battery Abarth 500 2015 Owner handbook (in English)

BATTERY
RECHARGING
IMPORTANT The battery recharging
procedure is given as information only.
It is advisable to contact an Abarth
Dealership to have this operation
performed.
Charging should be slow at a low
ampere rating for approximately 24
hours. Charging for a longer time may
damage the battery.
To recharge, proceed as follows:
❒disconnect the terminal from the
negative battery pole;
❒connect the charger cables to the
battery terminals, observing the
polarity;
❒turn on the charger;
❒when it is recharged, turn the charger
off before disconnecting it from the
battery;
❒reconnect the negative battery
terminal.
123) 124)
WARNING
123) Battery fluid is poisonous and
corrosive: avoid contact with
your skin and eyes. The battery
should be charged in a well
ventilated place, away from naked
flames or possible sources of
sparks: danger of explosion and
fire.
124) Do not attempt to charge a
frozen battery: it must be thawed
first, otherwise it may explode.
If the battery was frozen, have it
inspected by specialised
personnel before recharging to
check that the internal elements
are not damaged and that the
casing is not cracked, which
causes the risk of leakage
of poisonous, corrosive acid.
LIFTING THE CAR
28)
As a result of its sporty nature, the car
is fitted with aerodynamic spoilers at
the bottom and side skirts at the sides.
If the vehicle needs to be raised, go
to an Abarth Dealership which is
equipped with arm lifts and workshop
lifts.
IMPORTANT
28) Take special care when
positioning the arm lifts or the
workshop lift in order not to
damage the aerodynamic spoilers
and side skirts.
149

SERVICING AND MAINTENANCE
Correct maintenance permits the
performance of the car to be
maintained over time, as well as limited
running costs and safeguarding the
efficiency of the safety systems.
This chapter explains how.SCHEDULED SERVICING ...............154
SCHEDULED SERVICING PLAN .....155
PERIODIC CHECKS ........................158
HEAVY-DUTY USE OF THE CAR .....158
CHECKING LEVELS........................159
AIR CLEANER/POLLEN FILTER ......162
BATTERY ........................................162
WHEELS AND TYRES.....................164
RUBBER HOSES ............................165
WINDSCREEN/REAR WINDOW
WIPER ............................................165
BODYWORK ...................................167
INTERIORS .....................................169
153

SCHEDULED SERVICING PLAN
The checks listed in the Scheduled Servicing Plan, after reaching 120,000 km/8 years, must be cyclically repeated starting from
the first interval, thus following the same intervals as before.
Thousands of miles 9 18 27 36 45 54 63 72 81 90
Thousands of kilometres 15 30 45 60 75 90 105 120 135 150
Years12345678910
Check tyre condition/wear and adjust pressure, if
necessary; check “Fix&Go Automatic” kit recharge expiry
date (for versions/markets, where provided)●●●●●●●●●●
Check operation of lighting system (headlights, direction
indicators, hazard warning lights, luggage compartment,
passenger compartment, glove compartment, instrument
panel warning lights, etc.)●●●●●●●●●●
Check and, if necessary, top up fluid levels (engine
coolant, hydraulic clutch/brakes, screen washer, battery,
etc.)●●●●●●●●●●
Check exhaust emissions/smokiness●●●●●●●●●●
Use the diagnosis socket to check supply/engine
management systems operation, emissions and, for
versions/markets, where provided, engine oil degradation●●●●●●●●●●
Visually inspect condition of: exterior bodywork,
underbody protection, pipes and hoses (exhaust, fuel
system, brakes), rubber elements (gaiters, sleeves,
bushes, etc.)●●●●●
Check windscreen/rear window wiper blade position/wear●●●●●
155

