belt VOLVO XC70 2004 Owner's Guide

2004 VOLVO XC70
Fuel filter
The fuel filter should be replaced at 105,000 miles (168,000 km) or at\
120,000 miles (193,000 km) for
the 2.5T engine on AWD models. The filter is replaced as a complete unit\
. Replace more frequently if
contaminated fuel is introduced into the tank, or if there is reason to \
suspect that this has occurred.
Fuel system, including filler cap, tank and lines and
connections
The ability of the fuel system to contain hydrocarbons depends upon a le\
ak-free system. Inspect fuel
lines every 30,000 miles (48,000 km). Check for proper sealing of the \
fuel filler cap which contains "O"
ring seals.
NOTE: If the fuel filler cap is not closed tightly or if the engine is running\
when the car is refueled, the
Check Engine light (Malfunction indicator) may indicate a fault. Howev\
er, your vehicle's performance
will not be affected. Use only Volvo original or approved fuel filler ca\
ps.
Timing belt
For proper functioning of the engine and its emission control systems, t\
he timing belt and belt tensioner
must be replaced every 105,000 miles (168,000 km) or at 120,000 miles \
(193,000 km) for the 2.5T
engine on AWD models. Engine damage will occur if the belt fails.
PCV system
(on turbocharged models)
The nipple in the intake manifold and the filter at the end of the PCV h\
ose in the air cleaner should be
inspected and cleaned at 105,000 miles (168,000 km) or at 120,000 mile\
s (193,000 km) for the 2.5T
engine on AWD models, and again at 150,000 miles (240,000 km).
Spark plugs
The spark plugs should be replaced every 60,000 miles (96,000 km) unde\
r normal driving conditions.
City driving or fast highway driving may necessitate replacement sooner.\
Under normal driving conditions, spark plugs require no maintenance betw\
een replacement intervals.
When installing new plugs, be sure to use the right type and to tighten \
them correctly. When changing
the plugs, clean the terminals and rubber seals. Also check that the sup\
pressor connectors are in good
condition. Cracked or damaged connectors should be replaced.
file:///K|/ownersdocs/2004/2004_XC70/04xc70_08b.htm (4 of 16)12/30/200\
6 4:33:06 PM

2004 VOLVO XC70
Courtesy lights (front) - replacing 126
Courtesy lights - exterior
76
Cruise control
33
Cup holder
59
Cup holder in the center console
60
D
Detachable trailer hitch - installing
103
Dimensions
145
Direction indicators
36
Distributor ignition system
149
Door step courtesy lights - replacing
125
Doors and locks
76
Drive belt
133
Driver's seat and remote keyless entry system
57
Driving economy
96
Driving mode indicator
27
Driving mode W
91, 93, 105
Driving with trunk open
97
E
Economical driving
96
Electric socket in cargo compartment
67
Electrical system
150
Electrical system - general information
97
Electrically operated front seats
56
Electrically operated moonroof
42
Electrically operated sideview mirrors
41
Electrically operated windows
40
Electronic Brake Force Distribution
19
Electronic Climate Control (ECC)
48 - 51
Emergency Locking Retractor (ELR)
14
Emergency towing
100, 101
Emergency warning flashers
38
file:///K|/ownersdocs/2004/2004_XC70/04xc70_12.htm (4 of 12)12/30/2006\
4:33:10 PM

2004 VOLVO XC70
R-models, checking oil level 138
Radio
153
Rain sensor - windshield wipers
37
Reading lights - front/rear
74
Rear fog light
29, 35
Rear reading lights
74
Rear seat backrest
66
Rear window - heated
38
Rearview mirror
41
Refrigerant
47
Refueling
86
Remote central locking system and sideview mirrors
system
41
Remote control - keyless entry system
77
Remote control - Homelink® Universal Transceiver
170
Remote keyless entry system
77
Remote keyless entry system - replacing batteries
78
Remote keyless entry system and driver's seat
57
Removing the seat cushion
66
Replacing bulbs
122-127
Replacing fuses
118
Replacing wiper blades
142
Road assistance
151
Roadholding
96
Roof load - maximum
145
Roof racks
98
S
Safety locks - child
82
Seat belt maintenance
17
Seat belts
2, 3, 14
Seat belts - cleaning
130
Seats - front
56
file:///K|/ownersdocs/2004/2004_XC70/04xc70_12.htm (9 of 12)12/30/2006\
4:33:10 PM

2004 VOLVO XC70
T
Tachometer
27
Tailgate - locking/unlocking
79
Tailgate wiper blade - replacing
142
Temperature gauge
27
Temporary spare tire
112
Text window
30
Three-way catalytic converters
107
Timing belt
134
Tire pressure
112
Tires
110 -113
Tires - changing
114, 115
Tool bag
72
Towing a trailer
102
Towing eyelet
100
Towing the car
100, 101
Trailer towing
102
Trailer weight - maximum
145
Transmission - automatic
90-95
Trip computer
32
Trip odometer
27
Turn signals
36
U
Uniform tire quality grading
113
Unlocking the tailgate
79
Upholstery - cleaning
130
V
Vanity mirror lights - replacing
126
Vehicle Identification Number (VIN)
144
Vehicle loading
112
Ventilation
46
Volvo On Call
151
file:///K|/ownersdocs/2004/2004_XC70/04xc70_12.htm (11 of 12)12/30/200\
6 4:33:10 PM