differential HONDA RIDGELINE 2007 1.G Owners Manual

Î
Î
Ì Ì
Ì
Î
Maintenance Minder
242
: Maintenance
Sub Items
Replace dust and pollen filter
Inspect drive belt
Replace transmission and transfer fluid
Replace spark plugs
Replace timing belt and inspect water pump
Inspect valve clearance
Replace engine coolant
Replace VTM-4 rear differential fluid
Maintenance
Main Items
Replace engine oil
Replace engine oil and oil filter
Inspect front and rear brakes
Check parking brake adjustment
Inspect these items:
Tie rod ends, steering gear box, and boots
Suspension components
Driveshaft boots
Brake hoses and lines (including ABS)
All fluid levels and condition of fluids
Exhaust system
Fuel lines and connect ions
Maintenance Sub Items
Rotate tires
Replace air cleaner element
If you drive in dusty conditions, replace
every 15,000 miles (24,000 km). 2
3
4
5
Symbol
A
B
Symbol 1
2 Symbol
6
If you drive primarily in urban areas that have high
concentrations of soot in the air from industry and from diesel-
powered vehicles, replace every 15,000 miles (24,000 km).
Driving in mountainous areas at very low vehicle speeds or
trailer towing results in higher transmission and transfer
temperatures or frequently fully loaded. This requires
transmission and transfer fluid changes more frequently
than recommended by the Maintenance Minder.
If you regulary drive your vehicle under these conditions, have
the transmission and transfer fluid changed every 30,000 miles
(48,000 km).
If you drive regularly in very high tempera tures (over 110°F,
43°C), in very low temperatures (under-20°F, -29°C), or towing a
trailer, replace every 60,000 mile (U.S.)/100,000 km (Canada)
Driving in mountainous areas at very low vehicle speeds or
trailer towing results in higher level of me chanical (shear) stress
to fluid or frequently fully loaded. This requires differential fluid
changes more frequently than recommended by the
Maintenance Minder. If you regularly drive your vehicle under
these conditions, have the differential fluid changed at
7,500 miles (12,000 km), then every 15,000 miles (24,000 km).
1
1
If the message ‘‚SERVICE DUE NOW ’’ does not appear more than 12 months
after the display is reset, change the engine oil every year.
See information on maintenance and emissions warranty on page .
Independent of the maintenance messages in the information display,
replace the brake fluid every 3 years.
Inspect idle speed every 160,000 miles (256,000 km).
Adjust the valves during services A, B, 1, 2, or 3 only if they are noisy.
NOTE: 1:
240
Maintenance Minder

The rear differential should be
drained and refilled with new fluid
when this service is indicated by a
maintenance message on the
info rmation display. This service
may be needed more often under
certain driving conditions (see page
).
Always use Honda VTM-4
Dif f erential Fluid, and have your
dealer replace the rear differential
f luid.
Insert the dipstick all the way back
in the transmission.
If the level is below the lower
mark, remove the f ill plug, then
add the f luid into the hole to bring
it to the level between the upper
and lower marks.
Pour the f luid slowly and caref ully so
you do not spill any. Clean up any
spill immediately; it could damage
components in the engine
compartment.
Always use Honda ATF-Z1
(automatic transmission f luid). If it’s
not available, you may use a
DEXRON
III automatic
transmission f luid as a temporary
replacement. However, continued
use can affect the shift quality. Have
the transmission f lushed and ref illed
with Honda ATF-Z1 by your dealer
as soon as it is convenient. If you are not sure how to add f luid,
contact your dealer. 6.
5.
242
Automatic transmission Fluid, Rear Dif f erential Fluid
Rear Dif f erential Fluid
252

ÎÎ
Î
Î
Î
µµ Î
Î
Î
Î
Î
Specif ications
302
Capacities
Dimensions
Weights
Air Conditioning 1.64 US gal (6.2
)
2.14 US gal (8.1)
4.5 US qt (4.3
)
4.2 US qt (4.0
)
5.3 US qt (5.0
)
3.3 US qt (3.1)
8.5 US qt (8.0)
206.7 in (5,250 mm)
78.0 in (1,980 mm)
70.3 in (1,785 mm)
2.79 US qt (2.64
)
3.01 US qt (2.85)
0.45 US qt (0.43
)
0.48 US qt (0.45)
0.16 US gal (0.6
) 4.8 US qt (4.5
)
Excluding the oil remaining in the engine Including the coolant in the reserve tank and that remaining in the
engine
Reserve tank capacity:
Fuel tank
Engine
coolant
Engine oil
Automatic
transmission
fluid
Rear
differential
fluid
Transfer
assembly
fluid
Windshield
washer
reservoir
Length
Width
Height
Wheelbase
Track
122.0 in (3,100 mm)
67.1 in (1,705 mm)
66.9 in (1,700 mm) 22.01 US gal (83.3
)
See the tire information label
attached to the driver’s doorjamb.
Gross vehicle weight rating
Gross combined weight
rating (GCWR)
Maximum load limit
(Payload)
The GCWR must be reduced 2 percent for every 1,000 feet (305
meters) of elevation.
Refrigerant type
Charge quantity
Lubricant type HFC-134a (R-134a)
21.2 22.9 oz (600 650 g) ND-OIL8 Approx.
Front
Rear
1:
2:Change
Total
Change
Including
filter
Without
filter
Total
Change
Total
Change
Total
Change
Total
10,088 lbs (4,575 kg)
1:
2:
3: On vehicles without moonroof or navigation system 1,530 lbs (690 kg)
1,480 lbs (670 kg)
On vehicles with moonroof and navigation system
1 1
2
2
3

