ignition coil BMW 540i 2001 E39 Repair Manual
Page 470 of 1002
Downloaded from www.Manualslib.com manuals search engine 
Fuel Injection 
Connector X60005 (continued) 
I I I 
6 /output l~erminal 1 signal ICylinder 1 ignition coil 
Cylinder 
2 ignition 
coil 
Cylinder 
3 ignition  coil 
Ground point 
3 
4 
5 
7 
8 -- 9 
Output 
Output 
Ground  Terminal 1 signal 
Terminal 
1 signal 
Ground 
Output 
Output 
Output  Terminal 
1 signal 
Terminal 
1 signal 
p 
Cylinder 4 ignition  coil 
Cylinder 
5 ignition  coil 
Cylinder 
6 ignition  coil    
Page 476 of 1002
Downloaded from www.Manualslib.com manuals search engine 
.-- - 
/ Fuel Tank and Fuel Pump - .. -. -- 1 
Fuel pump fuse and relay 
Troubleshooting  of any  fuel pump  fault should begin with 
checking  the fuel pump fuse  and the fuel pump  relay. The 
DME main relay should also be  checked. The fuel pump relay 
is located behind right side luggage compartment interior 
panel. 
I Fuel  pump relay 
BLU =blue ERN = blo$,m GRN =groan GRY = grsy ORG =orange PNI< =pink RED =red VIO =violel WHT = wlilte 
rk-; I I 1 ECM 
I I I 31 8 ,._--___.I 
NOTE- 
Special  tools are  required for some  of the tests  described 
here. 
4 Fuel pump circu~t is  fuse-protected. 
0 6-cylinder  models with Siemens DME MS41 .I, MS42, V-8 
models with Bosch DME  M5.2,  M5.2.1 englne manage- 
ment:  Fuse 
F54,15A (luggage compartment fuse panel) 
6-cylinder  models with Siemens DME MS43  engine man- 
agement: Fuse 
F22,25A (glove  compartment fuse panel) 
V-8 models with Bosch  DME M7.2: Fuse F54,25A (lug- 
gage  compartment  fuse  panel) 
- Fuse 31 in glove  compartment fuse panel supplies  power to 
coil side  of fuel  pump  relay. Engine  control module (ECM) 
supplies switched ground to  relay. During starting, fuel pump 
runs  as long  as ignition  switch is in START  position  and con- 
tinues to  run once  engine starts. If electrical system  fault in- 
terrupts power to fuel  pump, engine  will not run. 
. . 
Operating fuel  pump for tests 
- To operate fuel pump  for testing purposes without  having to 
run  engine,  bypass fuel pump  relay to power  pump directly. 
< To run fuel  pump, open luggage compartment  and release 
right side trim  panel.    
Page 992 of 1002
Downloaded from www.Manualslib.com manuals search engine 
2 INDEX 
Battery, starter,  alternator 
alternator (generator) 
121-10 
6-cylinder  engine, removingi 
installing 121-15 
M62 engine 121-16 
M62 TU  engine  (water cooled) 
121-18 
battery 
121-5 charging 121-9 
safety  terminal 121-3 
testing 121-5 charging  system,  troubleshooting 
121-12 
starter 
121-1 9 
6-cylinder  engine, removingi instaliinq 121-20 . V-8 engine, rernovinglinsialiing 
121-21 
solenoid, removinglinstalling 
121-23 troubleshooting 121-19 
see also Maintenance 
Bearing,  wheel 
see  Front  suspension 
see also  Rear suspension 
Belts  see Maintenance,  drive belts 
Blade,  wiper 
see Wipers and  Washers 
Blower motor  see 
A/C 
BMW  emblem 
see Exterior  trim 
BMW special tools  010-18 see also special  tools section  at 
beginning 
of each repair  group 
Body  dimensions 400-2 
interior  features 
400-9 salety and  security 400-7 
Body side  molding 
see  Exterior  trim 
Bonnet  see Engine hood 
Boot see  Trunk 
Brake  fluid 
020-24, 340-8 
Brake fluid pressure sensor 
340-30 
Brakes 
ABS,  ASC or DSC  system 
300-12 
component replacement 340-26 
ASCIDSC switch 
see  Switches 
bleeding 
bralces 340-8 
brake booster 340-1 9 bralce Dads. caiioers and  rotors ,., 340-1 1 
descriotion 300-10 
e~ectrdnic brake & stability 300-11 
light  switch 
see  Switches 
master cylinder 
340-16 pariking brake 340-22 
troubleshooting 340-5 
Bulbs  see Lights 
Bumper 
lront 510-6 height, adjusting 510-12 
rear 510-9 
Bus  system 
600-4 
Camber 
320-33 
Camshaft 
removingiinslaiiing 
M52  engine  116-12 
M52 TU 
/ M54  engine 116-1 9 M62 engine  11 6-39 
wear 
116-6 
Camshaft position  sensors 
see ignition  system 
Camshaft  timing chain 
adjusting  M52  engine 
