warning FORD RANGER 2000 2.G Owner's Manual

Plain water may be added in an emergency, but youmustreplace it with
a 50/50 mixture of engine coolant and distilled water as soon as possible.
Check the coolant level in the reservoir before you drive your vehicle the
next few times (with the engine cool). If necessary, add a50/50
mixtureof engine coolant and distilled water to the engine coolant
reservoir until the coolant level is at the ªcold fill levelº or within the
ªcold fill rangeº as listed on the reservoir (depending upon application).
Have your dealer check the engine cooling system for leaks if you have
to add more than 1.0 liter (1.0 quart) of engine coolant per month.
To avoid scalding hot steam or coolant from being released from
the engine cooling system, never remove the radiator cap while
the engine is running or hot. Failure to follow this warning may result
in damage to the engine's cooling system and possible severe personal
injury.
If you must remove the radiator cap, follow these steps to avoid personal
injury:
1. Before you remove the cap, turn the engine off and let it cool.
2. When the engine is cool, wrap a thick cloth around the cap. Slowly
turn cap counterclockwise until pressure begins to release.
3. Step back while the pressure releases.
4. When you are sure that all the pressure has been released, use the
cloth to turn it counterclockwise and remove the cap.
Recycled engine coolant
Ford Motor Company recommends the use of a recycled engine coolant
produced by Ford-approved processes.
Not all coolant recycling processes produce coolant which meets Ford
specification ESE-M97B44-A. Use of a recycled engine coolant which
does not meet the Ford specification may harm engine and cooling
system components.
Always dispose of used automotive fluids in a responsible manner.
Follow your community's regulations and standards for recycling and
disposing of automotive fluids.
Maintenance and care
171

If other than Ford, Motorcraft or Ford-authorized parts are used for
maintenance replacements or for service of components affecting
emission control, such non-Ford parts should be equivalent to genuine
Ford Motor Company parts in performance and durability.
Do not park, idle, or drive your vehicle in dry grass or other dry
ground cover. The emission system heats up the engine
compartment and exhaust system, which can start a fire.
Illumination of the ªCheck Engineº light, charging system warning light
or the temperature warning light, fluid leaks, strange odors, smoke or
loss of engine power, could indicate that the emission control system is
not working properly.
Exhaust leaks may result in entry of harmful and potentially
lethal fumes into the passenger compartment.
Do not make any unauthorized changes to your vehicle or engine. By
law, vehicle owners and anyone who manufactures, repairs, services,
sells, leases, trades vehicles, or supervises a fleet of vehicles are not
permitted to intentionally remove an emission control device or prevent
it from working. Information about your vehicle's emission system is on
the Vehicle Emission Control Information Decal located on or near the
engine. This decal identifies engine displacement and gives some tune up
specifications.
Please consult your ªWarranty Guideº for complete emission warranty
information.
Readiness for Inspection/Maintenance (I/M) testing
In some localities, it may be a legal requirement to pass an I/M test of
the on-board diagnostics system. If your ªCheck Engine/Service Engine
Soonº light is on, refer to the description in theWarning Lights and
Chimessection of theInstrumentationchapter. Your vehicle may not
pass the I/M test with the ªCheck Engine/Service Engine Soonº light on.
If the vehicle's powertrain system or its battery has just been serviced,
the on-board diagnostics system is reset to a ªnot ready for I/M testº
condition. To ready the on-board diagnostics system for I/M testing, a
minimum of 30 minutes of city and highway driving is necessary as
described below:
²First, at least 10 minutes of driving on an expressway or highway.
Maintenance and care
196

