fuel KIA QUORIS 2014 Workshop Manual

787
Maintenance
Canister
Fuel vapors generated inside the fuel tank are absorbed and stored in the
onboard canister. When the engine is
running, the fuel vapors absorbed in
the canister are drawn into the surgetank through the purge control sole-
noid valve.
Purge Control Solenoid Valve(PCSV)
The purge control solenoid valve is
controlled by the Engine Control
Module (ECM); when the engine
coolant temperature is low during
idling, the PCSV closes so that evapo-
rated fuel is not taken into the engine.
After the engine warms-up during ordi-
nary driving, the PCSV opens to intro-
duce evaporated fuel to the engine. 3. Exhaust emission control
system
The Exhaust Emission Control
System is a highly effective system
which controls exhaust emissions
while maintaining good vehicle per-
formance.
Vehicle modifications
This vehicle should not be modified.
Modification of your vehicle could
affect its performance, safety or
durability and may even violate gov-
ernmental safety and emissions reg-
ulations.
In addition, damage or performance
problems resulting from any modifi-
cation may not be covered under
warranty.
If you use unauthorized electronic devices, it may cause the vehicle to
operate abnormally, wire damage,
battery discharge and fire. For your
safety, do not use unauthorized
electronic devices.
Engine exhaust gas precautions
(carbon monoxide)
Carbon monoxide can be present with other exhaust fumes.
Therefore, if you smell exhaust
fumes of any kind inside your vehi-
cle, have it inspected and repaired
immediately. If you ever suspect
exhaust fumes are coming into
your vehicle, drive it only with all
the windows fully open. Have your
vehicle checked and repaired
immediately.
WARNING - Exhaust
Engine exhaust gases contain
carbon monoxide (CO). Though
colorless and odorless, it is
dangerous and could be lethal if
inhaled. Follow the instructions
on this page to avoid CO poi-soning.

Maintenance
88
7
Do not operate the engine in con-
fined or closed areas (such as
garages) any more than what is
necessary to move the vehicle in orout of the area.
When the vehicle is stopped in an open area for more than a short
time with the engine running,
adjust the ventilation system (as
needed) to draw outside air into the
vehicle.
Never sit in a parked or stopped vehicle for any extended time with
the engine running.
When the engine stalls or fails to start, excessive attempts to restart
the engine may cause damage tothe emission control system.Operating precautions for catalyt-
ic converters (if equipped)Your vehicle is equipped with a cat-
alytic converter emission control
device.
Therefore, the following precautions
must be observed:
Make sure to refuel your vehicle according to the "Fuel require- ments" suggested in section 1.
Do not operate the vehicle when there are signs of engine malfunc-
tion, such as misfire or a noticeable
loss of performance.
Do not misuse or abuse the engine. Examples of misuse arecoasting with the ignition off and
descending steep grades in gear
with the ignition off.
Do not operate the engine at high idle speed for extended periods (5
minutes or more).
Do not modify or tamper with any part of the engine or emission con-
trol system. We recommend that
the system be inspected by an
authorized Kia dealer.
WARNING - Fire
A hot exhaust system can ignite flammable items under
your vehicle. Do not park, idle,
or drive the vehicle over or
near flammable objects, such
as grass, vegetation, paper,
leaves, etc.
The exhaust system and cat- alytic system are very hotwhile the engine is running or
immediately after the engine
is turned off. Keep away from
the exhaust system and cat-
alytic, you may get burned.
Also, do not remove the heat
sink around the exhaust sys-
tem, do not seal the bottom of
the vehicle or do not coat the
vehicle for corrosion control.
It may present a fire risk under
certain conditions.

789
Maintenance
Avoid driving with a extremly lowfuel level. Running out of fuel could
cause the engine to misfire, dam-
aging the catalytic converter.
Failure to observe these precautionscould result in damage to the catalyt-
ic converter and to your vehicle.
Additionally, such actions could void
your warranties.