117-22 
M52 TU I M54 engine 117-43 
M62 engine 117-79 removinglinstalling 
M52 engine 117-26 
M52TU 1 M54 engine 113-46.116- 
28 
M62 engine 117-66 
Capacities, fluid 
020.10 
Car rnemorvlicev memorv .  . 600-10 
see also Centrai 
lociking 
Carbon  canister,  activated 
see Fuel 
tank 
Caster 
320-33 
Catalytic converter  and  oxygen sensor  020-19 
see  also Exhaust  system: exhaust 
manilolds 
Cautions 
001-3 
CD changer 
650-4 
Center  bearing,  driveshaft 
see Driveshait 
Center  brake light 
sedan 
630-13 
Center  console 
513-3 
Centrai  body electronics (ZKE 111) 
600-6 
Central locking 
car memoryiey memory 515.12 general module iunctions 515-2 
remote  entry (FZV) 515-8 
remote  lkey initialization 515-10 single lociddouble ioclk 515-6 
switch 515-4 
Chain 
see  Camshaft  liming chain 
Characteristic  map (electrically  heated)  thermostat 
see Electrically  heated thermostat 
Charging  system 
see  Battery, starter,  alternator 
Cluster  see  instruments 
Clutch  fluid see  Maintenance 
hydraulics 
210-4 
mechanical 210-9 
switch 
see  Switches, pedal ciuster 
variations 
210.10 
Codes, fault OED-1 
Coil 
see Ignition  system 
Coil  spring 
see  Front  suspension 
see also  Rear 
suspe nsion    
Page 996 of 1002
Downloaded from www.Manualslib.com manuals search engine 
Gaskets and seals 01 
0-9 
Gearshift automatic  transmission 
adjusting 
250-7 
shift interiock.  checkino function " 250-9 
shiftloclc.  checicino function 250-8 - manual transmission 
gearshift  lever, removingiinstalling 
250-5 
steptronic 250-7 
General  module (GM Ill) 
600-8 
see also Central  locking 
Generator  see Battery,  starter, alternator 
Glass  see Door  window 
Glove compartment 
513-16 
see also 
Global  positioning  system 
(GPS) 
620-9 
Grill 
see Exterior  trim 
Grounds 
100-5 
Guide  link 
see Rear  suspension,  suspension 
arms 
Halogen headlight 
630-5 
Hand brake 
see  Brakes, pariring brake 
Handle,  door 
see Door 
locks 
Hatch seeTailgate 
Hazard  warning switch 
see  Switches  Headlight 
housing  trim 
see Exterior  trim 
washer611-17 see also  Lights 
Headlight  spray 
nozzle 
611-17 
Headlight switch 
see  Switches 
Heater  core 
see Heating 
Heater  valve 
see Heating 
Heating  lieater core, replacing 
640-18 
lheater  core temperature sensor, 
removingiinstalling 
640-12 heater  valve, replacing 640-17 
IHKA housing, removinglinstallin~ 
640-21 
see  also NC 
Hood 
410-6 
Hood latch and  release 
410-10 
Hydraulic  valve lifters 
see  Cylinder  head and  valvetrain 
IAT 
(lntalce air temperature)  sensor 
see  130 
under appropriate  fuel 
injection system 
idle  speed  control  valve 
see 130 
under appropriate fuel injection system 
Idle stabilizer 
see  130 
under appropriate  fuel 
injection  system, idie speed controi 
valve 
idler  arm 
320-30 
lgnition coll 
see lgnition  system 
lgnition  interlock 
320-13 
lgnition lock  cylinder 
removingiinstalling 
320-1 1. 612-4 
lgnition  switch 
seeSwifches 
Ignition system 
diagnosis  checking  for 
spark 120-10 
disabling ignition system 120-10 misfire detection 120-6 
oscilioscope diagrams 120.6 
troubleshooting 120-6 
camshaft  position sensors 120-14 coils 120.10 
crankshaft  speed sensor 120-12 firing order 120-9 
knoclc  sensors  120-16 
IHKA 
see NC 
IHKR see NC 
Injector 
see  130 under appropriate 
fuel 
injection system, luel injector 
Input  shaft 
oil seal 
see Manual transmission,  oil seals 
Inspection 
see Maintenance 
Instruments  GPS see Global  positioning  system 
(GPSI layout 6202 
removingiinstalling 620-8 self-testing 620-6 
Intake air temperature sensor  (IAT) 
see 130 under  appropriate fuel 
injection  system 
Intake  manifold 
removingiinstalling 
6-cvlinder enoine  110-10. 113-8. 113-22 - 
V-8 engine (M62) 113-56 
Integral  link 
see  Rear  suspension, suspension 
arms 
lnterior  lights 
see Lights 
lnterior protection 
(FISIUIS) 515-25 
lnterior trim 
513-13 
lnterior ventilation microfilter  see 
NC, ventilation  microfiller