maintenance VOLVO C70 CONVERTIBLE 2007 Owner´s Manual

2007 Volvo C70
2 0 0 7
VOLVO C70
184 09 Maintenance and servicing
Volvo maintenance
186
Maintaining your vehicle
187
Hood
189
Engine compartment
190
Engine oil
191
Fluids
193
Wiper blades
195
Battery
196
Bulbs
198
Replacing bulbs
199
Fuses
208
185 09 Maintenance and servicing
186 09 Maintenance and servicing
Volvo maintenance
file:///K|/delme/2007_C70/07c70_09.htm (1 of 36)12/22/2006 9:15:54 PM

2007 Volvo C70
General
Volvo advises you to follow the maintenance program outlined in the Warr\
anty and Service Records
Information booklet. This maintenance program contains inspections and s\
ervices necessary for the
proper function of your vehicle. The maintenance services contain severa\
l checks that require special
tools and training, and therefore must be performed by a qualified techn\
ician. To keep your Volvo in top
condition, specify time-tested and proven Genuine Volvo Parts and Access\
ories.
The Federal Clean Air Act - U.S
The Federal Clean Air Act requires vehicle manufacturers to furnish writ\
ten instructions to the ultimate
purchaser to assure the proper servicing and function of the components \
that control emissions. These
services, which are listed in the "Warranty and Service Records Informat\
ion" booklet, are not covered by
the warranty. You will be required to pay for labor and material used.
Maintenance
Your Volvo passed several major inspections before it was delivered to y\
ou, in accordance with Volvo
specifications. The maintenance procedures outlined in the Warranty and \
Service Records Information
booklet, many of which will positively affect your vehicle's emissions, \
should be performed as indicated.
It is recommended that receipts for vehicle emission maintenance be reta\
ined in case questions arise
concerning maintenance. Inspection and maintenance should also be perfor\
med anytime a malfunction is
observed or suspected.
Applicable warranties - U.S/Canada
In accordance with applicable U.S. and Canadian regulations, the followi\
ng list of warranties is provided.
l New Vehicle Limited Warranty
l Parts and Accessories Limited Warranty
l Corrosion Protection Limited Warranty
l Seat Belt and Supplemental Restraint Systems Limited Warranty
l Emission Design and Defect Warranty
l Emission Performance Warranty
These are the federal warranties; other warranties are provided as requi\
red by state/provincial law. Refer
to your separate Warranty and Service Records Information booklet for de\
tailed information concerning
each of the warranties.
Periodic maintenance helps minimize emissions
file:///K|/delme/2007_C70/07c70_09.htm (2 of 36)12/22/2006 9:15:54 PM

2007 Volvo C70
Periodic maintenance will help keep your vehicle running well. Your Warr\
anty and Service Records
Information booklet provides a comprehensive periodic maintenance schedu\
le up to 150,000 miles
(240,000 km) of vehicle maintenance. The schedule includes components \
that affect vehicle emissions.
This page describes some of the emission-related components.
Vehicle Event Data (Black Box)
Your vehicle's driving and safety systems employ computers that monitor,\
and share with each other,
information about your vehicle's operation. One or more of these compute\
rs may store what they monitor,
either during normal vehicle operation or in a crash or near-crash event\
. Stored information may be read
and used by:
l Volvo Car Corporation
l service and repair facilities
l law enforcement or government agencies
l others who may assert a legal right to know, or who obtain your consent \
to know such information.
187 09 Maintenance and servicing
Maintaining your vehicle
Owner maintenance
Periodic maintenance requirements and intervals are described in your ve\
hicle's Warranty and Service
Records Information booklet.
The following points can be carried out between the normally scheduled m\
aintenance services.
Each time the car is refueled:
l Check the engine oil level
l Clean the windshield, windshield wipers, headlights, and taillights
Monthly:
l Check cold tire pressure in all tires. Inspect the tires for wear.
l Check that engine coolant and other fluid levels are between the indicat\
ed "min" and "max" markings.
l Clean interior glass surfaces with a glass cleaner and soft paper towels\
.
l Wipe driver information displays with a soft cloth.
l Visually inspect battery terminals for corrosion. Corrosion may indicate\
a loose terminal connector, or
a battery near the end of its useful service life. Consult your Volvo re\
tailer for additional information.
As needed:
l Wash the car, including the undercarriage, to reduce wear that can be ca\
used by a buildup of dirt, and
file:///K|/delme/2007_C70/07c70_09.htm (3 of 36)12/22/2006 9:15:54 PM

