check engine CHEVROLET MONTE CARLO 1981 4.G Owner's Guide

Downloaded from www.Manualslib.com manuals search engine CAUTION': It" the alr 'l;lMner i, ren;oveci during repair or maintenance, bel"'re to put H bl,ck on'eQr~ctly. It the air cleilner Is 'not correctly Inltalled. there could bea fire in the engine compertment (It there ~Id h..,.,en to be a backfire) , or other engitie mallunc1lon .
Front Suspension and Steering Linkage
Lubric;lte fi tngsatlhEj ' intery;>1 showninthe Maintenance Schedule with water
resistant
EP Chassis lUb(icantwhich meets GM SpecifICation 6031M.
NOTICE: ,Ball ' joints, should "not be . lubrieak.d unlesS, their temperature il -12"C (10"f},or higher,During ,coldweather, theyahould" .. ~"al,)c)~ to,warm up al nece ... ry ,before being lubricated or damttge to the baH jOint-Could occur. . , ' '.' "
.. ,. fIRnl 'N. c~~~arings
Clean and repack front wheel bearings with a high melting point wheel bearing
lubricant . at the interval shown in the Maintenance Schecule. Use wheel
' bearing lubricant GM Part No. 10 5~ 344 or equivalent.
NonCE: ," Long fiber " or "vbeou.'-' type"iubricenf ~kI nol be used, Do not mix wheel ~irinQ"lUbricant., Be sure to thoroughly c5aan bearings and hubl of all old lubricant before repacking.
Tapered roller,bearings uaed'h'Hhis 'veh icle have' .. sUghtly looSe teel when properly adjusted, They must never ~ over tightened (preJoaded) or sev .... bearing damage may resuit. Con.utt your,Authorized Deektr or Servi<:e.r.enual tor peper detailed adjustment procedures and specifications. . '~". :...,"" .... ~"";~f>"'~"'-"'''''',','',' ,::, Hood tlltchesand.Hood Hinge
At the interva l shown in the Maintenan ce Schedule lubricate hood latch
assembly
and hood hinge assembly as follows :
1. Wipe off any accumul"ti~!).ofqirt Qfoontaminationon latch Pi1!'ts.
2. Apply Lubriplate . or equivalent to latch pilot bolts and latch locking
plate .
3. Apply light engine oil to all pivot paints in release mechanism, as well
as primary and Secbndary latch mechanisms.
4. Lubricate hood hinges .
5~ Make hood hinge and latch mechanism functional check to assure the assembly is working COfTectiy.
Freedom Battery
Your new vehicle has a Delco FREEOOM battery. It neecs . no periodic
maintenance .
Its top is permanently sealec (except for two small vent holes) and has no filler capS. You will never have to add water.
The hydrometer (test indicator) in the top of the battery provides information for
testing purposes only.
For full power needs at replacement time, a Delco battery wijh the same catalog number as shown on the original battery's labe l is recommended ..
CAUTIQN: ",' FOllOW the precautions listed in the' Jump Starting ' 'Caution (see ' Ihe "In Case of EmergenCy " settlon of this manual) when workmg On or 08. a bMtery. Personal Injury {particularly to eyea} or 'property damage may result from battery e~ battery acid, or electrical (short circuit) burns.
5-10

Downloaded from www.Manualslib.com manuals search engine If the tires are other than standard load range (or load range B for metric size
tires). the
load range will appear after the tire size stated on the Tire Placard.
Inflation Pressure
The Cold inflation pressures listed on the Tire Placard provide for the best
balance of fuel economy. tire life. riding comfort. and vehicle handling under
normal driving conditions.
These pressures
should be used for all vehicle loading conditions. except When towing a trailer. See. "Trailer Towing in "Belore Driving Your Monte
Carlo." Section 1 of this manuaL
Incorrect tire inflation pressures can. have adverse effects on tire. lije and
vehicle performance. Too low an air preS$urecaul>eS incre<llled tire flexing and heat build up. This weakens the tire and increases the chance of damage or
f~lure,. It can result in tire overloading, abnormal tire wear, adverse vehicle handling. and reduced fuel~nomy .. Too high an air pressure can result in
abnormal wear. harsh ride. an.d can increase the chance of damage from road
hazards.
