check engine light FIAT PUNTO EVO 2009 1.G Owner's Manual

214
KNOWING
YOUR
VEHICLE
SAFETY
STARTING
AND DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN
EMERGENCY
SERVICING
AND CARE
TECHNICAL
SPECIFICATIONS
CONTENTS
●● ● ● ●
●● ● ● ●
●● ● ● ●
●● ● ● ●
●● ● ● ●
●● ● ● ●
●●
●● ● ● ●
●● ● ● ●
●● ● ● ●
●● ● ● ●
●●
●● ● ● ●
●● ● ● ●
●
EURO 5 DIESEL VERSIONS
Thousands of kilometres 35 70 105 140 175
Check tyre condition/wear and adjust pressure if required
Check operation of lighting system (headlamps, direction indicators, hazard warning lights,
boot, passenger compartment, glove box, instrument panel warning lights, etc.)
Check operation of windscreen washer system and adjust nozzles
if necessary
Check windscreen/rear window wiper blade position/wear
Check condition and wear of front disc brake pads and operation of pad
wear indicator
Check condition and wear of rear disc brake pads (1.6 Multijet versions)
Check condition and wear of rear drum brake linings (1.3 Multijet version)
Visually inspect the conditions of: bodywork, underbody protection,
pipes and tubes (exhaust - fuel - brakes), rubber parts (boots, sleeves, bushes, etc.)
Check cleanliness of bonnet and boot locks, as well as cleanliness and lubrication of linkages
Check and, if necessary, top up fluid levels (brakes/hydraulic clutch, windscreen washer,
battery, engine coolant, etc.)
Check the handbrake lever stroke and adjust it, if necessary
Visually inspect the condition of accessory drive belts
Check emissions/fumes
Check engine management system operation (via diagnostic socket)
Replace accessory drive belt/s
211-234 PUNTO FL EN 3ed 9-12-2009 13:38 Pagina 214

216
HEAVY USAGE OF THE VEHICLE
Should the car be used predominantly in one of the fol-
lowing particularly demanding conditions:
❒ trailer or caravan towing;
❒ dusty roads;
❒short (less than 7-8 km) and repeated journeys in sub-
zero temperatures;
❒frequently idling engine or long-distance, low-speed dri-
ving (e.g. door-to-door deliveries), or in the event of
long-term inactivity;
❒ in cities;
perform the following inspections more frequently than
shown on the Scheduled Servicing Plan:
❒ check condition and wear of front disc brake pads;
❒check cleanliness of bonnet and boot locks, as well as
cleanliness and lubrication of linkages;
❒visually inspect the conditions of: engine, gearbox, trans-
mission, pipes and tubes (exhaust – fuel – brakes), rub-
ber parts (boots, sleeves, bushes, etc.);
❒check battery charge and liquid level (electrolyte);
❒ visually inspect condition of accessory drive belts;
❒ check pollen filter and replace it, if required;
❒ check air filter and replace, if required.
REGULAR CHECKS
Every 1,000 km or before long journeys, check and, if nec-
essary, top up:
❒engine coolant fluid level;
❒brake fluid level;
❒windscreen washer fluid level;
❒tyre pressures and conditions;
❒operation of lighting system (headlights, direction indi-
cators, hazard lights, etc.);
❒operation of the windscreen wiper/washer system, po-
sition and wear of the windscreen and rear window
wiper blades;
Check and top up, if required, the engine oil level every
3,000 km.
You are recommended to use PETRONAS LUBRICANTS
products, which have been designed and produced specif-
ically for Fiat cars (see table “Capacities” in the “Techni-
cal specifications” section).
KNOWING
YOUR
VEHICLE
SAFETY
STARTING
AND DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN
EMERGENCY
SERVICING
AND CARE
TECHNICAL
SPECIFICATIONS
CONTENTS
211-234 PUNTO FL EN 3ed 9-12-2009 13:38 Pagina 216

