alternator belt MAZDA MX-5 1994 User Guide

CHARGING SYSTEM G TROUBLESHOOTING Check 1 Check if battery p Check battery (Refer to page G-8) J Check 2 I. Turn ignition switch ON Check wire harness 2. Check if voltage exists at each terminal of alternator Check 3 YES 1. Start engine Check alternator (Refer to page G-10) 2. Check if alternator warning light goes off I YES Check if drive belt t Adjust or replace drive belt (Refer to page G-14) 1 YES I Check for dark current (Refer to page G-3) I Check 1 BATTERY r"; Check 3 I ALTERNATOR WARNING LIGHT Check 2 B+: Battery positive voltage I I I B 1 Approx. 12V 1 Approx. 12V I B+ ON ON (Idle) L S 45UOGX-006 OV Approx. 12V Approx. 1V Approx. 12V B+ B+ Gartner Banana

CHARGING SYSTEM G * ttt I E (HEAT SINK) 05UOGX-034 V RIBBED BELT X 0 X Brush Spring 1. Measure the force of the brush spring with a spring pres- sure gauge. 2. Replace the spring if necessary. Standard force: 3.14.3 N (0.32-444 kgf, 0.71-0.96 Ibf) Minimum: 1.6--2.4 N (0.16-0.24 kgf, 0.36-0.52 Ibf) Note Read the spring pressure gauge at a brush tip projec- tion of 2mm (0.079 in). Rectifier 1. Check for continuity of the diodes with an ohmmeter. I Negative (Black) I Positive (Red) I Continuity 1 I E I I Yes I -- 2. Replace the rectifier if necessary. DRIVE BELT Inspection 1. Remove the intake air pipe. 2. Check the drive belts for wear, cracks, or fraying. Replace if necessary. 3. Verify that the drive belts are correctly mounted on the pulleys. 4. Check the drive belt deflection when the engine is cold, or at least 30 minutes after the engine has stopped. Ap- ply moderate pressure (98 N, 10 kgf, 22 Ibf) midway between the specified pulleys. Deflection mm {in) I Drive belt New Used Alternator PIS, PIS + A/C 5.b7.0 {0.224.27) 8.0-9.0 iO.32-0.35) 6.W7.5 (0.24--0.29) 9.0-1 0.0 {0.36-0.391 Gartner Banana

CHARGING SYSTEM I AIC EQUIPPED I WHEN MEASURED 45UOGX-015 - ADJUSTING BOLT I I 5. Check the drive belt tension with a tension gauge. Note Belt tension can be measured between any pulleys. J Tension N {kgf, Ibf) A belt that has been on a ruining engine for less than five minutes. Alternator 'IS
+ A/C 6. Install the intake air pipe. Used Drive belt Adjustment New* I Caution If a new belt is used, adjust the belt deflection at the midpoint of new belt specification. 491-745 (50-76,110-167) 49 1-588 (50-60, 11 0-1 32) d (1) Alternator belt Loosen the alternator bolts @ and @ and adjust the belt deflection by turning the adjusting bolt 0. 