PERIODIC CHECKS
Every 1,000 km or before long
journeys, check and, if necessary, top
up the following:
❒engine coolant level;
❒brake fluid level;
❒windscreen washer fluid level;
❒tyre inflation pressure and condition;
❒operation of lighting system
(headlights, direction indicators,
hazard warning lights, etc.);
❒operation of screen washer/wiper
system and positioning/wear of
windscreen/rear window wiper
blades.
Every 3,000 km check and, if
necessary, top up: engine oil level.
You are advised to use PETRONAS
LUBRICANTS products, which have
been designed and produced
specifically for Abarth cars (see table
"Capacities" in the "Technical
specifications" chapter).
HEAVY-DUTY USE OF
THE CAR
If the car is used mainly under one of
the following conditions:
❒towing a trailer or caravan;
❒dusty roads;
❒short, repeated journeys (less than
7-8 km) at sub-zero outside
temperatures;
❒engine often idling or driving long
distances at low speeds or long
periods of inactivity;
the following checks must be carried
out more often than indicated in the
Scheduled Servicing Plan:
❒check front disc brake pad condition
and wear;
❒check cleanliness of bonnet and
luggage compartment locks,
cleanliness and lubrication of linkage;
❒visually inspect condition of: engine,
gearbox, transmission, pipes and
hoses (exhaust - fuel system -
brakes) and rubber elements (boots -
sleeves - bushes - etc.);
❒check battery charge and battery
fluid level (electrolyte);
❒visually inspect condition of the
accessory drive belts;❒check and, if necessary, change
engine oil and replace oil filter;
❒check and, if necessary, replace
pollen filter;
❒check and, if necessary, replace air
cleaner.
158
SERVICING AND MAINTENANCE

CHECKING LEVELS
29)
130) 131).
A. Engine oil filler – B. Engine oil dipstick – C. Engine coolant – D. Windscreen washer fluid – E. Brake fluid – F. Battery
128AB0A0110
159

AIR CLEANER/
POLLEN FILTER
For filter replacement, contact an
Abarth Dealership.
BATTERY
The car is fitted with a low-maintenance
battery: no electrolyte top-ups with
distilled water are needed in standard
conditions of use.
INSPECTING THE
CHARGE AND THE
ELECTROLYTE LEVEL
The operations must be carried out as
described in this Owner Handbook only
by specialised personnel. Any top-up
operations must be carried out by
skilled personnel and by an Abarth
Dealership.
REPLACING THE
BATTERY
136) 137) 138) 139)
33)
4)
If required, replace the battery with an
original spare part with the same
specifications.
If a battery with different specifications
is fitted, the service intervals given in
the "Scheduled Servicing Plan" will no
longer be valid.
Follow the battery manufacturer's
instructions for maintenance.USEFUL ADVICE FOR
EXTENDING THE LIFE OF
YOUR BATTERY
To avoid draining your battery and
make it last longer, observe the
following instructions:
❒when you park the car, ensure that
the doors, tailgate and bonnet are
closed properly, to prevent any lights
from remaining on inside the
passenger compartment;
❒switch off all roof lights inside the car:
the car is however equipped with a
system which switches all interior
lights off automatically;
❒do not keep accessories (e.g. radio,
hazard warning lights, etc.) switched
on for a long time when the engine
is not running;
❒before performing any operation on
the electrical system, disconnect
the negative battery pole;
❒completely tighten the battery
terminals.
IMPORTANT If the charge level remains
under 50% for a long time, the battery
is damaged by sulphation, reducing
its capacity and efficiency at start-up.
162
SERVICING AND MAINTENANCE

The battery will also be more at risk of
freezing (this can happen as early as
-10°C). Refer to the paragraph "Car
inactivity" in "Starting and driving" if the
car is left parked for a long time.
If after buying the car, you want to
install electrical accessories that require
permanent electrical supply (alarm,
etc.) or accessories that in any case
burden the electrical supply, contact an
Abarth Dealership whose qualified
personnel, in addition to suggesting the
most suitable devices available in
Lineaccessori Abarth, will evaluate the
overall electric consumption, checking
whether the car’s electrical system is
capable of withstanding the load
required, or whether it should
be integrated with a more powerful
battery.
Since some of these devices continue
to consume electricity even when
the engine is off, they gradually run
down the battery.
WARNING
136) Battery fluid is poisonous and
corrosive. Avoid contact with
skin and eyes. Keep naked flames
and sources of sparks away from
the battery: risk of explosion and
fire.
137) Running the battery with an
excessively low fluid level will
damage the battery beyond repair
and could even cause its
explosion.
138) If the vehicle must remain
unused for a long time at a very
low temperature, remove the
battery and take it to a warm
place, to avoid freezing.
139) When performing any operation
on the battery or near it, always
protect your eyes with special
goggles.
IMPORTANT
33) Incorrect assembly of electrical
and electronic accessories may
cause severe damage to your car.
Go to an Abarth Dealership if
you want to install accessories
(anti-theft system,
radiotelephone, etc.): they will
suggest the most suitable devices
and advise you whether a higher
capacity battery needs to be
installed.
IMPORTANT
4) Batteries contain substances
which are very dangerous for the
environment. It is advisable to
contact an Abarth Dealership for
battery replacement.
163

