brake MAZDA PROTEGE 1992 Owners Manual

TECHNICAL DATA TD
Item
Coolant Engine/Transaxle B6 SOHC BP SOHC BP DOHC
MTX 1 ATX 1 MTX 1 ATX 1 MTX 1 ATX
Capacity
liters tus qt, Imp qt) (5Z.4) (8.E.3) (5&4) (SE.3) (5.?i.4) (S.E.3)
Coolant protection Volume percentage %
Specific gravity at
Water Coolant 20% (68OF)
Antifreeze solution Above -16OC (3OF)
65 35 1.054
Above -26OC (-15OF) 55 45 1.066
I Above -4OOC (-40°F) 45 55
1.078
F. FUEL AND EMISSION CONTROL SYSTEMS Item
idle speed*‘**
Ignition timing** Fuel pump
Maximum output pressure Fuel filter Engine
B6 SOHC BP SOHC BP DOHC
vm 700-800
BTDC 6O--8O 4O---6O 90-l 10
kPa (kg/cm*, psi) 1 441-637 (4.5-6.5, 64-92) ‘Type
Low-pressure side Nylon element (in fuel pump)
High-pressure side Paper element Pressure regulator
Regulating pressure kPa (kg/cm*, psi) 1 265-314 (2.7-3.2, 38-46) Injector
Type
High-ohmic
Type of drive Electromechanical
Resistance n 12-16 Idle speed control (ISC) valve
Type
Rotary
Resistance n ] 11-13 Purge control solenoid valve
Resistance n 1 23-27 Water thermosensor
-20°C( -4OF) 14.6-17.8
Resistance k6 20°C( 68QF) 2.21-2.69
40% (104OF) 1.0-l .3
80°C(1760F) 0.29-0.35 Airflow meter
E2++Vs Fully closed 20-600 q D Fully open 20-l ,000
E~HVC 200-400
Resistance g Ez++THAA -2O%(-4OF) 13,600-18,400
(Intake air 20%( 68OF) 2,210-2,690
thermosensor)
60°C(1400F) 493-667
Eic*Fc Fully closed 00
Fully open 0 Fuel tank
Capacity liters (US gal, Imp gal) I
Hatchback 50 (13.2, 11.0) PROTEGE . . . . 55 (14.5, 12.1) Air cleaner
Element type Oil permeated Fuel
Specification Unleaded regular (RON 91 or higher)
*’ With parking brake applied (Canada)
*’ TEN terminal of diagnosis connector grounded
TD-9

TD TECHNICAL DATA
K. AUTOMATIC TRANSAXLE
TransaxlelEngine F4A-EL
Item
66 SOHC
I BP SOHC
I BP DOHC Torque converter stall torque ratio
2.2 : 1
2.1 : 1
I 1st
2.800
Gear ratio .-.
2nd
1.540
3rd 1 .ooo
nn /“a..
n 7nn
I f-8 ^. .^ _^^ I
3 ,a?? I
Engine stall speed rpm D, S, L and A
Time lag -iOf I 7 Ann-3 7nn
I 7 7.513-7 550 I ran+ L,7”” +,I “V , -,--- . . ..--- , ,,200-2,500
0.5-0.6
, .