491-706 (50-72,110-158) 422490 (43-50,95--110) Tightening torque @: 19-25 N.m (1.9-2.6 kgf.m, 14-1 8 ft4bf) @: 38-51 N.m (3.8-5.3 kgf,m, 28-38 ft-lbf) (2) PIS belt, PIS + AIC belt Loosen the PIS oil pump bolts @ and @ and nut 0, and adjust the belt deflection by turning the adjusting bolt 0. Tightening torque @: 3246 N.m (3.24.7 kgf.m, 24--33 ft4bf) @: 37-53 N.m (3.7-5.5 kgf,m, 27-39 ft-lbf) 0: 19-25 N.m (1.9-2.6 kgf-m, 14-1 8 ft-lbf) (3) AIC belt Loosen the locknut and adjust the belt deflection by turning the adjusting bolt. Tightening torque: 38-51 N.m (3.8-5.3 kgf-m, 28-38 ft-lbf) Gartner Banana

T WARNING LIGHT AND SENDER UNIT WARNING LIGHT AND SENDER UNlT STRUCTURAL VIEW 1. Brake system warning light 2. Seat belt warning light 3. Air bag system warning light 4. Retractor indicator light 5. Alternator warning light 6. MIL (malfunction indicator light) 7. O/D OFF indicator light 8. Antilock brake system warning light 9. Washer level indicator light 10. Rear window defroster indicator light Reference Table Warning indicator light SRS air bag system Retractor indicator light Alternator MIL (malfunction indicator light) O/D OFF Antilock brake system Washer level 45UOTX-062 T-34 Reference page or section T-154 T- 48 section G section F section K section P T- 39 J Gartner Banana

ALPHABETICAL INDEX *a* ENGLISH S** - BELTtA1(L) ,FRT BELt'A1(R),FRT SEAT------ BOLT,JACK SET------------ BELTtB'(R),FRT SEAT------ BOLT,LAMP LID------------ BELTIB1,FRT SEAT--------- BELTlVl------------------ 1-05 2-KB BKACKETJCOUPLER-KNOCK SEN BHACKET,CRASH PAD-------- BRACK~T,E~G.K.PIPE------- BRACKET,FENDER----------- *********Y******* * * * A * * * **#*~******%***** ACTUATOR,A.C.C.---------- 2-Jl3 ACTUATOR, SHIFT LOCK---- -- 1-616 ADAPTERIDRIVE PLATE------ 1-J7 ADJUSTER NO .J-----.----- -- 2-M8 ADJUSTER N0.4------------ 2-M8 AGJUSTER,HYDRAULIC LASH-- 1-N3 ADJUSTER,NO.1------------ 2- J8 ADJUSTER,N0.2------------ ALTERNATOR--------------- 2-J8 1-C7 ANCHOR UNIT(L),BE?T------ 2-39 ANCHOR UNIT(R1,BELT------ 2-D9 ANTENNA,RADI3------------ 2-~141 ANTILOCK BRAKE----------- 1-N15 ARM NO.1, LINK------------ 2-H15 ARM N0.2,LINK------------ 2-115 ARM(L1,LOWER------------- 1-113 ARM(L),LOWER-REAR-------- 1-F12 ARM(L1,UPPER------------- 1 -H13 ARM(R),l.OWER------------- 1-H13 ARM(R),LOWER-REAR-------- 1-F121 ARM(R),UPPER------------- 1-H13 ARM,UPPFR-FRT------------ 1 -HI31 ARM.UPPER-REAR----------- 1-F121 - 1-~6 BEZEL(L1,HEAD LAMP------- 2-M3 BEZEL!"),HEAD LAMP------- 2 -M3 BLADE(d>,WIPER-FRONT----- 2-H15 BLADE WIPER-FRONT--------- 2-H15 BLOCK,CYLINDER----------- BLOCKIFUSE--------------- 1 -H3 2-614 BLOCK,MAIN FUSE---------- BLOWER UNIT-----.