lock Alfa Romeo 4C Spider 2019 Repair Manual
[x] Cancel search | Manufacturer: ALFA ROMEO, Model Year: 2019, Model line: 4C Spider, Model: Alfa Romeo 4C Spider 2019Pages: 292, PDF Size: 3.25 MB
Page 178 of 292

2. Open protective flap (2) and replace bulb (1), releas-ing it from the side contacts. Make sure that the new
bulb is correctly secured between the contacts.
3. Close protective flap (2) and install roof light in its housing, making sure that it is locked in place.Luggage Compartment Roof Light
To replace the bulb, proceed as follows:
1. Open the luggage compartment and remove luggagecompartment roof light, working in the direction
shown by the arrow.
1 — Bulb
2 — Protective Flap
1 — Light Cover
2 — Light Protector
176 IN CASE OF EMERGENCY
Page 181 of 292

CavityMaxi Fuse Mini Fuse Description
F01 70 Amp Tan –Body Controller
F03 20 Amp Yellow –Ignition Switch
F04 40 Amp Orange –Anti-Lock Brake Pump
F05 20 Amp Yellow –Anti-Lock Brake Valve
F06 40 Amp Orange –Radiator Fan - Low Speed
F07 50 Amp Red –Radiator Fan - High Speed
F08 20 Amp Yellow –Blower Motor
F09 –5 Amp Tan Headlight Beam Switch – If Equipped
F10 –10 Amp Red Horn
F11 –20 Amp Yellow Powertrain
F14 –15 Amp Blue Alfa Twin Clutch Transmission
F15 –15 Amp Blue Alfa Twin Clutch Transmission
F16 –5 Amp Tan Alfa Twin Clutch Transmission, ECM
F17 –10 Amp Red Powertrain
F18 –5 Amp Tan Powertrain
F19 –7.5 Amp Brown Air Conditioning Compressor
F21 –20 Amp Yellow Fuel Pump
F22 –20 Amp Yellow Engine Control Unit Power Supply
F23 –25 Amp Clear Alpine Amplifier – If Equipped
F24 –5 Amp Tan Anti-Lock Brake System (ABS)
7
IN CASE OF EMERGENCY 179
Page 182 of 292

CavityMaxi Fuse Mini Fuse Description
F30 –10 Amp Red Water Pump, HVAC
F82 30 Amp Green –Headlamp Washer – If Equipped
F83 40 Amp Orange –Alfa Twin Clutch Transmission Pump
F84 –5 Amp Tan After Run Pump
F86 –15 Amp Blue Rear Power Outlet 12V
F88 –7.5 Amp Brown Heated Mirrors
Dashboard Fuse Box
The dashboard fuse box is part of the Body Control
Module (BCM) and is located on the passenger side
under the forward passenger floor. Remove the six
screws and the forward floor pan to access the BCM.
CavityVehicle Fuse
Number Mini Fuse
Description
3 F53 7.5 Amp Brown Instrument Panel Node
4 F38 15 Amp Blue Central Door Locking
5 F36 10 Amp Red Diagnostic Socket, Vehicle Radio, TPMS, Alarm
6 F43 20 Amp Yellow Bi-Directional Washer
7 F48 20 Amp Yellow Passenger Power Window
9 F50 7.5 Amp Brown Airbag
180 IN CASE OF EMERGENCY
Page 200 of 292

Under any of the above circumstances, the following
checks need to be performed more frequently than
indicated in the Maintenance Plan:
•Check front and rear disc brake pad condition and
wear.
• Check cleanliness of tailgate locks.
• Check cleanliness and lubrication of chassis and
steering linkage.
• Visually inspect condition of: engine, gearbox, trans-
mission, pipes and hoses (exhaust - fuel system -
brakes) and rubber elements (gaiters - sleeves -
bushes - etc.).
• Check battery charge and battery fluid level (electro-
lyte).
• Visually inspect condition of the auxiliary drive belts.
• Check and, if necessary, change engine oil and re-
place oil filter.
• Check and, if necessary, replace air cleaner filter.
Using the vehicle on a track should be regarded as an
exception. The vehicle has been designed and manufac-
tured for road use. Change engine oil at 4,000 miles (6,500 km) if the
vehicle is operated in a dusty and off road environment.
This type of vehicle use is considered Severe Duty.
If the vehicle is operated in a dusty or dirty environ-
ment the engine air filter has to be changed every 6,500
miles (10,000 km).
Once A Month Or Before A Long Trip/Periodic
Checks
Every 600 miles (1,000 km) or before long trips, check
and, if necessary, top off the following:
•
Check engine oil level.
• Check brake fluid level.
• Check windshield washer fluid level.
• Check the tire inflation pressures and look for un-
usual wear or damage.
• Check the fluid levels of the coolant reservoir and
brake master cylinder reservoir, and add as needed
• Check function of all interior and exterior lights.
Every 2,000 miles (3,000 km) check and, if necessary, top
up: engine oil level.
198 SERVICING AND MAINTENANCE
Page 202 of 292

