brake sensor Alfa Romeo 156 2004 Owner handbook (in English)

GETTING TO KNOW YOUR CAR93
Warningl ight Message
on displayx
LOW BRAKE FLUID AND/OR HANDBRAKE ONWhen the ignition key is turned to MAR, the warning light comes on but must go out after a
few seconds.
The warning light comes on (together with the message + symbol shown on the display) when
the level of the brake fluid inside the tank falls below the minimum, due to a possible leak in the
circuit and when the handbrake is switch on with the car moving.
d
BRAKE PAD WEARThe warning light on the dial comes on (together with the message + symbol shown on the dis-
play) when the front brake pads are worn; in this case, have them replaced as soon as possible.
WARNINGAs the car is fitted with wear sensors for the front brake pads, when replacing them,
also check the rear brake pads.
If the warning light
x
comes on when travelling (together with the
message on the display), check that the handbrake is not engaged. If
the warning light stays on with the handbrake off (together with the message
on the display), stop immediately and contact Alfa Romeo Authorized Services.
WARNING

GETTING TO KNOW YOUR CAR
178
Braking on corners always requires the ut-
most caution, even with the help of the ABS.
The most important piece of advice, how-
ever, is the following:Following these instructions you will be
in a condition to obtain peak braking per-
formance at all times.
WARNINGCars fitted with ABS must
only be fitted with wheel rims, tyres and
brake linings of the type and brand approved
by the Manufacturer.
The braking system is completed by the
electronic control braking distribution system
called EBD(Electronic Braking Force Dis-
tributor) which distributes the braking action
through the ABSsystem control unit and
sensors.
In the event of a system
fault, with lighting up of
the
>
warning light on the instru-
ment cluster (together with the
message + symbol shown by the
display), have the vehicle checked
immediately by Alfa Romeo Au-
thorized Services, driving slowly
to be able to regain full system
performance.
WARNING
When the ABS cuts in and
you feel the pedal pulse, do
not reduce the pressure, but keep
the brake pedal firmly pressed
with no fear; this way you will
stop in the shortest possible space,
compatibly with the conditions of
the road surface.
WARNING
The car is fitted with an
electronic brake distributor
(EBD). If the
>
and
x
warning
lights, where required, come on at
the same time (together with the
message + symbol shown by the
display) when the engine is run-
ning, there is an EBD system fault;
in this case, violent braking may
lock the rear wheels too early, with
the possibility of skidding. Drive
extremely carefully to the nearest
Alfa Romeo Authorized Services to
have the system checked over.
WARNING
In order to be able to exploit as far as pos-
sible the possibility of the antilock system
in the case of need, it is wise to follow a few
pieces of advice:
The ABS exploits the avail-
able grip in full, but it can-
not increase it; therefore, caution
is required on slippery surfaces,
without running unnecessary risks.
WARNING
If the ABS cuts in, it means
that the grip limit between
the tyres and the road surface has
been reached: it is necessary to
slow down and adapt driving to
the grip available.
WARNING

GETTING TO KNOW YOUR CAR
179
If the
x
low brake fluid
warning light comes on (to-
gether with the message + symbol
shown by the display), stop the car
immediately and contact the near-
est Alfa Romeo Authorized Ser-
vices. Indeed, any leak of fluid
from the hydraulic system com-
promises the effectiveness of both
the conventional brake system and
the system with antilock system.
WARNING
The turning on of the
>
warning light (together
with the message + symbol shown
by the display) with the engine
running normally indicates an ABS
system fault. In this case the brak-
ing system preserves its effec-
tiveness, without however making
use of the antilock device. Under
these circumstances, the EBD sys-
tem may fail to give top perfor-
mance. In this case, too, you are
recommended to contact Alfa
Romeo Authorized Services imme-
diately, driving in such a way as to
avoid abrupt braking, to have the
system checked.
WARNING
VDC AND ASR
SYSTEMS(where required)VDC SYSTEM (VEHICLE
DYNAMICS CONTROL):
GENERALThe VDC is an electronic vehicle stability
control system which, acting on the torque
and braking the wheels in a differentiated
manner, helps to bring the car back to the
correct course in the event of loss of grip.
While travelling the car is subjected to lat-
eral and longitudinal forces that may be
controlled by the driver up to when the
tyres offer adequate road-holding; when
this falls below the minimum level, the car
starts to deviate from the course required
by the driver.
Above all on rough surfaces (such as cob-
bles, or due to the presence of water, ice
or soil), changes in speed (when accelerat-
ing or braking) and/or course (bends or the
need to avoid obstacles) can cause the tyres
to lose grip.When the sensors detect the conditions
that would lead to skidding, the VDC system
acts on the engine and brakes generating
a stabilising torque.
The system performance
levels, in terms of active
safety, should not induce the dri-
ver to run pointless and unjustified
risks. Driving conduct should al-
ways be suited to the conditions of
the road surface, vision and traf-
fic. The responsibility for road
safety is always and anyway the
vehicle driver’s concern.
The VDC system helps the driver
to keep control of the car in the
event of loss of tyre grip.
The forces induced by the VDC sys-
tem to control the lack of stability
of the car always and anyway de-
pend on the grip between the tyre
and the road surface.
WARNING

TECHNICAL SPECIFICATIONS
305
SPARK PLUGClean, intact spark plugs are determinant
with regard to engine efficiency and for re-
ducing the emission of pollutants.Spark plugs should be re-
placed at the intervals
specified in the Scheduled
Maintenance Programme. Only use
spark plugs of the specified type: if
the thermal capacity is inadequate
or if the envisaged life is not guar-
anteed inconveniences may ensue.BRAKESService brakes:
– front
– rearParking brake
If examined by an expert eye, the ap-
pearance of a spark plug is a sound clue
for locating a fault, even if not involving the
ignition system. Therefore if you are expe-
riencing any engine problems, it is impor-
tant to have the spark plugs checked by Al-
fa Romeo Authorized Services.
STEERING
1.6 T.SPARK 1.8 T.SPARK 2.0 JTS 2.0 JTS 2.5 V6 24V 2.5 V6 24V JTD JTD 20V
Selespeed Q-System JTD 16V Multijet
MultijetSelf-ventilated Self-ventilated Self-ventilated Self-ventilated Self-ventilated Self-ventilated Self-ventilated Self-ventilated
disk disk disk disk disk disk disk disk
Disk Disk Disk Disk Disk Disk Disk Disk
Wheel anti-look system (ABS) with electronic braking distribution.
Servo-brake. Electronic control with brake pad wear sensors. Gasket of ecological type.
Controlled by hand lever operating rear brakes.
Type Turning radius(between pavements)
1.6 T.SPARK 1.8 T.SPARK 2.0 JTS 2.0 JTS 2.5 V6 24V 2.5 V6 24V JTD-JTD 16V JTD 20V
Selespeed Q-System Multijet Multijet
Rack and pinion.
Hydraulic power steering with liquid reservoir in engine compartment
11.1 m 11.1 m 11.1 m 11.1 m 11.6 m 11.6 m 11.1 m 11.1