217
CHECKING LEVELSKNOWING
YOUR
VEHICLE
SAFETY
STARTING
AND DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN
EMERGENCY
SERVICING
AND CARE
TECHNICAL
SPECIFICATIONS
CONTENTS
fig. 198 – 1.2 and 1.4 8vversions
fig. 199 – 1.4 Multi Air versions
Never smoke while
working in the engine
compartment: inflammable gas-
es and vapours may be present,
constituting a fire risk.
WARNING
When topping up, take
care not to mix up the
various types of fluids:
they are not compatible with
each other and could seriously
damage the car.
1. Engine coolant
2. Battery
3. Windscreen washer fluid
4. Brake fluid
5. Engine oil.
F0U0181m
F0U0182m
211-234 PUNTO FL EN 3ed 9-12-2009 13:38 Pagina 217

220
KNOWING
YOUR
VEHICLE
SAFETY
STARTING
AND DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN
EMERGENCY
SERVICING
AND CARE
TECHNICAL
SPECIFICATIONS
CONTENTS
F0U0282mfig. 204 – 1.2 and 1.4 8vversions
ENGINE OIL fig. 204-205-206-207
Check the oil level a few minutes (about 5) after the en-
gine has stopped, with the car parked on level ground.
The oil level should be between the MIN and MAX marks
on the dipstick B.
The gap between the MIN and MAX marks corresponds
to about 1 litre of oil.
If the oil level is near or under the MIN line, add oil through
the filler A until it reaches the MAX line.
The oil level should never exceed the MAX line.
F0U0284mfig. 206 – 1.3 Multijet version
F0U0283mfig. 205 – 1.4 Multi Air versions
ENGINE OIL CONSUMPTION
The maximum engine oil consumption is usually 400 grams
every 1,000 km.
During the initial period of usage for the vehicle, the en-
gine is bedding in, therefore the engine oil consumption
may settle down only after the first 5,000 – 6,000 km.
211-234 PUNTO FL EN 3ed 9-12-2009 13:38 Pagina 220

221
F0U0285mfig. 207 – 1.6 Multijet version
IMPORTANT The oil consumption depends on driving
style and the conditions under which the car is used.
IMPORTANT After adding or changing the oil, let the en-
gine turn over for a few seconds and wait a few minutes
after turning it off before you check the level.KNOWING
YOUR
VEHICLE
SAFETY
STARTING
AND DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN
EMERGENCY
SERVICING
AND CARE
TECHNICAL
SPECIFICATIONS
CONTENTS
Be very careful working in the engine com-
partment when the engine is hot: you may
get burned. Remember that the fan may start up
if the engine is hot: this could injure you. Make
sure that scarves, ties and other items of loose-fit-
ting clothing do not get caught up in moving com-
ponents.
WARNING
Do not add oil with different characteris-
tics from those of the existing engine oil.
211-234 PUNTO FL EN 3ed 9-12-2009 13:38 Pagina 221

222
F0U0286mfig. 208
ENGINE COOLANT fig. 208
The coolant level should be checked when the engine is
cold and should be between the MIN and MAX lines on
the reservoir.
If the level is low, slowly pour a mixture of 50% distilled
water and 50% PARAFLU
UP(made by PETRONAS
LUBRICANTS) through the filler neck A until the level ap-
proaches MAX.
A 50-50 mixture of PARAFLU
UPand distilled water gives
freeze protection up to –35°C.
When the vehicle is used in particularly harsh weather con-
ditions, we recommend using a 60-40 mixture of
PARAFLU
UPand distilled water.
KNOWING
YOUR
VEHICLE
SAFETY
STARTING
AND DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN
EMERGENCY
SERVICING
AND CARE
TECHNICAL
SPECIFICATIONS
CONTENTS
The used engine oil and the replaced oil fil-
ter contain substances that are harmful to
the environment. It is advisable to have oil
and filters changed by a Fiat Dealership, where they
will be disposed of properly and in accordance with
the law.PARAFLUUPanti-freeze is used in the en-
gine cooling system. Use the same fluid as
in the cooling system when topping up.
PARAFLU
UPshould not be mixed with any other
type of fluid. If this accidentally occurs, do not start
the engine and contact a Fiat Dealership.
211-234 PUNTO FL EN 3ed 9-12-2009 13:38 Pagina 222

