weight FORD CAPRI 1974 Workshop Manual

)
Contents
Introductory pages
About th is manual 5
Introduction to the Capri VB 5
General dimensions, weights and capacities 6
Jacking and towing 7
Buying spare P M 'S and vehicle identification numb ers 8
G en eral rep air procedures 9
Tools and workrllU facilIties 10
Safety f irs t! 12
Routine main tenance
Recommended lullricants and flUids
Conv ersion !,I CIOIS
F aull dlilgn osis
Chapter 1
EIlUlne
C[Hlple r 2
Coolin\) system
Ch<lptcr 3
Fue l ,mel exhaust sy~telll
Chapter 4
Ignition sys!Cm
Chapter 5
Clutch
Chllptcr 6
Manllill IJCil,hox a nd 'llltonlil!'!.: lrililsn&#39;IS~IOII
Chopler 7
Propeller shalt
Ch(liltcr 8
IlCilr ilxl<:
Chapter 9
l3ulklilU sy~lem
Chapter 10
Suspension ilnd SluCIIIIU
Chapter 1 1
Bodyw or k and trl1il19S
Chapter 12
Electrical s y s!Cm
In de x
13
17
18
19
23
57
66
87
"
102
12 8
132
142
1 [is
171
196
248
procarmanuals.com

)
"'
General dimensions, weights and capacities
Dimensio ns (t y pic .. )) Ov"",11 lo'I1(llh Ov,,,,,11 wIdth Ov",;,11 IlI:!!lill Wh""IIJo1S() Tlack F,on1-30 h(I(!. 28 hire. ReiH. 3.0 !olle 2 .8 litre TlJJnOll(J circle (he1wccll ke,l>s) 30 hire 28 litre
Weights (typical ) 30 S Manl!~1 IIo1I1SI11;%IOI1 . Autulll"j,{; llimsmj~s&#39;on 30 Gill;] . Mallual 1,~nsrnISSIOll Automm,e tl""Slllission 2 8 IllJCClio 'l Roof ",d 10<1d
Ca pilcities (typiCill) EIlB"l(), 3 0 htH) . With tiller
Wrthout filter 28 litre : Wrth frller . Without frlter . COOI"l\1 system 3 0 li tre , 2 8 litre
Fuel sys tem . TrJnsrlllssion
M'III(rJI. 4·speed .
5 ·speed .
Automatic (JPprox)
Rear Jxle. Stee ring geM: MJrlU.11 Power·Jssistcd.
GeJr 001 Fluid Sr:p.lrate rese rvoir Imellr,, 1 reservoir
Series II 4340mm (1709 in). 1698 Illll) «(}(;,9 in) 1357 Ilun (53.4 in) 2559 ""11 (100.7 in)
1353 IlUll (53.3 in)
1384 mOl (54 5 in)
100m(32811)
1155 kg (2546 Ib) 11 <15 kU (2524 Ib)
1185kg (2612 11)) 1174 kg (2588 Ih) 1190 kg (2623 Ib) 75 kg (165 Ib) max
5.0 Irtre
(8.8 pint) 4.25 htre (7.5 pin1)
4.25 litre (7.5 pint) 4 .0 l i tre (7.0 pint)
9 .3 htre (16.4 pin1) 8 .7lotre (15.3 pin1) 58 litre (1 2.7 gal)
2 .0 litre (3. 5 pim) 1.9 Iotre (3.3 pim) 7 .5 litre (13 .2 pim) 1.1 litr e (1. 9 pint)
0.15 litle (0.26 pint)
0 .20 litre (0.35 p int)
2.2 litre (3 .87 Plllt) 0 .50 litre (0.88 pin1)
Series III 4439 mm (174.810) 11398 111m (66.9 in) 1323 mm(521 in) 2563 mill (1009 in)
1353 mm (53.5 in) 1400 mm (55.1 in)
1384 mm (54.5 in) 1431 mm (56.3 in)
98 m (32.2 II) 99111 (325 It)
procarmanuals.com

Chapter 1 Engine 49
----------------~--~----------------= anuill transmiSsIOn models, remove foul clops <lnd remove Ihe 16 On h(11 sing cover . On ilulonHll lC tr&#34;nsmIS~lon models dIsconnect Ch.llCh au lug the 011 cooler hoses. and P It the Irans!1lI$S10n then remove th e l'illlsnllSS lon to-engine 17 Suppa <
bolt~ n automatic 1.,J;lsmission .models. drilm the torque conve!ler ,\Ild 18 Ihe drivep l<lte boilS wllh ,clerence 10 Chnpler 6. UO~~~~ Ihe weight 01 tho engine on thc hoist ilnd then pull tile euuin!} " d \0 separJIC;1 1'0111 the \'<lnSIllISS'OIl. 0 " [lU10111<1(1(; IlilI151"'5' 10' ..... 31 , I
. odelS make s"re Ih,lt the torqlle converter ,em,,!!)s lilly 1f1 1he $lOI1 m transmission . 20 When the engine hilS been SCpM,lICd from 11l(l 11.,11$1111551011, 1,lllh!.! . ,lowly chccklll9 j,equently to see (hMllle CflUllle does not loul " ng,ne . ~nv part of the bo?ywork. 21 W hen the engUle 's cle,lr of the iJody . lower it to the ~lfOun(i. Of
Ir~nsler it to a WOrk lJench
4 $ Engine disill1lotling -generill
Refer \0 Sec t,on 7
46 Engine illlcillilrics -removi\1
..
