battery VOLVO S60 INSCRIPTION 2016 Owner´s Manual

||
10 Maintenance and servicing
10
296
Contains corrosive acid.
Risk of explosion
Recycle properly
NOTE
A used battery should be disposed of in an environmentally responsible manner. Con-sult your Volvo retailer or take the batteryto a recycling station.
Related information
•Battery – changing (p. 298)
• Battery – handling (p. 296)
• Battery – maintenance (p. 297)
Battery – handling
The battery's service life is affected by the number of starts, if it has been discharged,driving style, driving conditions, weather con-ditions ,etc.
Handling
• Check that the battery cables are cor- rectly connected and tightened.
• Never disconnect the battery when theengine is running (for example, whenreplacing the battery).
• If the battery is fully discharged a numberof times, this may shorten its service life.
• The service life of a battery is affected byfactors such as the number of starts, driv-ing conditions and climate. Extreme coldmay also further decrease the battery’sstarting capacity.
• Because the battery’s starting capacitydecreases with time, it may be necessaryto recharge it if the vehicle is not drivenfor an extended period of time or if thevehicle is usually only driven short dis-tances.
• Never use a quick charger to charge thebattery. Only traditional types of batterychargers should be used.
CAUTION
The infotainment system's energy-saving feature may not function correctly or at all,and/or a message may be displayed if abattery charger or jumper cables are notconnected properly.
• The negative terminal on the battery must
never be used to connect a
jumper cable or a battery charger.Only the ground point on the chassismay be used.
See Jump starting (p. 215) for an illustra- tion and additional information.
WARNING
• Never expose the battery to open flame or electric spark.
• Do not smoke near the battery.
• Battery fluid contains sulfuric acid. Donot allow battery fluid to contact eyes,skin, fabrics or painted surfaces. Ifcontact occurs, flush the affected areaimmediately with water. Obtain medi-cal help immediately if eyes are affec-ted.
NOTE
The life of the battery is shortened if it becomes discharged repeatedly.

10 Maintenance and servicing
10
297
Related information
•Battery – changing (p. 298)
• Battery – maintenance (p. 297)
• Battery – symbols (p. 295)
Battery – maintenance
Proper battery maintenance can help prolong its service life.
Maintenance
•Use a screw driver to open the caps or cover and a flashlight to inspect the level.
• If necessary, add distilled water. The levelshould never be above the indicator.
• The fluid level should be checked if thebattery has been recharged.
• After inspection, be sure the cap overeach battery cell or the cover is securelyin place.
• Check that the battery cables are cor-rectly connected and properly tightened.
• Never disconnect the battery when theengine is running, or when the key is inthe ignition. This could damage the vehi-cle's electrical system.
• The battery should be disconnected fromthe vehicle when a battery charger isused directly on the battery.
• To help keep the battery in good condi-tion, the vehicle should be driven for atleast 15 minutes a week or connected toa charger with an automatic chargingfunction.
• If the battery is fully discharged a numberof times, this may shorten its service life.Keeping the battery fully charged helpsprolong its service life. •
The service life of a battery is affected byfactors such as driving conditions and cli-mate. Extreme cold may also furtherdecrease the battery’s starting capacity.
• Because the battery’s starting capacitydecreases with time, it may be necessaryto recharge it if the vehicle is not drivenfor an extended period of time or if thevehicle is usually only driven short dis-tances.
CAUTION
•Always use distilled or deionized water (battery water).
• Never fill above the level mark in thecell.
Related information
•
Battery – changing (p. 298)
• Battery – handling (p. 296)
• Battery – symbols (p. 295)

10 Maintenance and servicing
10
298
Battery – changing
When changing batteries, be sure to use the correct battery for your vehicle. Consult aVolvo retailer or a trained and qualified Volvoservice technician.
Changing
WARNING
Connect and disconnect the positive and negative cables in the correct sequence.
RemovalSwitch off the ignition, remove the remote key from the ignition slot and wait at least5 minutes before disconnecting the battery sothat all information in the vehicle's electricalsystem can be stored in the control modules.
Open the clips on the front cover and remove the cover.
Release the rubber molding so that the rear cover is free.
Remove the rear cover by pulling it away.
Detach the black negative cable.
Detach the red positive cable
Detach the ventilation hose from the
battery
Loosen the screw holding the battery
clamp.
Move the battery to the side and lift it up.
WARNING
PROPOSITION 65 WARNING! Battery posts, terminals, and related accessories contain lead and lead com-pounds, chemicals known to the state ofCalifornia to cause cancer and reproduc-tive harm. Wash hands after handling.

