engine Citroen C4 PICASSO 2008.5 1.G Manual PDF

186
XI
P R A C T I C A L I N F O R M A T I O N
BATTERY
Procedure for charging your battery
when it is fl at or for starting the en-
gine using another battery.
Access to the battery
The battery is located under the
bonnet.
To gain access to it:

 open the bonnet using the inte-
rior lever, then the exterior lever,

 secure the bonnet strut,

 remove the plastic cover to gain
access to the two terminals,

 unclip the fuse box to remove
the battery, if necessary.
Do not force the plate as locking
will not be possible of the clip is po-
sitioned incorrectly.
Start the procedure again. Starting using another
battery

 Connect the red cable to the pos-
itive terminal (+) of the fl at battery

A , then to the positive terminal
(+) of the slave battery B .

 Connect one end of the green or
black cable to the negative ter-
minal (-) of the slave battery B .

 Connect the other end of the
green or black cable to an earth
point C on the broken down ve-
hicle.

 Operate the starter, let the en-
gine run.

 Wait until the engine returns to
idle and disconnect the cables.
Charging the battery using a
battery charger

 Disconnect the battery from the
vehicle.

 Follow the instructions for use
provided by the manufacturer of
the charger.

 Reconnect starting with the neg-
ative terminal (-).

 Check that the terminals and
connectors are clean. If they are
covered with sulphate (whitish or
greenish deposit), remove them
and clean them.
Disconnecting/
Reconnecting the cables

 Raise the locking plate 1 fully.

 Position the open clip of the ca-
ble on the positive (+) terminal of
the battery.

 Press vertically on the clip 2 to
position it correctly against the
battery.

 Lock the clip by lowering the
plate 1 .

192
XII
T E C H N I C A L D A T A

MODELS:
ENGINES AND GEARBOXES

Model codes:
UA... UD... UF...
5FW-C 5FX-H/P 5FT-F RFJ-F

PETROL ENGINES
1.6 l. VTi 16V
120 bhp
1.6 l. THP 16V
150 bhp
1.6 l. THP 16V
140 bhp
2 l. 16V 143 bhp
Cubic capacity (cm 3
) 1 598 1 598 1 997
Bore x stroke (mm) 77 x 85.8 77 x 85.8 85 x 88
EU standard maximum power (kW) 88 110 103 103
Maximum power engine speed (rpm) 6 000 5 800 6 000 6 000
EU standard maximum torque (Nm) 160 240 200
Maximum torque engine speed (rpm) 4 250 1 400 4 000
Fuel Unleaded Unleaded Unleaded
Catalytic converter Yes Yes Yes

GEARBOXES Manual
(5-speed)
Electronic gearbox system (6-speed) Auto.
(4-speed) Auto.
(4-speed)

OIL CAPACITIES (in litres)
Engine (with cartridge replacement) 4.25 4.25 4.25 5
Gearbox - Final drive 1.9 - - -

UA...: Grand C4 Picasso (7-seater). UD...: C4 Picasso (5-seater). UF...: C4 Picasso "Lounge" (4-seater).

196
XII
T E C H N I C A L D A T A

MODELS:
ENGINES AND GEARBOXES

Model codes:
UA... UD... UF...
9HZ-C 9HZ-H/P
RHR-H
RHE-8
RHJ-H/P RHR-J

DIESEL ENGINES 1.6 l. HDi 110 bhp 2 l. HDi 138 bhp
Cubic capacity (cm 3
) 1 560 1 997
Bore x stroke (mm) 75 x 88.3 85 x 88
EU standard maximum power (kW) 80 100
Maximum power engine speed (rpm) 4 000 4 000
EU standard maximum torque (Nm) 240 320
Maximum torque engine speed (rpm) 1 750 2 000
Fuel Diesel Diesel
Catalytic converter Yes Yes
Particle emission fi lter (PEF) Yes Yes

GEARBOXES Manual
(5-speed) Electronic
gearbox systeml
(6-speed) Manual
(6-speed) Piloted Manual
(6-speed) Auto.
(6-speed)

OIL CAPACITIES (in litres)
Engine (with cartridge replacement) 3.75 3.75 5.25 5.25 5.25
Gearbox - Final drive 1.9 - 2.4 - -

UA...: Grand C4 Picasso (7-seater). UD...: C4 Picasso (5-seater). UF...: C4 Picasso "Lounge" (4-seater).