LUGGAGE/CARGO LOAD CAPACITY
Maximum Luggage Compartment Load
Coupe 72 Kilograms (160 Pounds)
"'"~~\"'_"~"""_'","",' NOTICE: Total combined weight of luggage _compartment 16ad •. ·.luggage rack load (when equipped). trailer tongue load and passengers must not exceed the vehicle capacity
weight (shown on the Tire Placard located on the left front door).
· ·' .L' Check tire inflation pressures at least monthly (this includes the spare tire) and whenever your _ vehicle is serviced. When -possible, check tire inflation pressures when'the tires are "cold."
1. The "cold" ttr~inflation pressure is the tire pressure when a vehicle has
not been driven more than one mile. (1.6 kilometers) after Sitting for three
hours or more. This is the most accurate setting.
2. It is normal for tire pressures to increase 30 to 60 kilopascals (4 to 8
pounds per square inch) or more when the tires become hot from driving. If you must set inflation pressures when the tires are not "cold," add 30
kilopascals
(4 pounds per square inch) to the recommended cold pressures on the Tire Placard.
3. For sustained driving at speeds of 75 mph to 85 mph (120 km/h to
140 km/h), in countries where such speeds are allowed by law, cold
inflation
pressures must be increased 20 kPa (3 psi) above the cold
inflation pressures stated on the tire placard up to the maximum for
each load range as listed in the Chart below. Sustained speeds of 75 mph to 85 mph (120 km/h to 140km/h) ar!! not allow!!d when the 20
kPa (3 psi) adjustment Would require the pressures of either the front or
the rear tiles to be greater than the maximum pressure for each load
range listed on the chart below. For speeds faster than 85 mph (140 km/h) follow Caution at th!! beginning of this "tire" section.
5-12

Downloaded from www.Manualslib.com manuals search engine STANDARD EXTRA B C o
TIRE-LOAD AND INFLATION PRESSURES
TIRE lOAO RAlliGE
-{METRIC SIZE TIRE) " -{METRIC SIZE T!RE) -(ALPKA-NUMIiRIC SJZETIRE) -(ALPHA-NUMERIC SIZE TIRE) -(ALPHA-NUMERIC SIZE TIRE)
MAXIMUM COLO INHATtoN "'E$SURE
2
40 kPI 280 kPa 220 kPa 2M! kPt 27S kP.
t 35 psi J (41 psi) (32 psi) (36 psi) (40 p.JiI
TIRE LOAD RANGE IS MOLDED Off TIRE. !SEE I UUSTRATIOff ON PAGE ,So11 fOR lOCATION ON THE TIRE S IDEWALl! .
4. Always use a tire pressure gage when checking inflation pressures (we
suggest
you purchase a quality pocket-type gage). Simply looking at the
tires to check inftation pressures is not enough , especially with radia l tires .
Underinflated radial tires may
look like correctly inflated radial tires. H the.
inflation pressure on a tire is often low , have your d9aler correct the cause.
) , I" , "
,
~ , ~ , , , , ) ,
,
,
'"
,
~
'"
,
0:: ~ , , ~ :0 , ,
PROPERLY INFlATED IMPROPERLV INRATED
l ___ ~_~)
y IlADIAL TIRE
5. Be sure to put the tire inflation valve caps back on, if so equipped. This
will help keep dirt · and moisture from getting into the valve core which
could cause a leak.
6. If an air loss occurs while driving, do not drive on the flat tire more than is
needed to stop safely. Driving even a short distance
ona flat tire can
damage a tire and wheel beyond repair.
Inspection and Rotation
Front and rear tires perlorm different jobs and can wear differently depending
on the types of roads driven , your driving habits, etc .
