brake fluid VOLVO C70 CONVERTIBLE 2007 Owner´s Manual

2007 Volvo C70

09 Maintenance and servicing
Volvo maintenance
186
Maintaining your vehicle
187
Hood
189
Engine compartment
190
Engine oil
191
Fluids
193
Wiper blades
195
Battery
196
Bulbs
198
Replacing bulbs
199
Fuses
208

10 Audio
Audio functions
218
Radio functions
221
CD player/CD changer (option)
227
Audio menu
231

11 Specifications
Label information
234
Dimensions and weights
236
Fluids
238
Engine oil
239
Engine specifications
241
Electrical system
242
Volvo programs
244
6 Introduction
General information
Shiftlock (automatic transmission)
When your car is parked, the gear selector is locked in the Park (P) position. To release the selector from this position, turn the igniti\
on
key to position II (or start the engine), depress the brake pedal, pre\
ss the button on the front side of the gear selector and move the selector
from Park (P).
Keylock (automatic transmission)
When the ignition is switched off, the gear selector must be in the Park\
(P) position before the key can be removed from the ignition
switch.
Anti-lock Brake System (ABS)
The ABS system in your car performs a self-diagnostic test when the vehi\
cle first reaches the speed of approximately 12 mph (20 km/ h).
The brake pedal will pulsate several times and a sound may be audible fr\
om the ABS control module. This is normal.
Fuel filler door
Press the button on the light switch panel when the car is at a standsti\
ll to open the fuel filler door.
Fuel filler cap
After refueling, close the fuel filler cap by turning it clockwise until\
it clicks into place. If this cap is not closed tightly or if the engine is
running when the car is refueled, the Malfunction Indicator Lamp ("Chec\
k Engine" light) may indicate a fault.
Points to keep in mind
l Before you operate your vehicle for the first time, please familiarize y\
ourself with the new-engine oil consumption information on page
191. You should also be familiar with the information found in the chapters\
"Instruments and controls," and "Starting and driving."
l Information contained in the balance of the manual is extremely useful a\
nd should be read after operating the vehicle for the first time.
l The manual is structured so that it can be used for reference. For this \
reason, it should be kept in the vehicle for ready access.
l Do not export your Volvo to another country before investigating that co\
untry's applicable safety and emission control requirements. In
some cases it may be difficult or impossible to comply with these requir\
ements. Modifications to the emission control system(s) may
render your Volvo not certifiable for legal operation in the U.S., Canad\
a and other countries.
l All information, illustrations and specifications contained in this manu\
al are based on the latest product information available at the
file:///K|/delme/2007_C70/07c70_00.htm (4 of 7)12/22/2006 9:15:34 PM

