service VOLVO V60 2013 Manual PDF
[x] Cancel search | Manufacturer: VOLVO, Model Year: 2013, Model line: V60, Model: VOLVO V60 2013Pages: 422, PDF Size: 9.59 MB
Page 365 of 422
09 Maintenance and service
Car care09
363
order to maintain the water-repellent proper-
ties. This should be used first after three years
and then each year.
Rustproofing – inspection and
maintenance
The car received a thorough and complete
rustproofing at the factory. Parts of the body
are made of galvanised sheet metal. The
underbody is protected by a wear-resistant
anti-corrosion compound. A thin, penetrating
rustproofing fluid was sprayed into the
exposed members, cavities, closed sections
and side doors.
Under normal conditions the rustproofing does
not require treatment for approximately 12
years. After this period, it should be treated at
three-year intervals. Volvo recommends that
you engage an authorised Volvo workshop for
assistance if the car needs further treatment.
Dirt and road salt can lead to corrosion so it is
important to keep the car clean. The car's rust-
proofing needs to be checked regularly and
touched-up if necessary in order for it to be
maintained.
Cleaning the interior
Only use cleaning agents and car care prod-
ucts recommended by Volvo. Clean regularly
and follow the instructions included with the
car care product.
Vacuuming is important prior to using cleaning
agents.
Carpets and cargo areaRemove inlaid carpets for separate cleaning of
the floor carpet and the inlaid carpets. Use a
vacuum cleaner to remove dust and dirt.
Each inlay mat is secured with pins.
–Take hold of the inlay mat at each pin and
lift the mat straight up.
Fit the inlay mat in place by pressing it in at
each pin.
WARNING
Before setting off check that the inlaid mat
in the driver area is firmly affixed and
secured in the pins in order to avoid getting
caught adjacent to and under the pedals.
A special textile cleaner is recommended for
stains on the floor mat after vacuuming. Floor
mats should be cleaned with agents recom-
mended by your Volvo dealer!
Stains on fabric upholstery and roof
upholstery
A special fabric cleaning agent, available from
authorised Volvo dealers, is recommended to
avoid impairing the fire retardant qualities of
the upholstery.
IMPORTANT
Sharp objects and Velcro may damage the
fabric upholstery.
Treating stains on leather upholsteryVolvo's leather upholstery is chromium-free
and is treated to preserve its original appear-
ance.
Leather upholstery ages and acquires a beau-
tiful patina over time. The leather is refined and
processed so that it retains its natural charac-
teristics. It is given a protective coating, but
regular cleaning is required in order to maintain
both characteristics and appearance. Volvo
offers a comprehensive product for the clean-
ing and treatment of leather upholstery which,
when used in accordance with the instructions,
preserves the leather's protective coating.
After a period of use the natural appearance of
the leather will nevertheless emerge, depend-
ing more or less on the surface texture of the
leather. This is a natural maturing of the leather
and shows that it is a natural product.
ProCarManuals.com
Page 366 of 422
09 Maintenance and service
Car care 09
364
To achieve best results Volvo recommends
cleaning and the application of protective
cream once to four times per year (or more if
necessary). The Volvo Leather Care kit is avail-
able from your Volvo dealer.
IMPORTANT
•Certain items of coloured clothing (for
example, jeans and suede garments)
may stain the upholstery.
•Never use strong solvents. Such prod-
ucts may damage fabric, vinyl and
leather upholstery.
Washing instructions for leather
upholstery
1. Pour the leather cleaner on the dampened
sponge and squeeze out a strong foam.
2. Work the dirt away with gentle circular
movements.
3. Dab accurately with the sponge on the
stains. Allow the sponge to absorb the
stain. Do not rub.
4. Wipe off with soft paper or a cloth and
allow the leather to dry completely.
Protective treatment of leather
upholstery
1. Pour a small amount of the protective
cream on the felted cloth and massage in
a thin layer of cream with gentle circular
movements on the leather.
2. Allow the leather to dry for 20 minutes
before use.
The leather has now been given improved pro-
tection against stains and improved UV pro-
tection.
Washing instructions for the leather
steering wheel
•Remove dirt and dust with a soft pre-mois-
tened sponge and neutral soap.
•Leather needs to breathe. Never cover the
leather steering wheel with protective plas-
tic.
•Use natural oils. Volvo's leather care
agents are recommended for best results.