-------- 2-114 2-Fll BODY 8 PISTON(L),CALIPER- 1-F11 > -fit v BUSHlNG,RUBBER-LOWER ARM- A-LTAJ BODY & PISTON(R),CALIPER- 1-FS1 1-613 BODY(L),FRONT DOOR------- 2- J9 BODY(R),FRONT DOOR------- 2-J9 BODY,CONTROL VALVE-UP---- 1 -GB BODY,LOW-RADIO ANTENNA--- 2-El4 BODY,THROTTLE------------ 1 -K4 BODY.VALVE LWR----------- 1 -18 BRACKET,MEMBER----------- 2-J7 BRACKET.PARKING CABLE-FLO 2-K5 i-Miii SRACKET~STARTER----------- 1-~6 BRACKETISTOPPER-3kTTERY-- 1-i7 BRACKET,VANE PUMP-------- 1-C13 BRACKET, WASHER TANK ------ 2-C15 2-F15 BRACKET,WIRE CLIP-OXYGEN- 1-F3 BRACKET,WIRING----------- 2-H14 BREATHER---.-------------- 2-114 1-ti11 1 -L7 1-111 BRE/tTHER,AIR-T/MISSION--- 1-D6 BRKT(!i,BUMPER-RR SKIRT-- 2-L5 BdKT(L1,SEAT-F.FLOOR PAN- 2-L5 BRKT(L),TRK.BOARD-FENDER- 2-J5 BRKT(R),BUNPER-RR SKIRT-- 2-L5 BF!KT(R) ,SEAT-F. FLOOR PAN- 2-K5 BRKT,AIR CLNR-WHL APRON-- 2-C5 BRKT,BATT.CLANP-QTR PANEL 2-05 BRKT ,CAP-QUARTER PANEL--- 2- I5 BRKT,DIAGNOSlS UNIT------ 2-H13 BRKT,DIAGNOSIS/POWER UNIT 2-H13 BRKT,MOTOR-ANTENNA------- 2-El4 BRKTtA1,WASHER TANK-FRT-- 2-El5 BRUSH-.------------------- 1 -C7 1 -F7 BRUSH ,YOKE-- - - - - - --- - - - - -. 1-F7 BuLa--------------------- 1 -H7 2-C4 2-C7 2-D4 2-F.4 2-67 2-H4 2 -H7 2 - L 7 BULn 8 SOCKET------------ 2-L7 BUL0,MODE CONTROL-------- 2-El 1 BULB,RESISTOR------------ 2-C7 2-67 BULB'Bt,SWITCH-RR DEFOGER 2-El3 BUMPER, FRONT - --- - . -- -. .. - - BUMPER, REAR- - - - - - - - - - - - - - 2 - E3 2-H3 BUSH---------.----------- 1-1115 1-616 1 - r; 1 tl 1 - .I6 1 -Ll4 - .-.- - L A1 BRACKET------------------ 1 -LIB 1-K7 1-1.15 2-C15 2-G14 2-H141 2-L5 BRACKET NO 1,k.B.S.------ 1 -MI 5' BRACKET ~0.5,A.B.S.------ 1 -M! 5 BRACKET(L),CABLE--------- 1-GI1 BRACKET(L1,ENGINE-------- BRACKET(L),F. BUMPER SIDE 2-F3 BRACKET(L),FRONT-AUDIO--- BRACKETCL) ,HINGE-LAPP LID 2-M3 BRACKETfL),IHST.--------- 2-F5 BRACKET(L1,TUNER--------- BRACKET(L),RADTATOR------ 2-N4 BRACKET(L),STARILIZER---- 2-D5 2-N13 RRACKET(R),CABLE---------- 1 -Gll NRACKET(R),ENGINE-------- i l-cl41 BRACKET(P),FRONT-AUDIO--- BRACKET(R),HIHGE-LAMP LID 2-M3 IRAcKET(R),INsT.--------- 2-M131 2-F5 BRACKET(R1,RADIATOR------ 2-N4 I BRACVET(R),STARILIZER---- 2-C5 I bRACKET(R) ,TUNER--------- 2-N13 BRACKET(RR),AUDIO-------- 2-N131 BRACKET,ACCEL WIRE------- 1-04 BRACKET ,ACTUATOR--- - ----- 2-~131 BRACKET,ACTUATOR-P.C.C.-- 2-313 RRACKET,ACTUATUR-FRONT--- 2-J13 RRACKET,AIR CLEPAER------ 1-14 1 BRACKET,BATTERY CLAMP---- 1-17 BKACKET,BUHPER---- ------- 2-N4 I BRACKET,CAHISTER-- .--- .. - 1-F4 BRACKET,CLAMP------------ 2-1111 BRACKET ,CLIP ------ 2 - L 3 BRACKET,COMPRESSOR------- 1-65 1 BRACKE1,CONTROL UNIT- .--- 1-Cl5 2-C13' BRACKET,COUPLER----- ----- 1-1112' ... - - .