lock VOLVO 850 1996 Manual PDF

1996 Volvo 850
28 Cruise control, heated rear windows, seat belt reminder light,
bulb failure warning sensor, shiftlock 10A
29 ABS 15A
30 Cigarette lighter 10A
31 ECC blower (speeds 1-3), ECC, AC-compressor 25A
32 Audio system, remote controlled central locking 10A

Location * Amperage
33 Rear window wiper/washer (wagons) 15A
34 Windshield/headlight wipers/washers, horn 25A
35 Instrument panel lights, power sun roof 10A
36 –
37 Power windows, power sun roof AUT/CB **
38 –
39 Power seat (driver's side) AUT/CB **
40 Power seat (passenger's side) AUT/CB **
* Some of the equipment/systems listed may be available on certain model\
s only.
** This is an automatic circuit breaker located in the fuse box and does\
not normally need to be
replaced.

For more detailed information concerning function and location of relays\
, fuses, etc., refer to the Volvo
Service Manuals. These can be purchased directly using the Service Liter\
ature Brochure/Order Form or
through your Volvo retailer. pg. 6:15 Installation of accessories
file:///K|/ownersdocs/1996/1996_850/96850_613.htm (3 of 8)12/30/2006 9\
:59:46 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850

Shiftlock release (automatic transmission only)

The gear selector is locked in the (P)ark position. To manually releas\
e the shiftlock:
l Turn the starting (ignition) key to position I
l Press firmly on the "SHIFTLOCK OVERRIDE" button located to the right of \
the base of the gear
selector
l While holding the override button down, press the button on the front of\
the gear selector
l Move the selector from the ( P )ark position.


Fuel tank cover does not open

Faulty motor in fuel tank cover
(Sedans):
Open the cover panel on the right tail light unit and pull on the hook. \

The fuel tank cover can then be opened.
(Wagons):
file:///K|/ownersdocs/1996/1996_850/96850_613.htm (7 of 8)12/30/2006 9\
:59:46 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
l Wash off the dirt from the underside (wheel housings fenders, etc.).
l In areas of high industrial fallout, more frequent washing is recommende\
d.
CAUTION: During high pressure washing the spray mouth piece must never b\
e closer to the vehicle
than 13" (30 cm). Do not spray into the locks.

l When washing or steam cleaning the engine, avoid spraying water or steam\
directly on the electrical
components or toward the rear side of the engine.
l After cleaning the engine, the spark plug wells should be inspected for \
water and blown dry if
necessary.

Suitable detergents

Special car washing detergents or liquid dishwashing detergent can be us\
ed. A suitable mixture is about
2.5 fl. oz. (8.5 cl) of detergent to 2.6 US gal. (10 liters) of warm\
water. After washing with a detergent
the car should be well rinsed with clean water.

Bird droppings

Remove from paintwork as soon as possible. Otherwise the finish may be p\
ermanently damaged.

WARNING!
l When the car is driven immediately after being washed, apply the brake s\
everal times in order to
remove any moisture from the brake linings.
l Engine cleaning agents should not be used when the engine is warm. This \
constitutes a fire risk.


NOTE: When washing the car, remember to remove dirt from the drain holes\
in the doors and sills.
file:///K|/ownersdocs/1996/1996_850/96850_701.htm (5 of 8)12/30/2006 9\
:59:48 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
No. Lubrication point lubricant No. Lubrication point lubricant
1 Hood lock and latch Oil 6 Window winder (on
inside of door) Oil, grease, low
temperature grease
2 Door stop and hinges Oil 7 Front seat slide rail
and latch Oil
3 Sun roof wind
deflector Oil
Low temperature
grease
8
Door locks Volvo teflon lock
spray
4 Door lock catch plate Oil
5 Trunk/tailgate lid lock Low temperature
grease
To avoid rattles and unnecessary wear, the body should be lubricated at \
regular service intervals. This
should be done by an authorized Volvo retailer.
pg. 8:10 Engine oil
Checking the oil level

The oil level should be checked every time the car is refuelled. This is\
especially important during the
engine break-in period (up to the first service).
CAUTION : Not checking the oil level regularly can result in serious eng\
ine damage if the oil
becomes too low.
file:///K|/ownersdocs/1996/1996_850/96850_806.htm (6 of 11)12/30/2006 \
9:59:52 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850

Normally, the coolant does not need to be changed. If the system must be\
drained, use the following
procedure:
1 Remove the expansion tank cap.
2 Move the temperature adjustment control to max. heat. Open the drain c\
ocks at the rear left of the
engine block and at the bottom right corner of the radiator.
3 Disconnect the lower right radiator hose.
Filling:
4 Close the drain cocks and reconnect the hose.
5 Fill the expansion tank to the MAX mark or slightly above.
6 Run the engine until hot. Check the cooling system connections for tig\
htness. Recheck the coolant
level.