I 0.6-0.7
( D, S and L ranges
~-t- -r” I
&L :-I,- “7” \T.” V.“, “i)---,a,
nr IUlt:
I k :^^ -I ^^^.._^ Llllt: p,txis”ra R range 736---c-- . 983 17.5-9.0, 107-l 28)
I l/PI Ilsnlrm2 nci 1\1 u \‘.y,Y”’ , y-8, I n c lrw-4 I *n”nPc Y, ” UI I” L I UI ‘yvu I I FWA-1 no1 ma- ---
At stall ,_ - \-._ -10.2, 125-145)
R range I,41 3-1,638 (14.4-l 6.7, 205-237)
At idle 60-129 (0.61-1.31, 9-19)
At stall D range
I All.3 E?, ,A E,
Outer and inner rotor Standard “.“_ “... \-.-... - -v.vvru,
clearance
mm (in) Maximum
I n n!i (I7 nn7rv
.,.-- - . _ - - -,
Outer rotor clearance Standard n no-n 1.5 m mid- n n=m Y,YY “. * - \~ .--- -v.v.Jil I)
mm (in) Maximum 0.170 (0.0067)
Inner rotor inner Standard 0.04-0.115 (0.0078-0.0453)
diameter
mm (in) Maximum 0.125 (0.0049)
Number of drive/driven plates 414 I
Lt-+c---,,c) , \-t.d , -5.41, 64-77)
n n7-n n4 fn nn78- n finTQ
I I
T I Throttle pressure
kPa (kg/cm2, psi)
Oil pump
3-4 clutch
I Drive plate thickness 1.6 (0.063)
. ..I.. \‘..I , ,“,III,IIIUI,I
3-4 clutch clearance mm (in) 1.4 (0.055)
1.3-l .6 (0.051-0.063)
’ A ‘Ant==’ ’ C ‘“.063), 1.8 (0.071).
I Snan rim-7 ciza
mm fin I I.-t \“.“Qd,, I.” \”
^ ^ ,^ ^_... ,. ,. I,. “1 ,-I-’ I II ,y VI+...
.““’ \‘..I z.u (UUIY), z.z (U.O87j, 2.4 (0.095j.
1 Number of drive/driven plates
I 313
1.6 (0.063)
Drive plate thickness 1 Standard
mm (in) Minimum
Forward clutch clearance mm (in) ,
1.0-I .2 (0.039-n ’ 1.4 io.05si
I
“.347)
(0.071) 1.95 (0.07;), 2.1 (0.083) 2.25 (0.089)
I--’ ^^_ ,^ .,^
Snap ring size mm (in) 1.8 I
2.4
(u.uY~), L.CCJ (u. IUU), L.I
Number of drive/driven plates 2/z
Drive plate thickness Standard 1.6 (0.063)
mm (in) Minimum 1.4 (0.055)
Coasting clutch clearance mm (in) 1.0-l .2 (0.039-0.047)
4 c In Yj3), 1.75 (0.069), 1.9 (0.075) 2.05 (0.081)
.
L.C (u.u87), 2.35 (0.093) 2.5 (0.098), 2.65 (0.104)
1 Number of drive/driven plates I
2/z
1.6 (0.063) Forward clutch
Coasting clutch
IS nao rina size
Drive plate thickness Standard
I
mm (in) Minimu
Reverse clutch clearance mm (in) 1.0-l .3 (0.031
Snap ring size mm (in) 2.0 (0.079), 2.