193
XII
T E C H N I C A L D A T A

CONSUMPTION
Grand C4 Picasso and C4 Picasso
In accordance with directive 80/1268/CEE

Petrol engines Gearboxes
Model codes:
UA... UD... UF...
Urban driving
(litres/100 km)
Inter-urban
driving
(litres/100 km)
Mixed driving
(litres/100 km)
Emission of
CO 2 by weight
(g/km)

1.6 l. VTi 16V
120 bhp
Manual 5FW-C 10.1 6.0 7.5 177

1.6 l. THP 16V
150 bhp

Electronic
gearbox system
5FX-H/P 10.0 5.9 7.4 176

1.6 l. THP 16V
140 bhp
Auto. 5FT-F 11.9 6.5 8.5 200

2 l. 16V
143 bhp
Auto. RFJ-F 12.9 6.6 8.9 211
The consumption fi gures shown here correspond to the values commu nicated at the time of printing.
These consumption values were established in accordance with Di rective 80/1268/CEE. They may vary depending on the
style of driving, traffi c conditions, weather conditions, the load in the vehicle, the maintenance of the vehicle and the use
of the accessories.
Quality of the fuel used for petrol engines
The petrol engines are perfectly compatible with E5 type pet rol biofuels (containing 5 % ethanol), conforming to European
standard EN 228.
E85 type fuels (containing up to 85 % ethanol) are reserved e xclusively for vehicles marketed for the use of this type of
fuel (BioFlex vehicles). The quality of the ethanol must comply with European standard EN 15376.
For Brazil only, special vehicles are marketed to run on fuels co ntaining up to 100 % ethanol (type E100).

197
XII
T E C H N I C A L D A T A

CONSUMPTION
Grand C4 Picasso and C4 Picasso
In accordance with directive 80/1268/CEE

Diesel engines Gearboxes
Model codes:
UA... UD... UF...
Urban driving
(litres/100 km)
Inter-urban
driving
(litres/100 km)
Mixed driving
(litres/100 km)
Emission of
CO 2 by weight
(g/km)

1.6 l. HDi
110 bhp
Manual 9HZ-C 7.3 5.1 5.9 155

Electronic
gearbox system
9HZ-H/P 6.8 5.1 5.7 150

2 l. HDi
138 bhp
Manual
RHR-H
RHE-8 -
- -
- -
- -
-

Electronic
gearbox system
RHJ-H/P 7.9 5.1 6.1 158

Auto. RHR-J 9.9 5.9 7.4 195
The consumption fi gures shown here correspond to the values commu nicated at the time of printing.
These consumption values were established in accordance with Di rective 80/1268/CEE. They may vary depending on the
style of driving, traffi c conditions, weather conditions, the load in the vehicle, the maintenance of the vehicle and the use
of the accessories.
Quality of the fuel used for Diesel engines
The Diesel engines are perfectly compatible with biofuels w hich conform to current and future European standards (diesel
fuel which complies with standard EN 590 mixed with a biofue l which complies with standard EN 14214) which can be
distributed at the pumps (possible incorporation of 0 to 7 % Fatty Acid Methyl Ester).
The use of any other type of (bio)fuel (vegetable or animal oils, domestic fuel...) is strictly prohibited (risk of damage to
the engine and fuel circuit).

194
T E C H N I C A L D A T A
*
Not available on C4 Picasso "Lounge" (4-seater).
** The weight of the braked trailer can be increased, within the GTW limit, on condition that the GVW of the towing vehicle is reduced by the same amount; w arning, towing with a lightly
loaded towing vehicle may have an adverse effect on its road holding.

