catalytic converter Citroen C4 2016 2.G Owner's Manual

20
C4-2_en_Chap01_instruments-de-bord_ed02-2015
Warning/indicator lampis on Cause Action/Observations
Anti-lock
Braking System
(ABS) fixed.
The
  anti-lock   braking   system   has   a  
f

ault.The
  vehicle   retains   conventional   braking.
Drive carefully at reduced speed and contact a
CITROËN
  dealer   or   a   qualified   workshop   without  
d

e l ay.
Engine
autodiagnosis
system
flashing.
The
  engine   management   system   has  
a

  fault.Risk
  of   destruction   of   the   catalytic   converter.
Have
  it   checked   by   a   CITROËN   dealer   or   a   qualified
 w

orkshop.
fixed. The
  emission   control   system   has   a  
f

ault.
The warning lamp should go off when the engine is started.
I f   it   does   not   go   off,   contact   a   CITROËN   dealer   or   qualified w

orkshop   without   delay.
Low fuel level fixed,   accompanied   by  a
nd   audible   signal   and  
a

  message. When
  it   first   comes   on   there   remains  a
pproximately 6 litres of fuel in the
tank.
At
  this   point,   you   begin   to   use   the   fuel  
r

eserve.Refuel
  as   soon   as   possible   to   avoid   running   out   of  f
uel.
Until
  sufficient   fuel   is   added,   this   warning   lamp   will  
c

ome   on   every   time   the   ignition   is   switched   on,  
a

ccompanied   by   an   audible   signal   and   a   message.  
T

his   audible   signal   and   message   are   repeated  
with
  increasing   frequency   as   the   fuel   level   drops  
tow

ards "0".
Fuel
  tank   capacity:   approximately   60 litres.
Never continue to drive until you run out of fuel, as
this
  could   damage   the   emission   control   and   injection  
s

ystems.
Instruments

210
C4-2_en_Chap07_infos-pratiques_ed02-2015
Fuel used for petrol
engines
The petrol engines are compatible with E
10   bio-petrol   (containing   10   %   ethanol),  
c

onforming   to   European   standards   EN   228  
and
  EN   15376.
E85
  type   fuels   (containing   up   to   85   %   ethanol)  
a

re   reserved   exclusively   for   vehicles   marketed  
f

or   the   use   of   this   type   of   fuel   (BioFlex  
v

ehicles).   The   quality   of   the   ethanol   must  
c

omply   with   European   standard   EN   15293.
Fuel used for Diesel
engines
The Diesel engines are compatible with biofuels   which   conform   to   current   and   future  
E

uropean   standards   (Diesel   fuel   which  
c

omplies   with   standard   EN   590   mixed   with  
a

  biofuel   which   complies   with   standard  
E

N 14214)   available   at   the   pumps   (containing  
u

p   to   7   %   Fatty   Acid   Methyl   Ester).
B30
  biofuel   can   be   used   in   certain   Diesel  
e

ngines.   However,   this   use,   even   occasional,  
r

equires   strict   application   of   the   special  
s

ervicing   conditions.   Contact   a   CITROËN  
d

ealer   or   a   qualified   workshop.
The
  use   of   any   other   type   of   (bio)fuel  
(

vegetable   or   animal   oils,   pure   or   diluted,  
d

omestic   fuel...)   is   strictly   prohibited   (risk   of  
d

amage   to   the   engine   and   fuel   system).
The
 
petrol
 
or
 
Diesel
 
engine
 
of
 
your
 
vehicle
 
is
 f
itted with a catalytic converter, a device which
helps
 
to
 
reduce
 
the
 
level
 
of
 
harmful
 
emissions
 
i

n
 
the
 
exhaust
 
gases.
For petrol engines, the use of unleaded fuel
is compulsory.
The
 
filler
 
neck
 
is
 
narrower,
 
admitting
 
unleaded
 
p

etrol
 
nozzles
 
only.
Fuel supply cut-off
Your vehicle is equipped with a safety device w hich cuts off the fuel supply in the event of a
collision. If you have put in the wrong fuel for
your vehicle, you must have the tank
drained and refilled with the correct
fuel before you star t the engine.
Practical information