2.6 (0.102) 2.” ,v., ,v,, J.V \v. g
Number of drive/driven elates 414
m- I i .4 io.055j
3-0.051)
2 (0.087) 2.4 (0.095),
cth3i1n Qn~n*~o
-=----I
Reverse clutch t
1 Drive plate thickness 1 Standard 1 1.6 (0.063)
mm (in) 1 Minimum 1.4 (0.055)
Low and reverse brake clearance mm (in) 2.1-2.4 (0.08: 3-0.094)
I
2.0
(0.079), 2.2 (0.087) 2.4 (0.095)
I I 2.6 (0.102), 2.8 (0.110)
3.0 (0.118) Snap ring size mm (in) 1 Low and
reverse brake
TO-I 4

TD TECHNICAL DATA
Spring name
2-3 accumulator
small spring Outer diameter Free length Wire diameter
mm (in) mm (in) No. of coil
mm (in) BP DOHC 11.6 (0.457)
59.7 (2.350)
16.9 1.8 (0.071)
56 SOHC
BP SOHC 10.0 (0.394) 71.8
(2.827) 24.2 1.4 (0.055)
2-3 accumulator BP DOHC 15.0
(0.591) 71.8 (2.827) 9.8
1.2 (0.047)
large spring B6 SOHC
BP SOHC 15.0 (0.591)
71.8 (2.827)
15.8 2.0 (0.079)
l-2 accumulator small spring
11.2 (0.441)
84.7 (3.335)
25.5 1.5 (0.059)
BP DOHC
- - -
-
l-2 accumulator
Accumulator large spring B6 SOHC
BP SOHC 16.0 (0.630)
84.7 (3.335) 19.5
1.9 (0.075)
B6 SOHC 10.8 (0.425) 101.2 (3.984)
28.2
1.2 (0.047)
N-D Accumulator
small spring BP SOHC
BP DOHC
10.8 (0.425) 101.2 (3.984)
28.2
1.2 (0.047)
B6 SOHC
15.0 (0.591) 94.2 (3.709)
16.5
1.6 (0.063)
N-D Accumulator
large spring BP SOHC
BP DOHC 15.0 (0.591) 94.2
(3.709) 16.5
1.6 (0.063)
N-R Accumulator small spring
9.8 (0.386)
93.2 (3.669) 31.5
1.3 (0.051)
N-R Accumulator large spring
14.0 (0.551) 106.5 (4.193)
23.0 1.7 (0.067)
3-4 clutch
Return spring
74.4 (2.929)
40.5 (1.594) 1 .o
5.0 (0.197)
Coasting clutch
Return spring
7.3 (0.287) 20.45 (0.805)
10.0 1 .o (0.039)
Low and reverse
brake Return
spring 5.55 (0.219)
14.3 (0.563)
12.0 0.75 (0.030)
Servo
Return spring
27.7 (1.091) 43.25 (1.703)
4.5
3.2 (0.126)
Vehicle Speed at Shift point Table -
lode
- -
angc
-
D Throttle condition
(Throttle sensor
voltage)
Fully opened
(4.0 volt)
Half throttle
(1.6-2.2 volt)
/ &%L) j 3 1 850-2,500 2,100-2,650 2,300-3,000 74-100 (46-62) 91-116 (56-72) 93-120 (58-74
Lock-up
[1,850-2,20011,950-2.550(2,300-2,700/74-88 (46--55)185-110 (53-68)(93-108 (58-67)1
Kir.kdnwn OD -+ DI
1,05U
%lly opened
i4.0 volt)
Half throttle
s2 -+ s3 5,000-5,45c
s3 -+ s2 2,900
S2 -+ ST 2,300-2,6OC
SI * 52
2.500-3.35C
(1.6-2.2 volt)
s2 -+ s3 v, v...
Fully opened Ll + L2 5,150-5,75(
w-dt I7w-ln
nlf throttle 6-7 7 vnltl I Ll + L2 (2.500-3.350(2,850-3,8OOj3.300-4.300125-34 (16-21$1-41 (19-25)j33-43 (20-27)1
TD-16

TD TECHNICAL DATA
P. BRAKING SYSTEM
Item
3rake type
Brake pedal
Height mm (in)
Free play mm (in)
Reserve travel mm (in)
Clearance when pedal depressed at 589 N (60 kg, 132 lb)
Master cylinder
Type
Master cylinder
Bore diameter mm (in) 1
Front disc brake
We
Thickness of pad
mm (in) Standard
Minimum
Thickness of disc plate
mm (in) Standard
Minimum
Runout of disc plate mm (in)
Cylinder bore
mm (in) Specifications
Front . . . . . disc, Rear . . . . . disc or drum
193-196 (7.60-7.72)
4-7 (0.16-0.28)
70 (2.76) min
Tandem
22.22 (0.875)
Ventilated
10 (0.39)
2 (0.08)
22 (0.87)
20 (0.79)
0.1 (0.004)
53.97 (2.12)
Rear brake (drum)
We
Thickness of lining
I Drum inside diameter
1
tiheel cylinder bore
I Parking brake
Type
Parking brake lever notches Leading & trailing
mm (in) Standard 4.5 (0.18)
Minimum 1 (0.04)
mm (in) Standard 200 (7.90)
Maximum 201 (7.91)
mm (in) 17.46 (0.687)
Mechanical two-rear-wheel control
When lever is pulled at 98N (10 kg, 22 lb)
Power brake unit
Diameter mm (in) 5-7
(a): 214 (8.43) (b): 239 (9.41)
More than 1,177 (12, 171)/196 (20, 44)
Fluid pressure per treading force
kPa (kg/cm’, psi)/N (kg, lb) (4
@I at 0 mmHg (0 inHg)
More than 7,063 (72, 1,024)/l 96 (20, 44)
at 500 mmHg (19.7 inHg)
More than 1,517 (15, 213)/196 (20, 44)
at 0 mmHg (0 inHg)
More than 8,593 (88, 1,261)/196 (20, 44)
at 500 mmHg (19.7 inHg)
Rear wheel hydraulic control rystem
Type Dual proportioning valve
_-_.