WEIGHTS AND TOWED LOADS (in kg)

Petrol engines 1.6 l. VTi 16V 120 bhp * 1.6 l. THP 16V 150 bhp 1.6 l. THP 16V 140 bhp

Gearboxes Manual

Electronic gearbox system
Auto.

Model codes:
UA... UD... UF...
5FW-C 5FX-H/P 5FT-F
- Unladen weight 1 486 - 1 458 1 530 - 1 506 - 1 593 1 568 - 1 539 - 1 609
- Kerb weight 1 561 - 1 533 1 605 - 1 581 - 1 6 68 1 643 - 1 614 - 1 684
- Payload 714 - 557 690 - 534 - 382 667 - 516 - 381
- Gross vehicle weight (GVW) 2 200 - 2 015 2 220 - 2 040 - 1 975 2 235 - 2 0 55 - 1 990
- Gross train weight (GTW)
on a 12 % gradient 3 400 - 3 415 3 420 - 3 440 - 3 375 3 635 - 3 5 55 - 3 490
- Braked trailer (within GTW limit)
on a 10 % or 12 % gradient 1 200 - 1 400 1 200 - 1 400 - 1 400 1 400 - 1 5 00 - 1 500
- Braked trailer ** (with load transfer within GTW limit) 1 500 1 500 1 500
- Unbraked trailer 750 750 750
- Recommended nose weight 60 60 60
The GTW and towed load values indicated apply up to a maximum altitude of 1,000 metres; the towed load mentioned must be reduced by 10 % for each additio nal 1,000 metres of altitude.
The speed of a towing vehicle must not exceed 100 km/h (approx. 60 mph) (comply with the legislation in force in your country).
High exterior temperatures may result in a reducti on in the performance of the vehicle in order to protect the engine; when the exterior temperature is higher than 37°C, limit the weight towed.

195
XII
T E C H N I C A L D A T A
The GTW and towed load values indicated apply up t o a maximum altitude of 1,000 metres; the towed load mentioned must be
reduced by 10 % for each additional 1,000 metres of altitude.
The speed of a towing vehicle must not exceed 100 km/h (approx. 60 mph) (comply with the legislation in force in your country).
High exterior temperatures may result in a reducti on in the performance of the vehicle in order to pr otect the engine; when the
exterior temperature is higher than 37 °C, limit t he weight towed.

WEIGHTS AND TOWED LOADS (in kg)

Petrol engines
2 l. 16V 143 bhp

Gearboxes
Auto.

Model codes:
UA... UD... UF...
RFJ-F
- Unladen weight 1 600 - 1 552 - 1 600
- Kerb weight 1 675 - 1 627 - 1 675
- Payload 660 - 538 - 470
- Gross vehicle weight (GVW) 2 260 - 2 090 - 2 070
- Gross train weight (GTW)
on a 12 % gradient 3 660 - 3 590 - 3 570
- Braked trailer (within GTW limit)
on a 10 % or 12 % gradient 1 400 - 1 500 - 1 500
- Braked trailer ** (with load transfer within GTW limit) 1 500
- Unbraked trailer 750
- Recommended nose weight 60
** The weight of the braked trailer can be increased , within the GTW limit, on condition that the GVW o f the towing vehicle is reduced
by the same amount; warning, towing with a lightly loaded towing vehicle may have an adverse effect on its road holding.

198
XII
T E C H N I C A L D A T A

WEIGHTS AND TOWED LOADS (in kg)