1,',lh the engine sep,l rated from th" t r;IIl~:nHS~r()&#34; remove Ihe ~.tcrnally mounted componelliS ;l~ lulluw~
C;J//)Ulello, i.lnd fllcl {lump (C"'1!,lt" 3) IlIlel ,wll exhiwsl tII,wi/a/ris (Chaf!/t't 3) Sp,>r/( plugs and drS/fllmlor (Chaplet 4) AllCllwlor (Chaplet /2) F.w ,7I!d policy (CII,71I1C' 2) W.JICf pump ,wd Ihcffllos/.1I (Clmp/t't 2) C, ,1IIkc,lSC vcn/iliilion lubc 011 {,f/CI (Scc/ion 40) Ol/Icvl!! r/rpsllc/o; and {,/lCf C,?!, [II!1int' 1II01tn/ill.ll h,.1r:kvls Ciulell (Ch,7/I/l'l 5) Powl'r S/Cl'l/IIN 1'(11111' (Ch;lll/Vf 10J
<11 Cylind(Jr heads relllowti with engine in car
I
Q,scunnecllhe IJiltlery le,lds ") ~cmove the splilsh slucld. by renuJVIII<j 10\" holts nnd luur chps J II.lee il cOrltilm er 01 10 Irtre (I·' 6 pint) r.ap.lr.lty unde!l1e,Ilh Ihl.! ~&#34;lr.llor. remove the rmll:l\or hallam ho~e and drilill Ihe system Rr:rnove the rad "l\()r lap ilose . !l Rcrl10ve Ihe au Clealler. d'SC(lnner.t lile h,el p'pe fro m the ~MI;;&#34;rllor and Ihe l"e,lIiler hose hom Ihe rocker cover.
, R ernove the servo V,lCUlUl1 hose I<om tile Inlr:1 l11illlllold ~ enlOve Ihe IllIe e bolts and rem!)ve II,e Ihrollie Irnkaqe lI<ilC~l;t .omllic le wo1h Irll kilge '
~ DI~conrlccl Ihe rilll,.llul hose from Ihe ilulomallC choke D,s·
,onneCI the vac\JUnl h"e I<om cariJU!l:1I0r .
• D,sconnect" I I I 10 0 le ea( <orll Ihe lempelnllllc sende< Unit.
co I I~con&#34;ecllhe HT ICilds Irom the spark plugs and IrOlillhe Ign'llon I ,1od remove Jlw L T I I I I .
MId I I If . CiI( 10 lie dlSl1i Julor Reillove aile h Xlng bolt 11 0
' I
a Ihe dlst"I>[1I0r ilSsemlily.
'Sconllect Ihe all II 51 halts' , ' ernillOr Cil) es. ilcken the ailelllntor 1110ul1l11lg un( <emovelh~d b I hi· '" ... live C I. I en remove the fllCrnfilor h XlIlg bolts rernove the ~I&#39; . 12 R " erniltor ')nd liS I,x,ng lIrackel. CIlIOVe Ihe Spa k I cOvers d "p uos. Remove Ihe IIUIS secufII1(.l Ihe rocker 13 R an hll 011 tho covers. emove the I I I . . mlel III f IVC '0 IS sec linn\) the onlet lII,1(l,lold and take 011 lile 14 l an, old complr:te Wllh ca<lIurello, OOson Ihe rock turned a ·d er """ .ldjust"'g nulS ulI\ll Ihe !Ocker arms can be ) hoe Or SI CI(F'(J 1 10) Ihen rCOllOV!.! Ihe pushrods ilild lily them oul Itl PO,ition l~llS I, lill.!1[ finds through a sheel 01 paper 011 which Ihelr III I Ie ("",II,e . I
Pusil rod . C,II1)e "Oled. 11 IS very Imporl<lIlI Ihal the IOtnOVCdS .1<0 r(;f,tted \0 Ihe same villve as Ihat from which they were
"IOC>! "
Fi~,. 1 .10 Turn the rocker (HillS to olle side 10 relllove the pushrods (Sec 47)
15 n,,,,,ove Iwelve lIolts ilnd delilch Ihe exh,lusl I1\,lrlllolds frOI" Ihe cylrrlrtr:f he,lds. 16 Sinckell the cyhmter hend boilS progressively in the revtnSe order to Ih"l shown ill FIll 1.19. IlcrllOVC Ihe bolts nlld hit olt Ihe cylindOf head.
