gearbox CITROEN C-ELYSÉE 2017 Owner's Manual

148
C-elysee_en_Chap09_info-pratiques_ed01-2016
Removing a wheel
Parking the vehicle
Immobilise the vehicle where it does not block   traffic:   the   ground   must   be   level,  
s

table   and   not   slippery.
Apply
  the   parking   brake,   switch   off   the  
i

gnition   and   engage   first   gear*   to   block  
t

he   wheels.
Check
  that   the   parking   brake   warning  
l

amp   in   the   instrument   panel   comes   on.
The
  occupants   must   get   out   of   the  
v

ehicle   and   wait   where   they   are   safe.
Ensure
  that   the   jack   is   correctly  
p

ositioned   at   one   of   the   vehicle's  
j

acking   points.
Incorrect
  use   of   the   jack   could   cause  
t

he   vehicle   to   drop.
Never
  go   underneath   a   vehicle   raised  
u

sing   a   jack;   use   an   axle   stand.
List of operations
Do not use a jack other than the one supplied   by   the   manufacturer.
*
  
P

osition
 
R
 
for
 
an
 
electronic
 
gearbox;
 
P for an
automatic
 
gearbox.
Wheel with wheel trim
When removing the wheel , first
remove   the   wheel   trim   using   the  
w

heelbrace   1   by   pulling   at   the   valve  
a

perture.
When refitting the wheel , refit the
wheel
  trim,   starting   by   placing   its   cutout  
i

n   line   with   the   valve   and   then   pressing  
r

ound   its   edge   with   the   palm   of   your  
han

d. F
 
R
emove   the   wheel   bolt   cover   using   the  
t

ool 3   (alloy   wheels).
F
 
S
lacken   the   bolts   using   the   wheelbrace 1
o n l y.
Practical information

170
C-elysee_en_Chap09_info-pratiques_ed01-2016
Towing the vehicle
Access to the tools
The towing eye is installed in the boot under the   floor.
To
  gain   access   to   it:
F

o
pen the boot,
F
 
l
ift   the   floor   and   remove   it,
F
 
r
emove   the   towing   eye   from   the   holder.
General recommendations
Observe the legislation in force in your country.
E nsure   that   the   weight   of   the   towing   vehicle   is   higher   than   that   of   the   towed   vehicle.
The
  driver   must   remain   at   the   wheel   of   the   towed   vehicle   and   must   have   a   valid   driving  
l

icence.
When
  towing   a   vehicle   with   all   four   wheels   on   the   ground,   always   use   an   approved   towing  
a

rm;   rope   and   straps   are   prohibited.
The
  towing   vehicle   must   move   off   gently.
When
  towing   a   vehicle   with   the   engine   off,   there   is   no   longer   any   power   assistance   for  
b

raking   or   steering.
In
  the   following   cases,   you   must   always   call   on   a   professional   recovery   service:
-
 
v
ehicle   broken   down   on   a   motor way   or   fast   road,
-
 
f
our-wheel   drive   vehicle,
-
 
w
hen   it   is   not   possible   to   put   the   gearbox   into   neutral,   unlock   the   steering,   or   release  
t

he   parking   brake,
-
 
t
owing   with   only   two   wheels   on   the   ground,
-
 
w
here   there   is   no   approved   towing   arm   available...
Procedure
 
for
 
having
 
your
 
vehicle
 
towed.
Practical information

171
C-elysee_en_Chap09_info-pratiques_ed01-2016
Towing your vehicleTowing another vehicle
F On  the   front   bumper,   unclip   the   cover   by  p
ressing   on   the   left   edge.
F
 
S
crew   the   towing   eye   in   fully.
F
 
I
nstall   the   towing   bar. Put
  the   gear   lever   into   neutral  
(

position

N for an electronic or
automatic   gearbox).
Failure   to   follow   this   instruction   may  
c

ause   damage   to   some   components  
(

braking,   transmission...)   and   the  
a

bsence   of   braking   assistance   when  
t

he   engine   is   restarted.
F  U nlock   the   steering   by   turning   the   key  i
n   the   ignition   one   notch   and   release   the  
par

king
 b
rake.
F
 
S
witch   on   the   hazard   warning   lamps   on  
b

oth   vehicles.
F
 
M
ove   off   gently,   drive   slowly   and   for   a   short  
di

stance.This
  towing   is   strictly   prohibited   (risk   of  
d

amaging   your   vehicle).
9
Practical information

187
C-elysee_en_Chap10_verifications_ed01-2016
Manual gearbox
The gearbox does not require any maintenance   (no   oil   change).
Refer
  to   the   manufacturer's   service  
s