223
F0U0287mfig. 209
KNOWING
YOUR
VEHICLE
SAFETY
STARTING
AND DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN
EMERGENCY
SERVICING
AND CARE
TECHNICAL
SPECIFICATIONS
CONTENTS
The engine cooling system is pressurized.
If the cap needs replacing, do so with an-
other original or the effectiveness of the system
may be compromised. Do not remove the cap
from the reservoir when the engine is hot: you may
get burned
WARNING
WINDSCREEN/REAR WINDOW WASHER/
HEADLIGHT WASHER FLUID fig. 209
To top up, remove the cap A.
Pour in a mixture of water and TUTELA PROFESSION-
AL SC35 liquid, in the following concentrations:
30% TUTELA PROFESSIONAL SC35 and 70% water in
summer.
50% TUTELA PROFESSIONAL SC35 and 50% water in
winter.
At temperatures below –20°C, use undiluted TUTELA
PROFESSIONAL SC35 fluid.
Check the level through the reservoir.
Do not travel if the windscreen washer
reservoir is empty: using the windscreen
washer is essential for improving visibility.
WARNING
Some commercial additives for wind-
screen washing are flammable. The en-
gine compartment contains hot parts which could
cause a fire if they come into contact with these
additives.
WARNING
211-234 PUNTO FL EN 3ed 9-12-2009 13:38 Pagina 223

227
KNOWING
YOUR
VEHICLE
SAFETY
STARTING
AND DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN
EMERGENCY
SERVICING
AND CARE
TECHNICAL
SPECIFICATIONS
CONTENTS
IMPORTANT If the battery remains with the charge be-
low 50% for a long time it becomes damaged through sul-
phation and its starting capacity is reduced.
The battery will also be more at risk of freezing (this can
happen as early as -10°C). Refer to “Car inactivity” in
“Starting and driving” if the car is left parked for a long
time.
If, after buying the car, you want to install electrical devices
that require a permanent electric supply (alarm, etc.) or
devices that use a lot of electricity, contact a Fiat Dealer-
ship. Their qualified personnel, in addition to suggesting
the most suitable devices from the Lineaccessori Fiat range,
will evaluate the overall electricity consumption, check-
ing whether the car’s electrical system is capable of with-
standing the load required, or whether it should be inte-
grated with a more powerful battery.
Since these devices continue to consume energy even
when the engine is switched off, they gradually run down
the battery.WHEELS AND TYRES
Check the pressure of each tyre, including the spare, every
two weeks and before long journeys. The pressure should
be checked with the tyre rested and cold.
It is normal for the pressure to increase when the car is used;
for the correct tyre inflation pressure, see “Wheels” in the
“Technical specifications” section.
Incorrect pressure causes abnormal tyre wear fig. 211:
A normal pressure: tread evenly worn.
B low pressure: tread particularly worn at the edges.
C high pressure: tread particularly worn in the centre.
The tyres must be replaced when the tread is less than
1.6 mm thick. In all cases, follow the laws in force in the coun-
try where you are driving.
IMPORTANT NOTES
❒Where possible, avoid braking suddenly, wheel-spinning
and crashing into kerbs, potholes or other obstacles. Long
distances on uneven roads can damage the tyres;
211-234 PUNTO FL EN 3ed 9-12-2009 13:38 Pagina 227