If the steering wheel has stains:
Group 1 (ink, wine, coffee, milk, sweat and
blood)
–Use a soft cloth or sponge. Mix a 5%
ammonia solution. (For blood stains, use a
solution of 2 dl water and 25g salt.)Group 2 (fats, oils, sauces and chocolate)
1. Same procedure as group 1.
2. Polish with an absorbent paper or cloth.
Group 3 (dry dirt, dust)
1. Use a soft brush to remove the dirt.
2. Same procedure as group 1.
Treating stains on interior plastic, metal
and wood parts
A fibrillated fibre or microfibre cloth, lightly
moistened with water, available from Volvo
dealers, is recommended for cleaning interior
parts and surfaces.
Do not scrape or rub stains. Never use strong
stain removers. A special cleaning agent avail-
able from Volvo dealers can be used for more
difficult cleaning.
Cleaning seatbeltsUse water and a synthetic detergent. A special
textile cleaning agent is available from your
Volvo dealer. Make sure the seatbelt is dry
before allowing it to retract.
ProCarManuals.com
Page 367 of 422
09 Maintenance and service
Car care09
365 Touching up minor paintwork damage
Paint is an important part of the car's rust-
proofing and should therefore be checked reg-
ularly. To avoid the onset of rust, damaged
paintwork should be rectified immediately. The
most common types of paintwork damage are
stone chips, scratches, and marks on the
edges of wings, doors and bumpers.
Materials
•primer1 - for e.g. plastic-clad bumpers
there are special adhesive primers availa-
ble in spray cans
•base coat and clear coat - are available in
spray cans or as touch-up pens/sticks2
•masking tape
•fine sand paper1.
Colour code (Paint code)
Code for car's colour
It is important that the correct colour is used.
For product decal location, see page 370.
Repairing minor paint damage such as
stone chips and scratches
G021832
Before work is started, the car must be clean
and dry as well as at a temperature above
15 °C.
1. Apply a piece of masking tape over the
damaged surface. Then remove the tape to
remove any loose paint.
If the damage has reached down to a metal
surface (sheet steel), it is preferable to use
a primer. In the event of damage to a plas-
tic surface, an adhesive primer should be
used for better results - spray into the
spray can's cap and brush thinly.
1If required.2Follow the instructions that are included with the package for the touch-up pen/stick.
ProCarManuals.com
Page 368 of 422
09 Maintenance and service
Car care 09
366
2. A light sanding with very fine abrasive
material can be performed locally before
painting if necessary (e.g. if there are rough
edges). Clean the surface thoroughly and
allow to dry.
3. Stir the primer well and apply using a fine
brush, matchstick or similar. Finish with
base coat and clear coat once the primer
has dried.
4. For scratches, proceed as above, but
mask around the damaged area to protect
the undamaged paintwork.
NOTE
If the stone chip has not penetrated down
to the meal and an undamaged layer of paint
remains in place, fill in with base coat and
clear coat as soon as the surface has been
cleaned.
ProCarManuals.com
Page 369 of 422
09 Maintenance and service
09
367ProCarManuals.com
Page 380 of 422
10 Specifications
Engine oil
10
378
Adverse driving conditions
Adverse driving conditions can lead to abnor-
mally high oil temperature or oil consumption.
Below are some examples of adverse driving
conditions.
Check the oil level more frequently for long
journeys:
•towing a caravan or trailer
•in mountainous regions
•at high speeds
•in temperatures colder than -30 °C or hot-
ter than +40 °C
The above also apply to shorter driving dis-
tances at low temperatures.Choose a fully synthetic engine oil for adverse
driving conditions. It provides extra protection
for the engine.
Volvo recommends Castrol oil products.
IMPORTANT
In order to fulfil the requirements for the
engine's service intervals all engines are
filled with a specially adapted synthetic
engine oil at the factory. The choice of oil
has been made very carefully with regard to
service life, starting characteristics, fuel
consumption and environmental impact.
An approved engine oil must be used in
order that the recommended service inter-
vals can be applied. Only use a prescribed
grade of oil for both filling and oil change,
otherwise you will risk affecting service life,
starting characteristics, fuel consumption
and environmental impact.
Volvo Car Corporation disclaims all war-
ranty liability if engine oil of the prescribed
grade and viscosity is not used.
Volvo recommends that oil changes are car-
ried out at an authorised Volvo workshop.