For longer tire
life, you should inspect and rotate your tires as recommended in
Section A of the Maintenance Schedule folder. Many car and tire dealers will perform a free tire inspection to look for uneven or abnormal tire wear (usually
caused
by wrong inflation pressures, lack of regular rotation, improper wheel
alignment, out
of balance tires, or poor driving habits).
After rotation , adjust the front
and. rear tire pressures (see the Tire Placard)
and be sure to check wheel nut tightness . (Wheel nuts should also be
tightened at certain intervals; see the Wheel Nut Torque Caution in "In Case of
Emergency" section,
page 3·7, for further information.)
5-13

Downloaded from www.Manualslib.com manuals search engine SECTION 7
SPECIFICATIONS
These specifications are given here for information only. Before using them,
see
the cautions and other instructions throughout this manual. For further
information, see the service manual covering the ,chassis or body part in
question. Your Chevrolet dealer may also be able to help.
DIMENSIONS
Overall Length 2"000r Coupe ' ......... ' ..
Overall Height .. .. , .................... . Width .... ,., , .. . , ....... , ... , ..... ... .
Wheelbase
.. , .... ... ................ .. ,
CAPACITIES
Gasoline ,Tank (Approx.) All Models , .... , .. , , ........
Crankcase (App rox. Relill )
Oil Change Only
Meiric U.S.
Metric U.S.
Measure Measure
5090mm 200. ,4 "
1370mm
53,9"
1816mm '. 71,S " 2745mm 108 .1 "
Metric U .S . Measure Measure
68 .5L 18.1 ga l.
Oil Change and FilterCha~
Metric U.S. Measure Measure Measure Measure
V ·8 ..... .... 3.8L 4 qts. 4.7L 5 qts. V-6 3.8L 4 qts. 3.8L 4 qu. "'" After refill , fluid If wei must be checked as~ out~ed-under "Service and Maintenance " in thi s manual.
Cooling System (Appro •. )
3.8 (229) CIO Engine .............•...•..... 3.8 (231) C1D En9in~ .....•.......•..••• ,'" .
5. 0 (305) CID Engine ......... , ... " _ ..•.. : •. 4.4 (267) CID Engi ne ....... , . ....•... •...•. Thermostat (All) .... " .... ,. _, ...... Radiator Pressure Cap (All) ......•. _ ...... .
BATTERY RATING
Cold Crank ,
Engine 18°C (O°F)
All (Base)
". X ' 350 Amps F-14
Heavy Duty
F-18 460 Amps
7-1
Metric Measure
17.4 L
14.3 L
18·0L 2O.0L 91°e l05kPa
U.S. Measur.
l8Y.!: qts. 15% qts. 19 qts. 21 qts. 195 °F
15 PSI
25 AMP Reserve
Capacity (Minutes)
80
115

Downloaded from www.Manualslib.com manuals search engine FUSES AND CIRCUIT BREAKER
The wiring circuits in yoUr 198 -1 Chevrolet are protected from short circuits by
a
combination of fuses, circllit breakers, and fusible thermal links in the
wiring itself. This greatly reduces the hazard of electrically caused fires in the
automobile. The fuse junction block is located under the left side of the
instrument panel .
The headlight
wiring is protected by a circuit bre a ker in the light switch . An
electrical overload
will cause the lights to go on and off, or in some cases to
remain off. If this happens, have your headlight wiring checked right away.
Be sides a fuse , the windshield wiper
motor is also protected by a circuit
breaker .
If the motor overheats, due to over load ing caused by heavy snow,
etc
., the wiper will remain stopped until the motor cools. Be sure to have th';·
cause of the overloading corrected.
Also , a
circuit breaker , on the f~se. panel, protects the power window, power
seat , rear
window defogger (elec.) and oth'9rcircuits when vehicle is so
equipped. Where current load is too heavy , the circuit breaker intermittently
opens and. c loses , protecting the circu it until the cause is found and
eliminated.