It lile (.Iilsket has stuck and the cylrnder heJd cannot lJe lifted off. wp the cylinder heild wllh n hide·f.1cert. or plnstic·headed hJmmer. 00 nOI try to pri se IlIelil off wllh a screwdrivOf Of rtilillage WIll result.
4 8
Cylinder he,l(ls -rernovfli wilh engine O\lt o f car
Follow Ihe sequence (.I,,·elllll SectIon '17. 51;lItll1g.l1 PillillJl1lph 10. dl$lcoa,d,n!1 leil.!lellCeS to pa'is willch hJve alreildy bcen rcmuved
49 Villve$ _. removal
Rt:rllove the d('POSIlS /'0111 tire corllb\lsl,on chambers ~nd vnlve
h eads by ScrilPIl1!l and W&#34; ~ b'\Ishlll(.l Tilke CJre nOI 10 scratCh the cyllnde, he~d gaskel lilces 2 Lay the CylOl(ier hemt on ,IS sllll) .llld h t the lo,~ed cnd of .1 VJlve spllng compressor ove, the ~plln9 rctiluler ""d ti le head uf the complessor screw in Ihe cenl'e of Ihe v"lve head 3 Compress Ihe sprrng abolll " qUJller 01 an Ulc h 10 Iree Ihl} split colle l hom the top 0 1 the v,llve stelll. If Ihe sPltng ,eliHner "nd collel Slicks. do not screw the co",p,essor down lurlhc< . bec"use IIIIs lII.ly dJr11J\je the valve Slem. bUI lJp the sprong reliluler sha,ply wllh a Ioghl
hammer. 'I When the Iwo halves of Ihe collet h')ve been '(:nloved. onscrew the spllng compressor umrl Ihe spring IS no longe, compressed nnd
remove Ihe compreSSOr . 5 f1Olllove the spltng retnlner. the spflng and the oil seal from Ihe villve Slem. Ihen wrlhdrflw Ihe villve from I he cylinder head. 6 D iscard the valve Slem all senls and plflce Ihe Olher componenls to\jellrCt. identilying them so Ihal they arc refItted III the correC I plnce
III Ihe cylinder head. 7 Remove Ihe sp,11k plugs from Ihe cyhnder hend. II nOI alrendy
removed.
50 Rocker arms -removal
1 Remove the SIIfI nul from Ihe foch" .1'111 Illoullt,n\) stud 2 Lift off the rocker <Hill b')ll seiltin\! and Ihe roc~er Mm and Iny Ihe tl1<ee parIS 10<jethe r II IS ImpOrtilllt Ihat Ihe locke' arm. its hall SCJling and nUl ale refa ted \0 I he snme stud as Ihe one 110m which Ihey were
re moved.
procarmanuals.com

Chapte r 4 Ig nitio n sys te m
6,SA Unsc rew the clamp bolt, 680 ... and remove the (tistJlbu to. 68C Rotor nnn alignmen t ;]lter re movnl Irorn engine
~ I
~.

F ig . 4.3 IU "i\iol1 timinu ma,ks o n the 3,0 lit.e e:1Uine (Sec 6)
Allow ;//(lic<1leS din'cliu" 0' !(JIM;oll
7 Distributor (3.0 litre engine) -overhaul
W,th the diMJlhuto. removed from the entl,ne. 'emove the rotor arm and the cont.1CI breaker assembly . 2 Prose Ihe small Clfclll} I'om the v"cuum u,,,t p,vo l IXJSt. 3 flemove th e two sc,ews wh,ch sucure the hfllaker pl,lI!! to Ihe d,slJlbu tor body and hit the ,}I'rte orl.