10 Maintenance and servicing
10
}}
299
Installation1. Lower the battery into the battery box.
2. Move the battery inward and to the sideuntil it reaches the rear edge of the box.
3. Tighten the clamp that secures the bat- tery.
4. Connect the ventilation hose. > Be sure that it is correctly connectedto the battery and the vent in the vehi- cle's body.
5. Connect the red positive cable.
6. Connect the black negative cable.
7. Press in the rear cover. (See Removal).
8. Reinstall the molding. (See Removal).
9. Reinstall the front cover and secure it with the clips. (See Removal).
Related information
• Battery – handling (p. 296)
• Battery – symbols (p. 295)
Fuses – introduction
The fuses help protect the vehicle's electrical components from overloading. If an electrical component fails to function, this may be due to a blown fuse. The easiestway to see if a fuse is blown is to remove it. To do so:
1. Pull the fuse straight out. If a fuse is diffi-
cult to remove, a special fuse removal
tool is located on the inside of the engine compartment fusebox cover .
2. From the side, examine the curved metal wire in the fuse to see if it is intact.
If the wire is broken, insert a new fuse of the same color and amperage (written on thefuse). If fuses burn out repeatedly, have the electri- cal system inspected by a trained and quali-fied Volvo service technician.
WARNING
Never use metal objects or fuses with higher amperage than those stated on thefollowing pages. Doing so could seriouslydamage or overload the vehicle's electricalsystem.
Location of the fuseboxes
Fuses – engine compartment
The fuses in the engine compartment protect e.g., engine and brake functions.
PositionsThese fuses are all located in the engine com-partment box. Fuses in C are located under
A .
A decal on the inside of the cover shows thepositions of the fuses. • Fuses 1 – 15, 34 and 42 – 44 are relays/ circuit breakers and should only beremoved or replaced by a trained andqualified Volvo service technician.
• Fuses 16 – 33 and 35 – 41 may bechanged at any time when necessary.
There is a special fuse removal tool on the underside of the cover.
PosFunctionA
Circuit breaker: central electrical moduleunder the glove com- partment A50
Circuit breaker: central electrical moduleunder the glove com-partment50
60

10 Maintenance and servicing
10
307
PosFunctionA
Circuit breaker: fusebox A
under the glove compartment (see Fuses – glove compart-ment (p. 302))60
Circuit breaker: fusebox A
under the glove compartment (see Fuses – glove compart-ment (p. 302))60
60
Climate system blower40
––
––
Starter motor relay30
Internal diode50
Auxiliary battery70
Central electrical module: auxiliary battery referencevoltage, auxiliary batterycharging point15
Related information
• Fuses – engine compartment (p. 299)
• Fuses – glove compartment (p. 302)
• Fuses – cargo area/trunk (p. 305) •
Start/Stop – introduction (p. 221)

11 Specifications
11
326* Option/accessory, for more information, see Introduction.
Battery specifications
If the battery is replaced, replace it with a bat- tery of the same cold start capacity as theoriginal (see the decal on the battery).
General information
WARNING
PROPOSITION 65 WARNING! Battery posts, terminals, and related accessories contain lead and lead com-pounds, chemicals known to the state ofCalifornia to cause cancer and reproduc-tive harm. Wash hands after handling.
12 volt system with a voltage-regulated alter- nator. Single pole system in which the chas-sis and engine block are used as conductors.The negative terminal is connected to thechassis.
MotorVoltage (V)Cold start capacity
CCA (Cold Cranking Amperes) (A)
Engines with Start/Stop*12800 A
All other engines12520–800
A
AGM (Absorbed Glass Mat) batteries have to be used on models with Start/Stop