. .- ,. . . . !
P.IF
Switching point (Master cylinder pressure)
KPa (kg/cm-, PSI) ) z,4~j3 (25, 356)
(a): BP engine with SMTX, B6 engine
(b): BP engine with 4EATX ..-
-’
TD-18

TD TECHNICAL DATA
Coil Spring Specifications (See page R-5 for coil spring applications)
*’ Main identification mark color: Indicated on second coil from bottom. l * Auxiliary identification mark color: Indicated on third coil from bottom.
T. BODY ELECTRICAL SYSTEM
Item
Headlight
Frnnt tl wn sinnnl/Pnrkinn linht
Specification (W) (Bulb Trade number)
65145 (9004)
2718 II I 571
I
“‘VW, I u”“y’ 1. I” \’ ‘V’,
uinh mount stoplight 18.4 (1141)
turn single light 27 (1156)
Y-,-~p light 27 (1156)
Rear side marker light (Sedan) 3.8 (194)
License plate light 7.5 (89) [PROTEGE], 5 (168) [3HBl
Interior 10
Interior and spot lamp
spot 6
Interior lamp 10
‘i--” Spot lamp (in overhead console)
8 (67)
Cargo room lamp 5 (168)
Trunk room lamp 5 (168)
I I
ntminr Iamnc
I
Curtesy lamp
High beam
Turn light
Brake
Hold
) Charge 5 (168)
3.4
3.4
3
3 (158)
i
Oil pressure
Washer
Seat belt
Malfunction
Fuel
illumination 3 (158)
3 (158)
3 (158)
3 (158)
3 (158)
3 (158)
3.4 Indicator and
warning lamps
Check 3 (158)
Dif. lock
I 3 (158) .-
,
-.-’
I
I
TD-20

SPECIAL TOOLS ST
STEERING SYSTEM (CONT’D)
PRIORITY ILLUSTRATION I-OOL NUMBER
i DESCRIPTION PRIORITY ILLUSTRATION 1OOL NUMBER
h DESCRIPTION
-9 8032 307
19 8032 317
A
Yrench, outer
)0X ?emover, bearing
1 oil seal
19 GO32 317
-lose 19 B032 308
qemover body,
,od seal
49 F032 303 $9 8032 305
iolder, power
steering pump Handle A
A 49 HO32 301
Wrench A 49 B032 321
Adapter . .
49 F032 308
Installer. dust seal A - -
-
BRAKING SYSTEM
TOOL NUMBER
PRIORITY ILLUSTRATION TOOL NUMBER
& DESCRIPTION PRIORITY ILLUSTRATION
& DESCRIPTION
49 F043 001
Adjust gauge A 49 0221 600C
Expand tool, disc B
brake
ST-9

PARTS INDEX
‘I
A
ACCELERATOR CABLE ............................. F-l 14
ACCELERATOR PEDAL ............................. F-l 14
AIR CONDITIONER ...................................... u-30
A/C RELAY.. ........................................... U-56
A/C SWITCH ...........................................
