transmission oil VOLVO V60 2014 Owners Manual

Table of contents
10
11
11 Specifications
Type designations................................... 386
Dimensions............................................. 389
Weights................................................... 390
Towing capacity and towball load.......... 391
Engine specifications.............................. 393
Engine oil - adverse driving conditions... 395
Engine oil - grade and volume................ 396
Coolant - grade and volume................... 398
Transmission fluid - grade and volume... 399
Brake fluid - grade and volume............... 401
Power steering fluid - grade.................... 401
Washer fluid - quality and volume.......... 401
Fuel tank - volume.................................. 402
Fuel consumption and CO2 emissions... 403
Tyres - approved tyre pressures............. 407
Electrical system..................................... 410
Starter battery - specification................. 411Type approval - remote control key sys-
tem.......................................................... 412
Type approval - tyre pressure monitoring 412
Type approval - radar system................. 413 Type approval - Bluetooth®
.................... 414
Licenses.................................................. 422
Symbols in the display............................ 425
12
12 Alphabetical Index
Alphabetical Index.................................. 428
ProCarManuals.co’

||
03 Instruments and controls
03
102* Option/accessory, for more information, see Introduction.
MessageSpecification
Time for reg- ular mainte-nanceTime for regular service - contact a workshop B
. The
timing is determined by the number of kilometresdriven, number of monthssince the last service,engine running time andoil grade.
Maintenance overdueIf the service intervals are not followed then thewarranty does not coverany damaged parts - contact a workshop B
.
Transmission Oil changeneededContact a workshop B
to
check the car as soon as possible.
Transmission ReducedperformanceThe gearbox cannot han- dle full capacity. Drivecarefully until the mes- sage clears C
.
If shown repeatedly -contact a workshop B
.
Transmission hot ReducespeedDrive more smoothly or stop the car in a safemanner. Disengage thegear and run the engineat idling speed until the message clears C
.
MessageSpecification
Transmission hot Stopsafely Waitfor coolingCritical fault. Stop the car immediately in a safemanner and contact a workshop B
.
Temporarily offAA function has been tem- porarily switched off andis reset automaticallywhile driving or after star-ting again.
Low battery chargePower savemodeThe audio system is switched off to saveenergy. Charge the bat-tery.
A Part of message, shown together with information on where the problem has arisen.
B An authorised Volvo workshop is recommended.
C For more information regarding the automatic gearbox, seeAutomatic gearbox -- Geartronic* (p. 273).
Related information
• Messages - handling (p. 102)
• Menu navigation - combined instrument panel (p. 100)
Messages - handling
Use the left-hand stalk switch to acknowledge and browse among messages (p. 101) thatare shown in the information display of thecombined instrument panel. When a warning, information or indicator symbol illuminates, a corresponding messageappears in the display at the same time. Anerror message is stored in a memory list untilthe fault has been rectified. Press
OK on the left-hand stalk switch to
acknowledge a message. Scroll through mes- sages with the thumbwheel (p. 100).
NOTE
If a warning message appears while you are using the trip computer, the messagemust be read (press OK) before the previ-
ous activity can be resumed.
Related information
• Menu overview - combined instrument panel (p. 101)
ProCarManuals.co’