12 Index
12
332
A
ABS (anti-lock brake system).................. 230
Accessory installation warning.................. 23
Active chassis system............................. 141
Active high beams..................................... 77Active yaw control........................... 141, 142
Adaptive brake lights............................... 231
Adaptive cruise control.................... 150, 151Airbags disconnecting the front passenger’s
side....................................................... 36
front...................................................... 32
inflatable curtain................................... 41
side impact........................................... 39
Air conditioning........................................ 112
Air distribution.................................. 109, 114
Air distribution table................................. 116
Air vents................................................... 109
Alarm........................................ 136, 137, 138
All Wheel Drive......................................... 228
Ambient temperature sensor..................... 67
Anti-freeze....................................... 238, 288Anti-lock brake system warning light......................................... 63
Anti-lock Brake System (ABS)................. 230 Approach lighting.............................. 83, 127
Auto-dim rearview mirror........................... 89
Automatic locking retractor....................... 47Automatic transmission
Eco (driving function).......................... 226
Geartronic........................................... 218
general description..................... 216, 218
oil........................................................ 324
shiftlock override................................ 220
Axle weight.............................................. 261
B
Battery maintenance............................... 297, 298
remote key, replacing......................... 130
replacing............................................. 298
specifications...................................... 326
start/stop............................................ 326
warning symbols................................. 295
Blind Spot Information System (BLIS)..... 204 Cross Traffic Alert (CTA)..................... 206
Booster cushions....................................... 53
Brake lights.............................................. 231Brake system ABS..................................................... 230
Brake pad inspection.......................... 229 checking fluid level............................. 289
emergency brake assistance.............. 231
fluid..................................................... 324
general information............................. 228
Bulbs headlights........................... 290, 291, 292
introduction......................................... 290
license plate lights.............................. 292
specifications...................................... 293
C
Camera, Park Assist................................ 201
Capacity weight....................................... 261
Catalytic converter................................... 242
Central locking system, introduction 124, 125, 128, 129
Chains...................................................... 264
Check Engine warning light....................... 63Child restraints recalls and registration......................... 47
Child restraint systems.............................. 47 booster cushions.................................. 53
convertible seats.................................. 51
infant seats........................................... 49
ISOFIX/LATCH anchors........................ 54
top tether anchors................................ 55

12 Index
12
336
O
Occupant safety........................................ 26
Occupant weight sensor............................ 36
Octane recommendations....................... 240
Odometer, trip........................................... 68Oilchecking............................................. 286
volumes.............................................. 323
Oil level sensor........................................ 287
Oil quality................................................. 323
OK button............................................ 96, 97
On Call Roadside Assistance.................... 24
Outside temperature sensor...................... 67
Overhead courtesy lighting........................ 82
Overheating, engine................................... 65
Ownership, changing................................. 18
Oxygen sensors, heated.......................... 242
P
Paint, touching up.................................... 312
Park assist....................................... 198, 201
Park Assist Camera................................. 201 Parking brake
electric, applying/releasing. 232, 233, 235
warning light......................................... 64
Parking lights............................................. 80
Pedestrian detection........................ 180, 183
Polishing.................................................. 309Power front seat memory function................................... 71
Power meter.............................................. 61
Power mirrors...................................... 87, 88 defroster............................................... 89
Power steering adjustable........................................... 145
fluid..................................................... 289
Power steering fluid................................. 325
Power windows......................................... 86
Pregnancy, using seat belts during........... 30
PROPOSITION 65 WARNING.. 215, 298, 326
R
Rain sensor................................................ 84
Rear fog lights............................................ 80
Rear park assist............................... 198, 201 Rear seats
folding................................................... 74
heated................................................. 110
Rearview mirror auto-dim function................................. 89
compass............................................... 90
Rear window defroster.............................. 89
Recalls....................................................... 26
Recalls, child restraints.............................. 47
Refrigerant............................................... 325
Refueling.......................................... 239, 240 fuel filler cap....................................... 242
fuel filler door.............................. 241, 242
fuel tank volume................................. 325
Registering child restraints........................ 47
Remote key...................... 124, 125, 128, 129 approach lighting................................ 127
immobilizer......................................... 126
key blade.................... 124, 125, 128, 129
locking the vehicle.............................. 127
replacing the battery........................... 130
unlocking the vehicle.......................... 127
Reporting safety defects............................ 27
Roadside Assistance................................. 24
Road sign information (RSI)..................... 145
Roof loads............................................... 121