sport mode YAMAHA EX 2022 Owners Manual

Important manual information
EJU44337
Declaration of Conformity for Personal Watercraft (PWC)with the requirements of Directive 2013/53/EU
Name of PWC Manufacturer: YAMAHA MOTOR CO., LTD.
Address: 2500 Shingai, Iwata, Shizuoka 438-8501, Japan
Name of Authorised Representative: YAMAHA MOTOR EUROPE N.V.
Address: Koolhovenlaan 101, 1119 NC Schiphol-Rijk, The Netherlands
Name of Notified Body for exhaust and noise emission assessment: VINÇOTTE nv
EX1050D-X / EX LIMITED, EX1050A-X / EX DELUXE,
EX1050B-X / EX SPORT, EX1050C-X / EX 0026
ID Number:
Address: Jan Olieslagerslaan 35 1800 VILVOORDE BELGIUM
US-YAMA0001G122
Conformity assessment module used:
for construction:
for exhaust emissions:
for noise emissions:
DESCRIPTION OF WATERCRAFT
DESCRIPTION OF ENGINE A
A
Craft Identification Number : starting from
Model name / Commercial name : C
Design Category : Other Community Directives applied
Electromagnetic Compatibility Directive 2014/30/EU
EN 55012:2007/A1:2009
Standards
D
A1
A1B+C
B+CB+D
B+D B+E
B+EB+F
B+FG
G
GH
H
H
EN 61000-6-2:2005,
EN 61000-6-2:2005/AC:2005
Model Name:
6GA
Combustion Cycle:
4 stroke
Fuel Type:
Petrol
ESSENTIAL REQUIREMENTS
Essential requirements StandardsOther normative
document / method Technical filePlease specify in more detail
(* = mandatory standard)
Annex I.A Design and construction *EN ISO 13590:2018
Annex I.B Exhaust emission *EN ISO 18854:2015
Annex I.C Noise emission *EN ISO 14509-1:2018
*
* *
This declaration of conformity is issued under the sole responsibility of the manufacturer. I declare on behalf of the
manufacturer that the PWC(s) mentioned above complies (comply) with all applicable essential requirements in the way
specified.
Name / Title:
T. Ibata / Director, Marine Development Section(Identification of the person empowered to sign on behalf of the manufa\
cturer)
Signature:
Date and place of issue:
1st July, 2021, Shizuoka, Japan
Certificate for exhaust emission assessment:
C2160963397/001
UF3Y75E0.book Page 1 Tuesday, July 27, 2021 2:27 PM

Table of contents
General and important labels ........... 1Identification numbers .................... 1
Primary Identification (PRI-ID)
number............................................ 1
Craft Identification Number (CIN) ....... 1
Engine serial number.......................... 1
Manufactured date label .................... 2
Model information ........................... 3
Builder’s plate .................................... 3
Important labels .............................. 4
Warning labels.................................... 5
Other labels ........................................ 8
Safety information ............................. 9 Limitations on who may operate the watercraft ............................... 9
Cruising limitations ........................ 10
Operation requirements ................ 11
Recommended equipment ........... 13
Hazard information........................ 14
Watercraft characteristics ............. 14
Wakeboarding and water-skiing ... 16
Safe boating rules ......................... 17
Enjoy your watercraft responsibly ................................. 18
Description....................................... 19 Watercraft glossary ....................... 19
Location of main components ...... 20
Control function operation ............. 24 Watercraft control functions ......... 24
Engine stop switch .......................... 24
Engine shut-off switch .................... 24
Start switch ..................................... 24
Throttle lever .................................... 25
RiDE lever (EX DELUXE / EX
LIMITED) ....................................... 25
Steering system ............................... 25
Cooling water pilot outlet ................. 26
Water separator................................ 26
Watercraft operation ...................... 27 Watercraft operation functions ..... 27
Reverse system (EX SPORT) ............ 27
Shift system (EX DELUXE / EX
LIMITED) ....................................... 27
Instrument operation ...................... 31Multifunction information center ... 31
Information display ........................... 31
Equipment operation ...................... 36Equipment..................................... 36
Seat .................................................. 36
Handgrip........................................... 36
Reboarding grip................................ 37
Reboarding step (EX SPORT / EX
DELUXE / EX LIMITED) ................ 37
Bow eye............................................ 37
Stern eyes ........................................ 38
Cleat ................................................. 38
Pull-up cleats (EX LIMITED) ............ 38
Storage compartments .................... 38
Fire extinguisher holder .................... 40
Operation and handling
requirements ................................... 41 Fuel requirements ......................... 41
Fuel................................................... 41
Engine oil requirements ................ 43
Engine oil .......................................... 43
Draining the bilge water ................ 45
Draining the bilge water on land....... 45
Draining the bilge water on water .... 45
Transporting on a trailer................ 46
First-time operation ........................ 47 Engine break-in............................. 47
Pre-operation checks ..................... 48
Pre-operation checklist .................... 48
Pre-operation check points .......... 50
Pre-launch checks ........................... 50
Post-launch checks.......................... 55
UF3Y75E0.book Page 1 Tuesday, July 27, 2021 2:27 PM

