Citroen BERLINGO 2005 1.G Service Manual

Downloaded from www.Manualslib.com manuals search engine 35
GENERAL
LUBRICANTS - TOTAL recommended oils
GEARBOX OILS
TOTAL TRANSMISSION BV
Norms S.A.E: 75W80
Part No.: 9730 A2
TOTAL FLUIDE ATX
T O TA L F L U I D E AT 4 2
Special oil distributed by
CITROËN
Part No.: 9730 A6
Special oil distributed by
CITROËN
Part No.: 9736 22 Manual and piloted manual
gearboxes
MB3 automatic gearbox
4HP20 and AL4 autoactive
automatic gearboxes
All countries
Special oil distributed by
CITROËN
Part No.: 9980 D4
TOTAL TRANSMISSION X4
Part No.: 9730 A7 AM6 autoactive automatic gearbox
Transfer box and rear axle
Angl.-t2-page001-39-2005 9/01/06 10:07 Page 35

Downloaded from www.Manualslib.com manuals search engine 36
GENERAL
LUBRICANTS - TOTAL recommended oils
POWER STEERING OILS
ENGINE COOLANT FLUID
TOTAL FLUIDE ATX
TOTAL FLUIDE LDS
Special oil distributed by CITROËN
Part No.: 9979 A3
Power steering
All countries
All countriesCITROËN fluid
Protection: -35C°2Litres
5Litres
20 Litres
210Litres9979 70
9979 71
9979 76
9979 779979 72
9979 73
9979 74
9979 75 PacksCITROËN Part No.
REVKOGEL 2000 GLYSANTIN G33TOTAL FLUIDE DA
Special oil distributed by CITROËN
Part No.: 9730 A1
Very cold countries Power steering all vehicles
(except CITROËN C4and C5)
Power steering
C4and C5
Angl.-t2-page001-39-2005 9/01/06 10:07 Page 36

Downloaded from www.Manualslib.com manuals search engine 37
GENERAL
LUBRICANTS - TOTAL recommended oils
BRAKE FLUID
Synthetic brake fluid
HYDRAULIC SYSTEM
WARNING: TOTAL FLUIDE LDS fluid cannot be blended withTOTAL LHM PLUS.
WARNING: CITROËN C5: Use exclusively TOTAL FLUIDE LDS suspension fluid.
All countriesTOTAL HYDRAURINCAGE
All countriesCITROËN fluid0,5Litre
1 Litre
5 Litres9979 05
9979 06
9979 07 PacksCITROËN Part No.
PacksCITROËN Part No.
Norm
Colour All countries
TOTAL FLUIDE LDS
TOTAL LHM PLUS
TOTAL LHM PLUS
Very cold countriesOrange 9979 A3
9979 A1
9979 A2 Green1 Litre
Angl.-t2-page001-39-2005 9/01/06 10:07 Page 37

Downloaded from www.Manualslib.com manuals search engine 38
GENERAL
SCREEN WASH FLUID
GREASING
General use
All countriesConcentrated: 250ml
Fluid ready
to use9980 33
9980 06
9980 05ZC 9875 953U
ZC 9875 784U
ZC 9885 077U9980 56
ZC 9875 279U Packs
CITROËN Part No.
LUBRICANTS - TOTAL recommended oils
1Litre
5Litres
Norms NLGI
2
TOTAL MULTIS 2
TOTAL SMALL MECHANISMS All countries
Note: NLGI= National Lubrificating Grease Institude.
Angl.-t2-page001-39-2005 9/01/06 10:07 Page 38

Downloaded from www.Manualslib.com manuals search engine 39
GENERAL
ENGINE OIL CONSUMPTION
I -Oil consumption depends on:
- the engine type.
- how run-in or worn it is.
- the type of oil used.
- the driving conditions.
II - An engine can be considered RUN-INafter:
- 3,000 miles
(5,000 km)for a PETROLengine.
- 6,000 miles (10,000 km)for a DIESELengine.
III - MAXIMUM PERMISSIBLEoil consumption for a RUN-IN engine:
- 0.5 litres per 600 miles
(1,000 km)for a PETROLengine.
- 1 litre per 600 miles (1,000 km)for a DIESELengine.
DO NOT INTERVENE BELOW THESE VALUES.
IV - OIL LEVEL:The level should NEVERbe above the MAX.mark on the dipstick after changing or topping up the oil:
- This excess oil will be used up rapidly.
- It will reduce the engine output and adversely affect the operation of the air circuits and gas recycling.
Angl.-t2-page001-39-2005 9/01/06 10:07 Page 39

