjusting washer nozzles

The washer jets should spray the windshield as shown above. Use the edge\
of a small screwdriver to
adjust the nozzles if necessary.
file:///K|/ownersdocs/1996/1996_850/96850_813.htm (3 of 7)12/30/2006 9\
:59:53 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850


Washer fluid reservoir

The washer fluid reservoir is located in the engine compartment and hold\
s approx. 3.2 US qts. (3.0
liters).
During cold weather, the reservoir should be filled with windshield wash\
er solvent containing anti-
freeze. pg. 8:16 Coolant
Check coolant level

The cooling system must be filled with coolant and not leak to operate a\
t maximum efficiency. Check
the coolant level regularly. The level should be between the "MAX" and "\
MIN" marks on the expansion
tank. The check should be made with particular thoroughness when the eng\
ine is new or when the
cooling system has been drained.
Do not remove the filler cap other than for topping up with coolant. Fre\
quent removal may prevent
coolant circulation between the engine and the expansion tank during eng\
ine warm up and cooling.

Changing coolant

file:///K|/ownersdocs/1996/1996_850/96850_813.htm (4 of 7)12/30/2006 9\
:59:53 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
CAUTION: The cooling system must always be kept filled to correct level.\
If it is not kept filled, there
can be high local temperatures in the engine which could result in damag\
e. Different types of anti-
freeze/coolant may not be mixed.
pg. 8:17 Engine compartment
Engine compartment 850
(engine B 5254 S / B 5252 S)


1 Expansion tank, coolant
2 Engine designation plate
3 Oil filler cap, engine
4 Clutch/brake system fluid reservoir
5 Fuse box
6 Washer fluid reservoir
7 Power steering fluid reservoir
8 Dipstick - engine oil
9 Dipstick - automatic transmission
10 Air cleaner
11 Battery
12 Data plate
WARNING! The cooling fan may start or continue to operate (for up to 6 \
minutes) after the engine has
been switched off.
pg. 8:18 Engine compartment (cont.)
Engine compartment 850 Turbo
(engine B 5234 T)
1 Expansion tank, coolant
2 Engine designation plate
3 Oil filler cap, engine
4 Clutch/brake system fluid reservoir
5 Fuse box
6 Washer fluid reservoir
7 Power steering fluid reservoir
8 Dipstick - engine oil
file:///K|/ownersdocs/1996/1996_850/96850_813.htm (6 of 7)12/30/2006 9\
:59:53 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
Specifications
pg. 9:1 Specifications
Specifications

This chapter contains facts and figures pertaining to the technical spec\
ifications of your car.

9:2 Oil/Fluids specifications
9:3Engine specifications
9:4Cooling/fuel distributor ignition systems
9:4Front/rear suspensions
9:5Transmission, Capacities, Vehicle
loading
9:6
Electrical system/bulbs
9:7Dimensions and weights
9:8Service manuals, Road assistance
pg. 9:2 Oil/Fluids Specifications
Oil quality

Meeting API specification SG, SG/CD, SH or Energy Conserving (EC) II \
For best fuel economy and engine protection, consult with your authorize\
d Volvo retailer for
recommended oils. Oil with a different quality rating may not provide ad\
equate engine protection.
Synthetic oils complying with oil quality requirements are recommended. \
Volvo recommends the use of
fuel economy improving oils. Look for the API label.
Synthetic oils complying with oil quality requirements are recommended f\
or: Driving in areas of
sustained temperature extremes (hot or cold), when towing a trailer ov\
er long distances or for prolonged
driving in mountainous areas.
Extra oil additives must not be used unless advised by an authorized Vol\
vo retailer.