- - --.A- €-001 BACK(L1,FRONT SEAT------- 2-C9 I BACK(R),FRONT SEAT----- -- 2-1 A BAG,TOOL----------------- 2-MB / 2-Dl6 BALL JOINT,LOWER--------- BALL, S'TEEL - - - - - - - - - - - - - - - 1-113 1-El4 1 -H7 BAUD--------------------- 1-Dl41 CAP SET,KESERVE TANK----- 1 -I 131 BOLT,AIR CLEANER--------- 1-14 BOLT,AIR C0K.------------ 2-Jll BOLT,ANCHOR END---------- 1.M7 BOLT,BAFFLE PLATE-------- 1 -K7 dOLT,BEARING CAP--------- 1 -H3 BOLT,CAMSHAFT CAP-------- 1-E3 BOLT,CARRIER------------- 1 -K11 ~OLT,CL&MP--------------. 1-14111 1-17 BOLT .COMPRESSOR---------- 2-1111 BOLT,COEPRESSOR-AIR CON.- 2-Kll BOLT,CONNECTOR----------- 1-~151 1-615 BEARlNG,BALL------------- 1-66 ! BFARING.BALL-ALT. FRONT- - 1 -C7 I BEARING~BALL-ALT. REAR--- 1-ci I REARING, BALL-COUNTER SHAF 1 -G6 I BEARING~BALL-FLY WHEEL--- BEARING,RALL-MAIN DRIVE G BEARING,BALL-MAI!i SHAFT-- BEARING,IIEEDLE----------- CA?,TOP LOCK---------.--- CAP,VANE PUMP TANK------- CARRIER,DlFFERENTIAL----- BOLT ]CONTROL VALVE------- 1-C8 I 1 -E8 1-KB I !!7LT,CROSS MEMBER-------- 2-C5 I BOL1,CYLINDER HEAD------- 1-E3 ' BOLT.UECK LOCK----------- 2-112' 1-LIZ; BEAR1NCi.WtiEEL--------- ---- 1-El11 BELT TIMING------ 1-NJ ! .. . CAT . AUNAOS - U3 Gartner Banana

ALPHABETICAL INDEX *%* ENGLISH *** CASE,T/MISSlON------------ CASE'A' , LLOWER UNIT- ----- CASE'A',COOLING UNIT----- CASE'A1 ,HEATER UNIT------ CASEIB' ,BLOWER UNLT------ CASE'B' ,COOLING UNIT----- CASE'B9,HEATER UNIT------ CASE'OUT',ASHTRAY-------- CASING,DIFFERENTIAL------ CASING,HYDRAULIC UNIT---- CASING,STOPPER----------- CATALYST ,THREE WAY------- CEILING,TOP-----.--------- CHANNEL( L) DIVISION-DOOR- CHANNEL(R)lDIVISION-DOOR- CHECKER,DOOR------------- CLAMP---------.-..--------- CLAMP,BATTERY------------ CLAMP,HOSE--------------- 1-L11 DRUM,CLUTCH-------------- 1-N8 DRUM,CONNECTING---------- 1 -H9 DRUM,DIRECT------------.- 1-F9 DRUMIREAR CLUTCH------ -- 1-C9 DUCT(L)---------------..-- 2-DB DUCT(L1 ,SIDE DEMI .-- .---- DUCT(R)----..------------- 2-C8 2-DB DUCT(R1,SIDE DEMT,------- DUCT,AIR- ---- ------------ 2-C8 DUCT,CENTER-------------- 2-Cll 2-C8 DUCTIFRESII AIR----------- 1-14 CLIP,WEATHLRSTRIP-OUTER-- 2-El1 CLIPtA',SPEEDOMETER CABLL 2-F7 CLIPIA',WEATHERSTRIP-OUT- 2-El1 CLIPIB',WIRE-BONNET------ 2-E5 CLGTH,REPAIR-TOP-------..- 2-Dli CLAMt3,HOSE-A 1 .P. /A. CLNR CLAMP,WATER HOSE--------- ELEMENTIAIR CLEANER------ 1-J4 EMBLEM,CAP-WIiE€I.--------- 1-Ll;? END,CONTROL LEVtR-------- 1 -K6 ENDlS/ROD<1ST82ND)------- 1-J6 ENl)rS/ROD(3RDB4TH;------- 1-J6 ENG:SHIFf ROD(O/TOI'&REV.) 1-K6 ENGINE,PARTIAL----------- ENGINE,SHORT------------.- 1-D3 ESCUTCHEON--------------- 1-D3 EVAPORATOR--------------- 2-ti9 2-Mll EYE BOLT K?T,31. GEAR---- 1-M12 2-116 2-L12 2-N5 COVER,5OIE-CC1----------- 2-Ki COVER,HOLE-ANTENNA------- 2-El4 COVER,HOLE-LIFT GATE----- 2-Dl0 COVER,INNER HANDLE----.