brake fluid Alfa Romeo 159 2010 Owner handbook (in English)

230
SAFETY
DEVICES
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
TECHNICAL
SPECIFICATIONS
INDEX
CORRECT USE
OF THE CAR
DASHBOARD
AND
CONTROLS
CAR
MAINTENANCE
fig. 4 - 1.9 JTDM8v - 1.9 JTDM16v versionsA0E0162m
1.Engine oil - 2. Battery
3.Brake fluid - 4.Windscreen washer
fluid - 5.Engine coolant
6.Power steering fluid
1.Engine oil - 2. Battery
3.Brake fluid - 4.Windscreen washer
fluid - 5.Engine coolant
6.Power steering fluid
fig. 5 - 2.0 JTDMversion
653
2
4
1
A0E0853m
223-248 Alfa 159 GB 3-12-2009 14:11 Pagina 230

231
SAFETY
DEVICES
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
TECHNICAL
SPECIFICATIONS
INDEX
CORRECT USE
OF THE CAR
DASHBOARD
AND
CONTROLS
CAR
MAINTENANCE
fig. 6 - 2.4 JTDMversionA0E0203m
1.Engine oil - 2. Battery
3.Brake fluid - 4.Windscreen washer
fluid - 5.Engine coolant
6.Power steering fluid
223-248 Alfa 159 GB 3-12-2009 14:11 Pagina 231

BRAKE FLUID fig. 17
Check that the fluid level in the reservoir
is at maximum. Top up with the brake
fluid specified in the table “Fluids and
lubricants” (see section “Technical Spec-
ifications ").
NOTEClean accurately the tank cap A
and the surrounding surface. When
opening the cap take the utmost care to
prevent impurities entering the tank.
When topping up, always use a funnel
with built-in filter with mesh equal to
or lower than 0.12 mm.
A0E0016mfig. 17
Make sure that the high-
ly corrosive brake fluid
does not drip onto the
paintwork. If it does, wash it off
immediately with water.
IMPORTANTFor this operation it is
however recommended to contact Alfa
Romeo Authorised Services.
From time to time, check the instrument
panel warning light
x: pressing on cap
A(with key fitted into the ignition de-
vice) the warning light shall turn on.
IMPORTANTBrake fluid absorbs
moisture. For this reason, if the car is
mainly used in areas with a high degree
of atmospheric humidity, the fluid should
be replaced at more frequent intervals
than specified in the Service schedule.
CAR
MAINTENANCE
DASHBOARD
AND
CONTROLS
CORRECT USE
OF THE CAR
INDEX
TECHNICAL
SPECIFICATIONS
IN AN
EMERGENCY
WARNING
LIGHTS AND
MESSAGES
SAFETY
DEVICES
236
Brake fluid is poisonous
and highly corrosive. In
the event of accidental contact,
wash the parts involved im-
mediately with neutral soap
and water, then rinse thor-
oughly. Call the doctor imme-
diately if the fluid is swal-
lowed.
WARNING
Symbol πon the con-
tainer indicates syn-
thetic brake fluid, distinguish-
ing it from the mineral kind.
Using mineral fluids irre-
versibly damages the special
braking system rubber seals.
WARNING
223-248 Alfa 159 GB 3-12-2009 14:11 Pagina 236

242
SAFETY
DEVICES
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
TECHNICAL
SPECIFICATIONS
INDEX
CORRECT USE
OF THE CAR
DASHBOARD
AND
CONTROLS
CAR
MAINTENANCE
WINDSCREEN/REAR
SCREEN WIPERS
BLADES
Periodically clean the rubber part using
special products TUTELA PROFES-
SIONAL SC 35is recommended.
If the rubber blades are bent or worn
they should be replaced. In any case
they should be changed once a year.
A few simple notions can reduce the pos-
sibility of damage to the blades:
❒ if the temperature fall below zero,
make sure that ice has not frozen the
rubber against glass. If necessary,
thaw using an antifreeze product;
❒ remove any snow from the glass: in
addition to protecting the blades, this
prevents effort on the motor and
overheating;
❒do not operate the windscreen wipers
on dry glass.
RUBBER HOSES
As far as the brake system and fuel rub-
ber hoses are concerned, carefully fol-
low the Service schedule in this section.
Indeed ozone, high temperatures and
prolonged lack of fluid in the system
may cause hardening and cracking of
the hoses, with possible leaks. Careful
control is therefore necessary.
Driving with worn
wiper blades is a seri-
ous hazard, because visibility
is reduced in bad weather.
WARNING
223-248 Alfa 159 GB 3-12-2009 14:11 Pagina 242