Viscosity (stable ambient temperatures):
file:///K|/ownersdocs/1996/1996_850/96850_901.htm (1 of 7)12/30/2006 9\
:59:55 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850

Engine oil Quality: Meeting API specification SG
or SH Capacity (incl. filter): 850 (5-
cyl. engine) 5.6 US qts./5.3
liters (certain models: 6.1 US
qts./5.8 liters)
850 Turbo - 5.6 US qts. (5.3
liters)*
Automatic transmission
fluid Quality: ATF Dexron IIE/ III and
Mercon Capacity: 8 US qts. (7.6 liters)
Manual transmission fluid Quality: Volvo synthetic gearbox oil
1161423 Capacity: 2.2 US qts (2.1
liters)
Power steering fluid Quality: ATF Capacity: 0.85 US qts. (0.8
liters)
Brake fluid Quality: DOT 4+ Capacity: 0.64 US qts. (0.6
liters)

All specifications are subject to change without notice.

* Add 0.95 qts. (0.9 liters) if the oil cooler has been drained Capaci\
ty: 8 US qts (7.6 liters)
pg. 9:3 Specifications
file:///K|/ownersdocs/1996/1996_850/96850_901.htm (2 of 7)12/30/2006 9\
:59:55 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
1st gear 3.07:1
2nd gear 1.77:1
3rd gear 1.19:1
4th gear 0.87:1
5th gear 0.70:1
Reverse 2.99:1

Automatic transmission: AW 50-42 LE
4-speed automatic electronically controlled gearbox comprising a hydraul\
ic torque converter with a lock-
up function; planetary gear, integrated final drive.
Operation via a floor mounted gear selector lever. Drive shafts with sym\
metrical joint location.

Final drive ratio 2.74:1 (Turbo: 2.54:1)
Reduction ratios
1st gear 3.61:1
2nd gear 2.06:1
3rd gear 1.37:1
4th gear 0.98:1
Reverse 3.95:1

Capacities

Fuel tank 19.3 US gals (73 liters)
Cooling System 7.4 US qts. (7.0 liters)
Engine oil (incl. filter) 5.6 US qts. (5.3 liters)*
Automatic transmission 2 US gals (7.6 liters)
Manual transmission 2.2 US qts. (2.1 liters)
Power steering fluid 0.8 US qts. (0.8 liter)
Washer fluid reservoir 3.2 US qts. (3.0 liters)
Brake/clutch system 0.6 US qts (0.6 liters)

* Certain models: 6.1 US qts. (5.8 liters)
Turbo: Add 0.95 US qt. (0.9 liters) if the oil cooler has been drained\
.

Vehicle Loading

file:///K|/ownersdocs/1996/1996_850/96850_901.htm (6 of 7)12/30/2006 9\
:59:55 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850

The following should be checked regularly:*

1 Washer fluid reservoir should be filled with water and solvent (winte\
rtime: windshield washer anti-
freeze).
See page 8:15.

2 Coolant level should be between the expansion tank marks. Mixture 50% \
anti-freeze and 50% water.
See page 8:16.

3 Power steering - When cold, the level must not be above the COLD mark \
and when hot is must not be
above the HOT mark. Top up if the level drops to the ADD mark with ATF f\
luid.
See page 8:12.

4 Engine oil level should be between the dipstick marks. The distance be\
tween the marks represents
file:///K|/ownersdocs/1996/1996_850/96850_906.htm (7 of 9)12/30/2006 9\
:59:57 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
approx. 1 US qt. (1 liter) or on certain models 1.6 US qts (1.5 liter\
s). See page 8:10.

5 Brake fluid - check, without removing the cap, that the level is above\
the MIN mark. Use brake fluid
DOT 4+.
See page 8:12.

* Engine oil should be checked each time the car is refuelled.

UNLEADED FUEL ONLY

VOLVO
Octane rating, see p. 4:3.

Tire pressure, see label located on rear edge of right front door.

Bulbs Power Socket US Bulb
No.
1 70 W P 20d HB3/9005
2 60 W P 22d HB4/90006
3 24/5
W BAY 15
d
1157NA
4 21 W BA 15 s 1156
5 21/4
W BAZ 15 d
-
6 5 W BA 15 s 67
file:///K|/ownersdocs/1996/1996_850/96850_906.htm (8 of 9)12/30/2006 9\
:59:57 AMClassic Cars & Cycles www.ClassicCycles.org