--- 2-M9 COVER,INTERIOR MIRRORm--- 2-F16 COVER,JOINT-LOWER-------- 1-112 COVER,JOINT-UPPER-------- 1-112 COVER,LEVER-OPENER------- 2-L7 COVER,MAIN FUSE BLOCK---- 2- I1 4 COVER,OIL PUMP----------- COVER,REAR--------------- 1-N4 1-J3 1-K12 COVEK,RE&R-ALTERNATOR---- 1-C7 CQVER,RELAy------------..- 2-H1! COVER,ROD---------------- 1-1.6 COVER,SELECT LEVER------- 1-616 COVERISERVICE HOLE------- Z-F5 COVER,SERVO-------------- COVER,SIDE--------------- 1-N7 2-K7 COVERISPARE TIRE--------- 2-Cl6 COVER,l'HERHO------------- 1-D5 CQVER,THERMOSTAT--------- 1-D5 COVER,TIMING EELT-C. ----- 1-13 GASKET------------------- 1-C5 1-C15 1 -F3 1-H7 1-J14 1-L4 1 - L 14 1-N7 2- ~4 GASKET 8 SEAL KIT-------- 1-M9 GASKET KIT,COMPRESSOR---- 2-K11 GASKET SET ,CYL HEAD----- i -D3 GASKET SETIENGINE-------- 1-DY GASKET(C1 ,TIMING BELTCL) - 1-13 GASKEl'(INN),TIHIHG BELTCL 1-13 BASKET(L)---------------- GASKET,CAP--------------- 1-13 1-114 GASKETICONPRESSOR-------- 2-K11 GASKET,CONVERTER--------- !-Dl4 G0.SKET ,COVER PLATE------- 1-K6 GASKET,CYl.INDER WEAD----- 1-F3 GASKET,DRAIN PLUG-------- 1-li14 GASKETIDRUM SUPPORT- ----- 1 - D8 CASKET.E.G.R. VALVE------ 1-L4 CORD NO.1,HI.TENSION----- 1 -M6 CORD NO.2.HI.TENSION----- 1 -M6 CORD NO.~;HI.TENSION----- 1 -M6 CORD NU.4,HI.TENSION----- 1 -M6 CORD SET,HI.TENSION------ 1 -M6 CORa,EARTH--------------- 2-c14 2-Nl:! CORE,HEATER Ub!IT--------- 2-Dl1 COTTER,VALVE-IN.--------- 1 -N3 COUPLERISOLENOID VALVE--- 1-E0 COVER-------------------- l-Cl6 2-C6 COVER NO.l,ADJ-FRT------- 2-66 COVER NO.2,ADJ-FRT-a+----- 2-60 COVER N0.3.ADJ-FRT------- 2. SC COVER(C),SENSOK---------- 2-H9 COVER(L),BELT LINE------- 2-Kli COVER(L).BRACE BAR------- 2-C6 COVER,UNDER-------------- 2-C6 COVER,VALVE BODY--------- 1-10 COVER,WASHER TANK-------- 2-F1E COVER,WHEEL CORE--------- 1-Hli COVER, WIPER ARM-FRONT--- - 2-H15 COVER'L1,HYDRAULIC UNIT-- 1-Ml5 COWLING,RADIATOR--------- CRANKSHAFT--.. -- ------ ---- 1-E5 1 -K3 CUPISECONDARY------------ 1-H15 CUSHION(L),FRT SEAT------ 2-N8 CUSHIOW(R),FRT SEAT------ 2-K8 CUSHION,LID HINGE-------- 2-H4 CUSHION.RUBBER----------- 2-17 2-Ll CYL.,CLUTCH MASTER------- I -El4 CYL.,CLUTCH RELEASE------ 1-El4 CYL,,TAHDEM MASTER------- 1-F15 1-61 5 1-H15 /~ASKET;EX.MANIFOLD------- 1-E4 GASKET,EXH.PIPE-CONVERTER 1-Dl4 GASKET,EXTENSION--------- 1-C8 GASKET,FILLER PIPE------- 1-H14 GASKET ,FRONT COVER--- .--- I-C6 GASKET,HEAD COVER-------- 1-fi3 GASKET,IN.MANIFOl.D------- 1-D4 GASKET.LICENSE LAMP------ 2-H4 COVER( L) ;DECK LOCK------- 2- Jli COVER(I.),DRAIN-SOFT TOP-- 2-Hli COVER(L),DUST------------ 1-El2 1-Fl? COVER(L),HINGE----------- 2-D9 COVER( L) ,HOLE----------- - 2-Nl! COVER(L),KNUCKLE--------- 2-NB COVER(L).SEAT BACK------- 2-N8 - ... CLIP SET,DRlVE SI!AFT----- 1-DlI CLIP(L1 ,FORM PLATt .