Mileage or time passed
(whichever comes first)
12,000
24,000
36,000
48,000
60,000
72,000
84,000
96,000
108,000
120,000
132,000
144,000
156,000
Or Months: 12 24 36 48 60 72 84 96 108 120 132 144 156
Or Kilometers:
20,000
40,000
60,000
80,000
100,000
120,000
140,000
160,000
180,000
200,000
220,000
240,000
260,000
Check lighting system operation (head-
lights, direction indicators, hazard lights,
passenger compartment lights, boot lights,
instrument panel warning lights, etc.) XXXXXXXXXXXXX
Check vehicle fasteners X X X X X X X
Check mechanical components fasteners X X X X X X X X XXXXX
Check windshield/washer operation X X X X X X X X XXXXX
Check position/wear of windshield blade X X X X X X X X XXXXX
Check cleanliness of hood and deck lid
locks, as well as cleanliness and lubrica-
tion of associated linkages XXXXXXXXXXXXX
Visually inspect condition of: exterior body-
work, carbon monocoque, aerodynamic
bottom, pipes and hoses (exhaust, fuel
supply system, brakes), rubber elements
(boots, driveshaft boots, sleeves, bushes,
etc.) XXXXXXXXXXXXX
200 SERVICING AND MAINTENANCE
Page 214 of 292

WARNING!(Continued)
to Warranty Information Book, for further war-
ranty information.
• The air conditioning system contains refrigerant
under high pressure. To avoid risk of personal
injury or damage to the system, adding refriger-
ant or any repair requiring lines to be discon-
nected should be done by an experienced techni-
cian.
CAUTION!
Do not use chemical flushes in your air condition-
ing system as the chemicals can damage your air
conditioning components. Such damage is not cov-
ered by the New Vehicle Limited Warranty.
Refrigerant Recovery And Recycling — R–1234yf
R–1234yf Air Conditioning Refrigerant is a hydrofluo-
roolefin (HFO) that is endorsed by the Environmental
Protection Agency and is an ozone-friendly substance with
a low global-warming potential. The manufacturer recom-
mends that air conditioning service be performed by an
authorized dealer using recovery and recycling equipment.
NOTE: Use only manufacturer approved A/C system
PAG compressor oil, and refrigerants.
Body Lubrication
Locks and all body pivot points, including such items as
seat tracks, door hinge pivot points and rollers, liftgate,
tailgate, decklid, sliding doors and hood hinges, should
be lubricated periodically with a lithium based grease,
such as Mopar Spray White Lube to assure quiet, easy
operation and to protect against rust and wear. Prior to
the application of any lubricant, the parts concerned
should be wiped clean to remove dust and grit; after
lubricating excess oil and grease should be removed.
Particular attention should also be given to hood latch-
ing components to ensure proper function. When per-
forming other underhood services, the hood latch,
release mechanism and safety catch should be cleaned
and lubricated.
The external lock cylinders should be lubricated twice a
year, preferably in the Fall and Spring. Apply a small
amount of a high quality lubricant, such as Mopar Lock
Cylinder Lubricant directly into the lock cylinder.
212 SERVICING AND MAINTENANCE
Page 217 of 292

If there is not a jet of fluid, first check that there is fluid
in the washer reservoir. Refer to “Adding Washer
Solvent” in this chapter for further information.
Then check that the nozzle holes are not clogged; use a
suitable tool such as a needle to unblock them if
necessary.
Exhaust System
The best protection against carbon monoxide entry into
the vehicle body is a properly maintained engine ex-
haust system.
If you notice a change in the sound of the exhaust
system; or if the exhaust fumes can be detected inside
the vehicle; or when the underside or rear of the vehicle
is damaged; have an authorized technician inspect the
complete exhaust system and adjacent body areas for
broken, damaged, deteriorated, or mispositioned parts.
Open seams or loose connections could permit exhaust
fumes to seep into the passenger compartment. In
addition, have the exhaust system inspected each time
the vehicle is raised for lubrication or oil change.
Replace as required.
WARNING!
•Exhaust gases can injure or kill. They contain
carbon monoxide (CO), which is colorless and
odorless. Breathing it can make you unconscious
and can eventually poison you. To avoid breath-
ing CO, refer to “Safety Tips” in “Safety” for
further information.
• A hot exhaust system can start a fire if you park
over materials that can burn. Such materials
might be grass or leaves coming into contact with
your exhaust system. Do not park or operate your
vehicle in areas where your exhaust system can
contact anything that can burn.
CAUTION!
• The catalytic converter requires the use of un-
leaded fuel only. Leaded gasoline will destroy the
effectiveness of the catalyst as an emissions con-
trol device and may seriously reduce engine per-
formance and cause serious damage to the engine.
• Damage to the catalytic converter can result if
your vehicle is not kept in proper operating
(Continued)
8
SERVICING AND MAINTENANCE 215
Page 278 of 292