" Slacken Ihe self'lappmg SCfew which SC<:UlCS the condense, and low tenSion leads 10 Ihe contact l .. eaker a ssembly and shde OUI Ihe lo.ked ca ble terminations, 5 Undo imd remove Ihe condenser rCI.1,nlfl!.l screw and remove the condense •. 6 Remove the c" chp. lIiJt washer and wavy wash er from the pivot post. Se parat e the two plates by h,ingmu the holding down se,ew Ihrough Ihe keyhole sial in Ihe lowe. 1)late , Ta ke care not 10 lose the e.Jrt h spring on the prvo t flOst. 7 Remove the two se,ews seeu"n\) Ihe vilCuum un,t to the d IS t"lHIIO' hotly .Jntl remove the vacuum uni t. S To d,snl.JllIle Ihe vacuum unll, remove the plug I.om the end 01 the
unit (md withdraw the spring. vacuum stOp and shims 9 Oelo,e disll1<1ntling th e centJllugal .Jtlvance mech.Jnism. note thM th e tw O spri ngs arc d.lle.ent and ma,k them so th.Jtlh ey .Jre ref'tled in th ei r OJlgHlall}lilces . Remove the sp. ings. pJlse all the circ lil)S securong the cenlJlluga i weights. nl.J.k the weight s 10 'dent'fy their o"ginal positions and then remove them ,
1 0 M3<k which 0 1 th e end slo ts on th e n'cchan,c.J1 .Jdvanctl pl;]le
lages w llh the s tol) m Ihl! ;]C hOn I)I"le II II" s IS not dono. II rs ~ s, llle to h.Jve th e ,oto, ,'Jln 180' from 'I S COf/,-ct pOSition. 11 Remove the lelt pad 1 10m t h e centre 01 the C.JIll. e~pand the circhp
x - ------:::-.
z
y -
Fig . 4.4 Distrihutor lilting position on the 2.8litrc e ngine (Sec 6)
XX Re.1r "U;,.' of ellgmc yy V,1CI/(JIII flllil Mas Z = 0 '10 11/'
A Triggcr (lffll U Slillor l!fII!
whICh'S Ihen exposed Ilntl ,emove ,I L,lt all Ihe Ci"n and 1l(IV3ncc plJle ;Issemul y,
12 Do nOI .cmove t he d,stJluutor Sl)indle unless II 's necess.l'y to "1 a new ge.n. 0' S I)iJldle To remove Ihe uear . usc <1 IlUnch Ilnt! hJmmer t o dJlve outlhc lock P'" and Ihon pull tl)() !.Ic", frO'11 Ihe sprndle T"ke cn,e
1 0 rOIil'" ilny slums, 0' wllshe,s wh,ch fll.Jy be In led . W,t h the ueJ' lell'Ov\:(\. the sl)lIldle .Jsscmbly can be withd,awn hom the d ,s'Jlhu tor 13 Belore reassembhng. ca,elully clc.J1l the body 01 th e d,s lnbulOr and "II a s CO'llpo llent p"'ts. II th e sp,n(!ie has been .emoved. lulmenlC II w'lh e'lu",e oil h efor e ,ellssemhly. 14 Reassenlbly.s <1 SUa'ghtIOrw<1Jd ,eve'SilI 01 d,sman tling bUI t he,e Inc several pointS which shoold be noted.
15 Lut)JJc;]te th e ce Jltlil ugnl weights and otho. p3rtS ol the cenlrifugal
advnnce mechanism. the diSlrrbutor shah a nd Ihe pa'l 01 the spindle wh,eh c.l"'es Ihe cam assembly. using engine all. Do not orl excess,vely. 16 " Ih e dr'veshnlt hilS heen .emoved. firSt re fi t th e thru st wash ers below tho action plnte. bolore "'se,ting the S h .l h into thc disl. ih llto,
hody . FII the w3vy washer .Jnd IhrUSI washcr to the lowe! end 01 the shah and then relilthe ge.Jr. secuJlnU it with a new spring p in. II a now gear. or a ne w u"ves hnfL h,15 been fllt ed . a n\lW hole should be d"lIed .1t 90' 1 0 Ihe e~is&#39;U1g hole 17 Alte • .Jssemhhng the centJll ug.J 1 weIgh ts .Jnd sprrngs. check that Ihl!Y movo hccly. w,thout I)inding, 18 8clOle assemblmg Ihe breaker pla tcs . make sure thill the three nylon bearing slUds a.e located "1 tht) h oles ,n the uPllC' uearinU plale and Ih3tthe e.Jrth,ng sprrng ,s foiled to the p,vOt post 19 On complet'on of assemlJly. adlust the conlnCl b'eake , gilp to the spc cified selling
procarmanuals.com

")256
W
Water pump reliuinu -44. 61 removal -61 Weights. vehicle - 6 Wheels care Jod rll<lillteMnCe .. 171 nuts/bolts torque wrench selling -158 stud renew,,1 (rear) _ 140 Windscreen removnl nod ,ehtling -180
)
Index
W indscree n washe r nozzle removal and refitting -219 pump removal and refitting -219 Windsc ree n wipers arms and blades removal and relitting -220 fault tracing -219 motor and lin kage removal and refi1ting -218 mOlor dismantling and roassembly -219 switch (Series II) -225 Wiring diagrams -235 to 249 Working facilit ies -11
."
procarmanuals.com