249
SAFETY
DEVICES
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
CAR
MAINTENANCE
INDEX
CORRECT USE
OF THE CAR
DASHBOARD
AND
CONTROLS
TECHNICAL SPECIFICATIONS
T T
E E
C C
H H
N N
I I
C C
A A
L L

S S
P P
E E
C C
I I
F F
I I
C C
A A
T T
I I
O O
N N
S S
IDENTIFICATION DATA ........................................ 250
ENGINE CODES - BODYWORK VERSIONS ............... 252
ENGINE .......................................................... 253
FUEL FEED/IGNITION ........................................ 255
TRANSMISSION ............................................... 255
BRAKES........................................................... 256
STEERING........................................................ 256
SUSPENSIONS.................................................. 256
WHEELS.......................................................... 257
DIMENSIONS.................................................... 261
PERFORMANCE................................................. 263
WEIGHTS......................................................... 264
CAPACITIES...................................................... 266
FLUIDS AND LUBRICANTS................................... 267
FUEL CONSUMPTION......................................... 269
CO
2EMISSIONS .............................................. 270
RADIO FREQUENCY REMOTE CONTROL:
MINISTERIAL CERTIFICATIONS ............................. 271
249-270 Alfa 159 GB 3-12-2009 15:51 Pagina 249

268
SAFETY
DEVICES
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
CAR
MAINTENANCE
INDEX
CORRECT USE
OF THE CAR
DASHBOARD
AND
CONTROLS
TECHNICAL SPECIFICATIONS
Synthetic-based oil, grade SAE 75W-85
that passes API GL 4 specifications.
Qualification FIAT 9.55550-MZ1
Synthetic-based oil, grade SAE 75W-90 that passes
API GL-5 specifications, ZF-TE ML 18.
Qualification FIAT 9.55550-DA3
Synthetic fluid for hydraulic and electrohydraulic systems.
Qualification FIAT 9.55550-AG3.
Grease containing Molybdenum bisulphide for high temperature
appliances. NLGI 1-2 consistency.
Qualification FIAT 9.55580.
Grease for homokinetic joints with low friction coefficient.
NLGI 0-1 consistency.
Qualification FIAT 9.55580.
Synthetic fluid for Brake and clutch controls FMVSS n° 116
DOT 4, ISO 4925, SAE J1704, CUNA NC 956-01
Qualification FIAT 9.55597.
Protective with antifreeze action, red colour based on inhibited
monoethylen glycol and organic formula, that passes
CUNA NC 956-16, ASTM D 3306 specifications.
Qualification FIAT 9.555523.
Additive for diesel fuel with anti-freeze action,
protecting Diesel engines.
Mixture of alcohol and surfactants CUNA NC 956-11.
Qualification FIAT 9.55522.TUTELA CAR
MATRYX
Contractual Technical
Reference N° F108.F02
TUTELA
MULTIAXLE
Contractual Technical
Reference N° F426.E06
TUTELA GI/RContractual Technical
Reference N° F428.H04
TUTELA ALL STARContractual Technical
Reference N° F702.G07
TUTELA STAR 700Contractual Technical
Reference N° F701.C07
TUTELA TOP 4Contractual Technical
Reference N° F001.A93
PARAFLUUP(●)Contractual Technical
Reference N° F101.M01
TUTELA DIESEL ARTContractual Technical
Reference N° F601.L06
TUTELA
PROFESSIONAL SC 35
Contractual Technical
Reference N° F201.D02
Mechanical gearbox
and differential
Rear differential and
transmission unit
(3.2 JTS 4X4 and
2.4 JTD
M4x4 version)
Power steering
CV joints
on wheel side
CV joints
on differential side
Brake and clutch
hydraulic controls
Radiator antifreeze
proportion:
50% water and
50% PARAFLU
UP(❏)
To be mixed with fuel oil
(25 cc per 10 litres)
To be used diluted
or undiluted
Windscreen/
headlight washer
fluid Protective agent
for radiators Brake fluid
(●) IMPORTANTDo not top up or mix with fluids having different specifications from those described here.
(
❏) For particularly hard climate conditions, we recommend use of a 60% PARAFLUUPand 40% demineralized water mixture.
Additive for
diesel fluid
Use Fluid and lubricant specifications Original fluids Applications
for correct car operation and lubricants
Lubricants and
greases
for transmission
249-270 Alfa 159 GB 3-12-2009 15:51 Pagina 268

