AUDI A4 2000 B5 / 1.G APB Engine Motronic Syst

01-27

DTC
Description of malfunction
Corrective action
SAE
VAG


P0300 16684 Random/Multiple Cylinder
Misfire Detected
2) - Check cause for misfire Page 28
-52
P0301 16685
Cyl.1 Misfire Detected
2)
- Check fuel tank level
P0302 16686
Cyl.2 Misfire Detected 2)

P0303 16687
Cyl.3 Misfire Detected 2)

P0304 16688
Cyl.4 Misfire Detected 2)

P0305 16689
Cyl.5 Misfire Detected 2)

P0306 16690
Cyl.6 Misfire Detected 2)

2) With this malfunction the exhaust Malfunction Indicator Light (MIL) is only switched on by the ECM, if the malfunction is
recognized after the engine has been restarted. Significance of MIL Page 01
-3 .
The Malfunction Indicator Light (MIL) will blink if the Engine Control Module (ECM) recognizes misfire that could damage the
catalytic converters.
Notes:

On malfunction which could be caused by lack of fuel (e.g.: misfire) the malfunction P1250 "Fuel level too low" will be
displayed in addition. That means, the misfiring was detected due to lack of fuel in the tank and not due to a technical
malfunction.
Pa
ge 31 of 166 Motronic s
ystem, On Board Dia
gnostic
(OBD
)
11/22/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.FU04.01.1

Depending on malfunction recognition, the MIL comes on immediately or after it has been confirmed.
Pa
ge 32 of 166 Motronic s
ystem, On Board Dia
gnostic
(OBD
)
11/22/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.FU04.01.1

01-28

DTC
Description of malfunction
Corrective action
SAE
VAG


P0321 16705 Ign./Distributor Eng. Speed Inp. Circ.
Range/Performance
2) - Check Engine Speed Sensor Page 28
-21
P0322 16706 Ign./Distributor Eng. Speed Inp. Circ.
No Signal
2)
P0327 16711 Knock Sensor 1 Circ.
Low Input - Check Knock Sensor Page 28
-41
P0328 16712 Knock Sensor 1 Circ.
High Input
P0332 16716 Knock Sensor 2 Circ.
Low Input
P0333 16717 Knock Sensor 2 Circ.
High Input
P0341 16725 Camshaft Pos. Sensor Circ.
Range/Performance
2) - Check Camshaft Position Sensor Page 28
-45
P0346 16730 Camshaft Pos. Sensor Circ. 2
Range/Performance
2)
Pa
ge 33 of 166 Motronic s
ystem, On Board Dia
gnostic
(OBD
)
11/22/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.FU04.01.1

2) With this malfunction the exhaust Malfunction Indicator Light (MIL) is only switched on by the ECM, if the malfunction is
recognized after the engine has been restarted. Significance of MIL Page 01
-3 .
Pa
ge 34 of 166 Motronic s
ystem, On Board Dia
gnostic
(OBD
)
11/22/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.FU04.01.1

01-29

DTC
Description of
malfunction
Corrective action
SAE
VAG


P0421 16805 Warm Up Catalyst,
Bank 1
Efficiency Below
Threshold
2) Repair Manual, 2.7 Liter V6 5V BiTurbo Engine Mechanical, Repair Group 26;
Components of Exhaust system removing and installing, Catalytic converter
removing and installing - Generate readiness code Page 01
-99
, if same DTC is displayed again, replace
warm up catalytic converter bank 1
P0431 16815 Warm Up Catalyst,
Bank 2
Efficiency Below
Threshold
2) Repair Manual, 2.7 Liter V6 5V BiTurbo Engine Mechanical, Repair Group 26;
Components of Exhaust system removing and installing, Catalytic converter
removing and installing - Generate readiness code Page 01
-99
, if same DTC is displayed again, replace
warm up catalytic converter bank 1
2) With this malfunction the exhaust Malfunction Indicator Light (MIL) is only switched on by the ECM, if the malfunction is
recognized after the engine has been restarted. Significance of MIL Page 01
-3 .
Important note:
The warm up catalytic converters are located between the two oxygen sensors of the relevant cylinder bank. The warm up
catalytic converters (little smaller than main catalytic converter) are located closer to the engine, not to be misunderstood with
the main catalysts you see immediately once the vehicle is lifted.
Pa
ge 35 of 166 Motronic s
ystem, On Board Dia
gnostic
(OBD
)
11/22/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.FU04.01.1