2007 Volvo C70
time of publication. Please note that some vehicles may be equipped diff\
erently, depending on special legal requirements. Optional
equipment described in this manual may not be available in all markets. \
l Volvo reserves the right to make model changes at any time, or to change\
specifications or design without notice and without incurring
obligation.
WARNING
If your vehicle is involved in an accident, unseen damage may affect its\
drivability and
safety.
WARNING
CALIFORNIA proposition 65
Engine exhaust, some of its constituents, and certain vehicle components\
contain or emit chemicals known to the state of California to
cause cancer, and birth defects or other reproductive harm. In addition,\
certain fluids contained in vehicles and certain products of
component wear contain or emit chemicals known to the State of Californi\
a to cause cancer, and birth defects or other reproductive
harm.
7 Introduction
Volvo and the environment
Volvo is committed to the well being of its customers. As a natural part\
of this commitment, we care about the environment in which we
all live. Caring for the environment means an everyday involvement in re\
ducing our environmental impact. Volvo's environmental
activities are based on a holistic view, which means we consider the ove\
rall environmental impact of a product throughout its complete
life cycle. In this context, design, production, product use, and recycl\
ing are all important considerations. In production, Volvo has partly
or completely phased out several chemicals including CFCs, lead chromate\
s, asbestos, and cadmium; and reduced the number of
chemicals used in our plants 50% since 1991.
Volvo was the first in the world to introduce into production a three-wa\
y catalytic converter with a Lambda sond, now called the heated
oxygen sensor, in 1976. The current version of this highly efficient sys\
tem reduces emissions of harmful substances (CO, HC, NOx) from
the exhaust pipe by approximately 95-99% and the search to eliminate the\
remaining emissions continues. Volvo is the only automobile
manufacturer to offer CFC-free retrofit kits for the air conditioning sy\
stem of all models as far back as the 1975 model 240. Advanced
electronic engine controls and cleaner fuels are bringing us closer to o\
ur goal. After Volvo vehicles and parts have fulfilled their use,
recycling is the next critical step in completing the life cycle. The me\
tal content is about 75% of the total weight of a vehicle, which makes
the vehicle among the most recycled industrial products. In order to hav\
e efficient and well controlled recycling, all Volvo variants have
printed dismantling manuals, indicating the weight and material of indiv\
idual components. For Volvo, all homogeneous plastic parts
weighing more than 3.4 oz. (100 grams) are marked with international s\
ymbols that indicate how the component is to be sorted for
recycling. In addition to continuous environmental refinement of convent\
ional gasoline-powered internal combustion engines, Volvo is
actively looking at advanced technology alternative-fuel vehicles.
When you drive a Volvo, you become our partner in the work to lessen the\
car's impact on the environment. To reduce your vehicle's
environmental impact, you can:
l Maintain proper air pressure in your tires. Tests have shown decreased f\
uel economy with improperly inflated tires.
l Follow the recommended maintenance schedule in your Warranty and Service\
Records Information booklet.
l Drive at a constant speed whenever possible.
l See a trained and qualified Volvo service technician as soon as possible\
for inspection if the check engine (malfunction indicator) light
illuminates, or stays on after the vehicle has started.
l Properly dispose of any vehicle-related waste such as used motor oil, us\
ed batteries, brake pads, etc.
l When cleaning your vehicle, please use genuine Volvo car care products. \
All Volvo car care products are formulated to be
environmentally friendly.
For additional information regarding the environmental activities in whi\
ch Volvo Cars of North America, LLC and Volvo Car Corporation
file:///K|/delme/2007_C70/07c70_00.htm (5 of 7)12/22/2006 9:15:34 PM

2007 Volvo C70
4. Oil pressure warning light1

If the light comes on while driving, stop the car, stop the engine immed\
iately, and check the engine oil level. If the oil
level is normal and the light stays on after restart, have the car towed\
to the nearest trained and qualified Volvo
service technician. After hard driving, the light may come on occasional\
ly when the engine is idling. This is normal,
provided it goes off when the engine speed is increased.
5. Seat belt reminder
See page 16 for detailed information.
6. Generator warning light

If the light comes on while the engine is running, have the charging sys\
tem checked by a trained and qualified Volvo
service technician.
7. Brake failure warning light

If this light comes on while driving or braking, stop the car as quickly\
as possible in a safe place, open the hood, and
check
1 On certain engines, this symbol is not used to indicate low oil pressur\
e. Instead, a text warning is provided in the information
display, see also
page 192.
52 02 Instruments and controls
Symbols - instrument panel
the brake fluid level in the reservoir. See page 190 for the location of the reservoir.
file:///K|/delme/2007_C70/07c70_02.htm (11 of 43)12/22/2006 9:15:42 PM\

2007 Volvo C70
NOTE
Canadian models are equipped with the second
symbol.
WARNING
If the fluid level is below the MIN mark in the reservoir or if a "Brake failure - Service urgent" message \
is
displayed in the information display: DO NOT DRIVE. Have the car towed to a trained and qualified Volvo service
technician and have the brake system inspected.
If the fluid level is below the MIN mark in the reservoir or if a "BRAKE FAILURE - SERVICE URGENT" message
is displayed in the information display: DO NOT DRIVE. Have the car towed to a trained and qualified Volvo service
technician and have the brake system inspected.