319
SAFETY
DEVICES
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
CORRECT USE
OF THE CAR
DASHBOARD
AND
CONTROLS
INDEX
– useful advice for
lengthening the life ............. 239
Bodywork (cleaning) ................ 244
Bonnet ................................... 105
Boot ...............................101-277
– light replacement ................ 208
Brakes ................................... 256
Bulb (replacement) .................. 196
– general instructions ............. 196
– types of bulbs .................... 197
Capacities .............................. 266
Car inactivity ........................... 164
Car maintenance................ 223
– periodical checks ................ 227
– use of the car under heavy
conditions .......................... 227
– service Schedule ................. 225
– scheduled service ................ 224
Carrying children safely ............. 135
– child restraint systems ......... 138
– passenger’s seat compliance . 138
– presetting for mounting the
“Universal Isofix” child restraint
system .......................140-285Ceiling lights
– front ................................. 78
– rear .................................. 80
Checking fluid levels ................. 228
Child lock device ...................... 97
Cigar lighter ............................ 85
Climate control system .............. 53
– automatic two-/three-zone .. 58
– manual ............................. 55
CO
2emissions ......................... 270
CODE card .............................. 12
Containing running costs ........... 157
Controls ................................. 81
Correct use of the car........ 149
Courtesy mirror light
– bulb replacement ................ 206
Cruise Control .......................... 76
Dashboard and controls.... 6
Dashboard buttons ................... 72
Dimensions ............................. 261
Dipped beam headlights
– bulb replacement ................ 201
– control .............................. 70 ABS system ............................ 108
Accessories purchased
by the owner ........................ 116
Additional heater ..................... 69
Air bags ...........................141-145
Air/pollen filter ........................ 237
Air vents ................................. 54
Alarm ..................................... 17
Alfa Romeo CODE system .......... 10
Alfa 159 Sportwagon....... 275
Armrest
– central .............................. 82
– rear ........................... 83-84
Ashtray .................................. 87
ASR system ............................ 112
At the filling station .................. 125
Automatic headlight sensor ........ 71
Automatic two/three-zone
climate control system ............ 58
Battery
– checking the charge ............ 237
– jump starting ..................... 182
– recharging ......................... 219
– replacing ........................... 238
I I
N N
D D
E E
X X
319-328 Alfa 159 GB 3-12-2009 15:53 Pagina 319