U-57
COMPRESSOR.. ..................................... U-41
CONDENSER.. ....................................... U-53
CONDENSER FAN ................................. u-57
CONDENSER FAN RELAY .................... U-56
COOLING UNIT ..................................... U-38
MAGNETIC CLUTCH ............................. u-51
RECEIVER/DRIER .................................. U-52
REFRIGERANT PRESSURE SWITCH.. .. U-55
AIR FLOW METER ..................................... F-l 68
AIR VALVE.. ................................................ F-l 16
ALTERNATOR .............................................. G-10
ANTENNA FEEDER
AUDIO
....... .......................................................................................... T-i;
AUTOMATIC TRANSAXLE ............................. K-l
2-4 BRAKE BAND ................................ K-l 97
3-4 CLUTCH.. ....................................... K-l 87
ACCUMULATORS ................................ K-l 67
ATF ....................................................... K-135
ATF THERMOSENSOR ........................ K-142
BEARING COVER ASSEMBLY ............ K-208
CLUTCH ASSEMBLY ........................... K-l 72
CONTROL VALVE BODY.. .....
K-21 0,224,234
DIFFERENTIAL ..................................... K-236
DRIVE PLATE.. ..................................... K-267
EC-AT CONTROL UNIT ....................... K-144
HOLD SWITCH ..................................... K-140
HYDRAULIC CIRCUIT .......................... K-278
IDLER GEAR ........................................ K-203
INHIBITOR SWITCH ............................. K-l 41
LOW AND REVERSE BRAKE .............. K-192
MAIN CONTROL VALVE BODY .......... K-220
OIL COOLER.. ...................................... K-265
OIL PUMP ............................................
K-169
OIL SEAL ..............................................
K-209
ONE-WAY CLUTCH 2
CARRIER HUB ASSEMBLY ............... K-185
OUTPUT GEAR .................................... K-206
P RANGE SWITCH.. ............................. K-271
PREMAIN CONTROL VALVE BODY .a. K-218
PULSE GENERATOR ........................... K-142
SELECTOR LEVER ............................... K-272
SHIFT MECHANISM ............................. K-269
SHIFT-LOCK ACTUATOR
..................... K-271
SMALL SUN GEAR AND
ONE-WAY CLUTCH 1 ........................ K-l 82
SOLENOID VALVE.. ............................. K-l 43
SPEEDSENSOR .................................. K-l 43
THROTTLE CABLE .............................. K-l 37
TORQlJE CONVERTER.. ...................... K-l 66
TRANSAXLE UNIT. ......... K-149,153,246,261 UPPER CONTROL VALVE BODY.. ..... K-215
BACK-UP LIGHT SWITCH..
..........................
BATTERY T;4;
- .......................................................
BLOWER UNIT ............................................
U-23
BRAKE FLUID.. .............................................. P-8
BRAKE MASTER CYLINDER. ...................... P-10
BRAKE PEDAL ...............................................
P-8
C
CALIPER .................................................. P-21,26
CARGO COMPARTMENT LAMP ................. T-54
CENTRAL PROCESSING UNIT..
.................. T-55
CHARCOAL CANISTER ............................. F-l 41
CHECK VALVE (TWO-WAY) .......................
CHECK-AND-CUT VALVE - .......................... ;-;b$
CIRCUIT OPENING RELAY.. ...................... F-129
CLUTCH COVER ......................................... H-l 7
CLUTCH DISC ............................................. H-l 7
CLUTCH FLUID ............................................. H-4
CLUTCH MASTER CYLINDER.. .................... H-7
CLUTCH PEDAL ............................................ H-5
CLUTCH RELEASE CYLINDER..
