Oil Abarth 500 2010 Owner handbook (in English)
[x] Cancel search | Manufacturer: ABARTH, Model Year: 2010, Model line: 500, Model: Abarth 500 2010Pages: 170, PDF Size: 3.04 MB
Page 122 of 170
121
WARNING
LIGHTS AND
MESSAGES
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
YOUR CAR
SAFETY
DEVICES
CORRECT USE
OF THE
CAR
IN AN
EMERGENCY
IF THE BATTERY IS FLAT
IMPORTANT The battery recharging pro-
cedure is provided as an example only.
You are recommended to go to a Abarth
Dealership to have this operation per-
formed.
Low amperage slow recharging for ap-
proximately 24 hour is advised. A pro-
longed recharge might damage the battery.
Charge the battery as follows:
❒disconnect battery negative terminal;
❒connect the charger cables to the bat-
tery terminals, observing the poles;
❒turn on the charger;
❒when you have finished, turn the charg-
er off before disconnecting the battery;
❒reconnect battery negative terminal.
Battery fluid is poisonous
and corrosive: avoid contact
with your skin and eyes. The battery
recharging operation must be per-
formed in a ventilated place, away
from naked flames or possible sources
of sparks to avoid the risk of explo-
sion and fire.
WARNING
Don’t try to recharge a
frozen battery: defrost it first
to prevent the risk of explosion. If a
battery was frozen, have it inspect-
ed by specialised personnel before
recharging to check that the internal
elements are not damaged and that
the casing is not cracked causing the
risk of leakage of poisonous, corrosive
gas.
WARNING
RAISING THE CAR
As a result of its sporty nature, the car is fit-
ted with aerodynamic spoilers at the bot-
tom and miniskirts at the side. If the vehi-
cle needs to be raised, go to an Abarth
Dealership which is equipped with arm lifts
and workshop lifts.
Take special care when posi-
tioning the arm lifts or the
workshop lift in order not to
damage the aerodynamic
spoilers and miniskirts.
fig. 41a
169,5 mm 150,7 mm
F0S139Ab
095-122 ABARTH 500 GB 29-04-2009 9:43 Pagina 121
Page 127 of 170
30 60 90 120 150 180
●●●●● ●
●●●●● ●
●●●●● ●
●●
●
●●●●● ●
●●●●● ●
●●
●●●●● ●
●●●
●●●●● ●
●●●●● ●
126
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICATIONS
INDEX
YOUR CAR
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
Thousands of kilometres
Check rear disk brake pad conditions and wear
Replace the air filter cartridge
Top up fluids (engine coolant,
brakes, windscreen washer, battery, etc.)
Check the conditions of the distribution control toothed belt
Replace the distribution control toothed belt (*)
Replace the spark plugs (❍)
Check engine control system operation
(through diagnosis socket)
Check the mechanical gearbox oil level
Change engine oil and replace oil filter (or every 24 months)
Change brake fluid (or every 24 months)
Change the pollen filter (or anyway every year)
Check emissions at the exhaust
(*) Regardless of the km covered, the timing belt shall be replaced every 4 years for particularly demanding use (cold climates,
driving in the city, idling for a long time) or in any case every 5 years
If the car is mainly used for driving in the city, and in any case with an annual mileage of below 10,000 km, change
engine oil and filter every 12 months.
(❍) In order to ensure correct efficiency and avoid damaging the engine, it is necessary to:
- exclusively use certified spark plugs specific for the 1.4 TB BZ Abarth engines. All candles to be fitted must be
of the same type and same manufacturer (see recommendations reported in the “Engine” paragraph);
- strictly respect the candles’ Scheduled Maintenance Plan;
- it is recommended to apply to Abarth Dealership.
123-140 ABARTH 500 GB 29-04-2009 9:44 Pagina 126
Page 128 of 170
127
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICATIONS
INDEX
YOUR CAR
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
DEMANDING
USE OF THE CAR
Should prevailing use of the car be under
one of the following specially heavy con-
ditions:
❒dusty roads;
❒short distances (less than 7-8 km) re-
peated and with external tempera-
tures below zero;
❒frequently idling engines or long dis-
tance low speed driving or in case of
a long term inactivity;
❒in cities;
perform the following inspections more
frequently than shown on the Service
Schedule:
❒check front/rear disc brake pad con-
dition and wear;
❒check cleanness of bonnet and boot
locks and lever cleanness and lubrica-
tion;
❒visually inspect the conditions of: en-
gine, gearbox, transmission, pipes and
hoses (exhaust - fuel - brakes), rubber
parts (boots, sleeves, bushes, etc.);
❒inspect the battery charge and fluid
level (electrolyte) (refer to the para-
graph “Battery - Inspection of the bat-
tery charge and of the electrolyte lev-
el” in this chapter);
❒visual check on various drive belt con-
ditions;
❒check and if necessary replace the
pollen filter; in particular it shall be re-
placed if a decrease in the air flow in-
to the passenger comportment is de-
tected;
❒check air cleaner and replace, if re-
quired.