232
C4-2_en_Chap07_infos-pratiques_ed02-2015
AdBlue® additive and SCR system
f
or
 
BlueHDi   Diesel   engines
To assure respect for the environment and c
onformity   with   the   new   Euro   6   emissions  
s

tandard,   without   adversely   affecting   the  
p

er formance   or   fuel   consumption   of   Diesel  
e

ngines,   CITROËN   has   taken   the   decision   to  
e

quip   its   vehicles   with   an   effective   system   that  
a

ssociates   SCR   (Selective   Catalytic   Reduction)  
w

ith   a   particle   filter   (FAP)   for   the   treatment   of  
e

xhaust   gases.
Presentation of the SCR system
Using an additive called AdBlue® containing urea, a
 
catalytic
 
converter
 
turns
 
up
 
to
 
85%   of   nitrous o

xides
 
(NOx)
 
into
 
nitrogen
 
and
 
water,   which   are
 h

armless
 
to
 
health
 
and
 
the
 
environment.
The AdBlue® additive is held in a special
tank
 
located
  under   the   boot   at   the   rear   of  
t

he
 
vehicle.
 
It   has   a   capacity   of   17   litres:   this  
p

rovides
 
a
 
driving   range   of   about   12   500   miles  
(

20
 
000
 
km),
  after   which   an   alert   is   triggered  
w

arning
 
you
 
when   the   reserve   remaining   is  
e

nough
 
for
 
just   1   500   miles   (2   400   km).
During
 
each
  scheduled   service   of   your   vehicle  
b

y
 
a
 
CITROËN   dealer   or   a   qualified   workshop,  
t

he AdBlue
® additive tank is refilled in order to a
llow
 
normal   operation   of   the   SCR   system.
If
 
the
 
estimated   mileage   between   two   services  
i

s
 
greater
 
than   12   500   miles   (20   000   km),   we  
r

ecommend
  that   you   go   to   a   CITROËN   dealer  
o

r
 
a
 
qualified   workshop   to   have   the   necessary  
t

op-up
 
carried   out. Once the AdBlue
® tank is empty, a s
ystem
 
required
 
by   regulations   prevents  
s

tarting
 
of
 
the
 
engine.
If the SCR is faulty, the level of
emissions
 
from
 
your   vehicle   will   no  
l

onger
 
meet
 
the
 
Euro   6   standard:   your  
v

ehicle
 
becomes
 
polluting.
In
 
the
 
event
 
of
 
a
 
confirmed   fault  
w

ith
 
the
 
SCR
 
system,   you   must   go  
t

o
 
a
 
CITROËN
 
dealer   or   a   qualified  
w

orkshop
 
as
 
soon   as   possible:   after  
a

 
running
 
distance   of   650   miles  
(

1 100
 
km),
 
a
 
system   will   be   triggered  
a

utomatically
 
to
 
prevent   engine   starting.
Freezing of the AdBlue
® additive
The AdBlue
® additive freezes at
temperatures   below   around   -11°C.
The
 
SCR
 
system   includes   a   heater  
f

or the AdBlue
® tank, allowing you to c
ontinue
 
driving   in   very   cold   conditions.
Practical information

271
C4-2_en_Chap09_caracteristiques_ed02-2015
Petrol engines and gearboxes
Petrol enginePureTech 110 V Ti 120 PureTech 130 S&S
Gearbox Manual
(5 - speed) Manual