2007 Volvo C70
corrosion that can be caused by salt residues.
l Clean leaves and twigs from air intake vents at the base of the windshie\
ld, and from other places where
they may collect.
NOTE
Complete service information for qualified technicians is available onli\
ne for purchase or subscription at
www.volvotechinfo.com.
188 09 Maintenance and servicing
Maintaining your vehicle
Emission inspection readiness
What is an Onboard Diagnostic System (OBD II)?
OBD II is part of your vehicle's computerized engine management system. \
It stores diagnostic
information about your vehicle's emission controls. It can light the Che\
ck Engine light (MIL) if it detects
an emission control "fault." A "fault" is a component or system that is \
not performing within an expected
range. A fault may be permanent or temporary. OBD II will store a messag\
e about any fault.
How Do States Use OBD II for Emission Inspections?
Many states connect a computer directly to a vehicle's OBD II system. Th\
e inspector can then read
"faults." In some states, this type of inspection has replaced the tailp\
ipe emission test.
How Can My Vehicle Fail OBD II Emission Inspection?
Your vehicle can fail OBD II emission inspection for any of the followin\
g reasons.
l If your Check Engine (MIL) light is lit, your vehicle may fail inspect\
ion.
l If your vehicle's Check Engine light was lit, but went out without any a\
ction on your part, OBD II will
still have a recorded fault. Your vehicle may pass or fail, depending on\
the inspection practices in your
area.
l If you had recent service that required disconnecting the battery, OBD I\
I diagnostic information may be
incomplete and "not ready" for inspection. A vehicle that is not ready m\
ay fail inspection.
How Can I Prepare for My Next OBD II Emission Inspection?
l If your Check Engine (MIL) light is lit - or was lit but went out with\
out service, have your vehicle
diagnosed and, if necessary, serviced by a qualified Volvo technician.
l If you recently had service for a lit Check Engine light, or if you had \
service that required
disconnecting the battery, a period of driving is necessary to bring the\
OBD II system to "ready" for
inspection. A half-hour trip of mixed stop-and-go/highway driving is typ\
ically needed to allow OBD II to
reach readiness. Your Volvo retailer can provide you with more informati\
on on planning a trip.
file:///K|/delme/2007_C70/07c70_09.htm (4 of 36)12/22/2006 9:15:54 PM

2007 Volvo C70
l Maintain your vehicle in accordance with your vehicle's maintenance sche\
dule.
189 09 Maintenance and servicing
Hood
Opening the hood
To open the hood:
1. Pull the lever located under the left side of the dash to release the\
hood lock.
2. Lift the hood slightly.
3. Press up the release control located under the front edge of the hood\
(at the center) up to the right, and
lift the hood.
WARNING
Check that the hood locks engage properly when
closed.
190 09 Maintenance and servicing
Engine compartment
file:///K|/delme/2007_C70/07c70_09.htm (5 of 36)12/22/2006 9:15:54 PM

2007 Volvo C70
1. Cooling system expansion tank
2. Power steering fluid reservoir (concealed behind the headlight)
3. Dipstick - engine oil
4. Radiator
5. Cooling fan
6. Washer fluid reservoir
7. Engine oil filler cap
8. Brake/clutch fluid reservoir
9. Battery
10. Relay/fuse box
11. Air cleaner
WARNING
The cooling fan may start or continue to operate (for up to 6 minutes)\
after the engine has been switched
off.
191 09 Maintenance and servicing
Engine oil
Changing engine oil and oil filter
See
page 239 for oil specifications. Refer to the Warranty and Service Records Infor\
mation booklet for
information on the oil change intervals.
file:///K|/delme/2007_C70/07c70_09.htm (6 of 36)12/22/2006 9:15:54 PM

