HYUNDAI I20 2015 Repair Manual


"&t%'s%st&'!"'%!'&&

• There are even circumstancesunder which contact with the steer
ing wheel air bag can cause fatal
injuries, especially if the occupant is
positioned excessively close to the
steering wheel.Noise and smoke
When the air bags inflate, they make
a loud noise and they leave smoke
and powder in the air inside of the
vehicle. This is normal and is a result
of the ignition of the air bag inflator.
After the air bag inflates, you may
feel substantial discomfort in breath
ing due to the contact of your chest
with both the seat belt and the air
bag, as well as from breathing the
smoke and powder. Open your doors
and\for windows as soon as possible
after impact in order to reduce dis
comfort and prevent prolonged expo
sure to the smoke and powder.
Though smoke and powder are non
toxic, it may cause irritation to the
skin (eyes, nose and throat, etc.). If
this is the case, wash and rinse with
cold water immediately and consult
with the doctor if the symptom per
sists.
•To avoid severe personal injury
or death caused by deploying air
bags in a collision, the driver
should sit as far back from the
steering wheel air bag as possi
ble. The front passenger should
always move their seat as far
back as possible and sit back in
their seat.
•Air bag inflates instantly in an
event of a collision, passengers
may be injured by the air bag
expansion force if they are not in
a proper position.
•Air bag inflation may cause
injuries including facial or bodily
abrasions, injuries from broken
glasses or burns.
When the air bags deploy, the air
bag related parts in the steering
wheel and\for instrument panel
and\for in both sides of the roof
rails above the front and rear
doors are very hot. To prevent
injury, do not touch the air bag
storage areas internal compo
nents immediately after an air bag
has inflated.
WARNING
WARNING


"&t%'s%st&'!"'%!'&&
Do not install a child restraint on
the front passenger’s seat.
(if equipped)
Never place a rearfacing child
restraint in the front passenger’s
seat. If the air bag deploys, it would
impact the rearfacing child restraint,
causing serious or fatal injury.
In addition, do not place frontfacing
child restraints in the front passen
ger’s seat either. If the front passen
ger air bag inflates, it would cause
serious or fatal injuries to the child.
Air bag warning and indicator
(if equipped)
Air bag warning light
The purpose of the air bag warning
light in your instrument panel is to
alert you of a potential problem with
your air bag Supplemental Restraint
System (SRS).
OYDESA2042
•NEVER use a rearward facing
child restraint on a seat protect
ed by an ACTIVE AIR BAG in
front of it, DEATH or SERIOUS
INJURY to the CHILD can
occur.
•Never put a child restraint in the
front passenger’s seat. If the
front passenger air bag inflates,
it would cause serious or fatal
injuries.
•When children are seated in the
rear outboard seats of vehicle
equipped with curtain air bags,
be sure to install the child
restraint syst

em as far away
from the door side as possible,
and securely lock the child
restraint system in position.
Inflation of curtain air bags could
cause serious injury or death to
an infant or child.
WARNING
W7147


"&t%'s%st&'!"'%!'&&

When the ignition switch is turned
ON, the warning light should illumi
nate for approximately 6 seconds,
then go off.
Have the system checked if:
• The light does not turn on brieflywhen you turn the ignition ON.
• The light stays on after illuminating for approximately 6 seconds.
• The light comes on while the vehi cle is in motion.
• The light blinks when the ignition switch is in ON position.SRS components and functions
The SRS consists of the following
components:
(1) Driver's front air bag module*
(2) Passenger's front air bag module*
(3) Pretensioner seatbelt system*
(4) Air bag warning light*
(5) SRS control module (SRSCM)*
(6) Front impact sensors*
(7) Side impact air bag modules*
(8) Curtain air bag modules *
(9) Side impact sensors *
* : if equipped The SRSCM continuously monitors
all SRS components while the igni
tion switch is ON to determine if a
crash impact is severe enough to
require air bag deployment or pre
tensioner seat belt deployment.
The SRS air bag warning light on the
instrument panel will illuminate for
about 6 seconds after the ignition
switch is turned to the ON position,
after which the air bag warning light
should go out.
OIB034043\fQ


"&t%'s%st&'!"'%!'&&The air bag modules are located
both in the center of the steering
wheel and in the front passenger's
panel above the glove box. When the
SRSCM detects a sufficiently severe
impact to the front of the vehicle, it
will automatically deploy the front air
bags. Upon deployment, tear seams mold
ed directly into the pad covers will
separate under pressure from the
expansion of the air bags. Further
opening of the covers then allows full
inflation of the air bags.
If any of the following conditions
occurs, this indicates a malfunc
tion of the SRS. We recommend
that the system be inspected by
an authorized HYUNDAI dealer.
•The light does not turn on briefly
when you turn the ignition ON.
•The light stays on after illuminat
ing for approximately 6 seconds.
•The light comes on while the
vehicle is in motion.
•The light blinks when the ignition
switch is in ON position.
WARNING
B240B01L