------ 2-El2 CLIP(R),FORM PLATE------- CLIP,CABiE--------------- 2-El2 1-Dl6 CLIP ,ENGINE HARNESS------ 2-N141 CLIP,FLEXIBLE Hi3SE------- 1-C16' l-~ld I-Ml5 2-1314 FASTENER SET ,TOP CLOTH--- 2- Dl2 FASTENER,BONNET RELEASE-- 2-KG FASTENER,DOOR TRIM------- 2-rl0 2-#7 GASKET,OIL PUMP---------- 1- J7 GASKET ,OIL STRAINER-- ---- 1-C5 1-rJ4 GASKET.RR.COH0.---------- 2-F4 1-1jsl CQv~~(~);S~~so~-l-------- 2-H9 I I-K~SI COVER( L) ,SENSOR-AIR BAG-- 2-H9 CLIP,HAHNESS------------- 2-E15: COVER(R),REL'I LINE------- FKl4 2-G13! COVER(R),BRACE BAR------- 2-C6 , 2-M14' CUVER(W),DECK LOCK------- 2-1121 2-N14( COVERIR) ,DRAIN-SOFT TOP-- 2-HIZi CLlP,HARNESS-HAND BRAKE-- 2-M7 I COVERCR) ,DUST.----------- 1-E13i CLlP,HEATER COtITKOL--- - -- 2-Elli 1-F131 CLIP, HOSE- SUB T.8 VATFR H 1 -F5 i COVER(R) ,HINGE- ---------- 2-C9 ! CLIP,OIL FJPE-------. ---- 1-L7 I CLIP ,PIPE--- -..- ---------. 2-N8 j I-El6: COVER(R),HOLE------------ Z-N1S1 x-~I(+ COVER(RI,KNUCKLE--------- 2-18 I 1-Fl6, COVER(R) ,SEAT BACK------- 2-K8 I FASTEHERILIFT GATE TRIM-- 2-F14 FASTENERBRAIN RAIL-REAR-- %-Eli FASTEHER; RAIN FASTENER. REAR 1 SIDE TUXN- - .SPRANG CAP- FASTEYER,SEEL------------ 1- J3 1-K4 FASTENER, STOP LAMP-HI . --- II D f FEEDER-ANTENNA- - - - - -- - - - - 2-F14j GASKET~VAC POWER ASSIST- !-El5 I )t s FILTER ,AIR--------..------ 2 - N 12 1-G15 FILTER, FUEL- - ..- - - - - - ----.. ~%*t*~x*rfi**tf%%w 1-F4 1 SASK6T.W.PUMP INLET------ 1-D5 I FII.TEP,FUEL PUMP--------- 1-H14 GASKET,WATER PUMP------ - 1-05 IlAl~,FRONT-WIND.---------- 2-~111 FINISHEPIWEAR------.----- 2-i4 GASKET,WINDOW REGULATOR-- 2-C10 . . . . . . . -. . . . . . -- .. - -- ------- L.- -.- --- -.-- CAT. AUNA04-03 F.-002 Gartner Banana

ALPHABETICAL INDEX *** ENGLISH **E SPRING,SHIFT ROD ENS----- SPRING,SHIFT ROD-REVERSE- SPRING,SYNCHRO. KEY------ SPRlNG.SYNCHR0 .KEY------- I-LB SPRING,3-4 SHIFT--------- 1-K8 STABILIZER,FRONT--------- 1-K13 STABXLIZER,RR------------ STARTER..----------------- 1-El2 1-E7 STATOR ---.-.---- - 1-67 1 -C7 STAY(L1,RR. RUMPER------- 2-H3 STAYCR) ,RR. BUMPER------- 2-H3 STA~,B~NNET-------------- 2-K4 STAY,LOCK-BONNET--------- 2-N4 STAY,MANIFOLD------------ 1-D4 S~EM,PJSTON-------------- 1-N7 STEH,PISTON BAND--------- STOPPER SET-------------- 1-E8 1-E7 1-67 STOPPER,RUMP------------- 1 -C12 1-H13 STOPPERICONSOLE LID------ 2-N7 STOPPER,FILLER LID------- 1-K14 STOPPEK,GLASS------------ 2-L'3 STOPPERILINK-HOOD-------- 2-Dl2 STOPPERISOFT TOP--------- 2-L12 STOPPER,LIPPEP-BACK WINDO 2-El2 STRAINER,INNER----------- 1 -K8 STRAINER,OJL-------- ----- 1-18 1-J8 1-144 STRAP ,ALTERNATOR--------- 1 -M6 STRIKER-- ------ ----- ---- - 2-C10 2- J7 STRIKER(L),LOCK-TOP------ 2- J12 STRIKEK(R),LOCK-TOP------ 2- J1.2 STRIKER,LID---..