General and important labels
1
EJU36453
Identification numbers
Record the Primary Identification (PRI-ID)
number, Craft Identification Number (CIN),
and engine serial number in the spaces pro-
vided for assistance when ordering spare
parts from a Yamaha dealer. Also record and
keep these ID numbers in a separate place in
case your watercraft is stolen.
EJU30284Primary Identification (PRI-ID) number
The PRI-ID number is stamped on a plate at-
tached inside the engine compartment. (See
page 36 for seat removal and installation pro-
cedures and page 40 for information on the
seat storage compartment.)
MODEL:
EX1050C-X (EX)
EX1050B-X (EX SPORT)
EX1050A-X (EX DELUXE)
EX1050D-X (EX LIMITED)
EJU36551Craft Identification Number (CIN)
The CIN is stamped on a plate attached to
the aft deck.
EJU44440Engine serial number
The engine serial number is stamped on a
plate attached to the engine unit. (See page
36 for seat removal and installation proce-
dures and page 40 for information on the seat
storage compartment.)1Primary Identification (PRI-ID) number loca-
tion
1
1Craft Identification Number (CIN) location
MODELYAMAHA MOTOR CO.,LTD.
ASSEMBLED IN U.S.A. WITH FOREIGN AND DOMESTIC COMPONENTS.
ASSEMBLÉ EN U.S. AVEC DES COMPOSANTS ÉTRANGERS ET
DOMESTIQUES. PRI-I.D.
1
UF3Y75E0.book Page 1 Tuesday, July 27, 2021 2:27 PM

Safety information
14
EJU44610
Hazard information
Never start the engine or let it run for any
length of time in an enclosed area. Exhaust
fumes contain carbon monoxide, a color-
less, odorless gas that may cause loss of
consciousness and death within a short
time. Always operate the watercraft in an
open area.
Do not touch the hot oil tank, muffler, or en-
gine during or immediately after engine op-
eration; they can cause serious burns.
Do not place magnets or objects with a
strong magnetic force near the throttle le-
ver or RiDE lever (EX DELUXE / EX
LIMITED). The electronic throttle mecha- nism of the levers can be adversely affect-
ed, which could cause loss of control. In
addition, do not place objects susceptible
to magnetic forces (i.e., credit cards,
watches, etc.) close to the throttle lever or
RiDE lever.
EJU44341
Watercraft characteristics
Jet thrust turns the watercraft. Releasing
the throttle lever completely produces only
minimum thrust. If you are traveling at
speeds above trolling, you will have rapidly
decreasing ability to steer without throttle.
This model is equipped with the Yamaha
Engine Management System (YEMS) that
includes an off-throttle steering (OTS) sys-
tem. It will activate at planing speeds
should you attempt to steer the watercraft
after releasing the throttle lever. The OTS
system assists in turning by continuing to
supply some thrust while the watercraft is
decelerating, but you can turn more sharp-
ly if you apply throttle while turning the han-
dlebars.
The OTS system does not function below
planing speeds or when the engine is off.
Once the engine slows down, the water-
craft will no longer turn in response to han-
dlebar input until you apply throttle again or
you reach trolling speed.
Practice turning in an open area without
obstacles until you have a good feel for this
maneuver.
EX: This watercraft is water-jet propelled.
The jet pump is directly connected to the
engine. This means that jet thrust will pro-
duce some movement whenever the en-
gine is running. There is no “neutral”
position.
EX SPORT: This watercraft is water-jet pro-
pelled. The jet pump is directly connected
to the engine. This means that jet thrust will
produce some movement whenever the
engine is running. There is no “neutral” po-
sition. You are in either “forward” or “re-
verse”, depending upon the shift lever
position.
UF3Y75E0.book Page 14 Tuesday, July 27, 2021 2:27 PM