Specifications & Consumer information
6
8
RECOMMENDED LUBRICANTS AND CAPACITIES
To help achieve proper engine and powertrain performance and durability, use only lubricants of the proper quality.
The correct lubricants also help promote engine efficiency that results in improved fuel economy.
These lubricants and fluids are recommended for use in your vehicle.
Lubricant Volume Classification
Engine oil * 1
*2
(drain and refill) Recommends Gasoline Engine
Lambda II 3.8 5.7
l(6.02 US qt.) API Service SM *
3
,
ILSAC GF-4 or above ACEA A5 (or above)
Engine oil consumption Normal driving condition MAX. 1L / 1,500 km -
Severe driving condition MAX. 1L / 1,000 km -
Automatic transaxle fluid Gasoline Engine
Lambda II 3.8 9.6
l(10.14 US qt.) GS ATF SP-IV-RR,
Kia genuine ATF SP-IV-RR
Power steering fluid With EHPS 0.9
l(0.95 US qt.)
Pentosin CHF 202
Coolant Gasoline Engine
Lambda II 3.8 8.4 ~ 8.6
l
(8.88 ~ 9.09 US qt.) Mixture of antifreeze and distilled water
(Ethylene glycol base coolant for aluminum radiator)

87
Specifications & Consumer information
*1
: Refer to the recommended SAE viscosity numbers on the next page.
* 2
: Engine oils labeled Energy Conserving Oil are now available. Along with other additional benefits, they contribute to fuel econ -
omy by reducing the amount of fuel necessary to overcome engine friction. Often, these improvements are difficult to measure
in everyday driving, but in a year’s time, they can offer significant cost and energy savings.
* 3
: If the API service SM engine oil is not available in your country, you are able to use API service SL. Lubricant Volume Classification
Brake fluid 0.7~0.8
l
(0.74~0.85 US qt.) FMVSS116 DOT-3 or DOT-4
Rear differential oil 1.4
l(1.48 US qt.) HYPOID GEAR OIL API GL-5, SAE 75W/90
(SHELL SPIRAX X or equivalent)
Fuel 75
l(19.81 US gal.)
Refer to “Fuel requirements” in section 1

Specifications & Consumer information
8
8
Recommended SAE viscosity
number Engine oil viscosity (thickness) has
an effect on fuel economy and cold
weather operating (engine start and
engine oil flowability). Lower viscosi-
ty engine oils can provide better fuel
economy and cold weather perform-
ance, however, higher viscosity
engine oils are required for satisfac-
tory lubrication in hot weather.Using oils of any viscosity other thanthose recommended could result in
engine damage. When choosing an oil, consider the
range of temperature your vehicle will
be operated in before the next oil
change. Proceed to select the recom-
mended oil viscosity from the chart.
CAUTION
Always be sure to clean the area
around any filler plug, drain
plug, or dipstick before check-
ing or draining any lubricant.
This is especially important in
dusty or sandy areas and when
the vehicle is used on unpaved
roads. Cleaning the plug and
dipstick areas will prevent dirt
and grit from entering the
engine and other mechanisms
that could be damaged.
Temperature Range for SAE Viscosity Numbers
Temperature
Gasoline
Engine Oil * 1°C
(°F)-30 -20 -10 0 10 20 30 40 50 -10 0 20 40 60 80 100 120
*1
: For better fuel economy, it is recommended to use the engine oil of a viscosity grade SAE
5W-20 (API SM / ILSAC GF-4). However, if the engine oil is not available in your country,
select the proper engine oil using the engine oil viscosity chart.
* 2
: In Middle East, do not use the engine oil of viscosity grade SAE 5W-20.
20W-50
10W-30
15W-40
5W-20, 5W-30, 5W-40