Fuses, located in th .e Junction Block beneath the dash on the
driver'S side are:
Fuses
Instrument Lamp , Heater Dial, Audio Alarm ........................ 5 Amp
Electronic Control Module. . . . . . . . . . . . . . . . . . . 10 Amp Cru ise Control ,Rear Defogger , Gages , Warning
Lamps, Warning Buzzers, Closed Loop
......................... 20 Amp
License , Parking
Lamp, Sidemarker Lamps, Tail Lamp ............. 20 Amp
Heater ,
AIC ................................. _ ................... 25 Amp
W iS Wiper ..... · ................................................. 25 Amp Stop Lamp ,Hazard Lamp, Courtesy Light, Dome Light,
Glove
Box Light , Underhond Light ............................. 20 Amp
Luggage Lamp, Lighter, Clock, Key .Warning Buzz er, Dome & .
Read Light, Power Antenna , Closed Loop ....................... 20 Amp
Radio, Delay Wiper ,
Idle Stop Sol. .............. _ ................. 10 Amp
Back-up Lamps, Dir.
S ig. Lamps ................................. 20 Amp
Choke Heater ............. .............. _ ............... ........ 20 Amp
7·3

Downloaded from www.Manualslib.com manuals search engine AJt Cleaner. Ail CoricIitionor FOlK Season .. Mainten ance .. AM" Pressu-e. Tires. AM" Vents. Alterna tOf tGEN) l.ghl AUniIlUffi Cafe .. AM or AM-FM Radios Antenna Antifreeze . Appearaoc e Care . Ash1rays & Lignler s. Assistance. Owl"lef Automat ic Door Locks. Automatic Transmission CorwElfter ClUlch Maintenanr;e
"""'-OpefaJ .... '1 TiPS.: AKIe. Re ar Standard . lifnited-SHp . Babies. AesCraint 01 .. BaIt Joints .. fun..., E mergency S ta ring F reedom. Gas Caution ..• GEN 191I... .•.• Test Indicator ...
. ........ 5-9
2-24
5-11
5-12
2-23 ....... 2·17 ... 2:27. 2-28 2·29 (Seo "Coolant") ,.,
2·22 6·' ,.,
2·10 5-5 .. 2 -9 2 ·'
5 ·'
5·' 1·10. ,-" . 5·1 0
3 ·' 5-10 3·' 2-17 5·10 Betore Dr iving Your Vehide... \. Bells: Sea!....,.. . (See I'Se at Belts") Blower, Healer & Air Cond.. 2-24. 2-25
Body Da mage . 4-4
.. """ ~,. Pedal Travel Trailer Towing .... Warning Ught .
2·14 2-\4 H2 2-17
Breakers . <;ircui t. • ..... 2-21. 7·3 Bteak ..... Period. New Vehicle ..• 2·2 Srioj'!( Headlights 2·7. 2·21 Brighl Metal Cleaning 4-4
Bulbs & Fuses.. 7·3. 7-4 Bumpers & HiIC:·~s. '·13 ~ 'Jack Operation ...... 3-4 B.w:ers._ . (See "'SOunds'" CoirpJler Con"mand Cont rOl System:~ 2·\8, 5·3 Cop Coolant A ecovery Tant.: .. ................. , .. 5-6 F uel.. 5-2 f>o¥Iier Steefing.. _____ -._ ....... ...... 0<. _____ -5-9 Radiator ... 5·8 Capacity, Cargo Weight. 5-11 Capacities. FlUid:. 7- Car Break-In Period . New.. 2-2 . car -Chemicals ... carbon Monoxide cautJorI .... ___ 4·' 2·' Care & Cleaning. Appearance . . .. 4·' Cargo Capacity . 5-11 Cargo on Root . Carrying,. '·2 Catalytic Converter . . ..................... ....... 5-2 ~ Command Control System .. -2·18. , ·3 Chains. Tire .. 5·15
7-6
Changing Wheets & Tires .. _ Cl-£O< ENGtl'E light .. Chectlbt, DrillSf . Child Seals & Restr ainls Chrome Protection .. ag.yette lighter ... CirCUIt Beakers QtiZOtlS Band Raoio . C!earIing .. Clock.I .. Cloth Trim Care .. ClutCh . Converter
Cold W&ather Starting ....
