oil temperature VOLVO 850 1996 User Guide

1996 Volvo 850

A - Drain plug, B - Oil filter, C - Oil dipstick, D - Oil filler cap
WARNING! Oil spilled on a hot exhaust pipe constitutes a fire
risk.
pg. 8:11 Engine oil (cont.)
Oil quality

Meeting API specification SG, SG/CD, SH or Energy Conserving (EC) II

For best fuel economy and engine protection consult with your authorized\
Volvo retailer for
recommended oils. Oils with a different quality rating may not provide a\
dequate engine protection.

Viscosity (stable ambient temperatures):

file:///K|/ownersdocs/1996/1996_850/96850_806.htm (8 of 11)12/30/2006 \
9:59:52 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850

Do not use oils with other viscosity ratings. The use of incorrect visco\
sity oil can shorten engine life.
Volvo recommends the use of energy-conserving oils. Look for the API lab\
el. Synthetic oils complying
with oil quality requirements are recommended for: Driving in areas of s\
ustained temperature extremes
(hot or cold), when towing a trailer over long distances or for a prol\
onged driving in mountainous areas.
Extra oil additives must not be used unless advised by an authorized Vol\
vo retailer.
SAE 15W/40 is recommended for use in driving conditions that raise oil t\
emperature and increase oil
consumption (i.e., mountain driving, trailer towing).

NOTE: SAE 15W-40 must not be used at low ambient temperatures; see visco\
sity chart.

Changing oil and oil filter

Oil and oil filter changes should be made as specified in the following \
table:
If driving conditions include: Then the correct oil/oil filter change interval
is:
l Extended periods of idling and/or low-speed
operation
l Frequent short trips less than 7 miles 11 km
l Extended periods of driving in dusty and/or sandy
areas
l Trailer towing
l Driving in mountainous areas EVERY
5,000 miles= 8,000 km
OR EVERY 6 MONTHS,
WHICHEVER COMES FIRST
l Primarily highway driving
l Frequent trips of longer than 7 miles = 11 km
EVERY
10,000 miles = 16,000 km
5,000 miles= 8,000 km *
OR EVERY 12 MONTHS,
WHICH EVER COMES FIRST
* Turbo models

file:///K|/ownersdocs/1996/1996_850/96850_806.htm (9 of 11)12/30/2006 \
9:59:52 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850



American Petroleum Institute (API) labels. These labels certify the oi\
l conforms to the
applicable standards and specifications of the API.
pg. 8:12 Power steering fluid, Brake/clutch fluid reservoir

Power steering fluid

The dipstick has marks for checking hot and cold oil. The oil level when\
the engine is cold must never
be higher than the COLD mark. After the engine has reached normal operat\
ing temperature, the level
may not be higher than the HOT mark. Top up when the level is at the ADD\
mark.
Check the level at every service.

Fluid type: ATF
Replace: no fluid change required.

Brake and clutch systems

The brake and clutch systems share the same fluid reservoir. The fluid l\
evel should be between the MIN
file:///K|/ownersdocs/1996/1996_850/96850_806.htm (10 of 11)12/30/2006\
9:59:52 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
pg. 8:13 Automatic transmission fluid

Check the oil level as follows:

Park the car on a level surface with the engine idling . Slowly move the\
gear selector lever through all
the shift positions and then to position P. Wait 3 minutes before checki\
ng the oil level.
As the illustration shows, the dipstick has a COLD and a HOT side. The o\
il level should between the
MIN and MAX marks. Wipe the dipstick with a clean cloth.
WARNING! The oil may be very
hot.

Do not use rags that could leave lint on the dipstick. The transmission \
is topped up via the dipstick tube.
The space between the MIN and MAX marks on the dipstick corresponds to 0\
.5 US qt. (0.5 liter). Do
not fill the transmission with too much oil, since this can result in oi\
l being ejected from the
transmission. Too little oil, on the other hand, can negatively affect t\
ransmission operation, particularly
in very cold weather.

A Cold transmission: oil temperature 105° F (40° C). This is a n\
ormal temperature for the transmission
after idling for about 10 minutes. At oil temperatures below 105° F (\
40° C), the level may be below the
MIN mark.
B Warm transmission: oil temperature 169° F (80° C). This temper\
ature after driving for about 30
minutes. At oil temperatures above 190° F (90° C), the level may\
be above the MAX mark.