01-30

DTC
Description of
malfunction
Corrective action
P0441 16825 EVAP Emission Contr.
Sys. Incorrect
Purge Flow
2) - Check EVAP canister purge regulator valve, perform output Diagnostic Test
Mode (DTM) Page 01
-75

P0442 16826 EVAP Emission Contr.
Sys. (Small Leak)
Leak Detected
2) - Check EVAP system and tank system for leaks
P0455 16839 EVAP Emission Contr.
Sys. (Gross Leak)
Leak Detected Repair Manual, Fuel Supply System, Repair Group 20, Components of EVAP
system servicing, carry out tank leak test

P0456 16840 Tank ventilation system
Pin-hole leak detected
Repair Manual, 2.7 Liter V6 5V BiTurbo Engine Mechanical, Repair Group 20;
Fuel supply, gas engine; EVAP canister system components, servicing; tank leak diagnostic, performing.
- Checking fuel supply and ventilation systems for leaks
2) With this malfunction the exhaust Malfunction Indicator Light (MIL) is only switched on by the ECM, if the malfunction is
recognized after the engine has been restarted. Significance of MIL Page 01
-3 .
Pa
ge 36 of 166 Motronic s
ystem, On Board Dia
gnostic
(OBD
)
11/22/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.FU04.01.1

01-31

DTC
Description of
malfunction
Corrective action
SAE
VAG


P0501 16885 Vehicle Speed Sensor
Range/Performance
2) - Check Vehicle Speed Signal (VSS) Page 24
-182
P0506 16890 Idle Control System
RPM Lower than
Expected
2) - Carry out adaptation of Throttle Valve Control Module Page 24
-146
P0507 16891 Idle Control System
RPM Higher than
Expected
2) - Check for unmetered (false) air Page 24
-76
P0560 16944 System Voltage
Malfunction - Check control module voltage supply Page 28
-32
P0562 16946 System Voltage
Low Voltage

P0563 16947 System Voltage
High Voltage

P0571 16955 Cruise/Brake Switch (A)
Circ.
Incorrect Signal Repair Manual, Electrical Equipment, Repair Group 01, On Board
- Check brake light switch and/or brake pedal switch Page 24
-185
Pa
ge 37 of 166 Motronic s
ystem, On Board Dia
gnostic
(OBD
)
11/22/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.FU04.01.1

Diagnostic for Cruise Control System

2) With this malfunction the exhaust Malfunction Indicator Light (MIL) is only switched on by the ECM, if the malfunction is
recognized after the engine has been restarted. Significance of MIL Page 01
-3 .
Pa
ge 38 of 166 Motronic s
ystem, On Board Dia
gnostic
(OBD
)
11/22/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.FU04.01.1

01-32

DTC
Description of malfunction
Corrective action
SAE
VAG


P0601 16985 Internal Contr. Module Memory
Check Sum Error
2) - Replace Engine Control
Module (ECM) Page 24
-24
P0604 16988 Internal Contr. Module Random Access
Memory (RAM) Error
2)
P0605 16989
Internal Contr. Module ROM Test Error
2)

P0606 16990 Control module faulty
- Replace Engine Control Module (ECM) Page 24
-24
2) With this malfunction the exhaust Malfunction Indicator Light (MIL) is only switched on by the ECM, if the malfunction is
recognized after the engine has been restarted. Significance of MIL Page 01
-3 .
Pa
ge 39 of 166 Motronic s
ystem, On Board Dia
gnostic
(OBD
)
11/22/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.FU04.01.1

01-33

DTC
Description of malfunction
Corrective action
SAE
VAG


P1102 17510 O2 Sensor Heating Circ., Bank1-
Sensor1
Short to B+
2) - Check oxygen sensor heater Page 24
-114
P1105 17513 O2 Sensor Heating Circ., Bank1-
Sensor2
Short to B+
2)
P1107 17515 O2 Sensor Heating Circ., Bank2-
Sensor1
Short to B+ 2)
P1110 17518 O2 Sensor Heating Circ., Bank2-
Sensor2
Short to B+ 2)
P1111 17519 O2 Control (Bank 1)
System too lean - Check oxygen sensor adaptation values and oxygen sensor control
Page 24
-86

P1112 17520 O2 Bank 1
System too rich
2) With this malfunction the exhaust Malfunction Indicator Light (MIL) is only switched on by the ECM, if the malfunction is
recognized after the engine has been restarted. Significance of MIL Page 01
-3 .
Pa
ge 40 of 166 Motronic s
ystem, On Board Dia
gnostic
(OBD
)
11/22/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.FU04.01.1