3 ·4 . 3·5 2 ·18. 5-3 ,., I -tO. 1·11 ... 2·22 2·21 , 7·3 2·29 . ..... 4·' 2-22 '·2 2·10 2·8 ~ip""lt Plocedu.-e . . ... 6 ·1
Condi lioner, Air (See "All" Cooditioner"~ Cons umer Relation s ... Converter ClUtch Con...eJo: Mirror Cooling System Afltilreeze (CooIanI) .. Overheating R ecovery Tank Service,. Thermoslal . COfl"lefing Lights . CorTosion Pmlection. Countries. Oper-ating in Fo.-eign .. Courtesy lights CruISe Control Cus!omer Service . 5·6
3·3
3 ·4 ,
5·6 '·7 '·8 2·7 . . 4-5 2· ' 2·30
2·12
6·' Damage, Sheet Metal . 4·4 Detogger,Re..-WiNJoW.. 2-25 DelrOSlor. Windshield . 2·24. 2·25 Delay Wipers 2·20 Descending a· Grade 2-9 Ditlererlliai (Rear Axle) limited·Slip __ 5·9 ,Malt)l~O 5 ·9
Trailllfing. 1·1 2
Dimensions 7· , Oimn'\e( Switch, Head~L 2·14 O ipshCks A.utomalic Tfansmission .. . 5-4 Engine Oil 5·3 Power Steering. 5-9 Directional Signals.. 2-7 Disc Brakes 2·15 Door loc::ks . __ ................ 1-2 Orivet' Checklist 1-1 Driving Down S teep Grades .... 2-9 in OU'sty Areas . 5 .... on Slippery Surlaces .................... 2·9 Economy ripS. Fuel .............................. 2-4 E lectric· Po_oo QpIion$ .. (See "Power"') Electrical System Banerv .. S-1 0 Bulbs .. . ....... ...... .... ........... 7,4 Circuit Breakers ....... , ........................ , 7-3 Fuses:. 7·3 GEN (Genefalor) lighI ..................... 2· 17 Jump S tarting 3- Spark Plugs 7-2 Voltmeter . 2·19 Emetgency. In Case oj Bralle WCIIllWlg li!1Il .. Eroglne Hot light .. • .. 2·17 . 2·17

Downloaded from www.Manualslib.com manuals search engine Freeing Vehicle When Stuck . Hazard Warnong FlaSher Jacking Jump Starti ng
Towing: Cru EtIlIssion Caution EmISSic:m Control
3·9 3·' 3·4, 3'5
C ata lytic Conve rter 5-2 ~te< Command ContrOl System 2·18. ; ·3 CHECK ENGINE ligh t Exha ust Ga s Caution
F uel Requ irements (Gas) E",,~
2·18. 5·3 ,., , .,
... " Break -In Code Coo~ng
(See Ma intenance Schedule) 2·2 , .; ;·6 El<haust Ga s Cau tion Fa.1s 10 Slarl Flooded, Sll!ttlng Fue l Roc'orTVDendation
,.,
.. , 2·9 ,.,
(See "Fuel") ' ·5 . .. 3·1 Ideflti hcation Jump Starting . C>r Overheating . Spec~fcations Starling . Cold WeaHJeI Star ting (Gasoline) Temperature Gage Tempera ture 19h1 Thermostat E OOIN E ligh!
{See ··Oir . . EllIjne··) 3·3 ,., ,.,
'·6 2·t9 2· 17 5·6 2·t8 El"9oo Oil. (See ·'Oi l. E'ngine.') E thylene Glycot Antifree ze
E)(hausl Gas Cau tion E~~. System , If'Ispection. Ederior Fnsh Care .
