engine overheat DODGE CHALLENGER 2017 3.G User Guide

WHAT TO DO IN EMERGENCIES
CONTENTS
HAZARD WARNING FLASHERS ............382
 IF YOUR ENGINE OVERHEATS .............382
 TIRE SERVICE KIT — IF EQUIPPED ..........383
▫ Description .......................... .383
▫ Tire Service Kit Storage ..................383
▫ Tire Service Kit Components And Operation . . .384
▫ Tire Service Kit Usage Precautions ..........385
▫ Sealing A Tire With Tire Service Kit .........387
 WHEEL AND TIRE TORQUE SPECIFICATIONS . .391
▫ Torque Specifications ....................391
 JACKING AND TIRE CHANGING ...........392
▫ Jack Location/Spare Tire Stowage ...........393
▫ Preparations For Jacking .................394
▫ Jacking And Changing A Tire ..............395▫
Road Tire Installation ...................398
 JUMP-STARTING PROCEDURES ............399
▫ Preparations For Jump-Start ...............400
▫ Jump-Starting Procedure .................401
 FREEING A STUCK VEHICLE ..............402
 MANUAL PARK RELEASE — 8 SPEED
TRANSMISSION ....................... .404
 TOWING A DISABLED VEHICLE ............406
▫ Rear-Wheel Drive (RWD) Models ...........407
▫ All Wheel Drive (AWD) Models ............407
 ENHANCED ACCIDENT RESPONSE SYSTEM
(EARS) .............................. .408
 EVENT DATA RECORDER (EDR) ............408
6

HAZARD WARNING FLASHERS
The Hazard Warning flasher switch is located on the
instrument panel, below the radio.Push the switch to turn on the Hazard Warning
flasher. When the switch is activated, all directional
turn signals will flash on and off to warn oncoming traffic
of an emergency. Push the switch a second time to turn off
the Hazard Warning flashers.
This is an emergency warning system and it should not be
used when the vehicle is in motion. Use it when your
vehicle is disabled and it is creating a safety hazard for
other motorists.
When you must leave the vehicle to seek assistance, the
Hazard Warning flashers will continue to operate even
though the ignition is placed in the OFF position.
NOTE: With extended use, the Hazard Warning flashers
may wear down your battery.
IF YOUR ENGINE OVERHEATS
In any of the following situations, you can reduce the
potential for overheating by taking the appropriate action.
• On the highways — slow down. •
In city traffic — while stopped, place the transmission in
NEUTRAL, but do not increase the engine idle speed.
NOTE: There are steps that you can take to slow down an
impending overheat condition:
• If your air conditioner (A/C) is on, turn it off. The A/C
system adds heat to the engine cooling system and
turning the A/C off can help remove this heat.
• You can also turn the temperature control to maximum
heat, the mode control to floor and the blower control to
high. This allows the heater core to act as a supplement
to the radiator and aids in removing heat from the
engine cooling system.
WARNING!
You or others can be badly burned by hot engine
coolant (antifreeze) or steam from your radiator. If you
see or hear steam coming from under the hood, do not
open the hood until the radiator has had time to cool.
Never try to open a cooling system pressure cap when
the radiator or coolant bottle is hot.
382 WHAT TO DO IN EMERGENCIES

CAUTION!
Racing the engine or spinning the wheels may lead to
transmission overheating and failure. Allow the en-
gine to idle with the transmission in NEUTRAL for at
least one minute after every five rocking-motion
cycles. This will minimize overheating and reduce the
risk of clutch or transmission failure during prolonged
efforts to free a stuck vehicle.
NOTE: Push the ESC Off switch to place the Electronic
Stability Control (ESC) system in Partial Offmode before
rocking the vehicle. Refer to “Electronic Brake Control” in
“Starting And Operating” for further information. Once
the vehicle has been freed, push the ESC Offswitch again
to restore ESC Onmode.
WARNING!
Fast spinning tires can be dangerous. Forces generated
by excessive wheel speeds may cause damage, or even
failure, of the axle and tires. A tire could explode and
injure someone. Do not spin your vehicle’s wheels
faster than 30 mph (48 km/h) or for longer than 30
seconds continuously without stopping when you are
(Continued)
WARNING! (Continued)
stuck and do not let anyone near a spinning wheel, no
matter what the speed.
CAUTION!
•When “rocking” a stuck vehicle by shifting between
DRIVE / FIRST GEAR and REVERSE, do not spin
the wheels faster than 15 mph (24 km/h), or drive-
train damage may result.
• Revving the engine or spinning the wheels too fast
may lead to transmission overheating and failure. It
can also damage the tires. Do not spin the wheels
above 30 mph (48 km/h) while in gear (no transmis-
sion shifting occurring).
6
WHAT TO DO IN EMERGENCIES 403