chedule   for   the   checking   interval   for  
t

his
 c
omponent.
Electronic gearbox
The gearbox does not require any maintenance   (no   oil   change).
Refer
  to   the   manufacturer's   service  
s

chedule   for   details   of   the   checking  
i

nterval   for   this   component.
Automatic gearbox
The gearbox does not require any maintenance   (no   oil   change).
Refer
  to   the   manufacturer's   service  
s

chedule   for   details   of   the   level  
c

hecking   interval   for   this   component. Brake
  wear   depends   on   the   style
 o

f   driving,   particularly   in   the   case
 o

f   vehicles   used   in   town,   over   short
 d

istances.   It   may   be   necessary   to   have
 t

he   condition   of   the   brakes   checked,
 e

ven   between   vehicle   services.
Brake pads
For information on checking brake d
isc   wear,   contact   a   CITROËN   dealer  
o

r   a   qualified   workshop.
Brake disc wear Parking brake
If excessive travel or a loss of e
ffectiveness   of   this   system   is  
n

oticed,   the   parking   brake   must   be  
c

hecked,   even   between   two   services.
Only
  use   products   recommended   by  
C

ITROËN   or   products   of   equivalent  
q

uality
 an
d
 sp
ecification.
In
 
order   to   optimise   the   operation   of  
u

nits   as   important   as   those   in   the  
b

raking   system,   CITROËN   selects   and  
o

ffers   very   specific   products.
After
  washing   the   vehicle,   dampness,  
o

r
 
in   wintry   conditions,   ice   can   form  
o

n
 
the   brake   discs   and   pads:   braking  
e

fficiency   may   be   reduced.   Make   light  
b

rake   applications   to   dry   and   defrost  
t

he
  brakes.
Checking
  this   system   must   be   done   by   a  
C

ITROËN   dealer   or   a   qualified   workshop.
Unless
 
there
 
is
 
a
 
leak
 
in
 
the
 
circuit,
 
a
 
drop
 
in
 
t

he
 
brake
 
fluid
 
level
 
indicates
 
that
 
the
 
brake
 
p

ads
 
are
 
worn.
10
Checks

188
C-elysee_en_Chap11_caracteristiques-techniques_ed01-2016
EnginePureTech 72 PureTech
82 PureTech
82 S&S VTi 115
Gearbox Manual
(5-speed) ETG
 e

lectronic
(5-speed) Manual
(5-speed) ETG
 e

lectronic
(5-speed) Manual
(5-speed) Automatic
 (

4-speed)E AT 6
 au

tomatic
 (

6-speed)
Model code : DD... HMY0 HMY0/PHMZ6HMZ6/PS NFP0
NFP6NFP9
NFPT
Cubic
  capacity   (cc) 1
  1991
  199 1   1991
  587
Bore
  x   stroke   (mm) 75
  x   90.575
  x   90.5 75   x   90.578.5
  x   82
Max
  power:   EU   standard   (kW)* 536060 85
Max
  power   engine   speed   (rpm) 5
  5005
  750 5   7506
  050
Max
  torque:   EU   standard   (Nm) 11 0118 118 150
Max
  torque   engine   speed   (rpm) 3
  0002
  750 2   7504
  000
Fuel Unleaded
  91   RON  
to
  98   RONUnleaded
 9

1   RON   to  
9

8   RONUnleaded
 9

1   RON   to  
9

8   RONUnleaded
  91   RON   to   98   RON
Catalytic converter yesyes yes yes
Engine
  oil   capacity   in   litres   (with   filter  
r

eplacement) 3.25
3.25 3.25 3.5
Petrol engines
* The maximum power corresponds to the value type approved on a test bed, under conditions defined by European legislation (Directive 1999/99/EC).
Technical data

189
C-elysee_en_Chap11_caracteristiques-techniques_ed01-2016
EnginePureTech 72PureTech
82 PureTech
82 S&S VTi 115
Gearbox Manual
(5-speed) ETG
 e

lectronic
(5-speed) Manual
(5-speed) ETG
 e

lectronic
(5-speed) Manual
(5-speed) Automatic
 (

4-speed)E AT 6
 au

tomatic
 (

6-speed)
Model code: DD... HMY0 HMY0/PHMZ6HMZ6/PS NFP0
NFP6NFP9
NFPT
Unladen
  weight 980980 980 1
  0901
  115
Kerb
  weight* 1
  0551
  055 1   0551
  1651
  190
Gross
  vehicle   weight   (GV W) 1
  459 1   467 1   470149 0 1
  524 1   559 1   585
Gross
  train   weight   (GTW)
on
  a   12%   gradient 1
  909 1   917 1   920 1   990 2   274 2   309 2   335
Braked
  trailer   (within   the   GTW   limit)  
o

n   a   10%   or   12%   gradient 450
450500 750
Braked
  trailer**   (with   load   transfer   within   the  
G