Operation
63
EWJ01971
Allow adequate stopping distance. Stay
far enough away from others so you can
always safely coast to a stop.
Take early action to avoid collisions. Re-
member, watercraft and other boats do
not have brakes.
Operate defensively at safe speeds and
keep a safe distance away from people,
objects, and other watercraft to give you
time to stop.
Do not shut the engine off when slowing
down in case you need engine power to
steer away from a boat or other obstacle
that comes into your path.
EX SPORT: Do not use the reverse func-
tion to slow down or stop the watercraft
as it could cause you to lose control, be
ejected, or impact the handlebars.
EX DELUXE / EX LIMITED: To avoid
rear-end collisions while operating the
watercraft, check behind you before us-
ing the RiDE lever to slow down or stop
the watercraft.
EJU44682Operating the watercraft in reverse or
neutral (EX SPORT / EX DELUXE / EX
LIMITED)
Operating in reverse (EX SPORT)
Pull the shift lever rearward to the reverse po-
sition. The watercraft will move in reverse.
(See page 27 for information on the reverse
system.) Make sure that there are no obstacles or peo-
ple behind you before shifting into reverse.
TIP
This model is not equipped with a neutral
function.
Operating in reverse (EX DELUXE / EX
LIMITED) When the RiDE lever is squeezed, the “R” (re-
verse) shift indicator will be displayed and the
watercraft will move in reverse. (See page 27
for shift system operation procedures.)
1 Shift lever
2 Reverse position
1
2
UF3Y75E0.book Page 63 Tuesday, July 27, 2021 2:27 PM

Index
91
Maintenance ............................................ 77
Manufactured date label ............................ 2
Model information ...................................... 3
Multifunction information center .............. 31
Multifunction information center check ... 56
O
Oil pressure warning ................................ 34
Operating in weeded areas ...................... 69
Operating the watercraft .......................... 59
Operating the watercraft in reverse or neutral (EX SPORT / EX DELUXE /
EX LIMITED).......................................... 63
Operating your watercraft ........................ 57
Operation requirements ........................... 11
P
Periodic maintenance chart ..................... 78
Post-launch checks ................................. 55
Post-operation care ................................. 71
Pre-launch checks ................................... 50
Pre-operation check points ..................... 50
Pre-operation checklist ............................ 48
Primary Identification (PRI-ID) number ...... 1
Pull-up cleats (EX LIMITED) ..................... 38
R
Raising the reverse gate (EX DELUXE / EX LIMITED).......................................... 87
Reboarding grip ....................................... 37
Reboarding step (EX SPORT / EX DELUXE / EX LIMITED) ......................... 37
Recommended equipment ...................... 13
Reverse system checks (EX SPORT) ....... 52
Reverse system (EX SPORT) ................... 27
RiDE lever checks (EX DELUXE / EX LIMITED) ............................................... 53
RiDE lever (EX DELUXE / EX LIMITED) .... 25
Riding position ......................................... 58
Rustproofing ............................................ 75
S
Safe boating rules .................................... 17
Safety equipment check .......................... 54
Seat .......................................................... 36
Seat storage compartment ...................... 40
Shift indicator (EX DELUXE / EX
LIMITED) ............................................... 32 Shift system check (EX DELUXE / EX
LIMITED) ............................................... 56
Shift system (EX DELUXE / EX LIMITED) ............................................... 27
Speedometer ........................................... 31
Start switch .............................................. 24
Starting off ............................................... 67
Starting off from a trailer .......................... 67
Starting the engine on water .................... 58
Steering system ....................................... 25
Steering system checks ........................... 52
Stern drain plug checks ........................... 55
Stern eyes ................................................ 38
Stopping the engine ................................. 59
Stopping the watercraft ........................... 62
Storage compartment checks.................. 54
Storage compartments ............................ 38
Submerged watercraft ............................. 88
Switch checks .......................................... 53
T
Tachometer .............................................. 32
Throttle lever ............................................ 25
Throttle lever checks ................................ 53
Towing the watercraft .............................. 88
Transporting on a trailer ........................... 46
Troubleshooting ....................................... 83
Troubleshooting chart .............................. 83
Turning the watercraft .............................. 60
W
Wakeboarding and water-skiing .............. 16
Water separator ....................................... 26
Water separator check ............................. 50
Watercraft characteristics ........................ 14
Watercraft control functions..................... 24
Watercraft operation functions ................ 27
UF3Y75E0.book Page 91 Tuesday, July 27, 2021 2:27 PM