08 Starting and driving
08
297
Fording
Fording means that the car is driven through a water-covered roadway. Fording must be car-ried out with great caution. The car can be driven through water at a maximum depth of 25 cm at a maximumspeed of 10 km/h. Extra caution should beexercised when passing through flowingwater. During driving in water, maintain a low speed and do not stop the car. When the water hasbeen passed, depress the brake pedal lightlyand check that full brake function is achieved.Water and mud for example can make thebrake linings wet resulting in delayed brakefunction. •Clean the electric contacts of the electric engine block heater and trailer couplingafter driving in water and mud.
• Do not let the car stand with water overthe sills for any long period of time - thiscould cause electrical malfunctions.IMPORTANT
Engine damage can occur if water enters the air filter. In depths greater than 25 cm, water could enter the transmission. This reduces thelubricating ability of the oils and shortensthe service life of these systems. In the event of the engine stalling in water, do not try restart - tow the car from thewater to a workshop - an authorised Volvoworkshop is recommended. Risk of enginebreakdown.
Related information
•Recovery (p. 316)
• Towing (p. 313)
Overheating
Under special conditions, for example hard driving in hilly terrain and hot climate, there isa risk that the engine and drive system mayoverheat - in particular with a heavy load. For information about overheating when driv- ing with a trailer, see Driving with a trailer (p.306). • Remove any auxiliary lamps from in front of the grille when driving in hot climates.
• If the temperature in the engine's coolingsystem is too high then a warning symbolis illuminated in the combined instrumentpanel's information display and a text message
High engine temp Stop safelyis shown there - stop the car in a safe way and allow the engine to run at idlingspeed for several minutes in order to cooldown.
• If the text message
High engine temp
Stop engine or Coolant level low, Stop
engine is shown then the engine must be
switched off after stopping the car.
• In the event of overheating in the gearbox a built-in protection function is activatedwhich, amongst other things, illuminatesa warning symbol in the combined instru-ment panel, and its display shows the text message
Transmission hot Reduce
speed or Transmission hot Stop safely- follow the recommendation given and lower the speed and stop the car in a safeway and allow the engine to run at idling
ProCarManuals.co’

08 Starting and driving
08
308* Option/accessory, for more information, see Introduction.
Driving with a trailer - manual gearbox
When driving with a trailer in hilly terrain in a hot climate there may be a risk of overheating.
OverheatingWhen driving with a trailer in hilly terrain in ahot climate there may be a risk of overheat-ing. • Do not run the engine at higher revolu- tions than 4500 rpm(diesel engines: 3500 rpm) - otherwise theoil temperature may become too high.
Diesel engine 5-cyl
•In the event of a risk of overheating theoptimal speed for the engine is2300-3000 rpm for optimal circulation ofthe coolant.
Related information
•Driving with a trailer (p. 306)
Driving with a trailer - automatic gearbox
When driving with a trailer in hilly terrain in a hot climate there may be a risk of overheating.
• An automatic gearbox selects the opti- mum gear related to load and enginespeed.
• In the event of overheating a warningsymbol is illuminated in the combinedinstrument panel with a message that isshown in the information display - followthe recommendation given.
Steep inclines
•Do not lock the automatic transmission ina higher gear than the engine "can copewith" - it is not always a good idea todrive at a high gear with low engine revo-lutions.
Parking on a hill1. Depress the foot brake.
2. Activate the parking brake.
3. Move the gear selector to position
P.
4. Release the foot brake.
• Move the gear selector to park position
P
when parking an automatic car with a hitched trailer. Always use the parkingbrake.
• Block the wheels with chocks when park-ing a car with hitched trailer on a hill.
IMPORTANT
See also the specific information on slow driving with a trailer for cars with thePowershift automatic transmission, seeAutomatic gearbox -- Powershift* (p. 276).
Starting on a hill1. Depress the foot brake.
2. Move the gear selector to driving posi-
tion D.
3. Release the parking brake.
4. Release the foot brake and start driving off.
Related information
• Automatic gearbox -- Geartronic* (p. 273)
ProCarManuals.co’

||
10 Maintenance and service
10
370* Option/accessory, for more information, see Introduction.
FunctionA
Relay coils5
Auxiliary lamps*20
Horn15
Relay coil in main relay for engine management system;Engine control module (4-cyl. 2.0 l B
, 5, 6-cyl.)10
Transmission control module15
Solenoid clutch A/C (not 4-cyl. 2.0 l C
, not 5-cyl. diesel); Sup-
porting coolant pump (4-cyl. 2.0 l diesel)15
Relay coil in relay for solenoid clutch A/C (not 5-cyl. diesel);Relay coil in relay for coolantpump (1.6 l petrol Start/Stop);Relay coils in central electricalunit in engine compartmentcold zone (Start/Stop)5
Start relay A30
FunctionA
Ignition coils (1.6 l petrol, engine B4204T7); Glow controlmodule (5-cyl. diesel)10
Engine control module (4-cyl. 2.0 l
B
); Ignition coils (5, 6-cyl.
petrol); Capacitor (6-cyl.)20
Engine control module (petrol except 4-cyl. 2.0 l C
)10
Engine control module (1.6 l diesel, 5-cyl. diesel)15
Engine control module (4-cyl. 2.0 l B
)20
FunctionA
Valves (1.6 l petrol); mass air flow sensor (1.6 l, 4-cyl. 2.0 l B
);
Thermostat (4-cyl. 2.0 l pet-rol B
); EVAP valve (4-cyl. 2.0 l
petrol B
); Cooling valve for cli-
mate control system (4-cyl. 2.0 l diesel); Cooling pump for EGR(4-cyl. 2.0 l diesel) Mass air flow sensor (engine D4162T); Control valve, fuelflow (engine D4162T)10
Mass air flow sensor (5-cyl. diesel, 6-cyl.); Control valves(5-cyl. diesel); Injectors (5, 6-cyl. petrol); Engine controlmodule (5-cyl. petrol, 6-cyl.)15
ProCarManuals.co’