REGULAR
INSPECTIONS
Every 1,000 km or before long journeys,
check and top up if required:
❒engine coolant fluid level;
❒brake fluid level;
❒windscreen washer fluid level;
❒tyre pressure and conditions;
❒operation of lights (headlights, direc-
tion indicators, hazard lights, etc.);
❒operation of the windscreen wiper/
washer system, position and wear of
the windscreen and rear window
wiper blades;
Every 3,000 km check the following and
top-up, if required: engine oil level.
You are recommended to use FL
Seleniaproducts, designed and produced
specifically for Abarth cars (see table “Ca-
pacities” in section “Technical specifica-
tions”).
123-140 ABARTH 500 GB 29-04-2009 9:44 Pagina 127
Page 129 of 170
128
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICATIONS
INDEX
YOUR CAR
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
CHECKING FLUID
LEVELS
A.Engine oil filler
B.Engine oil level dispstick
C.Engine coolant
D.Windscreen washer fluid
E.Brake fluid
F.Battery
fig. 1 Never smoke while working
in the engine compartment.
there might be flammable gases and
vapours, with fire hazards.
WARNING
When topping up, pay atten-
tion not to confuse the vari-
ous types of fluids: they are all
reciprocally incompatible and
may severely damage your car.
B
A
D
CE
F
F0S117Ab
123-140 ABARTH 500 GB 29-04-2009 9:44 Pagina 128
Page 130 of 170
129
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICATIONS
INDEX
YOUR CAR
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
Engine oil consumption
The maximum engine oil consumption is
usually 400 grams every 1000 km.
When the car is new, the engine needs
to run in, therefore the engine oil con-
sumption can only be considered stabilised
after the first 5,000 ÷ 6,000 km.
IMPORTANT The oil consumption de-
pends on driving style and the conditions
under which the car is used.
IMPORTANT After adding or changing
the oil, let the engine turn over for a few
seconds and wait a few minutes after turn-
ing it off before you check the level. ENGINE OIL fig.1
Check the oil level a few minutes (about
5) after the engine has stopped, with the
car parked on level ground.
The oil level shall be included between the
MIN and MAX marks on the dipstick B.
The range between the MIN and MAX
levels corresponds to approximately 1
litre of oil.
If the oil level is near or even under the
MIN line, add oil through the filler Ato
reach the MAX line.
Oil level shall never exceed the MAX line.
Proceed very carefully inside
the engine compartment
when the engine is hot: risk of burns.
Remember that the fan may start up
if the engine is hot: risk of injury. Pay
attention to scarves, ties and other
loose fitting garments: they might get
caught by moving components.
WARNING
Don’t add any oil having dif-
ferent characteristics from
those of the existing engine oil.
The exhausted engine oil and
the replaced oil filter contain
substances that may be dan-
gerous for the environment. It
is advisable to have oil and filters
changed by a Abarth Dealership where
they will be disposed of according to
the law.
