oil type YAMAHA YD110 2007 Owners Manual

1. Engine oil drain plug
batu vkW;y Mªsu Iyx
c. Remove the drain plug and drain
the oil.
Mªsu Iyx dks [kksy dj ckgj fudky
ysa v©j rsy dks fudyus nsaA
d. Reinstall the drain plug and
tighten it to the specified torque.
Mªsu Iyx dks fQj ls yxk nsa v©j bls
fu£n"V VkdZ rd dl nsaaA
f. Start the engine and warm up for
a few minutes. While warming
up, check for oil leakage. If oil
leakage is found, stop the engine
immediately and check for the
cause.
batu dks pkyw djsa v©j dqN feuVksa
ds fy, FkksM+k xeZ djrs le; rsy ds
fjlko dh tk¡p dj ysaA ;fn rsy
*yhd^ dj jgk gks rks batu dks rqjar
can dj nsa vkSj dkj.k dh tk¡p djsaA
ALWAYS CHANGE ENGINE OIL AT RECOMMENDED GRADE OF ENGINE OIL
ges'kk dsoy çLrkfod xzsM dk batu&vkW;y gh ç;ksx djsaA
e. Fill engine with oil and install the
dipstick.
batu dks rsy ls Hkj ysa v©j fMikfLVd
dks mlesa yxk nsaA
Tightening torque
dlk x;k VkdZ %
Drain plug
Mªsu Iyx %
14.5 Lt.-lb (2.0 m-kg)
Recommended oil:
YAMALUBE 4 stroke motor oil
(20 W 40 type SG) or equivalent.
Oil quantity:
Total amount : 1.2 L
Periodic oil change :1.0 L
6.13
çLrkfod rsy %
;kekY;wc&
4 LVªksd eksVj vkW;y
¼
20
M~CY;w
40
Vkbi ,l th½ vFkok
mlds leku½
rsy dh ek=kk %
dqy ek=kk %
1.2
fyñ
le;≤ ij rsy esa
ifjorZu %
1.0
fyñ
PERIODIC MAINTENANCE AND MINOR REPAIR
lkef;d j[kj[kko rFkk ekewyh ejEer
1
PG1_55.pmd10/15/2006, 9:15 AM 51

CAUTION :
•Make sure the air filter is
properly seated in the air filter
case.
• The engine should never be run
without the air filter installed.
Excessive piston and/or
cylinder wear may result.
• Dirty Element Air Cleaner
causes excessive fuel
consumption and loss of
power.
• Clean Element Air Cleaner after
every 2000 kms.
• The Element Air Cleaner should
be cleaned and lubricated more
frequently (every 1000 km,s), if
Motorcycle is operated in very
dusty (e.g. unpaved, dust laden
roads) conditions. lko/kkuh %•
;g lqfufpr djsa fd ,;j&fQYVj
lgh tk,A
excess oil. They should be wet
but not dripping.çR;sd ewy Hkkx dh van#uh lrg ij
çLrkfod rsy gh yxk, v©j Qkyrw
rsy ds fupksM+ ysA os ¼ewy Hkkx½ xhys
gksus pkfg, u fd rsy esa Mwcs gq,A
6.15
PERIODIC MAINTENANCE AND MINOR REPAIR
lkef;d j[kj[kko rFkk ekewyh ejEer
Recommended oil
çLrkfod rsy :
20W40 type SG
7. Pull the air filter elements over
the frame and install the air filter
in the case.
,;j&fQYVj ds ,yhesaV ¼ewy&fgLlksa½
dks Ýse ds Åij ls [khap ys rFkk
,;j&fQYVj dks dsl ds vanj yxk nsaA
8. Install the Spring Wire.
¯Lçx okW;j Hkh yxk,¡A
9. Install the air filter case cover and
panel
,;j&fQYVj dsl ds doj v©j iSuy
dks yxk nsaA
CAUTION :

Do not twist Element Air Cleaner.lko/kkuh
:
,;j&fQYVj ,fyesaV dks u ?kqek;saA WARNINGEnsure no distortion/proper
positioning of felt seal 1 if damaged
contact YMIS dealer.
psrkouh
QsYV lhy
1 lgh rjg ls yx;sa vxj [kjkc
gks rks okbZñ ,eñ vkbZñ ,lñ ds Mhyj ls laidZ
djsaA1
PG1_55.pmd10/17/2006, 8:31 AM 53