WARNING!
•Exhaust gases can injure or kill. They contain carbon
monoxide (CO), which is colorless and odorless.
Breathing it can make you unconscious and can
eventually poison you. To avoid breathing CO, refer
to “Safety Tips/Exhaust Gas” in “Things To Know
Before Starting Your Vehicle” for further informa-
tion.
• A hot exhaust system can start a fire if you park over
materials that can burn. Such materials might be
grass or leaves coming into contact with your exhaust
system. Do not park or operate your vehicle in areas
where your exhaust system can contact anything that
can burn.
CAUTION!
• The catalytic converter requires the use of unleaded
fuel only. Leaded gasoline will destroy the effective-
ness of the catalyst as an emissions control device
and may seriously reduce engine performance and
cause serious damage to the engine.
(Continued)
CAUTION! (Continued)
•Damage to the catalytic converter can result if your
vehicle is not kept in proper operating condition. In
the event of engine malfunction, particularly involv-
ing engine misfire or other apparent loss of perfor-
mance, have your vehicle serviced promptly. Contin-
ued operation of your vehicle with a severe
malfunction could cause the converter to overheat,
resulting in possible damage to the converter and
vehicle.
Under normal operating conditions, the catalytic converter
will not require maintenance. However, it is important to
keep the engine properly tuned to assure proper catalyst
operation and prevent possible catalyst damage.
NOTE: Intentional tampering with emissions control sys-
tems can result in civil penalties being assessed against
you.
In unusual situations involving grossly malfunctioning
engine operation, a scorching odor may suggest severe and
abnormal catalyst overheating. If this occurs, stop the
vehicle, turn off the engine and allow it to cool. Service,
including a tune-up to manufacturer’s specifications,
should be obtained immediately.
7
MAINTAINING YOUR VEHICLE 429

The cap should be inspected and cleaned if there is any
accumulation of foreign material on the sealing surfaces.
WARNING!
•The warning words “DO NOT OPEN HOT” on the
cooling system pressure cap are a safety precaution.
Never add engine coolant (antifreeze) when the
engine is overheated. Do not loosen or remove the
cap to cool an overheated engine. Heat causes pres-
sure to build up in the cooling system. To prevent
scalding or injury, do not remove the pressure cap
while the system is hot or under pressure.
• Do not use a pressure cap other than the one speci-
fied for your vehicle. Personal injury or engine
damage may result.
Disposal Of Used Engine Coolant
Used ethylene glycol-based engine coolant (antifreeze) is a
regulated substance requiring proper disposal. Check with
your local authorities to determine the disposal rules for
your community. To prevent ingestion by animals or
children, do not store ethylene glycol-based engine coolant
in open containers or allow it to remain in puddles on the ground. If ingested by a child or pet, seek emergency
assistance immediately. Clean up any ground spills imme-
diately.
Coolant Level
The coolant bottle provides a quick visual method for
determining that the engine coolant (antifreeze) level is
adequate. With the engine OFF and cold, the level of the
engine coolant (antifreeze) in the bottle should be between
the ranges indicated on the bottle.
The radiator normally remains completely full, so there is
no need to remove the radiator cap unless checking for
engine coolant (antifreeze) freeze point or replacing engine
coolant (antifreeze). Advise your service attendant of this.
As long as the engine operating temperature is satisfactory,
the coolant bottle need only be checked once a month.
When additional engine coolant (antifreeze) is needed to
maintain the proper level, it should be added to the coolant
bottle. Do not overfill.
7
MAINTAINING YOUR VEHICLE 433