Fluid type: ATF Dexron IIE/III and Mercon.
file:///K|/ownersdocs/1996/1996_850/96850_813.htm (1 of 7)12/30/2006 9\
:59:53 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850

Normally, the coolant does not need to be changed. If the system must be\
drained, use the following
procedure:
1 Remove the expansion tank cap.
2 Move the temperature adjustment control to max. heat. Open the drain c\
ocks at the rear left of the
engine block and at the bottom right corner of the radiator.
3 Disconnect the lower right radiator hose.
Filling:
4 Close the drain cocks and reconnect the hose.
5 Fill the expansion tank to the MAX mark or slightly above.
6 Run the engine until hot. Check the cooling system connections for tig\
htness. Recheck the coolant
level.

Capacity: Approx. 7.6 US qts. (7.2 liters)
Turbo - 7.4 US qts. (7.0 liters)

Coolant: Volvo Genuine Coolant/Antifreeze only

NOTE: Do not top up with water only. Water by itself reduces the rust-pr\
otective and anti-freeze
qualities of the coolant and has a lower boiling point. It can also caus\
e damage to the cooling system if it
should freeze.
WARNING: If the engine is warm and you are going to top up coolant, unsc\
rew the cap slowly in
order to allow any excess pressure to escape.
file:///K|/ownersdocs/1996/1996_850/96850_813.htm (5 of 7)12/30/2006 9\
:59:53 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
CAUTION: The cooling system must always be kept filled to correct level.\
If it is not kept filled, there
can be high local temperatures in the engine which could result in damag\
e. Different types of anti-
freeze/coolant may not be mixed.
pg. 8:17 Engine compartment
Engine compartment 850
(engine B 5254 S / B 5252 S)


1 Expansion tank, coolant
2 Engine designation plate
3 Oil filler cap, engine
4 Clutch/brake system fluid reservoir
5 Fuse box
6 Washer fluid reservoir
7 Power steering fluid reservoir
8 Dipstick - engine oil
9 Dipstick - automatic transmission
10 Air cleaner
11 Battery
12 Data plate
WARNING! The cooling fan may start or continue to operate (for up to 6 \
minutes) after the engine has
been switched off.
pg. 8:18 Engine compartment (cont.)
Engine compartment 850 Turbo
(engine B 5234 T)
1 Expansion tank, coolant
2 Engine designation plate
3 Oil filler cap, engine
4 Clutch/brake system fluid reservoir
5 Fuse box
6 Washer fluid reservoir
7 Power steering fluid reservoir
8 Dipstick - engine oil
file:///K|/ownersdocs/1996/1996_850/96850_813.htm (6 of 7)12/30/2006 9\
:59:53 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
Specifications
pg. 9:1 Specifications
Specifications

This chapter contains facts and figures pertaining to the technical spec\
ifications of your car.

9:2 Oil/Fluids specifications
9:3Engine specifications
9:4Cooling/fuel distributor ignition systems
9:4Front/rear suspensions
9:5Transmission, Capacities, Vehicle
loading
9:6
Electrical system/bulbs
9:7Dimensions and weights
9:8Service manuals, Road assistance
pg. 9:2 Oil/Fluids Specifications
Oil quality

Meeting API specification SG, SG/CD, SH or Energy Conserving (EC) II \
For best fuel economy and engine protection, consult with your authorize\
d Volvo retailer for
recommended oils. Oil with a different quality rating may not provide ad\
equate engine protection.
Synthetic oils complying with oil quality requirements are recommended. \
Volvo recommends the use of
fuel economy improving oils. Look for the API label.
Synthetic oils complying with oil quality requirements are recommended f\
or: Driving in areas of
sustained temperature extremes (hot or cold), when towing a trailer ov\
er long distances or for prolonged
driving in mountainous areas.
Extra oil additives must not be used unless advised by an authorized Vol\
vo retailer.

Viscosity (stable ambient temperatures):
file:///K|/ownersdocs/1996/1996_850/96850_901.htm (1 of 7)12/30/2006 9\
:59:55 AMClassic Cars & Cycles www.ClassicCycles.org