---------- 2-M4 STRUT,BAND--------------- 1 -n7 STUD--------------------- 1-E3 1 -E4 STUD,EX. MANIFOLD------- -- 1-E3 STUD,HEX-HYD. UHJT------- 1 -MI5 SUN VISOR(L)-----------..- 2-F16 SUN v~so~(~)------------- 2-Fl6 §UPPORT(L),MOUNTING------ 1-F11 1-613 SUPPOHT(R),MOUNTING------ 1-F11 1-G13 SUPPORT,C€NTER----------- 1 -G9 SUPPORT,DRUH------------- 1 -D8 SUPPORT.OIL PIPE--------- 1-L7 SUPPURTER,ACTUATOR------- 1-K9 SUPPORTER,FORK----------- 1-C6 ..- - . - - - - --.- - - CAT. AUNA04 - 03 2-~12 SWITCH(R),CLUSTER-------- 2-El3 SWITCH,BACK UP LAMP------ 2-N12 SWITCH,Cl.UTCH------------ 1-L14 SWITCH ,CLUTCH CUT-------- 1 -HI4 SWITCHICOMBINATION------- SWJTCH,DOOR-------------- 2.-F13 2-113 SWITCHIFAN-HEATER CONTROL 2-Ell SWITCH,IGNITION---------- 2-C3 SWITCH,INHIBITOR--------- 2-C13 SWITCH,LEVEL-WASHER TANK- 2-El5 SWITCH,MAIN-------------- 2-El3 SWITCHIOIL PRESSURE------ 2-N12 SWITCH,OVER DRIVE CONTROL 1-616 SWITCH,PARKING LAMPe----- 1-Dl6 SWITCH,POWER WINDOW------ 2-N7 SWITCH,RMT.MIRROR--------- 2-El3 SWITCH,RR.DEF.----------- 2-El3 SWITCH,STOP-LAMP--------- 1-Dl5 1-M14 1-N14 2-Fi5 TANK,WASHEH-FRONT-------- 2-C15 2-El5 TAPE,EDGE PROTECTOR-CTR-- Z-K12 TAPE,PROTECTOR-STOPPER--- 2-El0 TAPE,SEAL-RAIN RAIL------ 2-El2 TENSIONER,T.BELT--------- 1 -C4 TERMINAL SET------------- 1-D7 THERMOSTAT SET----------- 1 -D5 THERMOSTAT,COOLIHG UNIT-- 2-Mll TIMER & BUZZER----------- TIRE ---..- ----------..----- 2-013 TOOL SET----------------- 1-L13 2-Dl6 TRA~,ASH----------------- 2-D7 TRAY,BATTER~--------.----- 1-17 TRAYIREAR PACKAGE-------- 2-L15 TRIMIL),'A'PILLAR-------- 2-K15 TRIM(L1,DOOR------------- 2-61 0 2-HlO TRIM(L1,FRONT SIDE------- 2-l.15 TRIMCL) ,UUARTER---------- 2-116 TRIM(L),SEAT BACK-------- 2-CY 2-D9 TRIM(L1,SEAT CUSHION----- 2-NO TRIM(L),TRUNK SIDE------- 2-M15 TRIM(R),'A'PILLAR-------- 2-K15 TRIM(R),DOOR------------- 2-F10 2-61 0 TRIM(R),FRONT SIDE------- 2-L15 TRIM(R),OUARTER---------- 2-116 TRIMCR) ,SEAT BACK----.---- 2-M8 TRIM(K),SEAT CUSHION----- 2-KO TKIH,FRONT HEADER------ -- 2-K15 TRIM,TRUNK END--------- -- 2-MIS TUBE,FILLER---------TuBE,FILLER------------..---TuBE,FILLER------------..-TuBE,FILLER------------..-- I -D8 TUBE,HEAD LAMP----------- 2-C4 TUBEIOIL FILTER-UPPER-- -- 1-00 TU3E,SILJCOq------------- 1-J3 TUBE,VACUUH-------------- 1 -F4 1-17 1-L4 TUNER 8 DEC.:,COHB.------- 2-M13 VALVE,CONTROL------------ 1-00 VALVE,CONTROL BACK UP---- VALVE,E,G.R. ..