I5
Index
Feeling (Haptic switch feeling) (Type B) . . . . . . . . . . . 4-67
Flat tire (with spare tire) . . . . . . . . . . . . . . . . . . . . . . . . 6-15
Changing tires. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-16
Jack and tools . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-15
Removing and storing the spare tire . . . . . . . . . . . . . 6-16
Floor mat anchor(s) . . . . . . . . . . . . . . . . . . . . . . . . . . 4-157
Fluid Brakes/clutch fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-29
Power steering fluid . . . . . . . . . . . . . . . . . . . . . . . . . . 7-30
Washer fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-31
Fog light (front) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-116
Fog light (rear) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-116
Front blind spot monitoring system . . . . . . . . . . . . . . 4-108
Front lamp switch (Type A) . . . . . . . . . . . . . . . . . . . . 4-121
Front lamp switch (Type B) . . . . . . . . . . . . . . . . . . . . 4-123
Front seat adjustment . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-4
Fuel filler lid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-34
Fuel Gauge . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-54
Fuel requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-2
Fuse switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-56
Fuses . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-54
Fuse switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-56
Fuse/relay panel description . . . . . . . . . . . . . . . . . . . . 7-56
Instrument panel fuse . . . . . . . . . . . . . . . . . . . . . . . . . 7-55 Main fuse . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-57
Multi fuse . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-58
Gauges . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-52
Glove box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-147
Glove box lamp . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-125
Gross vehicle weight . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-5
Hazard warning flasher. . . . . . . . . . . . . . . . . . . . . . . . . . 6-2
Hazardous driving conditions . . . . . . . . . . . . . . . . . . . . 5-96
Head up display (HUD) . . . . . . . . . . . . . . . . . . . . . . . . 4-96
Headlight (Headlamp) escort function . . . . . . . . . . . . 4-110
Headlight bulb replacement . . . . . . . . . . . . . . . . . . . . . 7-75
Headlight leveling device . . . . . . . . . . . . . . . . . . . . . . 4-117
Headlight position . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-113
Headlight washer . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-117
Headlight(Headlamp) welcome . . . . . . . . . . . . . . . . . 4-126
Headrest(front) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-8
Headrest(rear) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-16
Heated steering wheel. . . . . . . . . . . . . . . . . . . . . . . . . . 4-42
Heater Automatic climate control system . . . . . . . . . . . . . . 4-128
Height adjustment(front seat) . . . . . . . . . . . . . . . . . . . . 3-22
F
G
H

Index
10
I
Steering wheel. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-41
Electronic Hydraulic Power Steering (EHPS) . . . . . . 4-41
Heated steering wheel . . . . . . . . . . . . . . . . . . . . . . . . 4-42
Horn . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-43
Tilt steering . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-41
Steering wheel audio control . . . . . . . . . . . . . . . . . . . 4-163
Storage compartment . . . . . . . . . . . . . . . . . . . . . . . . . 4-146 Center console storage . . . . . . . . . . . . . . . . . . . . . . . 4-146
Glove box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-147
Map pocket . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-149
Rear seat storage. . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-146
Seatback pocket . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-148
Sunglass holder. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-147
Sunglass holder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-147
Sunroof . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-37
Sunvisor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-151
Tachometer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-52
Tether anchor system . . . . . . . . . . . . . . . . . . . . . . . . . . 3-38
Theft-alarm system . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-12
Tilt steering . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-41
Tire chains. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-102
Tire pressure monitoring system . . . . . . . . . . . . . . . . . . 6-9
Tire rotation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-45
Tire specification and pressure label . . . . . . . . . . . . . . 8-10 Tires and wheels . . . . . . . . . . . . . . . . . . . . . . . . . . 7-43, 8-4
Checking tire inflation pressure . . . . . . . . . . . . . . . . . 7-44
Recommended cold tire inflation pressures . . . . . . . . 7-43
Tire care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-43
Tire maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-48
Tire replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-47
Tire rotation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-45
Tire sidewall labeling . . . . . . . . . . . . . . . . . . . . . . . . . 7-49
Tire traction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-48
Wheel alignment and tire balance . . . . . . . . . . . . . . . 7-46
Wheel replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-48
Towing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-22
Traffic change . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-111
Transaxle Shift Indicator . . . . . . . . . . . . . . . . . . . . . . . 4-55
Transmission
Automatic transmission (shift by cable) . . . . . . . . . . 5-12
Automatic transmission (shift by wire) . . . . . . . . . . . 5-19
Trip computer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-75 Average Fuel Economy . . . . . . . . . . . . . . . . . . . . . . . 4-78
Average Vehicle Speed . . . . . . . . . . . . . . . . . . . . . . . . 4-76
Distance To Empty . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-77
Elapsed Time . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-77
Instant Fuel Economy. . . . . . . . . . . . . . . . . . . . . . . . . 4-79
Trip modes (Type A) . . . . . . . . . . . . . . . . . . . . . . . . . 4-75
Trip modes (Type B) . . . . . . . . . . . . . . . . . . . . . . . . . 4-75
Tripmeter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-76
T