Air bag supplemental
restraint system ..........................84
and child safety seats ..............85
description ................................84
disposal ......................................88
driver air bag ............................86
indicator light ......................10,87
operation ...................................86
passenger air bag .....................86
passenger
deactivation switch ..............25,88
Air cleaner filter .......................209
Air conditioning ..........................19
manual heating and air
conditioning system .................21
Ambulance packages ....................3
Antifreeze
(see Engine coolant) ................168
Anti-lock brake system
(see Brakes) .......................107,108
Anti-theft system
warning light .............................11
Audio system (see Radio) .........26
Automatic transmission ............111
driving an automatic
overdrive ..........................112,114
fluid, adding ............................173
fluid, checking ........................173
fluid, refill capacities ..............209
fluid, specification ..................214
Auxiliary power point .................25
Axle
lubricant specifications ...212,214
refill capacities ........................209
traction lok ..............................124
Battery .......................................178
acid, treating emergencies .....178
charging system
warning light .............................11
jumping a disabled battery ....152
maintenance-free ....................178
replacement, specifications ...209servicing ..................................178
voltage gauge ............................17
Belt minder .................................80
Brakes ........................................106
anti-lock .....................106,107,108
anti-lock brake system (ABS)
warning light ......................10,108
brake warning light ..................10
fluid, checking and adding ....166
fluid, refill capacities ..............209
fluid, specifications ..........212,214
lubricant specifications ...212,214
parking ....................................108
shift interlock ..........................111
Break-in period .............................2
Capacities for refilling fluids ....209
Cargo area shade ........................63
Cargo net .....................................63
Certification Label ....................217
Child safety restraints ................93
child safety belts ......................93
Child safety seats ........................94
attaching with tether straps ....99
in front seat ..............................96
in rear seat ................................96
tether anchorage hardware .....99
Cleaning your vehicle ...............203
engine compartment ..............204
exterior .............................204,207
exterior lamps .........................206
instrument panel ....................207
instrument panel lens ............207
interior .....................................207
mirrors .....................................208
plastic parts ............................206
safety belts ..............................207
washing ....................................203
waxing .....................................203
wheels ......................................204
windows ..................................208
wiper blades ............................206
Index
231

Climate control (see Air
conditioning or Heating) ............19
Clock .............................29,36,42,51
Clutch
fluid ..........................................167
operation while driving ..........116
recommended shift speeds ....118
Console ........................................63
Coolant
checking and adding ..............168
refill capacities .................172,209
specifications ...................212,214
Cruise control
(see Speed control) ....................55
Customer Assistance ................137
Ford accessories
for your vehicle ......................225
Ford Extended
Service Plan ............................218
Getting assistance outside the
U.S. and Canada .....................224
Getting roadside assistance ...137
Getting the
service you need ....................218
Ordering additional
owner's literature ...................229
The Dispute
Settlement Board ...................221
Utilizing the Mediation/
Arbitration Program ...............224
Daytime running lamps
(see Lamps) ................................18
Dipstick
automatic
transmission fluid ...................173
engine oil .................................163
Doors
door ajar warning .....................12
lubricant specifications ..........212
Driveline universal
joint and slip yoke ....................177Driving under
special conditions ..............122,123
mud ..........................................122
sand .........................................122
snow and ice ...........................123
through water ..................122,124
Emergencies, roadside
jump-starting ..........................152
Emission control system ..........195
Engine .................................214,215
check engine/
service engine soon light ...........8
cleaning ...................................204
coolant .....................................168
idle speed control ...................178
lubrication
specifications ...................212,214
refill capacities ........................209
service points ............160,161,162
starting after a collision .........138
Engine block heater .................104
Engine oil ..................................163
checking and adding ..............163
dipstick ....................................163
filter, specifications .........165,209
recommendations ...................165
refill capacities ........................209
specifications ...................212,214
Exhaust fumes ..........................105
Fluid capacities .........................209
Foglamps .....................................18
Four-Wheel Drive vehicles ..12,119
control trac ...............................24
description ..............................119
driving off road .......................121
electronic shift ...................24,119
indicator light .........................119
preparing to drive your
vehicle .....................................110
Fuel ............................................186
calculating fuel economy .......192
cap ...........................................188
Index
232

capacity ...................................209
choosing the right fuel ...........189
comparisons with EPA fuel
economy estimates .................195
detergent in fuel .....................191
filling your vehicle
with fuel ....................186,188,192
filter, specifications .........192,209
fuel pump shut-off switch .....138
gauge .........................................14
improving fuel economy ........192
octane rating .............190,214,215
quality ......................................190
running out of fuel .................191
safety information relating to
automotive fuels .....................186
Fuses ...................................140,141
Gas cap (see Fuel cap) ............188
Gas mileage
(see Fuel economy) .................192
Gauges .........................................14
battery voltage gauge ...............17
engine coolant
temperature gauge ...................15
engine oil pressure gauge ........17
fuel gauge ..................................14
odometer ...................................16
speedometer .............................16
tachometer ................................15
trip odometer ............................16
GAWR
(Gross Axle Weight Rating) .....125
calculating ...............................127
definition .................................125
driving with a heavy load ......125
location ....................................125
GVWR (Gross
Vehicle Weight Rating) .............125
calculating ........................125,127
definition .................................125
driving with a heavy load ......125
location ....................................125Hazard flashers .........................138
Headlamps ...................................18
aiming ......................................202
bulb specifications ..................201
daytime running lights .............18
flash to pass ..............................19
high beam ............................11,18
replacing bulbs .......................197
turning on and off ....................18
warning chime ..........................13
Heating ........................................19
heater only system ...................19
Hood ..........................................159
Ignition ................................214,215
positions of the ignition ...........54
Infant seats (see Safety seats) ..94
Inspection/maintenance (I/M)
testing ........................................196
Instrument panel
cleaning ...................................207
cluster ...................................8,207
lighting up
panel and interior .....................19
location of components ..............8
Jump-starting your vehicle ......152
Keys
key in ignition chime ...............13
positions of the ignition ...........54
Lamps
bulb replacement
specifications chart ................201
cargo lamps ...............................19
daytime running light ...............18
fog lamps ...................................18
headlamps .................................18
headlamps, flash to pass ..........19
instrument panel, dimming .....19
interior lamps .........................202
replacing bulbs ..197,199,200,201
Lane change indicator
(see Turn signal) ........................54
Lights, warning and indicator ......8
Index
233