ÎÎ
...
Identif ication Number, Vehicle .300
...............
Gas Mileage, Improving .183
Gasoline
...............
Fuel Reserve Indicator .65
...........................................
Gauge .71
................
Octane Requirement .178
........................
Tank, Filling the .179
................
Gas Station Procedures .179
Gauges
...
Engine Coolant Temperature .72
...............................................
Fuel .71
...............................
Speedometer .70
.................................
Tachometer .70
GAWR (Gross Axle Weight .......................................
Rating) .213
GCWR (Gross Combined Weight .......................................
Rating) .213
............
Gearshif t Lever Positions .198
......................................
Glove Box .115
GVWR (Gross Vehicle Weight
.......................................
Rating) .213
.....................................
Floor Mats .261
Fluids
..........
Automatic Transmission .251
..........................................
Brake .253
..........................
Power Steering .254
.......................
Rear Differential .252
...................
Transf er Assembly .253
..................
Windshield Washer .250
FM Stereo Radio ...................................
Reception .140
.................
Folding the Rear Seats .103
..........................
Four-way Flashers .79
........................................
Front Seat .98
..............................
Adjusting . 98, 100
.........................................
Airbags .23
.......................................
Heaters .104
.................................................
Fuel .178
......................
Fill Door and Cap .179
...........................................
Gauge .71
................
Octane Requirement .178
...............................
Oxygenated .178
........................
Reserve Indicator .65
........................
Tank, Filling the .179
.....................
Fuses, Checking the .291
.............
Halogen Headlight Bulbs . 255..............
Hazard Warning Flashers . 79
.................................
Headlights . 75, 76
........................................
Aiming .255
..............
Automatic Lighting Off . 77
.................................
Control Dial .76
.......
Daytime Running Lights . 78
..................
High Beam Indicator . 65
.....
High Beams, Turning on . 75, 76
............
Low Beams, Turning on . 76
.........................
Reminder Chime .77
........
Replacing Halogen Bulbs . 255
..................................
Turning On .76
............................
Head Restraints .102
.............................
Heated Mirrors .111
...............................
Heaters, Seats .104
.....................
Heating and Cooling .123
.................
High-Low Beam Switch . 75
HomeLink Universal ................................
Transceiver .171
.......................
Hood, Opening the .181
..................................................
Horn .74
Index
G
H I
IV

Service Information Summary
Gasoline: Tire Pressure (measured cold):
Fuel Tank Capacity:
Recommended Engine Oil:
Automa tic Transmission Fluid:Power
Steering Fluid:
Brake Fluid:
Rear Differential Fluid:
Transfer Assembly Fluid: 32
psi (220 kPa , 2.2 kgf/cm
)
Front/Rear:
Compact
Spare Tire:
60 psi (420 kPa , 4.2 kgf/cm
)
22.01 US gal (83.3
)
API Premium grade 5W-20
detergent oil (see page ).
Oil change capacity (including
filter): 4.5 US qt (4.3
)
Honda ATF-Z1 (Automatic
Transmission Fluid) preferred, or
aDEXRON
III ATF as a
temporary replacement (see page
). Honda
Power Steering Fluid
preferred, or another brand of
power steering fluid as a
temporary replacement. Do not
use ATF (see page ).
Honda Heavy Duty Brake Fluid
DOT 3 preferred, or a DOT 3 or
DOT 4 brake fluid as a temporary
replacement (see page ).
Honda VTM-4 Differential Fluid
(see page ).
SAE 90 or SAE 80W-90 viscosity
hypoid gear oil, API service
classified GL4 or GL5 only (see
page ).
Unleaded gasoline, pump octane
number of 87 or higher.
251 254
252
253
246
253