Fabric Care
Fan,
Healer & Air Cond FASTEN SEAT BELTS Light. . Fastener s. RepIacemeflI .. Fifter s
Air Cleal'lEl!' . , Finish Care. Firish Damage . Flammable C\e.aoets .. .. F lashers Hazard w arning . Turn Signal..
Flooded EngIne . Starling . Floor Controls .. F luid Capacities .. FM Radios .. Folding Seats ...
5·' ,.,
, .,
... . 4·4 ,., 2-24. 2·25 '·6 5 ·'
;., ,., ,., . . • -1
3·.1 ..... 2:7 . ....... , 2·9 ......... 2·13 ..... ..... 7·1
F Ofeign CounlrllltS . Operation in ... FOUl' Season Ioit ~ . Four·WayHazard FlasheI' ... Freedom Battery .. Freeirig Car When Stt.JCk.". , .... Cop . Economy Tips .. Gogo Gasohol .. a...... Octane RaIing ..
;., , ., . 2 ·15 . '. ..... 2-3 ....... .. . 2-3
7 ·7
Overse3$ OpefatiOtl _. Tanl( Capacity Fuse
Cha rt
Circuit Breakers ...
""'" Engrne Temperat lJ'e
Fuel.. Oil Prossure Tachometef (Engille $peed) Voltmetet' , .. Gasoline
GEN (Gener ator) Light
Glas s Clea ning
Gto"e 80)( Guard AQaIIlSl Theft Hazar d Warning Flasher Headlight s Circuil &eakel IJimmtIf Switc h
instrument Pa~ SWitch Light s ON Reminder .. Head Restraint s .. tEAT Light. Heated Rear Wmdow .
2·' ,.,
'·3 '·3
2-1 9 2-15 2·19 2·18
2· 19
(See "Fuer') 2-\7 ..,
2-16 ,.,
3'
.7-3 2,14 2--?1
2-21
'·5 2·17 2·25 Heat er/Air Condihoner2·23. 2-24 High ·Beam Head~ghl!i 2-2t _ 1·13 5·10 . (Inside Back Colter) 5·10. !Inside Sack Cover)
Hitches. Traile( . Hood Latches .. Hood Release . Horn .. HOT UghL Ideotihcation Nt.mbers 19r>ilion K9YS Lock . In Case of EIT1efgenc:y .nocator lights ... Infant Seats & Aestra.nt .. II1l1ati04'l Pressure. Tires. Inlets . Air.
2-t3 2·t7 7.·5
,.,
2·' ,., (See "UghIS") 1 ·10. r_ll 5·12 2·23 Inside Rearview Muror , '-3 Instrumetl t Pan&! & Controts .. 2·15 InleilOl Appe«i¥1Ce Care.. 4-1 Interior & inst rumen t Lights (See "Lights" ) Jacl:: Operation & Stowage.. 3- 4. 3 ·5 . 3-6 ~ S\aI1ing .. 3- 1 Keys...... '·1 Lane Ct\ange &. Turn Signals 2-7 Lap- Shoulcler Belts . (See "Seat Bells") L_
,_­Hood ...
,..
(Inside 8acto: Cover) Sealback. From. 1-4 Trunk . 2-22 lighter. Cigarette ... 2·22 ligh<' BRAKE .... ...................... .................. 2·1 7
Bright s On. !lui> c.... O£CI( ENGINE Choke Warning .. Comoring .................. . CouttKY·· ClimrneI-Swoi1ch. HNdigflt .. Electrical S)Stem (GEN) ..
2-21 ,..
2·18.,5·2 2-17 .. ....... 2-7 '·30 2-1. 2-11

Downloaded from www.Manualslib.com manuals search engine Service Publications­
Monte Carlo
The following publications covering the operation and servic·
ing of your Chevrolet can be purchased by filling out the
reverse side of this order
forril and mailing it with your check
or money order to Helm, Incorporated .
.
Form No. Description Price
ST 329·81 1981 PASSENGER CAR $12.00 .
SERVICE
MANUAL . Includes coverage of engine and
chassis components in terms of
maintenance,
on·the·vehicle reo ~;,"":."'dc'· pairs and adjustments, removal·
and installation of components.