Throttle cable and grip
lubricationFkzkWVy dscy v©j fxzi Y;wczhdsV
djukAThe throttle twist grip assembly
should be greased at the time that
the cable is lubricated, since the
grip must be removed to get at the
end of the throttle cable. After
removing the screws, hold the end
of the cable up in the air and put in
several drops of lubricant. With the
throttle grip disassembled, coat the
metal surface of the grip assembly
with a suitable all purpose grease.ftl le; dscy dks Y;wczhdsaV fd;k tkrk
gS mlh le; ^FkzkWVy V~foLV fxzi vlsEcyh*rkj¨a d¨ tax&çfrj¨/kh rsy rFkk dscy ds
fdukj¨a ls yqczhdsV djsaA ;fn dscy lgh rjhds
ls dke ugh dj jgh g¨ r¨ okbZñ,eñvkbZñ,lñ
Mhyj ls bls cnyrs d¨ dgsaA
dh fxzlhax Hkh dh tkuh pkfg,A FkzkWVy dh
dscy ds fljs ds fy, FkzkWVy fxzi dks
[kksysaA isp gVkus ds ckn rkj ¼dscy½ ds
,d fljs ¼fdukjs½ dks gok esa idM+s jgsa
vkSj ml ij Y;wczhdsaV dh cgqr lh cwansa
MkysaA FkzkWVy fxzi dks [kksyus ¼vyx&vyx
djus½ ds lkFk fxzi vlsEcyh dks /kkrq ds
ry ij ;Fkk;ksX;] cgqmís'kh; ¼vkWy ijit+½
xzhl dh dks¯Vx dj nsaA
Cable inspection and
lubricationdscy dk fujh{k.k ,oa Y;wczhds'ku WARNINGDamage to the outer housing of
cables may lead to internal
rusting and interfere with the
cable movement. Replace
damaged cables as soon as
possible to prevent unsafe
conditions. psrkouhdscy ¼rkj¨a½ dh ckgjh gkůlx ds
{kfrxzLr g¨us ls ;g vanj ls tax idM+
ldrh gS v©j blls dscy d¨ Åij uhps
ewoesaV djus esa eqf'dy vk ldrh gSA
vlqjf{kr fLFkfr;¨a ¼gkykr¨aa½ ls cpus ds
fy, {kfrxzLr rkj¨a ¼dscy½ d¨ ftruh
tYnh g¨ lds cny nsaALubricate the cables and cable
ends with anticorrosive oil . If a
cable does not operate smoothly,
ask a YMIS dealer to replace it.Recommended lubricant
çLrkfod yqczhdsVj %20W40 Type SG
6.29
PERIODIC MAINTENANCE AND MINOR REPAIR
lkef;d j[kj[kko rFkk ekewyh ejEer
pg56_96.pmd10/15/2006, 8:53 AM 65

SPECIFICATIONS
ModelCRUX
Dimensions:
Overall length2,000 mm
Overall width735 mm
Overall height1,075 mm
Seal height 780 mm
Wheelbase1,260 mm
Ground clearance160 mm
Minimum turning radius 2,000 mm
Weight : ( With oil & 90% fuel ) 113 kg
Engine :Engine type Air cooled 4-stroke,
SOHC
Cylinder arrangement Forward inclined
single cylinder
Displacement105.6 cm
3
Boer × Stroke49×56 mm
Compression ratio9.0 : 1
Starting systemKick starter
Lubrication systemWet sump
Maximum power7.60 PS(5.59kw) @ 7500 RPM
Maximum torque 0.8 Mkg @ 6000 RPM
EngineOil
Type:
CAUTION :
Be sure to use motor oils that do not contain
antifriction modifiers. Passenger car motor oils
(often labelled Energy conserving) contain anti-
friction additives which will cause clutch/or
starter clutch slippage, resulting in reduced
component life and poor engine performance.
Capacity :
Periodic oil change 1.0 L
Total amount 1.2 L
Air filter:Foam type element
Fuel :
Type Regular gasoline
(petrol)
Fuel tank capacity 11.0 Litres
Reserve amount1.4 Litres
Carburetor:
Type VM17SH
ManufactureMIKUNI
SPECIFICATIONSfo'ks"k fooj.k
8.1
YAMALUBE
4-Stroke motor oil (20W40)
Type SG
pg56_96.pmd10/15/2006, 8:53 AM 88

Wheels:
Ty p e :
FrontSpoke wheel
RearSpoke wheel
Size:Front1.60 × 18
Rear1.60 × 18
Brake:
Front :
Type Drum brake
operationright Hand lever
Rear :
Type Drum brake
Operation Right foot operation
Suspention :
Front Telescopic fork
RearSwing arm
Shock absorber:
Front Coil spring/oil damper
RearCoil spring/oil damperWheels travel:
Front 110 mm
Rear 70 mm
Electrical:
Ignition system:CDI (Digitally
Controlled)
Generator system:
Type Flywheel magneto
Standard output 12V
Battery:
Type Lead acid
Voltage, capacity 12V 2.5AH
Bulb voltage, Wattage × Quantity:
Headlight12V 35W/35W × 1
Tail/Brake light 12V 21W/5W × 1
Front flasher light 12V 10W × 2
Rear flasher light 12V 10W × 2
Meter light 12V 2W × 1
Neutral indicator light 12V 3.4W × 1
High beam indicator light 12V 3.4W × 1
Turn indicator light 12V 3.4W × 1
Fuse:
Main 10A
8.5
SPECIFICATIONSfo'ks"k fooj.k
pg56_96.pmd10/15/2006, 8:53 AM 92

14. Location of Storage and Tool Kit compartments and their use.
15. Procedure of opening and closing of L. H. Side Panel.
16. Battery Maintenance : Checking of electrolyte level (To add only distilled water if required &
to maintain its Specified Level)
17. Correct Drive Chain Slackness (20 ~30 mm).
18. Correct type of Spark Plug and Spark Plug gap.
19. Engine Oil (in Gear Box), level checking and explaining the importance of replacing the Engine
Oil after every 2000 KMS Always use YAMALUBE 4T OIL SG Grade.
20. TFF oil to be replaced after every 10000 Kms.
21. Running- In Period/ Preventive Maintenance Schedule Instructions
22. Information of emission and safety norms alongith Catcon & AIS.
23. Importance and schedule of Free Services
24. Warranty Terms and Conditions.
INSTALLATION
IMPORTANT CAUTION
EXPLAINED BY:SIGNATURE :NAME :
MAIN SELLING DLR'S STAMP, SIGN & CODE
CUSTOMER’S SIGNATURE:10-36
SERVICE2.pmd10/15/2006, 8:54 AM 6