ProCarManuals.com
Page 381 of 422
10 Specifications
Engine oil
10
379 Engine oil grade
EngineEngine codeARecommended oil gradeVolume, incl. oil filter
(litres)
T6B6304T4Oil grade: ACEA A5/B5
Viscosity: SAE 0W–30approx 6.8
D4D5204T3approx. 5.9
D4 AWDD5244T17approx. 5.9
D3D5204T7approx. 5.9
D5D5244T11Bapprox. 5.9
D5D5244T15Capprox. 5.9
T5B4204T7Oil grade: ACEA A5/B5
Viscosity: SAE 5W–30
When driving under adverse conditions, use ACEA A5/B5 SAE 0W-30.approx. 5.4
D2D4162Tapprox. 3.8
T3B4164T3Certified and factory-filled oil: Oil grade WSS-M2C925-A
options for service:
Oil grade: ACEA A5/B5
Viscosity: SAE 5W–30approx. 4.1
T4DB4164Tapprox. 4.1
T4FB4164T2approx. 4.1
ProCarManuals.com
Page 385 of 422
10 Specifications
Fluids and lubricants
10
383
NOTE
Under normal driving conditions, the gear-
box oil does not need to be changed during
its service life. However, this may be nec-
essary under adverse driving conditions,
see page 381.
ProCarManuals.com
Page 418 of 422
11 Alphabetical Index
11
416
S
Safety grille.............................................. 296
Safety mode.............................................. 30
Safety net................................................. 295
Seat, see Seats.......................................... 80
Seatbelt
rear seat................................................ 18
seatbelt tensioner................................. 18
Seatbelt reminder...................................... 18
Seatbelts.................................................... 16
Seats.......................................................... 80
head restraints, rear.............................. 82
heating................................................ 215
lowering the front backrest................... 80
lowering the rear backrest.................... 83
power seats.......................................... 81
Securing loads (Loading)......................... 293
Sensus....................................................... 77
Service position....................................... 341
Service programme................................. 328
Set time interval....................................... 165
Side airbags............................................... 24
Signal input, external.......................235, 256SIPS bags.................................................. 24
Soot filter................................................. 290
Soot filter full............................................ 290
Spare wheel............................................. 314
Spin control............................................. 146
Spin control function...............................146
SST – Self Supporting run flat Tyres....... 320
Stability and traction control system....... 146
Stability system....................................... 146
Stains....................................................... 363
Start assistance....................................... 120
Steering force, speed related.................. 226
Steering force level, see Steering force... 226
Steering lock............................................ 114
Steering wheel........................................... 85
keypad.......................... 85, 152, 203, 236
keypad, adaptive cruise control......... 156
steering wheel adjustment.................... 85
Stone chips and scratches...................... 365
Storage spaces in the passenger compart-
ment......................................................... 227
Sunroof
opening and closing...........................107
pinch protection.................................. 108sunscreen........................................... 108
ventilation position.............................. 107
Sunscreen, sunroof.................................. 108
Surround.......................................... 234, 240
Symbols................................................... 147
indicator symbols................................. 72
warning symbols................................... 72
Symbols and messages
Adaptive Cruise Control..................... 162
Collision Warning with Auto
Brake..........................................171, 179
Distance Alert..................................... 167
Driver Alert Control............................. 183
Lane Departure Warning..................... 186
T
Tailgate
locking/unlocking.................................. 59
Temperature
actual temperature.............................210
Temperature control................................ 216
Timer........................................................ 217
Total airing function...........................58, 210
ProCarManuals.com
Page 420 of 422
11 Alphabetical Index
11
418
Warning symbols....................................... 72
Warning triangle....................................... 318
Washer fluid, filling................................... 343
Washer nozzles, heated............................. 99
Washers
rear window.......................................... 99
washer fluid, filling.............................. 343
windscreen........................................... 99
Water and dirt-repellent coating.............. 101
Water-repellent surface, cleaning............ 362
Waxing..................................................... 362
Weights
kerb weight......................................... 373
Wheels
changing............................................. 315
installation........................................... 316
rims..................................................... 311
snow chains........................................ 312
spare wheel........................................ 314
Wheels and tyres..................................... 310
Whiplash injury, WHIPS............................. 27
WHIPS
child seat/booster cushion................... 27
whiplash injury...................................... 27
Windows, rearview and door mirrors....... 101Windscreen washing.................................. 99
Windscreen wipers.................................... 98
rain sensor............................................ 98
Winter driving........................................... 285
Winter tyres.............................................. 312
Wiper blades............................................ 341
changing............................................. 341
cleaning.............................................. 342
replacing, rear window.......................342
service position................................... 341
Wipers and washing.................................. 98
ProCarManuals.com