Diesel engines
1.6 l. HDi 110 bhp

Gearboxes
Manual Electronic gearbox system

Model codes:
UA... UD...
9HZ-C 9HZ-H/P
- Unladen weight 1 530 - 1 489 1 539 - 1 499
- Kerb weight 1 605 - 1 564 1 614 - 1 574
- Payload 720 - 561 711 - 561
- Gross vehicle weight (GVW) 2 250 - 2 050 2 250 - 2 060
- Gross train weight (GTW)
on a 12 % gradient 3 130 3 130
- Braked trailer (within GTW limit)
on a 10 % or 12 % gradient 880 - 1 080 880 - 1 070
- Braked trailer * (with load transfer within GTW limit) 1 180 - 1 300 1 180 - 1 300
- Unbraked trailer 750 750
- Recommended nose weight 50 - 60 50 - 60
*
The weight of the braked trailer can be increased, within the GTW limit, on condition that the GVW of the towing vehicle is reduced
by the same amount; warning, towing with a lightly loaded towing vehicle may have an adverse effect on its road holding.
The GTW and towed load values indicated apply up to a maximum altitude of 1,000 metres; the towed load mentioned must be
reduced by 10 % for each additional 1,000 metres of altitude.
The speed of a towing vehicle must not exceed 100 km/h (approx. 60 mph) (comply with the legislation in force in your country).
High exterior temperatures may result in a reducti on in the performance of the vehicle in order to protect the engine; when the
exterior temperature is higher than 37°C, limit the weight towed.

199
T E C H N I C A L D A T A
The GTW and towed load values indicated apply up to a maximum altitude of 1,000 metres; the towed load mentioned
must be reduced by 10 % for each additional 1,000 metres of a ltitude.
The speed of a towing vehicle must not exceed 100 km/h (approx. 60 mph) (comply with the legislation in force in your country).
High exterior temperatures may result in a reduction in the perf ormance of the vehicle in order to protect the engine; when
the exterior temperature is higher than 37 °C, limit the wei ght towed.

WEIGHTS AND TOWED LOADS (in kg)

Diesel engines
2 l. HDi 138 bhp

Gearboxes Manual

Electronic gearbox system
Auto.

Model codes:
UA... UD... UF...
RHR-H
RHE-8
RHJ-H/P RHR-J
- Unladen weight 1 613 - 1 610 - 1 630 1 620 - 1 581 - 1 615 1 650 - 1 640 - 1 655
- Kerb weight 1 688 - 1 685 - 1 705 1 695 - 1 6 56 - 1 690 1 725 - 1 715 - 1 730
- Payload 695 - 520 - 432 700 - 559 - 475 700 - 510 - 475
- Gross vehicle weight (GVW) 2 308 - 2 130 - 2 062 2 320 - 2 140 - 2 090 2 3 50 - 2 150 - 2 130
- Gross train weight (GTW)
on a 12 % gradient 3 508 - 3 530 - 3 562 3 620 - 3 540 - 3 490 3 5 50 - 3 550 - 3 530
- Braked trailer (within GTW limit)
on a 10 % or 12 % gradient 1 200 - 1 400 - 1 500 1 300 - 1 400 - 1 400 1 2 00 - 1 400 - 1 400
- Braked trailer * (with load transfer with GTW limit) 1 400 - 1 600 - 1 700 1 500 1 500
- Unbraked trailer 750 750 750
- Recommended nose weight 70 70 - 60 - 60 70 - 60 - 60
**
The weight of the braked trailer can be increased , within the GTW limit, on condition that the GVW o f the towing vehicle is reduced
by the same amount; warning, towing with a lightly loaded towing vehicle may have an adverse effect on its road holding.

203
XII
T E C H N I C A L D A T A
IDENTIFICATION FEATURES
Various visible marking components
for vehicle identifi cation and searches.
The vehicle type and the identifi ca-
tion number are also indicated on
the registration document.
All CITROËN original replacement
parts are available exclusively within
the dealer network.
For your safety and in order to re-
main within the terms of the guar-
antee, you are advised to use only
CITROËN replacement parts A. Manufacturer’s plate
Located in the engine compartment.

1. EU type approval number.

2. Vehicle identifi cation No. (VIN).

3. Gross vehicle weight.

4. Gross train weight.

5. Maximum weight on front axle.

6. Maximum weight on rear axle. B. Vehicle identification No.
(VIN)
Located on bodywork and behind
windscreen.
C. Paint colour code Tyre reference
Tyre pressures
Located on the driver's door interior
pillar.
Use the tyre pressures recom-
mended by CITROËN.
Check the tyre pressures when the
tyres are cold, on a frequent basis.
Never reduce the pressure of a hot
tyre.
If replacing your tyres, it is essen-
tial to use the tyre sizes that are
recommended for your vehicle.