................. H-12
CLUTCH SWITCH (MTX) ............................ F-l 72
COMBINATION SWITCH .............................. T-23
COWL GRILLE ............................................. S-53
CRUISE CONTROL UNIT.. ...................... T-78,85
D
DASHBOARD ............................................... S-94
DASHPOT ................................................... F-l 42
DISTRIBUTOR .............................................. G-20
DOOR LOCK TIMER UNIT ........................... T-17
DOOR MIRROR ............................................ S-54
REMOTE CONTROL MIRROR ............... S-56
REMOTE CONTROL MIRROR SWITCH. S-55
DOOR SPEAKER .......................................... T-98
DRIVE SHAFT.. ....................................... M-l 7,21
DRL RELAY.. ................................................ T-18
DRL RESISTOR ............................................ T-46
DUAL PROPORTIONING VALVE..
............... P-l 6
DYNAMIC CHAMBER ................................ F-l 12
E
ELECTRIC COOLING FAN SYSTEM ........... E-13
ENGINE (B6 & BP SOHC) ........................... Bl-2
CAMSHAFT ..........................................
Bl-58
CAMSHAFT PULLEY ...........................
Bl-65
CONNECTING ROD ............................. 81-63
PI-I

PARTS INDEX
I
CRANKSHAFT.. ....................................
I31 -64
CYLINDER BLOCK .............................. 61-60
CYLINDER HEAD..
............................... 81-54
CYLINDER HEAD GASKET .................
Bl-16
DRIVE BELT(S). ...................................... 81-5
FRONT OIL SEAL ................................ 81-23
HLA .............................................. Bl-7,20,60
OIL JET ................................................ 81-61
PISTON.. ...............................................
Bl-62
PISTON PIN..
........................................ 81-62
PISTON RING
....................................... 81-62
REAR
OIL SEAL..
................................. 81-25
TENSIONER, IDLER ............................. Bl-65
TENSIONER
SPRING ...........................
Bl-65
TIMING BELT ..................................
Bl-12,65
TIMING BELT PULLEY ........................
Bl-65
VALVE MECHANISM ........................... Bl-55
ENGINE
(BP DOHC) .................................... B2-2
CAMSHAFT ..........................................
82-58
CAMSHAFT PULLEY ...........................
B2-65
CONNECTING ROD..
........................... 82-63
CRANKSHAFT ......................................
B2-64
CYLINDER BLOCK ..............................
82-60
CYLINDER
HEAD.. ............................... B2-54
CYLINDER HEAD GASKET .................
82-16
DRIVE
BELTS.. .......................................
B2-5
FRONT
OIL SEAL ................................
82-26
H LA ..............................................
OIL JET .......................... B2-7iyL;;
......................
PISTON .................................................
B2-62
PISTON PIN ..........................................
82-62
PISTON RING..
..................................... 82-62
REAR OIL SEAL ................................... B2-28
TENSIONER, IDLER ............................. B2-65
TENSIONER SPRING ........................... B2-65
TIMING
BELT.. ................................
B2-12,65
TIMING BELT PULLEY ........................ 82-65
VALVE MECHANISM ........................... 82-55
ENGINE CONTROL UNIT (ECU) ............... F-149
ENGINE COOLANT
........................................ E-5
ENGINE OIL.. .................................................
D-7
ENGINE OIL FILTER.. .................................... D-8
’ EXHAUST SYSTEM. ...................................
F-136
EXTRACTOR CHAMBER .............................. S-53
F
FAN MOTOR (COOLING FAN). ................... E-14
FAN RELAY (COOLING FAN). ..................... E-18
FLASHER UNIT ............................................
T-17
FLOORMAT ..................................................
S-99
FLYWHEEL ..................................................
H-18
FRONT AXLE .................................................
M-4
FRONT BRAKE ............................................
P-l 8
FRONT BUMPER ......................................... S-39
FRONT DOOR ................................................