123-140 ABARTH 500 GB 29-04-2009 9:44 Pagina 129
Page 161 of 170
160
WARNING
LIGHTS AND
MESSAGES
YOUR CAR
SAFETY
DEVICES
CORRECT USE
OF THE
CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
Boot light .............................................. 46
– bulb replacement .......................... 115
Boot ........................................................46
– opening ........................................... 46
– closing ............................................. 47
– extension ........................................ 48
Brake fluid level ................................... 131
Brakes..................................................... 147
– specifications ................................. 147
– brake fluid level ............................. 131
Capacities ............................................ 154
Car maintenance and care ................123
– scheduled servicing ...................... 127
– service schedule ........................... 124
– scheduled maintenance plan ...... 125
– heavy-duty use of the car ........... 127
Carrying children in safety ................ 67
Ceiling light .......................................... 36
– activation ........................................ 36
– bulb replacement .......................... 114
Ceiling light .......................................... 36
– front ................................................ 36
– boot compartment ....................... 46
Central storage compartment ......... 40
Chassis marking ................................ 143
Checking fluid levels ........................... 128Child seats
(compliance for use) .................. 70-72
Cigar lighter ......................................... 39
Climatic comfort ................................ 27
– ventilation ...................................... 27
Clutch ................................................... 146
CO
2emissions .................................... 158
Code card ............................................ 5
Consumptions ..................................... 157
– fuel ................................................... 157
– motor oil ........................................ 139
Controls ............................................... 37
Cup holders ......................................... 40
Current outlet ..................................... 41
Dashboard .......................................... 3
Daytime lights....................................... 34
– activation......................................... 34
– bulb replacement........................... 113
Dimensions .......................................... 151
Dipped beam headlights .................... 34
– activation ........................................ 34
– bulb replacement .......................... 112
Direction indicators ........................... 34
– activation ........................................ 34
– front bulb replacement ............... 111
– side bulb replacement ................. 112
ABS System ........................................ 53
Accessories purchased by
the owner .......................................... 60
Air filter ................................................ 132
Air recycle ..................................28-29-31
Air vents ............................................... 27
Airbag .................................................... 73
– driver's front airbag....................... 74
– front airbag passenger side .......... 74
– driver's knee-level airbag............. 75
– Side bag-Window bag ............75-76
ASR ......................................................... 56
Automatic climate control system 31
Battery.................................................. 132
– jump starting with battery .......... 96
– useful advice .................................. 133
– inspecting the charge ................ 132
– battery charger ............................. 121
– replacement ................................... 132
Bodywork.............................................. 137
– version codes ................................144
– warranty ......................................... 138
– maintenance .................................. 138
– protection ...................................... 137
Bonnet .................................................. 49
Boot extension .................................... 48
I
I I I
N N N N
D D D D
E E E E
X X X X
160-168 ABARTH 500 GB 7-05-2009 16:45 Pagina 160
Page 162 of 170
161
WARNING
LIGHTS AND
MESSAGES
YOU CAR
SAFETY
DEVICES
CORRECT USE
OF THE
CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
Front seats ........................................... 23
– cleaning ........................................... 140
Fuel cap ................................................. 61
Fuel cut-off system ............................. 38
Fuel filler cap ....................................... 61
Fuel level gauge ................................... 11
Fuel .........................................................154
– tank capacity .................................. 154
– fuel consumption .......................... 157
– fuel level gauge .............................. 11
– refuelling ......................................... 154
– fuel cut-off system ....................... 38
Functions menu ................................... 14
Fuse positions ...................................... 117
Fuse replacement ............................... 116
Glove compartment ......................... 40
Handbrake .......................................... 81
Hatchback emergency opening ........ 47
Hatchback opening.............................. 46
Hatchback/Boot door ........................ 46
Hazard lights ........................................ 37
Headlights ............................................. 51
– beam aim control ........................ 52
– beam orientation ......................... 51
– orientation of fog lights ............... 52
– beam orientation abroad ............ 52
Heated rear window ................28-29-31
Heating/ventilation system ............... 28
Heating/ventilation system................. 28Hill Holder system ............................. 55
Hill Holder system ............................. 55
Identification data .............................. 142
Ignition switch .................................... 8
In an emergency .................................. 95
Installing electrical/electronic
devices ................................................ 60
Instrument panel ................................. 9
Instruments .......................................... 9
Intelligent washing .............................. 35
Interior fittings .................................... 39
Interiors ................................................ 139
Isofix child seat ................................. 71
Isofix child seat .................................. 71
Isofix child seat ready ........................ 71
Jacking the car .................................... 121
Key with remote control ................ 5
– request for extra remote
controls .......................................... 7
– battery replacement .................... 7
– remote control cover
replacement ................................7
Key without remote control .......... 5
Levels ................................................... 128
Lighting (replacing a light bulb) ........107
– general indications ........................ 108