If the BRAKE and ABS warning lights come on at the same time, this could\
indicate a fault in the brake
system. In this case:
1. Stop the car in a suitable place and switch off the engine.
2. Restart the engine.
3. If both warning lights go off, no further action is required and the \
car can be driven.
4. If both lights remain on after the engine has been restarted, switch \
off the engine again and check the brake fluid
level. See
page 190 for the location of the reservoir.
Door open warning
The driver will be alerted if either door, the hood, or the trunk lid ar\
e open or ajar.
At low speeds

If the car is moving at a speed of less than approximately 4 m.p.h. (7 \
km/h), the Information symbol in the instrument
panel will light up and a message will be shown in the information displ\
ay indicating which door(s), etc is not
completely closed.
file:///K|/delme/2007_C70/07c70_02.htm (12 of 43)12/22/2006 9:15:42 PM\

2007 Volvo C70
l Check condition of drive belts.
l Check state of the battery's charge.
l Examine tires carefully (the spare tire as well), and replace those th\
at are worn. Check tire pressures.
l The brakes, front wheel alignment, and steering gear should be checked b\
y your Volvo retailer only.
l Check all lights, including high beams.
l Reflective warning triangles are legally required in some states/provinc\
es.
l Have a word with your Volvo retailer if you intend to drive in countries\
where it may be difficult to
obtain the correct fuel.
l Consider your destination. If you will be driving through an area where \
snow or ice are likely to occur,
consider snow tires.
1 To prevent injury from contact with hot surfaces, do not inspect your v\
ehicle's transmission fluid yourself. Have
your vehicle's transmission fluid level inspected by a qualified Volvo s\
ervice technician.
125 06 Starting and driving
Fuel requirements
Octane rating
Volvo engines are designed to achieve rated horsepower, torque, and fuel\
economy performance using
premium 91 octane fuel.
Volvo recommends premium for best performance, but using 87 octane or ab\
ove will not affect engine
reliability.
file:///K|/delme/2007_C70/07c70_06.htm (6 of 18)12/22/2006 9:15:48 PM

2007 Volvo C70
(Shiftlock). Manual transmission: the clutch must be fully depressed.
3. The vehicle is equipped with an autostart feature. Without touching t\
he throttle pedal, turn the key to
position III and release it. The starter motor will then operate automat\
ically (for up to ten seconds) until
the engine starts. If the engine fails to start, repeat this step.
NOTE
After a cold start, idle speed may be noticeably higher than normal for \
a short period. This is done to
help bring components in the emission control system to their normal ope\
rating temperature as quickly
as possible, which enables them to control emissions and help reduce the\
vehicle's impact on the
environment.
4. To release the gear selector from the Park (P) position, the engine must be running (or the ignition key
must be in position II) and the brake pedal must be depressed.
5. Select the desired gear. On models with an automatic transmission, th\
e gear engages after a very slight
delay which is especially noticeable when selecting R.
NOTE
l Immobilizer: If two of the keys to your vehicle are close together, e.g., on the sa\
me key ring when
you try to start the vehicle, this could cause interference in the immob\
ilizer system and result in the
vehicle not starting. If this should occur, remove one of the keys from \
the key ring before trying to start
the vehicle again.
l Keylock: Models equipped an automatic transmission have a keylock system. When \
the engine is
switched off, the gear selector must be in the Park (P) position before the key can be removed from the
ignition switch.
l When starting in cold weather, the transmission may shift up at slightly\
higher engine speeds than
normal until the automatic transmission fluid reaches normal operating t\
emperature.
l Do not race a cold engine immediately after starting. Oil flow may not r\
each some lubrication points
fast enough to prevent engine damage.
WARNING
Volvo's floor mats are specially manufactured for your car. They must be\
firmly secured in the clips on
the floor so that they cannot slide and become trapped under the pedals \
on the driver's side.
130 06 Starting and driving
file:///K|/delme/2007_C70/07c70_06.htm (13 of 18)12/22/2006 9:15:48 PM\