Downloaded from www.Manualslib.com manuals search engine ENGINE SPECIFICATIONS
Petrol engines
Engine type
Cubic capacity (cc)
Bore/stroke
Compression ratio
Power ISO or EEC (KW - rpm)
Torque ISO or EEC (m.daN - rpm)TU1JP TU3JP ET3J4 TU5JP+ TU5JP4 EW7J4 EW10A EW10J4 EW10J4S
HFX KFW KFU NFV NFU 6FZ RFJ RFN RFK
1124 1360 1587 1749 1997
72/69 75/77 78,5/82 82,7/81,4 85/88
10,5/1 11/1 10,5/1 11/1 10,8/1 11/1 10,8/1 11/1
44,1-5500 55-5500 65-5250 70-5700 80-5800 85-5500 103-6000 100-6000 13-7000
94-3500 12-2800 13,3-4250 13,5-3000 14,7-4000 16-4000 20-4000 19-4100 20,2-4750
40
ENGINE
All Types
Angl.-t2-page040-134-2005 9/01/06 10:11 Page 40

Downloaded from www.Manualslib.com manuals search engine 41
ENGINE
ENGINE SPECIFICATIONS
Diesel engines
Engine type
Cubic capacity (cc)
Bore/stroke
Compression ratio
Power ISO or EEC (KW - rpm)
Torque ISO or EEC (m.daN - rpm)DV4TD DV6TED4DV6 DW10AT DW10
ATED4DW8B DW10TD
ED BTED4
8HX 8HZ 9HY 9HZ 9HX WJY RHY RHZ RHR
1398 1560 1868 1997
73,7/82 75/88,3 82,2/88 85/88
17,9/1 18/1 23/1 17,6/1 18/1
50-4000 80-4000 66,2-4000 51-4600 66-4000 80-4000 100-4000
15-1750 16-2000 24-1750 21,5-1750 12,5-2500 20,5-1900 25-1750 32-2000All Types
Angl.-t2-page040-134-2005 9/01/06 10:11 Page 41

Downloaded from www.Manualslib.com manuals search engine 42
ENGINESPECIAL FEATURES - TIGHTENINGING TORQUES (m.daN)
Power unit
15 ± 0,5
26 ± 0,6
32,5 ± 0,2
46,5 ± 0,6
52,5 ± 0,2
64,5 ± 0,4
74,5 ± 0,4
Engine: KFW
B1BP1EYD
XSARA
Angl.-t2-page040-134-2005 9/01/06 10:11 Page 42

Downloaded from www.Manualslib.com manuals search engine 43
ENGINE
SPECIAL FEATURES - TIGHTENINGINGING TORQUES (m.daN)
Power unit
15,5 ± 0,5
25,5 ± 0,5
36,5 ± 0,6
46,5 ± 0,6
52,2 ± 0,2
63,3 ± 0,3
72,7 ± 0,2
84,6 ± 0,4
94,5 ± 0,4
104,5 ± 0,4,
Engine: NFV
B1BP21HP
XSARA PICASSO
Angl.-t2-page040-134-2005 9/01/06 10:11 Page 43

Downloaded from www.Manualslib.com manuals search engine 44
ENGINESPECIAL FEATURES - TIGHTENINGING TORQUES (m.daN)
Power unit
14,5 ± 0,4
26 ± 0,6
34,5 ± 0,4
44 ± 0,4
56 ± 0,6
65,4 ± 0,8
76,5 ± 0,6
83 ± 0,3
94,5 ± 0,6
Engine: NFU
B1BP2GGP
XSARA
Angl.-t2-page040-134-2005 9/01/06 10:11 Page 44