Also includes Electrical Trouble·
~h99ting and Wiring Diagram in·
formatiorf. Will provide coverage to handle most owner's reo
quirements.
(Available January,
1981).
For complete coverage, ST·333-81 and ST·335·81 must also be
purchased.
ST 333·81 1981 OVERHAUL MANUAL $7.00
Includes basic off·the·car overaul of major components, (e.g. trans·
mission,
etc.).
(Available January, 1981)
ST 335·81 1981 BODY SERVICE MANUAL $10.00 Includes: Complete Body Service
Information for
all body styles.
14021742
1981 MONTE CARLO $1.50
OWNER'S
MANUAL
PleaseJiflin reverse-side of this form completely. Prices subject to chahge.

Downloaded from www.Manualslib.com manuals search engine NOTE: Please fill in order form and MAIL TO:
HiLm
Post Office Box 07130
Detroit, Michigan 48207
All orders will be mailed within 10 days of receipt. Please allow adequate time for postal service.
QUANTITY
FORM NO. PRICE EAqH TOTAL
$ .. $
S S
$ S
$ S
$
$
PRICES SUBJECT TO CHANGE Total Order
S
Michigan Purchasers-Add 4% Sales Tax" Mich. Sale. Tax S
Grand Total $
Make check or money order (NO STAMPS) forthls ~ amount payable to Helm, Incorporated.
NOTE: Prices apply to owners In the United States only. Canadian residents
should obtain a Canadian Servlee Manual Order Form .romany General
Motors dealership.
e~~u,~c::a~~; outside"domesticU.S.A. please write to Helm, Incor· tI Box 07130, Detroit, Michigan 48207 for quotation.
Natneot Purchaser [Please print clearly]
Street Address Apt. No.
City, State and Zip Code
This ;s your shipping 'libel •. Pleas. print clearly
FROM ••• CHEVROLET MANUAL HiLm DISTRIBUTION DEPARTMENT
Post Office Box 07130 DETROIT, MICHIGAN 48207 Return Requested
FOR Name
Street
Address Apt. No.
City, State and Zip Code
.. PLEASE COMPLETE SHIPPING LABEL CUT HERE ..
." ,
,
,
•

Downloaded from www.Manualslib.com manuals search engine SERVICE STATION INFORMATION
Refer to "Service and Maintenance,"
Section 5 for Further Details
Fuel Cap -Localed behind the license plate.
See fuel cap removal procedl,lre on page 5-1.
Fuel Requirements -Use unleaded gasoline only. See "Fuel Requirements "
in "Starting and Operating. " Section 2 of this manual.
Hood Release - Located beneath the instrument panel to the left of the
steering column. To open, pull the handle to release the hood lock. Then push down slightly on the hood while lifting the underhood lever , and raise the hood. (See illustration).
Engine Oil Oipstiek-Located on right or left side of engine block depending on engine model. Check the engine oil level when the oil is warm, such as during a fuel stop. Keep the oil level above the "Add " line on the dipstick .
Engine Oil Recommendation (Gasoline Engine) -Use only SF-quality oils. (See "Service and Maintenance," Section 50f this manuaL) The chart on page 5·5 will serve as a guide for choosing the proper viscosity oil.
Tire Inflation. Pressures -Check at least monthly (including the spare, unless it is a stowaway spare). Keep them inflated to pressures shown on
the Tire Placard on the left door. (Keep compact spare tires inflated to 415 kPa or 60 psL)
Engine Cooling System -Check the fluid level in the "see·through " coolant recovery tank at regular intervals , such as during a fuel stop. (See "Engine Cooling System " in "Service and Maintenance, " Section 5 of this manual.
Windshield Washer -Check reservoir fluid level regularly. Use a washer fluid, such as GM Optikleen .
Battery -Your new car has a Delco FREE[X)M It battery. You will never have
to add water. The hydror:neter (test indicator) in ,the cover provides infor­mation for testing purposes only.