Dealer Service............................ .416
Deck Lid, Emergency Release ...................31
Deck Lid, Power Release ......................30
Defroster, Rear Window ..................... .166
Defroster, Windshield ........................72
Delay (Intermittent) Wipers ...................112
Diagnostic System, Onboard ...................414
Dimmer Switch, Headlight ....................109
Dipsticks Oil (Engine) ........................ .417, 418
Disabled Vehicle Towing .....................406
Disposal Antifreeze (Engine Coolant) .................433
Door Ajar ............................... .182
Door Ajar Light ........................... .182
Door Locks Door Locks .......................... .17, 23
KeyFob................................23
Remote ................................23
Remote Keyless Entry ......................23
Door Locks, Automatic .......................24
Door Opener, Garage ....................... .150Driving
Through Flowing, Rising, Or Shallow Standing
Water ................................ .319
Electrical Power Outlets ..................... .159
Electric Remote Mirrors .......................85
Electronic Brake Control System ................324
Anti-Lock Brake System ....................325
Electronic Roll Mitigation ...................334
Traction Control System ....................329
Electronic Power Distribution Center (Fuses) .......445
Electronic Speed Control (Cruise Control) . . .116, 117, 120
Electronic Stability Control (ESC) ...............330
Electronic Throttle Control Warning Light .........180
Emergency Deck Lid Release ...................31
Emergency, In Case Of Freeing Vehicle When Stuck .................402
Jacking ............................... .392
Jump Starting ....................399, 400, 401
Overheating ........................... .382
Towing ............................... .406
Emergency Trunk Release .....................31
Emission Control System Maintenance ............415
10
INDEX 489

Engine.............................. .412, 413
Air Cleaner ............................ .422
Block Heater ........................... .303
Break-In Recommendations ..................69
Checking Oil Level ....................417, 418
Compartment .....................411, 412, 413
Compartment Identification .................411
Coolant (Antifreeze) .............430, 462, 464, 465
Cooling .............................. .430
Exhaust Gas Caution ...................71, 368
Fails To Start ........................... .302
Flooded, Starting ........................ .302
Fuel Requirements ....................... .363
Jump Starting ....................399, 400, 401
Oil ..................417, 460, 461, 462, 464, 465
Oil Change Interval ...................... .418
Oil Filler Cap .......................... .420
Oil Filter .............................. .422
Oil Selection .....................419, 460, 461
Oil Synthetic ........................... .422
Overheating ........................... .382
Starting .............................. .299
Engine Oil Viscosity .....................419, 420
Engine Oil Viscosity Chart ....................419
Enhanced Accident Response Feature ..........52, 408Entry System, Illuminated
.....................16
Ethanol ................................. .365
Exhaust Gas Caution .....................71, 368
Exhaust System ........................ .71, 428
Exterior Folding Mirrors ......................85
Exterior Lighting .......................... .104
Exterior Lights .............................74
Filler Location Fuel ........................ .368
Filters Air Cleaner ............................ .422
Air Conditioning .....................278, 426
Engine Oil ...................422,
462, 464, 465
Engine Oil Disposal ...................... .422
Flashers ................................ .382
Hazard Warning ........................ .382
Turn Signal ...................... .74, 108, 194
Flash-To-Pass ............................ .109
Flooded Engine Starting ..................... .302
Fluid, Brake .................462, 463, 464, 465, 466
Fluid Capacities ....................... .460, 461
Fluid Leaks ...............................74
Fluid Level Checks Automatic Transmission ....................437
Brake ................................ .435
490 INDEX

Vanity.................................86
Modifications/Alterations, Vehicle ................6
Monitor, Tire Pressure System ..................357
Mopar Parts .......................... .416, 483
MTBE/ETBE ............................. .365
Multi-Function Control Lever ..................108
New Vehicle Break-In Period ...................69
Occupant Restraints .........................32
Octane Rating, Gasoline (Fuel) .......363, 462, 464, 465
Oil Change Indicator, Reset ...................201
Oil, Engine .....................417, 462, 464, 465
Capacity .......................... .460, 461
Change Interval ........................ .418
Checking .......................... .417, 418
Dipstick ........................... .417, 418
Disposal .............................. .422
Filter ...................... .422, 462, 464, 465
Filter Disposal .......................... .422
Identification Logo ...................... .419
Materials Added To ...................... .420
Pressure Warning Light ....................179
Recommendation ..................419, 460, 461
Synthetic ............................. .422Viscosity
.....................419, 420, 460, 461
Oil Filter, Change ......................... .422
Oil Filter, Selection ......................... .422
Oil Pressure Light ......................... .179
Onboard Diagnostic System ...................414
Operating Precautions ...................... .414
Operator Manual (Owner’s Manual) ...............4
Outside Rearview Mirrors .....................84
Overhead Console ......................... .149
Overheating, Engine ....................... .382
Owner’s Manual (Operator Manual) ...........4,483
Paint Care ............................... .439
Panic Alarm ...............................18
Parking Brake ............................ .322
ParkSense

System, Rear ..................... .140
Passenger Seat Easy Entry ..............................98
Passing Light ............................ .109
Performance ............................. .203
Personalized Menu Bar ..................... .280
Pets .....................................68
Placard, Tire And Loading Information ........340, 341
Power Brakes ............................... .324
10
INDEX 495