– types of lights ................................ 109
Load limiters ........................................ 65
Locking/unlocking from inside ......... 44 – rear bulb replacement ................. 113
Door lock device locking/unlocking
from outside ..................................... 43
Doors .................................................... 43
Dualdrive
(electric power steering system) .. 58
Dualdrive electric power
steering system ................................. 58
Engine compartment (washing) ...... 139
Engine Cooling Circuit ...................... 11
Engine cooling system fluid level ..... 130
Engine oil level. .................................... 129
Engine..................................................... 145
– identification code ........................ 144
– specifications ................................. 145
– branding .......................................... 143
EOBD (system) .............................54-57
ESP system ....................................... 54
External lights ...................................... 34
Fiat CODE system ........................... 4
Fix & Go (quick repair kit) .............. 98
Fixed glass roof ................................... 41
Flashing the headlights ....................... 34
Fluid gauge
Fluids and lubricants ........................... 155
Fog lights .............................................. 37
– activation ..................................37-38
– bulb replacement .......................... 113
Follow me home device .................... 35
160-168 ABARTH 500 GB 7-05-2009 16:45 Pagina 161
Page 163 of 170
162
WARNING
LIGHTS AND
MESSAGES
YOUR CAR
SAFETY
DEVICES
CORRECT USE
OF THE
CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
– request for extra remote
controls .......................................... 7
– battery replacement .................... 7
Rear fog lights ...................................... 38
– activation ........................................ 38
– bulb replacement .......................... 113
Rear head restraints............................ 24
Rear screen washer ........................... 36
– activation ........................................ 36
– fluid level ........................................ 130
Rear screen wiper .............................. 36
– activation ........................................ 36
– brushes ........................................... 136
– sprayers .......................................... 137
Rear seats ............................................. 24
Rear view mirrors .............................. 26
– exterior .......................................... 26
– interior ........................................... 26
Refuelling the car ................................ 61
Removal of parcel shelf ..................... 49
Rev counter ......................................... 11
Reversing light ..................................... 113
Roof rack/ski rack .............................. 51
– trailer hitch ready ......................... 51
Rubber hoses ....................................... 135
Safety ................................................... 63
Saving on fuel ....................................... 82
SBR (system) ........................................ 64
Seat adjustment ................................... 23
Seat belts............................................... 64
– warnings ......................................... 65– use of .............................................. 64
– load limiters ................................... 65
– maintenance .................................. 67
– seatbelt tensioners ....................... 65
Seatbelt tensioners ............................. 65
Seats ...................................................... 23
Sidelights ............................................... 34
– rear bulb replacement ................. 113
Snow chains ......................................... 85
Spark plugs............................................ 145
Speedometer (tachometer)............... 11
Sport functions activation ................. 37
Starting the engine ........................80-96
– jump starting with battery .......... 96
– bump starting ............................... 97
– ignition switch .............................. 8
– how to warm up the engine
that has just started ..................... 81
– engine turn off ...............................81
Starting the engine and driving ........ 79
Steering ................................................. 147
Steering column lock ......................... 8
Steering wheel adjustment ............... 25
Storing the car ....................................85
Sun roof ................................................ 41
– emergency action ......................... 43
Sun visors ............................................. 39
Suspension ........................................... 147
Symbols ................................................. 4
Tachometer (speedometer) ........... 11
TCC System ....................................... 56
Main beam headlights ....................... 34
– activation ........................................ 34
– flashing the headlights .................. 34
– bulb replacement .......................... 112
Manual climate control system ........29
Motor oil
– technical specifications ................ 155
– consumption .................................. 129
– checking fluid levels ...................... 129
MSR (system) ....................................... 56
Multifunctional and reconfigurable
multifunctional display...................... 12
– Display ............................................ 12
Number plate light ............................ 114
Oddment compartment .................. 39
Paint ..................................................... 138
Parking .................................................. 81
Particulate Filter (DPF) ...................... 132
Performance ........................................ 152
Plates...................................................... 142
– identification code ........................ 142
– bodywork paint ............................ 143
Power supply ....................................... 146
Power windows .................................. 45
Protecting the environment ............. 62
Radio .................................................... 59
Radio and cell phone transmitters .. 60
Radio frequency remote control .... 159
160-168 ABARTH 500 GB 7-05-2009 16:45 Pagina 162
Page 169 of 170
FUEL CAPACITIES (litres)
1.4 TB BZ ABARTH
Tank capacity 35
Reserve5
The car should only be refuelled with unleaded petrol with an octane rating (RON) of at least 95 (Specification EN 228)
Fiat Group Automobiles S.p.A. - Customer Services - Technical Services - Service Engineering -
Largo Senatore G. Agnelli, 5 - 10040 Volvera - Torino (Italia)
Print N. 603.81.381 - 04/2009 - 4
Edition
ENGINE OIL CHANGE1.4 TB BZ ABARTH
Engine sump 2.75
Engine sump and filter 2.90
COLD INFLATION PRESSURE (bar)
Add +0.3 bar to the prescribed inflation pressure when the tyres are warm.
Recheck pressure value with cold tyres.
Tyres Medium load * Full load
Front rear Front Rear
195/45 R16 84 V XL 2.3 2.1 2.6 2.4
205/40 R17 84 W XL 2.3 2.1 2.6 2.4
* At speeds above 160 km/h, use the inflation pressures for the maximum load conditions.
160-168 ABARTH 500 GB 7-05-2009 16:45 Pagina 168