11 Specifications
11
}}
399
Transmission fluid - grade and volume
The prescribed transmission fluid and volume for each respective gearbox alternative can beread in the table.
Manual gearbox
Manual gearboxVolume (litres)Prescribed transmission fluid
MMT6approx. 1.7BOT 350M3M66approx. 1.9 (approx. 1.45A
)
A Applies to the D4204T5 engine.
NOTE
Under normal driving conditions, the gear- box oil does not need to be changed dur-ing its service life. However, it may be nec-essary under adverse driving conditions.
Automatic gearbox
Automatic gearboxVolume (litres)Prescribed transmission fluid
MPS6approx. 7.3BOT 341
TF-80SCapprox. 7.0AW1
TF-80SDapprox. 7.0AW1
TG-81SCapprox. 6.6 A
approx. 7.5 BAW1
A
Petrol engines
B Diesel engines
ProCarManuals.co’

12 Alphabetical Index
12
437
Towbar
detachable, attachment...................... 310
detachable, removal........................... 311
Towbar, see Towing equipment.............. 309 Towbar - detachable attachment/removal.................... 310, 311
Towing..................................................... 313 towing eye.......................................... 315
Towing bracket........................................ 309 specifications...................................... 309
Towing capacity and towball load........... 391
Towing eye.............................................. 315
TPMS - Tyre Pressure Monitoring........... 330
Traction control........................................ 175
Trailer....................................................... 306 cable........................................... 306, 307
driving with a trailer............................ 306
snaking............................................... 312
Trailer stability assist............................... 176
Trailer Stability Assist.............................. 312
Transmission............................................ 271Transmission oil volume and grade............................... 399
Transponder.............................................. 17
Tread depth............................................. 321
Tread wear indicators.............................. 320 Trip computer.......... 104, 105, 109, 112, 113
Trip meter.................................................. 68
Trip meter, resetting................ 107, 110, 112Troubleshooting
Adaptive Cruise Control..................... 199
TSA - trailer stability assist ............. 176, 312
Tunnel console........................................ 139 12 V socket......................................... 141
cigarette lighter and ashtray............... 139
Tunnel detection........................................ 81 Type approval Bluetooth ®
.......................................... 414
radar system....................................... 413
remote control key system................. 412
tyre pressure monitoring..................... 412
Type designations................................... 386
Tyre dimension........................................ 322
Tyre load index........................................ 323
Tyre pressure label.................................. 328
Tyre pressure monitoring......................... 330 Adjust.................................................. 330
arming................................................. 331
deactivate........................................... 331
driveable punctured tyres (SST)......... 332
low tyre pressure................................ 331
recommendations............................... 332 Tyres
direction of rotation............................ 318
maintenance....................................... 318
pressure...................................... 328, 407
puncture repair................................... 333
specifications...................................... 407
tread depth......................................... 321
tread wear indicators.......................... 320
tyre pressure monitoring..................... 330
winter tyres......................................... 321
U
Unlockingfrom the inside.................................... 165
from the outside................................. 164
Unlocking with the key blade................... 162
V
Vanity mirror...................................... 88, 140
Ventilation................................................ 119
Vibration damper..................................... 309
Volvo Sensus............................................. 68
ProCarManuals.co’