Driver’s front air bag (1)
B240B02L
Driver’s front air bag (2)

"&t%'s%st&'!"'%!'&&

A fully inflated air bag, in combina
tion with a properly worn seat belt,
slows the driver's or the passenger's
forward motion, reducing the risk of
head and chest injury.
After complete inflation, the air bag
immediately star ts deflating,
enabling the driver to maintain for
ward visibility and the ability to steer
or operate other controls.
B240B03L
Driver’s front air bag (3)
B240B05L
Passenger’s front air bag
•Do not install or place any acces
sories (drink holder, cassette
holder, sticker, etc.) on the front
passenger's panel above the
glove box in a vehicle with a pas
senger's air bag. Such objects
may become dangerous projec
tiles and cause injury if the pas
senger's air bag inflates.
(Continued)
WARNING
(Continued)
•When installing a container of
liquid air freshener inside the
vehicle, do not place it near the
instrument cluster nor on the
instrument panel surface.
It may become a dangerous projectile and cause injury if the pas
senger's air bag inflates.
•If an air bag deploys, there may
be a loud noise followed by a
fine dust released in the vehicle.
These conditions are normal and
are not hazardous the air bags
are packed in this fine powder.
The dust generated during air
bag deployment may cause skin
or eye irritation as well as aggra
vate asthma for some persons.
Always wash all exposed skin
areas thoroughly with cold water
and a mild soap after an acci
dent in which

the air bags were
deployed.
(Continued)
WARNING

8
"&t%'s%st&'!"'%!'&&
Driver's and passenger's front air
bag (if equipped)
Your vehicle is equipped with a
Supplemental Restraint (Air Bag)
System and lap\fshoulder belts at
both the driver and passenger seat
ing positions. The indications of the system's pres
ence are the letters "AIR BAG"
engraved on the air bag pad cover in
the steering wheel and the passen
ger's side front panel pad above the
glove box.
The SRS consists of air bags
installed under the pad covers in the
center of the steering wheel and the
passenger's side front panel above
the glove box.
The purpose of the SRS is to provide
the vehicle's driver and\for the front
passenger with additional protection
than that offered by the seat belt sys
tem alone in case of a frontal impact
of sufficient severity.
(Continued)
•The SRS can function only
when the ignition switch is in the
ON position.
•Before you replace a fuse or dis
connect a battery terminal, turn
the ignition switch to the LOCK
position and remove the ignition
key. Never remove or replace
the air bag related fuse(s) when
the ignition switch is in the ON
position. Failure to heed this
warning will cause the SRS air
bag warning light to illuminate.
OIB034019
OIB034020

Driver’s front air bag
Passenger’s front air bag

9
"&t%'s%st&'!"'%!'&&

(Continued)
•Front and side impact air bags
can injure occupants improperly
positioned in the front seats.
•Move your seat as far back as
practical from the front air bags,
while still maintaining control of
the vehicle.
•You and your passengers
should never sit or lean unnec
essarily close to the air bags.
Improperly positioned drivers
and passengers can be severe
ly injured by inflating air bags.
•Never lean against the door or
center console – always sit in an
upright position.
(Continued)
Always use seat belts and child
restraints – every trip, every time,
everyone! Air bags inflate with
considerable force and in the blink
of an eye. Seat belts help keep
occupants in proper position to
obtain maximum benefit from the
air bag. Even with air bags,
improperly and unbelted occu
pants can be severely injured
when the air bag inflates. Always
follow the precautions about seat
belts, air bags and occupant safe
t

y contained in this manual.
To reduce the chance of serious
or fatal injuries and receive the
maximum safety benefit from your
restraint system:
•Never place a child in any child
or booster seat in the front seat.
•ABC – Always Buckle Children in
the back seat. It is the safest
place for children of any age to
ride. (Continued)
WARNING (Continued)
•No objects (such as crash pad
cover, cellular phone holder, cup
holder, perfume or stickers)
should be placed over or near
the air bag modules on the
steering wheel, instrument
panel, windshield glass, and the
front passenger's panel above
the glove box. Such objects
could cause harm if the vehicle
is in a crash severe enough to
cause the air bags to deploy.
•Do not attach any objects on the
front windshield and inside mir
r
or.
•Do not tamper with or disconnect
SRS wiring or other components
of the SRS system. Doing so
could result in injury, due to acci
dental deployment of the air
bags or by rendering the SRS
inoperative.
•If the SRS air bag warning light
remains illuminated while the
vehicle is being driven, we rec
ommend that the system be
inspected by an authorized
HYUNDAI dealer.
(Continued)