233
INTERIOR
Check regularly that water is not trapped under the mats
(due to drops from shoes, umbrellas, etc.), as this could
cause the sheet metal to rust.
KNOWING
YOUR
VEHICLE
SAFETY
STARTING
AND DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN
EMERGENCY
SERVICING
AND CARE
TECHNICAL
SPECIFICATIONS
CONTENTS
Detergents cause water pollution. The ve-
hicle should be washed only in areas
equipped for collecting and purifying the
liquids used in the washing process.
Windows
Use specific detergents to clean the windows.
Also use clean cloths to avoid scratching the glass or al-
tering the transparency.
IMPORTANT Wipe the rear window gently with a cloth
in the direction of the filaments to avoid damaging the heat-
ing device.
Engine compartment
Wash the engine compartment thoroughly at the end of
every winter. Be careful not to direct the jet of water on-
to electronic control units. Adequately protect the up-
per air vents to prevent damage to the windscreen wiper
motor. Have this operation performed at a specialised
workshop.
IMPORTANT The washing should take place with the en-
gine cold and the ignition key in the STOP position. After
the wash, make sure that the various protective devices
(e.g. rubber caps and guards) have not been removed or
damaged.
Front headlights
IMPORTANT Never use aromatic substances (e.g. petrol)
or ketenes (e.g. acetone) for cleaning the plastic lenses of the
front headlights.
Never use flammable products, such as
petroleum ether or modified petrol, to
clean inside the car. The electrostatic charges
which are generated by rubbing during cleaning
may cause a fire.
WARNING
Do not keep aerosol cans in the vehicle:
these could explode. Aerosol cans must
not be exposed to temperatures exceeding 50°C.
When the vehicle is exposed to sunlight, the tem-
perature inside can greatly exceed this value.
WARNING
211-234 PUNTO FL EN 3ed 9-12-2009 13:38 Pagina 233

KNOWING
YOUR
VEHICLE
SAFETY
STARTING
AND DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN
EMERGENCY
SERVICING
AND CARE
TECHNICAL
SPECIFICATIONS
CONTENTS
245
––
––
––
––
2.4 2.2
2.6 2.2
––
––
2.4 2.2
2.6 2.4
––
––
2.6 2.3
2.8 2.52.2 2.1
2.2 2.2
2.2 2.0
2.2 2.2
––
––
––
––
2.2 2.0
2.2 2.2
––
––
2.4
(Õ)2.2(Õ)2.4(Õ)2.4(Õ)
––
––
––
––
2.2 2.0
2.2 2.2
––
––
2.2 2.0
2.2 2.2
––
––
2.4 2.2
2.4 2.4––
––
––
––
2.2 2.0
2.2 2.2
2.2
(❒)2.0 (❒)2.2 (❒)2.2 (❒)
2.2 2.0
2.2 2.2
2.2
(❒)2.0 (❒)2.2 (❒)2.2 (❒)
2.4 2.2
2.4 2.4
2.4 2.1
2.5 2.2
2.3 2.1
2.3 2.3
––
––
––
––
2.3 2.1
2.4 2.4
––
––
2.4 2.2
2.5 2.4––
––
2.3 2.1
2.3 2.3
––
––
––
––
2.3 2.1
2.4 2.4
––
––
2.4 2.2
2.5 2.4
COLD TYRE PRESSURE (bar)
Versions1.2 – 1.41.4 Multi Air 1.4 Turbo Multi Air1.3 Multijet 75HP 1.3 Multijet 90HP 1.6 Multijet
1.3 Multijet 95HP
Front Rear Front Rear Front Rear Front Rear Front Rear Front Rear
175/65 R15 84T
Medium load
Full load
185/65 R15 88T
Medium load
Full load
185/65 R15 88H
Medium load
Full load
185/65 R15 88V
Medium load
Full load
195/55 R16 87H
Medium load
Full load
195/55 R16 87V
Medium load
Full load
205/45 R17 88V
Medium load
Full load
(❒) SPORT configuration (Õ) Tyre provided only for 1.4 engine
Add +0.3 bar to the prescribed inflation pressure when the tyres are warm. However, recheck that the value is correct with the tyre cold. With snow
tyres, add +0.2 bar to the pressure recommended for standard tyres. When running at speeds higher than 160 km/h, inflate tyres to full-load pres-
sures. If there is a TPMS system, add +0.1 bar to the prescribed pressure. 175/65 R15 84T tyres do not come with a TPMS system.
235-258 PUNTO FL EN 3ed 9-12-2009 13:41 Pagina 245