battery YAMAHA XVS650A 2001 Owners Manual

2-2
DESCRIPTION
1
2
2
4
5
6
7
8
9

Right view (XVS650)
8. Oil filter (page 6-10)
9. Battery (page 6-26)
10. Fuses (page 6-27)
11. Main switch (page 3-1)
12. Air filter (page 6-12)
13. Rear brake pedal (page 3-6)

2-4
DESCRIPTION
1
2
2
4
5
6
7
8
9

Right view (XVS650A)
8. Oil filter (page 6-10)
9. Battery (page 6-26)
10. Fuses (page 6-27)
11. Main switch (page 3-1)
12. Air filter (page 6-12)
13. Rear brake pedal (page 3-6)

3-1
INSTRUMENT AND CONTROL FUNCTIONS
1
23
4
5
6
7
8
9
EAU00029
Main switch/Steering lock
The main switch controls the ignition
and lighting systems. Its operation is
described below.
EAU00036
ON
Electrical circuits are switched on. The
engine can be started. The key cannot
be removed in this position.
EAU00038
OFF
All electrical circuits are switched off.
The key can be removed in this posi-
tion.
EAU00040
LOCK
The steering is locked in this position
and all electrical circuits are switched off.
The key can be removed in this posi-
tion. To lock the steering, turn the han-
dlebars all the way to the left. While
pushing the key into the main switch,
turn it from “OFF” to “LOCK” and re-
move it. To release the lock, turn the
key to “OFF” while pushing.
EW000016
WARNING

Never turn the key to “OFF” or
“LOCK” when the motorcycle is
moving. The electrical circuits will
be switched off which may result in
loss of control or an accident. Be
sure the motorcycle is stopped be-
fore turning the key to “OFF” or
“LOCK”.
1. Push
2. Turn
EAU00044
(Parking)
The steering is locked in this position
and the taillight comes on, but all other
circuits are off. The key can be re-
moved in this position.
To use the parking position, first lock
the steering, then turn the key to “ ”.
Do not use this position for an extend-
ed length of time as the battery may
discharge.
EAU00027

Tool kit ................................................................ 6-1
Periodic maintenance and lubrication ................ 6-2
Panel removal and installation............................ 6-5
Panel A ............................................................... 6-6
Panel B ............................................................... 6-7
Spark plugs ........................................................ 6-7
Engine oil............................................................ 6-9
Final gear oil ..................................................... 6-11
Air filter ............................................................. 6-12
Carburetor adjustment...................................... 6-13
Idle speed adjustment ...................................... 6-14
Throttle cable free play inspection .................... 6-15
Valve clearance adjustment.............................. 6-15
Tires ................................................................. 6-15
Wheels ............................................................. 6-17
Clutch lever free play adjustment ..................... 6-18
Front brake lever free play
adjustment ...................................................... 6-19
Rear brake pedal height and free play
adjustment ...................................................... 6-20
Brake light switch adjustment ........................... 6-21
Checking the front brake pads and
rear brake shoes ............................................ 6-21
Inspecting the brake fluid level.......................... 6-22
Brake fluid replacement .................................... 6-22
Cable inspection and lubrication ....................... 6-23
Throttle cable and grip lubrication..................... 6-23
Brake and shift pedal lubrication....................... 6-23
Brake and clutch lever lubrication ..................... 6-24
Sidestand lubrication ........................................ 6-24
Front fork inspection ......................................... 6-25
Steering inspection ........................................... 6-25
Wheel bearings ................................................. 6-26
Battery .............................................................. 6-26
Fuse replacement ............................................. 6-27
Headlight bulb replacement .............................. 6-28
Turn signal and taillight bulb replacement......... 6-29
Supporting the motorcycle ................................ 6-30
Front wheel removal ......................................... 6-31
Front wheel installation ..................................... 6-31
Rear wheel removal .......................................... 6-32
Rear wheel installation...................................... 6-33
Troubleshooting ................................................ 6-34
Troubleshooting chart ....................................... 6-35