(5 - speed) Manual
(6- speed) E AT 6
automatic (6- speed)
Model c ode:
NC... HNZ6
HNZ6/1
HNZ6/2 5FS0
HNYM/S
HNYM/1S HNY T/S
HNY T/1S
HNY T/2S
Cubic
  capacity   (cc) 1 19 91
  5981 19 9
Bore
  x   stroke   (mm) 75
  x   90.577
  x   85.875
  x   90.5
Max
  power*:   EU   standard   (kW) 8188 96
Max
  power   engine   speed   (rpm) 5 5006
  0005 500
Max
  torque:   EU   standard   (Nm) 205160 230
Max
  torque   engine   speed   (rpm) 1 5004 250 1
  750
Fuel UnleadedUnleaded Unleaded
Catalytic converter Ye sYe s Ye s
Oil capacity in litres
(with filter replacement) 3.5
4.25 3.5
.../S:
 

model   fitted   with   Stop   &   Start.
.../1:  model
  fitted   with   low   rolling   resistance   tyres.
.../2:  model
  fitted   with   very   low   rolling   resistance   tyres.
*
  The   maximum   power   corresponds   to   the   value   type-approved   on   a   test   bed,   under   conditions   defined   in   European   legislation   (Directive   1999/99/EC).
9
Technical data

273
C4-2_en_Chap09_caracteristiques_ed02-2015
Diesel engines and gearboxes
* The maximum power corresponds to the value type-approved on a test bed, under conditions defined in European legislation (Directive 1999/99/EC).
D iesel engine
HDi 90HDi 90 FAP BlueHDi 100 e-HDi 115
Gearbox Manual
(5 - speed) Manual
(5 - speed) Manual
(5 - speed) Manual
(6- speed)
Model code:
NC... 9HJC

9HJC/1 9HP0BHY6
BHY6/1
BHY6/2S 9HD8/S

9HD8/1S
9HD8/2S
Cubic   capacity   (cc)
1   560
1   560
1   560
1   560
Bore   x   stroke   (mm)
75   x   88.3
75   x   88.3
75   x   88.3
75   x   88.3
Max   power*:   EU   standard   (kW)
6868 7384
Max   power   engine   speed   (rpm)
4 0004 000 3   750
3   600
Max   torque:   EU   standard   (Nm)
230230254 270
Max   torque   engine   speed   (rpm)
1   750
1   750
1   750
1   750
Fuel DieselDieselDieselDiesel
Catalytic converter Ye sYe sYe sYe s
Particle   filter   (FAP)
NoYe s Ye sYe s
Oil capacity in litres
(with filter replacement) 3.75
3.753.753.75
.../S:
 
model   fitted   with   Stop   &   Start.
.../1:
 

model   fitted   with   low   rolling   resistance   tyres   (for   example:   MICHELIN   Energy   Saver).
.../2:
 

model   fitted   with   very   low   rolling   resistance   tyres.
9
Technical data

274
C4-2_en_Chap09_caracteristiques_ed02-2015
.../S: model   fitted   with   Stop   &   Start.
.../1:  model   fitted   with   low   rolling   resistance   tyres   (for   example:   MICHELIN   Energy   Saver).
.../2:
 

model   fitted   with   very   low   rolling   resistance   tyres.
Diesel engine
BlueHDi 115 S&SBlueHDi 120 S&SBlueHDi 150
S&S
Gearbox Manual
(6- speed) E AT 6
automatic (6- speed) Manual
(6- speed) E AT 6
automatic (6- speed) Manual
(6- speed)
Model code:
NC... BHXM/S
BHXM/1S
BHXM/2S BHX T/S
BHX T/1S
BHX T/2S BHZM/S
BHZM/1S
BHZM/2S BHZT/S
BHZ T/1S
BHZT/2S AHRM/S
AHRM/1S
AHRM/2S
Cubic   capacity   (cc)
1   560
1   560
1   997
Bore   x   stroke   (mm)
75   x   88.3
75   x   88.3
85   x   88
Max   power*:   EU   standard   (kW)
858811 0
Max   power   engine   speed   (rpm)
3   500
3   500
4 000
Max   torque:   EU   standard   (Nm)
300300370
Max   torque   engine   speed   (rpm)
1   750
1   750
2 000
Fuel DieselDieselDiesel
Catalytic converter Ye sYe sYe s
Particle   filter   (FAP)
Ye sYe sYe s
Oil capacity in litres
(with filter replacement) 3.75
3.756 .1
*   The   maximum   power   corresponds   to   the   value   type-approved   on   a   test   bed,   under   conditions   defined   in   European   legislation   (Directive   1999/99/EC).
Technical data