TW   limit) 720
720 720 1
  010
Unbraked
 t

railer 450450 450 580
Recommended
  nose   weight 555555 55
*
  The   kerb   weight   is   equal   to   the   unladen   weight   +   driver   (75   kg).
**
  
T
he   weight   of   the   braked   trailer   can   be   increased,   within   the   GTW   limit,   if   the   GV W   of   the   towing   vehicle   is   reduced   by   an   equal   amount;   warning,  
t

owing   using   a   lightly   loaded   towing   vehicle   may   have   an   adverse   effect   on   its   road   holding.
The
  GTW   and   towed   load   values   indicated   are   valid   up   to   a   maximum   altitude   of   1   000   metres;   the   towed   load   mentioned   must   be   reduced   by   10   %   for  
e

ach   additional   1   000   metres   of   altitude.
The
  speed   of   a   towing   vehicle   must   not   exceed   60   mph   (100   km/h)   (comply   with   the   legislation   in   force   in   your   country).
High
  ambient   temperatures   may   result   in   a   reduction   in   the   per formance   of   the   vehicle   to   protect   the   engine;   if   the   ambient   temperature   is   above   37   °C,  
l

imit   the   towed   load.
Petrol weights (in kg)
11
Technical data

190
C-elysee_en_Chap11_caracteristiques-techniques_ed01-2016
EngineHDi 92BlueHDi 100
Gearbox Manual
 (

5-speed)Manual
 (

5-speed)
Model code: DD... 9HJC9HP0BHY6
Cubic
  capacity   (cc) 1
  5601
  560
Bore
  x   stroke   (mm) 75
  x   88.375
  x   88.3
Max
  power:   EU   standard   (kW)* 6873
Max
  power   engine   speed   (rpm) 4
  0003
  750
Max
  torque:   EU   standard   (Nm) 230254
Max
  torque   engine   speed   (rpm) 1
  7501
  750
Fuel DieselDiesel
Catalytic converter yesyes
Particle filter noyes yes
Engine
  oil   capcity   in   litres   (with   filter  
r

eplacement) 3.75
3.75
Diesel engines
* The maximum power corresponds to the value type approved on a test bed, under conditions defined by European legislation (Directive 1999/99/EC).
Technical data

191
C-elysee_en_Chap11_caracteristiques-techniques_ed01-2016
The GTW and towed load values indicated are valid up to a maximum altitude of 1 000 metres; the towed load mentioned must be reduced by 10 % for each   additional   1   000   metres   of   altitude.
The
  speed   of   a   towing   vehicle   must   not   exceed   60   mph   (100   km/h)   (comply   with   the   legislation   in   force   in   your   country).
High
  ambient   temperatures   may   result   in   a   reduction   in   the   per formance   of   the   vehicle   to   protect   the   engine;   if   the   ambient   temperature   is   above   37   °C,  
l

imit   the   towed   load.
*
  The   kerb   weight   is   equal   to   the   unladen   weight   +   driver   (75   kg).
**   
T
he   weight   of   the   braked   trailer   can   be   increased,   within   the   GTW   limit,   if   the   GV W   of   the   towing   vehicle   is   reduced   by   an   equal   amount;   warning,  
t

owing   using   a   lightly   loaded   towing   vehicle   may   have   an   adverse   effect   on   its   road   holding.
Engine
HDi 92BlueHDi 100
Gearbox Manual
 (
5-speed)
Manual
 (
5-speed)
Model code: DD... 9HJC9HP0BHY6
Unladen   weight
1   090
1   090
Kerb   weight*
1   165
1   165
Gross   vehicle   weight   (GV W)
1   549
1   548
1   585
Gross   train   weight   (GTW)
on   a   12%   gradient
2   299
2   298
2   335
Braked   trailer   (within   the   GTW   limit)
on   a   10%   or   12%   gradient
750
750
Brakled   trailer**   (with   load   transfer   within  
the   GTW   limit)
1   010
1   010
Unbraked
 t
railer
580580
Recommended   nose   weight
5555
Diesel weights (in kg)
11
Technical data

244
C-elysee_en_Chap13_recherche-visuelle_ed01-2016
Instruments and controls
Opening the bonnet 180
Manual
 g
earbox
 6
8
Electronic
  gearbox  
6
9 -72
Automatic
  gearbox  
7
3 -76
Automatic
  gearbox   (EAT6)  
7
7- 80
Gear
  shift   indicator  
8
1
USB
  port   /   Jack   socket  
6
0
12
  V   accessory   socket   /  