Adding Engine Coolant (Antifreeze)...........218
Adding Fuel ........................... .158
Adding Washing Fluid ....................205
Additives, Fuel ......................... .258
AirBag ...............................110 Air Bag Operation ......................112
Air Bag Warning Light ..................109
Driver Knee Air Bag ....................113
Enhanced Accident Response ...........117,194
Event Data Recorder (EDR) ...............194
If Deployment Occurs ...................116
Knee Impact Bolsters ....................112
Maintaining Your Air Bag System ...........119
Maintenance ..........................119
Transporting Pets ..................... .129
Air Bag Light .....................77, 109, 131
Air Cleaner, Engine (Engine Air Cleaner Filter) . . .210
Air Conditioner Maintenance ................211
Air Conditioner Refrigerant ..............211,212
Air Conditioner System ....................211
Air Filter ............................. .210
Air Pressure Tires .............................. .236
Alarm System Security Alarm .........................20 Alfa DNA System (Dynamic Car Control System) .146
Alfa Twin Clutch Transmission............83, 141
Fluid Type ....................... .225, 263
Alterations/Modifications Vehicle ...............................5
Antifreeze (Engine Coolant) ..............217, 261
Disposal ............................ .220
Anti-Lock Brake System (ABS) ................88
Anti-Lock Warning Light ....................79
Automatic Transaxle .......................18
Automatic Transmission ...................141
Fluid Type .......................... .263
Battery ............................ .77, 208
Charging System Light ...................77
Keyless Key Fob Replacement ..............16
Belts, Seat ............................. .130
Body Mechanism Lubrication ................212
B-Pillar Location ........................ .231
Brake Fluid ........................... .263
Brake, Parking ......................... .139
Brake
System ....................... .221, 256
Anti-Lock (ABS) ........................88
Master Cylinder ...................... .221
Parking ............................ .139
276 INDEX
Page 280 of 292

Customer Assistance..................... .270
Cybersecurity .......................... .266
Daytime Running Lights ....................31
Dealer Service .......................... .209
Deck Lid, Release .........................50
Defroster, Windshield .....................131
Delay (Intermittent) Wipers ..................34
Diagnostic System, Onboard .................83
Dimmer Control Switch ....................33
Disabled Vehicle Towing ...................191
Disposal Antifreeze (Engine Coolant) ...............220
Door Locks Child-Protection Door Lock — Rear Doors .....24
Doors .................................22
Driver ’s Seat Back Tilt ......................25
Driving Through Flowing, Rising, Or Shallow Standing
Water .............................. .161
Electrical Power Outlets ....................57
Electric Brake Control System ................89
Electric Remote Mirrors .....................29
Electronic Speed Control (Cruise Control) .......150Electronic Throttle Control Warning Light
........76
Emergency, In Case Of Hazard Warning Flasher .................166
Jacking ............................ .225
Jump Starting ........................ .186
Overheating ......................... .190
Towing ............................ .191
Emission Control System Maintenance ..........84
Engine ............................... .204
Air Cleaner ......................... .210
Break-In Recommendations ...............139
Checking Oil Level .....................205
Compartment ........................ .204
Cooling ............................ .216
Exhaust Gas Caution ................130, 261
Fails To Start ........................ .138
Flooded, Starting ..................... .138
Fuel Requirements .....................258
Jump Starting ........................ .186
O
il ............................ .209, 261
Oil Filler Cap ..................... .204, 210
Oil Filter ........................... .210
Oil Selection ......................... .209
Overheating ......................... .190
Starting ............................ .137
278 INDEX
Page 282 of 292

Cleaning........................... .250
Passing ..............................31
Head Restraints ..........................26
Heated Mirrors ...........................30
Heater .................................39
Holder, Cup .............................56
Ignition ................................18
Key ............................. .15, 18
Switch ...............................18
Ignition Key Removal ......................18
Immobilizer (Sentry Key) ...................19
Inside Rearview Mirror .....................28
Instrument Cluster ..................... .60, 82
Instrument Panel Lens Cleaning ..............253
Interior And Instrument Lights ...............32
Interior Appearance Care ...................252
Interior Lights ...........................32
Intermittent Wipers (Delay Wipers) ............34
Introduction .............................4
Jack Operation ......................... .225
Jump Starting .......................... .186Key Fob
Unlock The Doors ......................15
Key Fob Battery Service (Remote Keyless Entry) . . .16
Key-In Reminder .........................19
Keys ..................................15
Replacement ..........................20
Sentry (Immobilizer) .....................19
Lane Change Assist .......................32
Lap/Shoulder Belts ...................... .101
Latches .............................. .133
Lead Free Gasoline ...................... .258
Leaks, Fluid ........................... .133
Life Of Tires ........................... .239
Light Bulbs ........................ .133, 166
Lights ............................. .31, 133
AirBag .......................77, 109, 131
Brake Warning .........................75
Bulb Replacement ..................... .166
Cruise ...............................82
Electronic Stability Program(ESP) Indicator .....77
Exterior ......................... .30, 133
Hazard Warning Flasher .................166
Interior ..............................32
Malfunction Indicator (Check Engine) ........
81
280 INDEX