WHATTODOIF
Fault Possible solution
... A TYRE IS PUNCTURED. Use the Fix&Go tyre repair kit. See page 131
... A TYRE DEFLATES. Restore the correct pressure. See page 183
... THE BATTERY IS FLAT. -See page 149 or contact an
Abarth Dealership.
... THE INTERNAL ROOF LIGHT DOES NOT
SWITCH ON.Replace the bulb.See page 142 or contact an
Abarth Dealership.
... THE LUGGAGE COMPARTMENT ROOF
LIGHT DOES NOT SWITCH ON.Replace the bulb.See page 143 or contact an
Abarth Dealership.
... AN EXTERNAL BULB (main beam, dipped
beam headlights...) DOES NOT COME ON.-Contact an Abarth
Dealership.
Replace the bulb.See page 142 or contact an
Abarth Dealership.
... THE REMOTE CONTROL DOES NOT
WORK.Replace the batteries inside the remote
control.See page 13 or contact an
Abarth Dealership.
... AN ELECTRIC WINDOW DOES NOT
WORK.Check the relevant protection fuse.See GENERAL
INFORMATION
page 144 or
contact an Abarth
Dealership.
Have the relevant window raising / lowering
motor checked.Contact an Abarth
Dealership.
... AN INSTRUMENT PANEL WARNING
LIGHT SWITCHES ON.- See page 83.
195

INDEX
A
BS .............................................. 53
ABS (system) ................................. 53
Air cleaner ...................................... 162
Analogue pressure gauge............... 79
Automatic climate control
system ......................................... 26
Battery .......................................... 162
– advice for extending lifetime ...... 162
– inspecting the charge ................ 162
– replacement .............................. 162
Battery (recharging) ........................ 149
Bodywork (cleaning and
maintenance) ............................... 167
Bodywork (warranty) ...................... 167
Bonnet ........................................... 48
Brake fluid ...................................... 160
Brakes ........................................... 177
Bulbs
– bulbs (replacement) ................... 135
– general instructions ................... 135
– types of bulbs ........................... 136
Car inactivity ................................. 128
Carrying children safely .................. 105
Checking levels .............................. 159
Cigar lighter.................................... 36
Cleaning and maintenance
– car interior ................................. 169
– leather parts .............................. 169– plastic parts .............................. 169
– seats ......................................... 169
Climate control
– Passenger compartment air
diffusers .................................... 21
Climatic comfort ............................. 21
Clutch ............................................ 176
CO2 emissions............................... 192
CODE Card .................................... 11
Control panel and on-board
instruments .................................. 78
Controls ......................................... 34
Correct reading of the rim .............. 181
Correct tyre reading ....................... 180
Cup/bottle holders ......................... 38
Daytime running lights (DRL) ......... 30
Digital engine coolant
temperature gauge....................... 79
Digital fuel level gauge .................... 79
Dimensions .................................... 184
Dipped headlights (bulb
replacement) ................................ 140
Dipped headlights/side lights ......... 30
Direction indicators (bulb
replacement) ................................ 139
Direction indicators ........................ 31
Display ........................................... 68
Doors ............................................. 42
– Door central
locking/unlocking ...................... 42
– door locking/unlocking .............. 42– opening/closing with the key ..... 42
Driver side knee bag ...................... 115
Driver's side front airbag ................ 114
Dualdrive electric power steering .... 59
EBD (Electronic Brake force
Distribution) .................................. 53
eco Index ....................................... 69
Electric windows ............................ 44
Engine codes - bodywork
versions ....................................... 173
Engine compartment (washing) ...... 168
Engine coolant ............................... 160
Engine............................................ 174
– marking ..................................... 172
Engine oil (consumption) ................ 160
Engine oil (level check) ................... 160
EOBD system ................................ 59
ESC (Electronic Stability Control)
system ......................................... 52
External lights................................. 30
Fiat CODE system......................... 10
Fitting "Universal" child restraint
system ......................................... 107
Fixed glass roof .............................. 40
Fix&Go Automatic (kit) .................... 131
Flashing ......................................... 30
Fluids and lubricants ...................... 188
Fog lights (bulb replacement) ......... 140
Fog lights/rear fog light................... 35
Follow Me Home (device) ............... 31