320
SAFETY
DEVICES
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
CORRECT USE
OF THE CAR
DASHBOARD
AND
CONTROLS
INDEX
– fuel gauge ......................... 22
Fuel cut-off and power supply
switches ............................... 81
Fuel feed ................................ 255
Fuel filler cap .......................... 126
Fuses (replacement) .......... 209-292
Gearbox (use) ........................ 156
Glass/can holder ..................... 87
Glove compartment .................. 85
Glove compartment light
– bulb replacement ................ 207
Handbrake ............................. 155
Hazard lights ........................... 72
Head restraints ................. 48-49
Headlight washer
– control .............................. 73
– fluid level .......................... 232
Headlights .............................. 65
– adjusting headlight beam ..... 106
– headlight adjustment abroad 107
– headlight aiming device ....... 106
– front fog light adjustment ..... 107
Hill Holder system .................... 111
Homelink ............................... 89
Identification data .................... 250
If an exterior light burns out .. 196-288
If an interior light burns out .. 205-290
Ignition device ......................... 19In an emergency................ 181
Inactivity of the car .................. 164
Inertial fuel cut-off switch .......... 80
Installation of electric/
electronic devices ................... 117
Instrument panel ..................... 7-8
Instruments ............................ 21
Interior fittings ......................... 83
Interiors ................................. 247
Isofix universal
(child's seat) ..................140-286
Jacking the car ........................ 220
Labels
– identification data ............... 250
– bodywork paint .................. 251
Level checks ........................... 230
Main beam headlights
– bulb replacement ................ 199
– control .............................. 70
Manual climate control system ... 55
MSR system ........................... 114
Multifunction display ................ 25
Number plate light .................. 204
Oddments compartments .......... 88
Paint ..................................... 246
Parking .................................. 155 Direction indicators
– bulb replacement 200-201-204
– control .............................. 70
Doors ..................................... 96
Electronic key .......................... 12
Engine
– identification code ............... 252
– marking ............................ 251
– technical data .................... 253
Engine oil
– consumption ...................... 232
– level check ........................ 231
– specifications ..................... 266
Engine starting ........................ 150
Environment protection ............. 127
EOBD system .......................... 115
External lights ......................... 70
Eyeglasses holder .................... 87
Fix&Go automatic (device) ....... 190
Flashing the headlights ............. 70
Fluid level checks ..................... 230
Fluids and lubricants ................. 267
Follow me home (device) ......... 71
Front ceiling lights
– bulb replacement ................ 205
– control .............................. 78
Front fog lights
– bulb replacement ................ 202
– control .............................. 72
Fuel
– consumption ...................... 269
– fuel cut-off switch ............... 81
319-328 Alfa 159 GB 3-12-2009 15:53 Pagina 320

Rims
– understanding rim marking ... 258
Roof rack/ski rack ............ 106-284
Rubber hoses .......................... 242
Safe lock device ...................... 14
Safety devices.................... 129
S.B.R. system ......................... 131
Seat belts ............................... 130
Seats ..................................... 45
Side/taillights
– bulb replacement ......... 200-203
– control .............................. 70
Ski tunnel ............................... 84
Smart washing ........................ 74
Snow chains ........................... 163
Sound system ......................... 293
Steering ................................. 256
Steering lock ........................... 21
Steering wheel (adjustment) ..... 49
Sun curtains ............................ 88
Sun visors ............................... 88
Sunroof .................................. 93
Suspensions ............................ 256
Symbols ................................. 10
Technical Specifications...... 249
Third brake light ...................... 204
Top speeds .............................. 263
Towing the car ......................... 221
Towing trailers
– installing the tow hook ........ 159
T.P.M.S. system ....................... 122Transmission ........................... 255
Tyres
– changing ........................... 183
– inflation pressures ............... 260
– snow tyres ........................ 162
– standard tyres .................... 259
– understanding tyre marking .. 257
VDC system ........................... 110
Warning lights and
messages.......................... 165
Weights ................................. 264
Wheel geometry ...................... 260
Wheel rims
– understanding rim marking ... 258
Wheels
– changing ........................... 183
– technical data .................... 257
Wheels and tyres ..................... 240
Windows (cleaning) ................. 246
Windscreen washer
– control .............................. 75
– fluid level .......................... 232
Windscreen wiper
– blades .............................. 242
– control .............................. 73
– nozzle .............................. 243 Parking lights
– control .............................. 72
Parking sensors ....................... 118
Performance ........................... 263
Power windows ....................... 99
Pretensioners .......................... 132
Protecting the environment ........ 127
Puddle light
– bulb replacement ................ 208
Quick tyre repair kit
Fix&Go automatic .................. 190
Radio frequency remote control:
ministerial certifications ........... 271
Radio transmitters
and cellular telephones ........... 117
Rain sensor ............................. 74
Rear ceiling lights
– bulb replacement ................ 205
– control .............................. 80
Rear fog lights
– bulb replacement ................ 202
– control .............................. 72
Rearview mirrors ...................... 50
Reconfigurable multifunction
display ................................. 30
Rev counter ............................ 21
Reverse light
– bulb replacement ................ 202
Right hand drive version.. 297
321
SAFETY
DEVICES
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
CORRECT USE
OF THE CAR
DASHBOARD
AND
CONTROLS
INDEX
319-328 Alfa 159 GB 3-12-2009 15:53 Pagina 321