2007 Volvo C70
Starting the vehicle
CAUTION
Automatic transmission: The engine should be idling when you move the gear selector. Never
accelerate until after you feel the transmission engage! Accelerating im\
mediately after selecting a gear
will cause harsh engagement and premature transmission wear. Selecting P\
or N when idling at a
standstill for prolonged periods of time will help prevent overheating o\
f the automatic transmission
fluid.
WARNING
l Always place the gear selector in Park (manual transmission: first or r\
everse gear) and apply the
parking brake before leaving the vehicle.and apply the parking brake bef\
ore leaving the vehicle. Never
leave the vehicle unattended with the engine running.
l Always open garage doors fully before starting the engine inside a garag\
e to ensure adequate
ventilation. The exhaust gases contain carbon monoxide, which is invisib\
le and odorless but very
poisonous.
131 06 Starting and driving
Manual transmission
6-speed manual transmission (option on certain models)
Depress the clutch pedal completely when changing gears1.
file:///K|/delme/2007_C70/07c70_06.htm (14 of 18)12/22/2006 9:15:48 PM\

2007 Volvo C70
1. Cooling system expansion tank
2. Power steering fluid reservoir (concealed behind the headlight)
3. Dipstick - engine oil
4. Radiator
5. Cooling fan
6. Washer fluid reservoir
7. Engine oil filler cap
8. Brake/clutch fluid reservoir
9. Battery
10. Relay/fuse box
11. Air cleaner
WARNING
The cooling fan may start or continue to operate (for up to 6 minutes)\
after the engine has been switched
off.
191 09 Maintenance and servicing
Engine oil
Changing engine oil and oil filter
See
page 239 for oil specifications. Refer to the Warranty and Service Records Infor\
mation booklet for
information on the oil change intervals.
file:///K|/delme/2007_C70/07c70_09.htm (6 of 36)12/22/2006 9:15:54 PM

2007 Volvo C70
retailer.
NOTE
Do not top off with water only. This reduces the rust-protective and ant\
ifreeze qualities of the coolant
and has a lower boiling point. It can also cause damage to the cooling s\
ystem if it should freeze. Top off
with Volvo Genuine Coolant/Antifreeze only (a 50/50 mix of water and an\
tifreeze).
CAUTION
The cooling system must always be kept filled to the correct level, and \
the level must be between the
MIN and MAX marks. If it is not kept filled, there can be high local tem\
peratures in the engine which
could result in damage. Different types of antifreeze/coolant may not be\
mixed. Check coolant
regularly!
WARNING
Never remove the radiator cap while the engine is warm. Wait until the v\
ehicle cools. If it is necessary
to top off the coolant when the engine is warm, unscrew the expansion ta\
nk cap slowly so that the
overpressure dissipates.
194 09 Maintenance and servicing
Fluids
Brake fluid
file:///K|/delme/2007_C70/07c70_09.htm (10 of 36)12/22/2006 9:15:54 PM\

2007 Volvo C70
The brake fluid should always be between the MIN and MAX marks on the si\
de of the reservoir. Check,
without removing the cap, that there is sufficient fluid in the reservoi\
r.
Fluid type: DOT 4+ boiling point > 536°F (280°C), P/N 9437433
Replace: The fluid should be replaced according to the intervals specified in t\
he Warranty and Service
Records Information booklet. When driving under extremely hard condition\
s (mountain driving, etc), it
may be necessary to replace the fluid more often. Consult your Volvo ret\
ailer. Always entrust brake fluid
changing to an authorized Volvo retailer.
Power steering fluid
The fluid level is checked at each service interval.
Fluid type: Volvo power steering fluid or equivalent.
Replace: No fluid change required.
WARNING
If a problem should occur in the power steering system or if the vehicle\
has no electrical current and
must be towed, it is still possible to steer the vehicle. However, keep \
in mind that greater effort will be
required to turn the steering wheel.
195 09 Maintenance and servicing
file:///K|/delme/2007_C70/07c70_09.htm (11 of 36)12/22/2006 9:15:54 PM\