C

igarette   lighter  
6
0
Dashboard
  fuses  
1
59 -162
Electric   windows,   deactivating  
4
2 Heating,
 v

entilation
 4
9-51
Manual a ir c onditioning 
( without   display   screen)  5 1-52
Electronic
  air   conditioning  
(with
  display   screen)  
5
3 -55
Front
  demist /defrost  
5
6
Rear
  screen   demist /defrost  
5
7
Heated
  lower   windscreen  
5
7
Audio
  system   /   Bluetooth  
1
95 -225
Audio   system  
2
27-241
Setting   the   date/time  
2
6
Monochrome   screen   C  
(Audio   system   /   Bluetooth)  
2
9 -32
Courtesy   lamps  
9
9
Interior   rear   view   mirror  
4
7
Parking   brake  
6
7 Hazard
  warning   lamps  
1
00
Locking/unlocking   from   inside  
4
1
Visual search

248
C-elysee_en_Chap14_index-alpha_ed01-2016
Ignition ............................................................. 66
Immobiliser, e lectronic ..............................3 6,   64
Indicator
  lamps,   operation  
........................ 1
1,   15
I
F
Dials and gauges ............................................10
D iesel ............................... .............................131
Dimensions
 ..............................

.....................192
Dipstick
 ................

.......................................... 183
Direction
 i

ndicators
 .......................1
00,   154,   157
Display
  screen,   instrument   panel  
............. 1
0,   81
Display
  screen,   multifunction  
(with
  audio   system)  
....................................... 29
D

oor   pockets  
................................................... 58
D

oors
 ..............................................................
.39
Driving
 e

conomically ......................................... 8
Eco-driving
   ...............................

........................ 8
Eco-driving
 (

advice)
 .......................................... 8
E

conomy   mode  
...............................
..............168
Electronic
  brake   force   distribution   (EBFD)  
...10

5
Emergency
  braking   assistance   (EBA)  
..........10

5
Emergency
  braking   system  
..........................10

5
Emergency
 w

arning
 lam
ps
 ...........................10

0
Emissions
  control   system,   SCR  
.....................2

2
Energy
  economy   mode  
.................................16

8
Engine
 c

ompartment
 ............................ 18

1,
 18
2
Engine,
  Diesel  
......... 1
3,   131,   132,   182,   190,   191
Engine,
  petrol  
................................ 1
31,   181,   188
Engines
 ..............................

...........188,   190,   191
Environment
 ...............................

.................8,   36
ESP/ASR
 ...............................

........................10 6Gauge,
  fuel....................................................129
Gearbox,
  automatic  
.................. 7
3,   77,   164,   187
Gearbox,
 e

lectronic
 ..................6
9,   82,   164,   187
Gearbox,
 m

anual
 ..............................
......68,   187
Gear
  efficiency   indicator  
.................................81
G

ear lever
 ..............................
........................... 8
Gear lever, automatic
  gearbox  
........................................73H

azard
 w
arning
 lam
ps
 ..................................10

0
Hazard
  warning   lamps,   automatic   operation  
....10

0
headlamp
 adj

ustment
 .....................................96
H

eadlamps
 ...............................
.......................91
Headlamps,
  dipped   beam  
....................... 9
1,   155
Headlamps,
 hal

ogen
 .....................................15

3
Headlamps,
  main   beam  
.......................... 9
1,   154
Head
  restraints,   front  
......................................44
H

eating
 ................
.................................. 8,   51,   53
Horn ............................................................... 10 0
E
G
H
Filling the fuel tank .................................1 2 9 -131
Filter, air ............... ......................................... 18 6
Filter, oil
 ......................................................... 18

6
Filter, particle
 ........................................ 18

5,
 18
6
Filter,
 p

assenger
 c
ompartment
 .....................18

6
Fitting
  a   wheel  
...............................
................148
Fitting
  roof   bars  
............................................. 17

8
Fittings,
  boot  
................................................... 61
F

ittings,
 in
terior
 .........................................5
8,   59
Flap, fuel filler
 
...............................
......... 129,   130
Flashing
 in

dicators
 ................................1
00,   154
Foglamp,
 r

ear
 ...............................
........... 93,   157
Foglamps,
 f

ront
 ...............................
........93,   156
Fuel ............................................................ 8,
  131
Fuel
 c

onsumption
 .............................................. 8
F

uel   tank........................................................ 13 0
Fusebox,
 das

hboard
 ..................................... 15

9
Fusebox,
 e

ngine
 c
ompartment
 .....................15

9
Fuses
 ................

............................................. 159Gear lever,
electronic ge
arbox ......................................18
7
Gear
  lever,   manual   gearbox  
...........................68
G

love   box  
........................................................59
Alphabetical index