PERIODIC MAINTENANCE AND MINOR REPAIR
6

6-26
PERIODIC MAINTENANCE AND MINOR REPAIR
1
2
3
4
56
7
8
9
EAU01144
Wheel bearingsIf there is play in the front or rear wheel
hub or if the wheel does not turn
smoothly, have a Yamaha dealer in-
spect the wheel bearings.
EAU00800
BatteryThis motorcycle is equipped with a
sealed-type battery. Therefore it is not
necessary to check the electrolyte or
fill the battery with distilled water.l
If the battery seems to have dis-
charged, consult a Yamaha deal-
er.
l
If the motorcycle is equipped with
optional electrical accessories,
the battery tends to discharge
more quickly, so be sure to re-
charge it periodically.
EC000101
CAUTION:
Never try to remove the sealing
caps of the battery cells. The bat-tery will be damaged.
EW000116
WARNING
Battery electrolyte is poisonous
and dangerous, causing severe
burns, etc. It contains sulfuric acid.
Avoid contact with skin, eyes or
clothing.
ANTIDOTE:l
EXTERNAL: Flush with water.
l
INTERNAL: Drink large quanti-
ties of water or milk. Follow
with milk of magnesia, beaten
egg, or vegetable oil. Call a
physician immediately.
l
EYES: Flush with water for
15 minutes and get prompt
medical attention.
Batteries produce explosive gases.
Keep sparks, flame, cigarettes etc.,
away. Ventilate when charging or
using in an enclosed space. Always
shield your eyes when working near
batteries. KEEP OUT OF REACH OF
CHILDREN.

6-27
PERIODIC MAINTENANCE AND MINOR REPAIR
1
2
3
4
56
7
8
9Battery storage
When the motorcycle is not used for a
month or longer, remove the battery,
fully charge it and store it in a cool, dry
place.
EC000102
CAUTION:l
Completely recharge the bat-
tery before storing. Storing a
discharged battery can cause
permanent battery damage.
l
Use a battery charger designed
for a sealed-type (MF) battery.
Using a conventional battery
charger will cause battery
damage. If you do not have a
sealed-type battery charger,
contact your Yamaha dealer.
l
Always make sure the connec-
tions are correct when reinstall-ing the battery.
1. Fuse block
2. Main fuse
3. Spare fuse
EAU00825*
Fuse replacementThe fuses are located behind panel B.
(See page 6-5 for panel removal pro-
cedures.)
If a fuse is blown, turn off the main
switch and the switch of the circuit in
question. Install a new fuse of proper
amperage. Turn on the switches and
see if the electrical device operates. If
the fuse immediately blows again, con-
sult a Yamaha dealer.
1. Ignition fuse
2. Signaling system fuse
3. Headlight fuse
4. Carburetor heater fuse
5. Spare fuse
EC000103
CAUTION:
Do not use fuses of higher amper-
age rating than those recommend-
ed. Substitution of a fuse of
improper rating can cause exten-
sive electrical system damage andpossibly a fire.

6-35
PERIODIC MAINTENANCE AND MINOR REPAIR
1
2
3
4
56
7
8
9
EAU01297*
Troubleshooting chart
EW000125
WARNING
Never check the fuel system while smoking or in the vicinity of an open flame.
Check if there is fuel
in the fuel tank.1. Fuel
Enough fuel.
No fuel.
Go to compression check.
Supply fuel.
Engine doesn’t start, go to compression check.
Use the electric starter.2. Compression
There is compression.
No compression.
Go to ignition check.
Ask a Yamaha dealer to
inspect.
Remove spark
plugs and
check electrodes.3. Ignition
Wet.
Dry.
Wipe clean with dry cloth and correct
spark gap or replace spark plugs.
Ask a Yamaha dealer to inspect.
Engine doesn’t start, ask a Yamaha
dealer to inspect.Engine doesn’t start, go to battery
check.Open throttle half-way and start
the engine.
Use the electric starter.4. Battery
Engine turns over
quickly.
Engine turns over
slowly.
Battery good.Check connections or
recharge.