"&t%'s%st&'!"'%!'&&
(Continued)
•Children age 12 and under must
always be properly restrained in
the rear seat. Never allow chil
dren to ride in the front passen
ger seat. If a child over 12 must
be seated in the front seat, he or
she must be properly belted and
the seat should be moved as far
back as possible.
•For maximum safety protection
in all types of crashes, all occu
pants including the driver should
always wear their seat belts
w

hether or not an air bag is also
provided at their seating position
to minimize the risk of severe
injury or death in the event of a
crash. Do not sit or lean unnec
essarily close to the air bag while
the vehicle is in motion.
(Continued)
(Continued)
•Air bags can only be used once
– we recommend that the sys
tem be replaced by an author
ized HYUNDAI dealer.
•The SRS is designed to deploy
the front air bags only when an
impact is sufficiently severe and
when the impact angle is less
than 30° from the forward longi
tudinal axis of the vehicle.
Additionally, the air bags will only
deploy once. Seat belts must be
worn at all times.
•Front air bags are not intended to
d
eploy in sideimpact, rear
impact or rollover crashes. In
addition, front air bags will not
deploy in frontal crashes below
the deployment threshold.
•A child restraint system must
never be placed in the front
seat. The infant or child could be
severely injured or killed by an
air bag deployment in case of an
accident.
(Continued)
(Continued)
•Sitting improperly or out of posi
tion can result in serious or fatal
injury in a crash. All occupants
should sit upright with the seat
back in an upright position, cen
tered on the seat cushion with
their seat belt on, legs comfort
ably extended and their feet on
the floor until the vehicle is
parked and the ignition key is
removed.
•The SRS air bag system must
deploy very rapidly to provide
protection in a crash. If an occu
p

ant is out of position because
of not wearing a seat belt, the air
bag may forcefully contact the
occupant causing serious or
fatal injuries.

 1
"&t%'s%st&'!"'%!'&&

Side impact air bag
(if equipped)
The actual air bags in the vehicle may differ
from the illustration.
Your vehicle is equipped with a side
impact air bag in each front seat. The purpose of the air bag is to pro
vide the vehicle's driver and\for the
front passenger with additional pro
tection than that offered by the seat
belt alone.
The side impact air bags are
designed to deploy only during cer
tain sideimpact collisions, depend
ing on the crash severity, angle,
speed and point of impact. The side
impact air bags are not designed to
deploy in all side impact situations.
OIB034021
OJK032063
Do not allow the passengers to
lean their heads or bodies onto
doors, put their arms on the doors,
stretch their arms out of the win
dow, or place objects between the
doors and passengers when they
are seated on seats equipped with
side and\for curtain air bags.
WARNING
•The side impact air bag is sup
plemental to the driver's and the
passenger's seat belt systems
and is not a substitute for them.
Therefore your seat belts must
be worn at all times while the
vehicle is in motion. The air bags
deploy only in certain side
impact conditions severe
enough to cause significant
injury to the vehicle occupants.
•For best protection from the side
impact air bag system and to
avoid being injured by the
deployin

g side impact air bag,
both front seat occupants should
sit in an upright position with the
seat belt properly fastened. The
driver's hands should be placed
on the steering wheel at the 9:00
and 3:00 positions. The passen
ger's arms and hands should be
placed on their laps.
(Continued)
WARNING

 2
"&t%'s%st&'!"'%!'&&
Curtain air bag (if equipped)
The actual air bags in the vehicle may differ
from the illustration.
Curtain air bags are located along
both sides of the roof rails above the
front and rear doors.
(Continued)
•To prevent unexpected deploy
ment of the side impact air bag
that may result in personal injury,
avoid impact to the side impact
sensor when the ignition switch
is on.
•If the seat or seat cover is dam
aged, we recommend that the
system be serviced by an
authorized HYUNDAI dealer.
Inform the dealer that your vehi
cle is equipped with side impact
air bags.
(Continued)
•Do not use any accessory seat
covers.
•Use of seat covers could reduce
or prevent the effectiveness of
the system.
•Do not install any accessories
on the side or near the side
impact air bag.
•Do not place any objects over
the air bag or between the air
bag and yourself. Also, do not
attach any objects around the
area the air bag inflates such as
the door, side door glass, front
and rear pillar.
•Do not place any objects
between the door and the seat.
They may become dangerous
projectiles if the side air bag
inflates.
•Do not put any objects between
the side air bag label and seat
cushion. It could cause harm if
the vehicle is in a crash severe
enough to cause the air bags to
deploy.
(Continued)
OIB034022
OJK032066