Capacity: Approx. 7.6 US qts. (7.2 liters)
Turbo - 7.4 US qts. (7.0 liters)

Coolant: Volvo Genuine Coolant/Antifreeze only

NOTE: Do not top up with water only. Water by itself reduces the rust-pr\
otective and anti-freeze
qualities of the coolant and has a lower boiling point. It can also caus\
e damage to the cooling system if it
should freeze.
WARNING: If the engine is warm and you are going to top up coolant, unsc\
rew the cap slowly in
order to allow any excess pressure to escape.
file:///K|/ownersdocs/1996/1996_850/96850_813.htm (5 of 7)12/30/2006 9\
:59:53 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
Engine

Liquid-cooled gasoline, 5-cylinder, in-line engine. Aluminum alloy cylin\
der block with cast-iron
cylinder liners cast directly into block. Aluminum alloy cylinder head w\
ith double overhead camshafts
and separate intake and outlet channels.
Engine lubrication is provided by an eccentric pump driven from the cran\
kshaft. Full-flow type oil filter.
Exhaust emission control accomplished by fuel injection, heated oxygen s\
ensor(s) and three-way
catalytic converter
Designation Volvo B 5252 S Volvo B 5234
850 R Turbo Volvo B 5254 S Volvo B 5234 T
Turbo
Output 142 hp at 5400
rpm (106 kw/90
rps) 222 hp at 5280
rpm* (166 km/88
rps)* 168 hp at 6200
rpm (125 kw 103
rps) 222 hp at 5280
rpm (166 km/88
rps)
Max torque 152 lbs. at 3600
rpm (206 Nm/60
rps) 221 ft. lbs. at 2000-
5280 rpm (300
Nm/33-88 rps)* 162.3 ft. lbs. at
4700 rpm (220
Nm/55 rps) 221 ft. lbs. at 2000-
5280 rpm (300
Nm/33-88 rps)
Number of
cylinders 5
5 5 5
Bore 3.27" (83 mm) 3.19" (81 mm) 3.27" (83 mm) 3.19" (81 mm)
Stroke 3.54" (90 mm) 3.54" (90 mm) 3.54" (90 mm) 3.54" (90 mm)
Displacement 2.4 liters 2.3 liters 2.4 liters 2.3 liters
Compression ratio 10.0:1 8.5:1 10.5:1 8.5:1
Number of valves 10 20 20 20
Valve clearance Self-adjusting Self-adjusting Self-adjusting Self-adjusting

* The 850 R turbo engine generates increased power on cars equipped with\
an automatic transmission
file:///K|/ownersdocs/1996/1996_850/96850_901.htm (3 of 7)12/30/2006 9\
:59:55 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
1st gear 3.07:1
2nd gear 1.77:1
3rd gear 1.19:1
4th gear 0.87:1
5th gear 0.70:1
Reverse 2.99:1

Automatic transmission: AW 50-42 LE
4-speed automatic electronically controlled gearbox comprising a hydraul\
ic torque converter with a lock-
up function; planetary gear, integrated final drive.
Operation via a floor mounted gear selector lever. Drive shafts with sym\
metrical joint location.

Final drive ratio 2.74:1 (Turbo: 2.54:1)
Reduction ratios
1st gear 3.61:1
2nd gear 2.06:1
3rd gear 1.37:1
4th gear 0.98:1
Reverse 3.95:1

Capacities

Fuel tank 19.3 US gals (73 liters)
Cooling System 7.4 US qts. (7.0 liters)
Engine oil (incl. filter) 5.6 US qts. (5.3 liters)*
Automatic transmission 2 US gals (7.6 liters)
Manual transmission 2.2 US qts. (2.1 liters)
Power steering fluid 0.8 US qts. (0.8 liter)
Washer fluid reservoir 3.2 US qts. (3.0 liters)
Brake/clutch system 0.6 US qts (0.6 liters)

* Certain models: 6.1 US qts. (5.8 liters)
Turbo: Add 0.95 US qt. (0.9 liters) if the oil cooler has been drained\
.

Vehicle Loading

file:///K|/ownersdocs/1996/1996_850/96850_901.htm (6 of 7)12/30/2006 9\
:59:55 AMClassic Cars & Cycles www.ClassicCycles.org