----------a- 1 -K8 1-L4 VALVE,EXHAUST------------ 1-N3 VALVE,EXPAHSION---------- 2-Ml VALVE,FUEL VAPOR.-------- 1-11 VALVE,IDLE AIR CONTPOL--- 1-K4 VALVE,INLET-.------------- VALVE,MANUAL----------..-- 1-N3 1-00 VAL,VE,MODIFIER----------- 1 .H8 VALVE,NON RETURN--------- 1-11 VALVE,OIL JET------------ 1-H3 VALVE,ONE WAY------------ 1-E8 1-K8 VALVEjORIFICE CHECK------ VALVE,P.B.---------------- 1-Ha 1-11 1-Ki VALVE,P.C.V.------------- 1 -F3 VALVE,REDUCING----------- 1 -18 VALVE,REGULATOR---------- 1 -GB VALVE,RELIEF------..------ 2-Kl VALVE,SHIFT 3-4---------- 1-U8 VALVEISOLENOID----------- 1-L4 2-Hl VALVE,SOLENOID N01------- 1-K8 VALVE,ST. GEAR----------- 1-N1 YALVE,THREE WAY---------- 1-L4 2-Nl VALVE,THROTTLE----------- 1-Ha VALVE,THROTTLE BACK-UP--- 1-H8 VALVE,l-2 REDUCING------- 1-18 VALVE,l-2 SHIFT---------- 1-G8 VALVE,2-3 SHIFT---------- 1 -G8 VALVE,3-4 SHIFT-COAST---- 1 -K8 WASHER------------------- 1 -F9 1-H1 1-H1 1-11 1-K1 1-L1 1 -Ml 2- J1 2-L3 WASHER SET--------------- 2-Ll 1-E7 WASHER,DISHED------------ 1 -KB WASHER,FASTEN€k-RAIN PAIL 2-El WASHER,FRONT CLUTCH------ 1-E9 WASHER,HOOKmA'----------- 2-1.1 WASHER,HOOK'A'LIB'------- 2-K1 WASHERIHYD. UNIT--------- 1-Hl WASHER,LID OPENER-------- 1-K14 WASHER,LOCK-PUMP FILTER-- 1-H14 WASHERIPLAIN------------- 1-C8 1-H9 1-J7 1-N7 WASHERIPLAIN CYL. HEAD--- 1-E3 WASHER,PLAIN-FRAME------- 1-C14 WASHERISETTING----------- 2-J9 MASHER,STOP-------------- 1-F12 WASHER,THRUST-----------• 1-F6 1-Gh 1-16 WASHER,THRUST LOCK-OVER T 1-H6 1-16 WASHER,THRUST-REVERSE IDL 1-H6 WASHEW,TOOTHED----------- 2- J15 WASHER WAVE-CHANGE C0NT.C 1-L6 WASHER. A' DECK LOCK------ 2-112 WASHERIB',DECK LOCK------ 2- J12 WEATHERSTRIP N0.1-------- 2-El0 WEATHERSTRIP N0.2-------- ?-El0 WEATHERSTRIP(L1---------- 2-K9 WEATHERSTRIP(L1,DOOR----- 2-K9 2-L9 UEATHERSTRIP(L),OUT/---- 2-El0 WEATHERSTRIP(R)---------- 2-K9 WEATHERSTRIP(R),DOOR------ 2-K9 WEATHERSTRIPCR) ,OUT, ------ 2-El0 WEATHERSTRIP, BONNET-REAii- 2-K4 WEATHERSTRIP,D.TOP-REAR-- 2-K12 WEATHEWSTRIP,LID---me---- 2 -H4 WEDGE,DOOR-FRONT--------- 2-Dl0 WEIGHT,DISC WHEEL-ALUMI-- :-HI3 WEIGHTIDISC WHEEL-STEEL-- 1-L:3 1-M13 WIRING~INJECTOR---------- 2-114 WREHCH,HUB NUT----------- 2-Dl6 WRENCHIWHEEL CAP--------- 2-Dl6 WTHSTP NO.l(L),LINK------ 2-Gl2 WTHST? tiO.l(R) ,LINK------ 2-612 WTHSTP H0.2CL) ,LINK------ 2-01 2 WTHSTP NO.?(R),LINK------ 2-812 WTHSTP NU.3(L),LINK------ 2-612 WTHSTP H0.3(K),LINK------ 2-612 WTHST?(L),CAB SIDE------- 2-H12 WTHFiP(L),ROOF PANEL----- 2-K12 WTH'TP(R),CAB SIDE------- 2-H12 WT'iSTP(R),ROOF PANEL----- 2-K12 G'IHSTP,FROHT HEADER------ 2-612 YOKE------------.-------- 1 -E7 1-67 YOKE SETISUPPORT-ST. GEAR 1-L12 YOKE,DTFFEREHTIAL-------- 1-Jl1 Gartner Banana