LAND ROVER FRELANDER 2 2006 Repair Manual

Depres s and hold the s elector cable ball jointrel ease but ton, us ing a lever carefullydis connect the cable.Di sconnect and remove the cable.
10.
Releas e t he cabl e s eal ing pl at e.11.
12.
13.

14.
NOTE: Thi s s tep requires the ai d of anot her
t echnician.
Remove t he gear s elector cable as s embly.
14.
Installation 1. NOTE: Thi s s tep requires the ai d of anot her techni ci an.
Inst all t he s el ect or cable.
1.
Secure t he cabl es in t he cli ps.
2.
Inst all t he heat s hiel d.
3.
Secure t he s el ect or cabl es .
4.
Inst all t he s eal ing plat e.
T orque: 7 Nm 5.
Inst all t he gears hi ft l ever.
T orque: 10 Nm 6.
Connect t he s el ect or cabl e ball joi nt s .
7.
Inst all t he ins trument pack bracket.
T orque: 25 Nm 8.
Secure t he drain tube and heater duct.
9.
Inst all t he ins trument panel, l ower trim panel s.
10.
Inst all t he air cleaner as s embly.
Refer t o: Air Cleaner (303-12A Intake Ai r Dis tribut ion and Fil tering -
I6 3.2L Pet rol, Removal and Ins t al lat ion).
11.
Inst all t he fl oor consol e.
Refer t o: Fl oor Cons ole (501-12 Inst rument Panel and Cons ole,
Removal and Ins tall ati on).
12.
Inst all t he dri ves haft .
Refer t o: Dri ves haft - Vehicles W it hout : Dies el Part icul ate Fi lt er (DPF) (205-01 Driveshaft, Removal and Ins tal lati on).
13.

Publi s hed: 07-Nov-2011
Automatic Transmission/Transaxle External Controls - Selector Lever Knob,
Boot and Bezel
Removal and Inst all ati on
Removal
• NOTE: Make s ure t hat the sel ect or l ight s functi on correctl y. If t he ri bbon cable is damaged i t wil l be neces sary to removet he fl oor consol e t o acces s the ri bbon cable connect or on the s elect or l ever as s embly.
Pos it ion t he gears hi ft l ever i n NEUTRAL.1.
Swit ch t he ignit ion off.2.
Releas e t he gear l ever s urround by pul li ngupwards firmly at the rear.
3.

Releas e t he locki ng ring.4.
5.

6.
7. W ARNING: The sel ect or lever knob wi ll berel eased s uddenl y, keep face cl ear during removal .
CAUTION: Make s ure the s elect or l ever butt on i sdepres sed when removing t he s elector l ever knob.Fail ure t o fol low thi s ins truct ion may res ult i n damaget o t he s el ect or lever as s embly.
7.
8.

9. CAUTION: Take care not t o touch t he pri nt eds ide of t he pri nted circui t board (PCB).9.
10. CAUTION: Dis card the component .10.
11. CAUTION: Dis card the component .11.

12. CAUTION: Dis card the component .
Remove and dis card t he s elector lever ass embl y pri nt edcircui t board.
12.
Installation
1.

2.
3. CAUTION: Take care not t o touch t he pri nt eds ide of t he pri nted circui t board (PCB).3.
4. CAUTIONS:
Make s ure the sel ect or l ever but ton i s depres sedwhen i ns t alli ng t he s el ect or lever knob. Fai lure tofol low thi s ins truct ion may res ult i n damage t o thes elector lever ass embl y.
Make s ure the ribbon cable i s rout ed in front oft he s el ect or s haft.
4.

5. NOTE: Make s ure t he cut out on t he l ocking ringfaces t owards t he front of t he vehicle.
Inst all t he locki ng ring.
5.
Secure i nt o t he 3 cli ps.6.
Swit ch t he ignit ion on.7.
Pos it ion t he transmis s ion s elector lever int o PARK.8.

Publi s hed: 11-May-2011
Manual Transmission/Transaxle and Clutch - General Information -
LubricantItemSpecification
Recommended lubri cantCas trol BOT 350 M3 - Land Rover (vehicles buil t from 2011 onwards )
Cas trol MTF97309 - Land Rover (vehi cl es bui lt upt o 2011)
C apacities
ItemCapacity (liters/pints/US quarts)Init ial dry fil l1.9/3.3/2.0
General Specification
ItemSpecification
Trans mi ss ion make/typeM66 EH50Gears6 s peed manual
Synchromesh:
Tri ple1s t and 2ndDual3rd
Single4t h, 5th, 6t h and revers e
Torque - Maximum380 Nm (280 lb-ft )Gear ratios:
Firs t3.750:1
Second1.905:1Third1.182:1
Fourt h0.838:1
Fifth0.652:1Sixt h0.540:1
Revers e3.436:1
Torque Specifications
DescriptionNmlb-ftEart h cable t o t rans mis s ion mount ing bracket2518
Front flywheel clos ing panel6044
Front s ubframeSt age 1140103
St age 2240°
Rear fl ywheel clos ing panel2418Subframe cros s -brace
M16140103
M104533Trans mi ss ion bol ts6548
Trans mi ss ion mount ing bracket
M82418M128059
Trans mi ss ion mount ing to body mount ing175129
Trans mi ss ion fl ui d drai n plug3022Trans mi ss ion fl ui d fill er plug3526