2007 Volvo C70
Volvo recommends .
NOTE
Volvo does not recommend the use of oil additives.
l Synthetic oil is not used when the oil is changed at the normal maintena\
nce intervals except at owner
request and at additional charge. Please consult your Volvo retailer.
Checking and adding oil
The oil level should be checked every time the vehicle is refueled. This\
is especially important during the
period up to the first scheduled maintenance service
l The car should be parked on a level surface when the oil is checked.
l If the engine is warm, wait for at least 10-15 minutes after the engine has been switched off \
before
checking the oil.
Checking the oil
1. Pull out the dipstick and wipe it with a lint-free rag.
2. Reinsert the dipstick, pull it out, and check the oil level.
3. Add oil if necessary. If the level is close to the MIN mark, add appr\
oximately 1 US quart (1 liter) of oil.
4. Run the engine until it reaches normal operating temperature.
5. Switch off the engine and wait for at least 10-15 minutes and recheck\
the oil level. If necessary, add oil
until the level is near the MAX mark.
file:///K|/delme/2007_C70/07c70_09.htm (7 of 36)12/22/2006 9:15:54 PM

2007 Volvo C70
CAUTION
l Not checking the oil level regularly can result in serious engine damage\
if the oil level becomes too
low.
l Oil that is lower than the specified quality can damage the engine.
l Always add oil of the same type and viscosity as already used.
l Never fill oil above the MAX mark. This could cause an increase in oil c\
onsumption.
192 09 Maintenance and servicing
Engine oil
WARNING
Do not allow oil to spill onto or come into contact with hot exhaust pip\
e
surfaces
NOTE
Volvo uses different systems to indicate a low oil level or pressure. So\
me models have an oil pressure
sensor, in which case a warning symbol (see
page 48) is used to indicate low oil pressure. Other models
have an oil level sensor, in which case the driver is alerted by the war\
ning symbol in the center of the
instrument panel and a text in the information display. Some models use \
both systems. Contact an
authorized Volvo retailer for more information.
file:///K|/delme/2007_C70/07c70_09.htm (8 of 36)12/22/2006 9:15:54 PM

2007 Volvo C70
193 09 Maintenance and servicing
Fluids
Washer fluid
The washer fluid reservoir is located in the engine compartment and hold\
s approximately 6.8 US qts (6.5
liters). During cold weather, the reservoir should be filled with winds\
hield washer solvent containing
antifreeze.
Coolant
Normally, the coolant does not need to be changed. If the system must be\
drained, consult your Volvo
file:///K|/delme/2007_C70/07c70_09.htm (9 of 36)12/22/2006 9:15:54 PM

2007 Volvo C70
retailer.
NOTE
Do not top off with water only. This reduces the rust-protective and ant\
ifreeze qualities of the coolant
and has a lower boiling point. It can also cause damage to the cooling s\
ystem if it should freeze. Top off
with Volvo Genuine Coolant/Antifreeze only (a 50/50 mix of water and an\
tifreeze).
CAUTION
The cooling system must always be kept filled to the correct level, and \
the level must be between the
MIN and MAX marks. If it is not kept filled, there can be high local tem\
peratures in the engine which
could result in damage. Different types of antifreeze/coolant may not be\
mixed. Check coolant
regularly!
WARNING
Never remove the radiator cap while the engine is warm. Wait until the v\
ehicle cools. If it is necessary
to top off the coolant when the engine is warm, unscrew the expansion ta\
nk cap slowly so that the
overpressure dissipates.
194 09 Maintenance and servicing
Fluids
Brake fluid
file:///K|/delme/2007_C70/07c70_09.htm (10 of 36)12/22/2006 9:15:54 PM\