air bag ........................................10
anti-lock brakes (ABS) .....10,108
anti-theft ...................................11
brake ..........................................10
charging system ........................11
check coolant ............................12
check engine ...............................8
cruise indicator .........................12
door ajar ....................................12
fuel reset ...................................10
high beam .................................11
overdrive off ..............................11
safety belt .................................10
speed control ............................59
turn signal indicator .................11
Load limits .................................125
GAWR ......................................125
GVWR ......................................125
trailer towing ..........................125
Loading instructions .................126
Lubricant specifications ....212,214
Lumbar support, seats ...............71
Manual transmission .................116
fluid capacities ........................209
lubricant specifications ..........214
reverse .....................................118
Mirrors
cleaning ...................................208
side view mirrors (power) .......62
Motorcraft parts .................192,209
Octane rating ............................190
Odometer .....................................16
Oil (see Engine oil) ..................163
Overdrive .....................................59
Panic alarm feature, remote
entry system ................................64
Parking brake ............................108
Parts (see Motorcraft parts) ....209
Power distribution box
(see Fuses) ...............................144
Power door locks ........................62
Power steering ..........................109fluid, checking and adding ....173
fluid, refill capacity ................209
fluid, specifications ..........212,214
Preparing to
drive your vehicle .....................110
Radio ............................................26
Relays ........................................140
Remote entry system ............63,64
illuminated entry ......................67
locking/unlocking doors ...........64
panic alarm ...............................64
replacement/additional
transmitters ...............................66
replacing the batteries .............65
Safety belts (see Safety
restraints) ...........13,72,73,74,75,76
Safety defects, reporting ..........230
Safety restraints ......72,73,74,75,76
belt minder ...............................80
cleaning the safety belts ...83,207
extension assembly ..................79
for adults ....................73,74,75,76
for children ...............................93
lap belt ......................................78
warning light
and chime ........................10,13,79
Safety seats for children ............94
Seat belts
(see Safety restraints) ...............72
Seats ............................................70
child safety seats ......................94
SecuriLock passive
anti-theft system ...............67,68,69
Servicing your vehicle ..............158
Snowplowing .................................3
Spark plugs,
specifications ...............209,214,215
Special notice ................................3
ambulance conversions ..............3
utility-type vehicles ....................3
Specification chart,
lubricants ............................212,214
Index
234

Speed control ..............................55
Speedometer ...............................16
Starting your vehicle .........100,102
jump starting ..........................152
Steering wheel
tilting .........................................60
Tachometer .................................15
Tires ......................147,181,182,183
changing ...........................147,150
checking the pressure ............183
replacing ..................................184
rotating ....................................183
snow tires and chains ............185
tire grades ...............................182
treadwear ................................182
Towing .......................................183
recreational towing .................136
wrecker ....................................157
Traction-lok rear axle ...............124
Transfer case
fluid checking .........................177
Transmission
automatic operation ...............111
fluid, checking and adding
(automatic) .............................173
fluid, checking and adding
(manual) .................................176fluid, refill capacities ..............209
lubricant specifications ...212,214
manual operation ....................116
Trip odometer .............................16
Turn signal .............................11,54
Vehicle dimensions ...................215
Vehicle Identification Number
(VIN) ..........................................217
Vehicle loading ..........................125
camper bodies ........................136
Ventilating your vehicle ...........105
Warning chimes ...........................13
Warning lights (see Lights) .........8
Washer fluid ..............................168
Water, Driving through .............124
Windows
power .........................................61
Windshield washer fluid
and wipers
checking and adding fluid .....168
checking and cleaning ............180
operation ...................................61
replacing wiper blades ...........181
Wrecker towing .........................157
Index
235