7-5
MOTORCYCLE CARE AND STORAGE
1
2
3
4
5
6
7
7. Check and, if necessary, correct
the tire air pressure, then raise the
motorcycle so that both of its
wheels are off the ground. Alter-
natively, turn the wheels a little ev-
ery month in order to prevent the
tires from becoming degraded in
one spot.
8. Cover up the muffler outlets with
plastic bags to prevent moisture
from entering.
9. Remove the battery and fully
charge it. Store it in a cool, dry
place and recharge it once a
month. Do not store the battery in
an excessively cold or warm place
(less than 0˚C or more than 30˚C).
For more information, see “Bat-
tery storage” in the chapter “PE-
RIODIC MAINTENANCE AND
MINOR REPAIRS”.
NOTE:

Make any necessary repairs before
storing the motorcycle.

8-4
SPECIFICATIONS
1
2
3
4
5
6
7
8
9

Wheels
XVS650
Front
Type Spoke
Size 19
´
MT2.50
Rear
Type Spoke
Size 15M/C
´
MT3.50
XVS650A
Front
Type Spoke
Size 16
´
MT3.00
Rear
Type Spoke
Size 15M/C
´
MT3.50
Brakes
Front
Type Single disc brake
Operation Right hand operation
Fluid DOT 4
Rear
Type Drum brake
Operation Right foot operation

Suspension
Front
Type Telescopic fork
Rear
Type Swingarm
Shock absorber
Front Coil spring/oil damper
Rear Coil spring/gas-oil damper,
spring preload adjustable
Wheel travel
XVS650
Front 140 mm
Rear 86 mm
XVS650A
Front 140 mm
Rear 98 mm
Electrical
Ignition system T.C.I. (digital)
Charging system
Type A.C. magneto
Standard output 14 V 20 A @ 5,000 rpm
Battery
Type GT12B-4
Voltage, capacity 12 V, 10 AH

INDEX
A
Air filter ....................................................6-12
Antitheft alarm (optional) ..........................3-3
B
Battery ....................................................6-26
Brake and clutch lever lubrication ..........6-24
Brake and shift pedal lubrication ............6-23
Brake fluid replacement ..........................6-22
Brake light switch adjustment .................6-21
C
Cable inspection and lubrication ............6-23
Carburetor adjustment ............................6-13
Care ..........................................................7-1
Checking the front brake pads and
rear brake shoes ..................................6-21
Clutch lever ...............................................3-5
Clutch lever free play adjustment ...........6-18
Controls/Instruments
(XVS650/XVS650A) ..............................2-5
D
Dimmer switch ..........................................3-3
E
Engine break-in ........................................5-5
Engine oil ..................................................6-9
Engine stop switch ...................................3-4
Engine trouble indicator light ....................3-2
F
Final gear oil ...........................................6-11
Front brake lever ......................................3-5
Front brake lever free play
adjustment ...........................................6-19
Front fork inspection ...............................6-25
Front wheel installation ...........................6-31
Front wheel removal ...............................6-31
Fuel ...........................................................3-7
Fuel cock ..................................................3-8
Fuel tank breather hose ...........................3-7
Fuel tank cap ............................................3-6
Fuse replacement ...................................6-27
G
Give safety the right of way ......................1-1
H
Handlebar switches ..................................3-3
Dimmer switch ....................................3-3
Engine stop switch ..............................3-4
Horn switch .........................................3-3
Lights switch .......................................3-4
Pass switch .........................................3-3
Start switch .........................................3-4
Turn signal switch ...............................3-3
Headlight bulb replacement ...................6-28
Helmet holder .........................................3-12
High beam indicator light ..........................3-2
Horn switch ...............................................3-3
I
Identification number records ...................9-1
Idle speed adjustment ............................6-14
Indicator lights ..........................................3-2
Engine trouble indicator light ..............3-2
High beam indicator light ....................3-2
Neutral indicator light ..........................3-2
Turn indicator light ..............................3-2
Inspecting the brake fluid level ...............6-22
K
Key identification number .........................9-1
L
Left view (XVS650) ...................................2-1
Left view (XVS650A) ................................2-3
Lights switch .............................................3-4
Luggage strap holders ............................3-15
M
Main switch/Steering lock .........................3-1
Model label ...............................................9-2
N
Neutral indicator light ................................3-2
P
Panel A .....................................................6-6
Panel B .....................................................6-7
Panel removal and installation .................6-5
Parking ......................................................5-6