S-8
FRONT DOOR LOCK AND OPENER ..........
S-13
PI-2
FRONT FENDER PANEL ............................... S-7
FRONT LOWER ARM .................................. R-16
FRONT SHOCK ABSORBER AND SPRING R-11
FRONT SIDE WINDOW REGULATOR AND
GLASS ........................................................ S-10
FRONT STABILIZER..
................................... R-l 8
FRONT SUSPENSION .................................. R-l 0
FUEL FILLER LID AND OPENER..
.............. S-37
FUEL FILTER .............................................. F-l 24
FUEL GAUGE SENDER UNIT ..................... T-73
FUEL PUMP ............................................... F-125
FUEL TANK
................................................ F-123
FUSE AND JOINT BOX.. .............................. T-12
H
HEADLIGHT AND
FRONT COMBINATION LIGHT..
................ T-41
HEADLIGHT RELAY ..................................... T-l 8
HEADLINER ................................................. S-89
HEATER CONTROL UNIT.. ......................... U-26
HEATER UNIT
.............................................. U-21
HIGH-MOUNT STOPLIGHT
.......................... T-45
HIGH-TENSION LEAD ................................. G-l 7
HOOD ............................................................. S-5
HORN T-88
...........................................................
HORN RELAY
.......................................... T-18,88
.__. ’
I I
IGNITER .......................................................
G-23
IGNITION COIL.. .......................................... G-19
INJECTOR .................................................. F-l 31
INSTRUMENT CLUSTER
AND SPEEDOMETER CABLE
.................... T-69
INTAKE MANIFOLD ................................... F-113
INTERIOR LAMP ..................................... T-52,53
ISC VALVE.. ................................................ F-l 16
J
JOINT SHAFT (FRONT AXLE) .................... M-18
L
LATERAL LINK AND TRAILING LINK.. ....... R-26
LICENSE PLATE LIGHT.. ............................. T-47
i
M
I
---
MAIN RELAY (FUEL INJ. RELAY). ............ F-172
MANUAL STEERING ..................................... N-4
MANUAL TRANSAXLE (F5M-R). .................. Jl-2

PARTS
DIFFERENTIAL ..................................... Jl-52
SHIFT MECHANISM ............................. Jl-56
TRANSAXLE ............................................ Jl-8
TRANSAXLE OIL .................................... Jl-7
MANUAL TRANSAXLE (G5M-R) .................. J2-2
DIFFERENTIAL ..................................... J2-43
SHIFT MECHANISM ............................. J2-46
TRANSAXLE.. .......................................... J2-8
TRANSAXLE OIL .................................... J2-7
MOLDING, PROTECTOR, GARNISH ...........
S-42
BELTLINE MOLDING ............................. S-48
REAR WINDOW MOLDING.. ............. S-43,44
ROOF MOLDING.. .................................. S-46
SIDE PROTECTOR ................................. S-49
UPPER WINDSHIELD MOLDING,
A-PILLAR GARNISH ............................ S-42
NEUTRAL SWITCH (MTX) . . . . . . . . . . . . . . . . . . . . . . . . . . F-l 73
0
1
\_ OIL COOLER (ENGINE). ................................ D-8
OIL PAN (ENGINE) ........................................ D-9
OIL PUMP (ENGINE) ................................... D-l 3
..................................... F-l 71
OXYGEN SENSOR
P
PARKING BRAKE ......................................... P-31
PARKING BRAKE CABLE ............................ P-32
PARKING BRAKE LEVER ............................ P-33
PARKING BRAKE SHOE ............................. P-31
PASSIVE SHOULDER BELT SYSTEM.. ..... S-103
DOOR CATCH SWITCH ....................... S-l 07
LIMIT SWITCH ...................................... S-l 07
PASSIVE SHOULDER BELT MOTOR.. S-106
SPEED SENSOR ................................... S-l 07
WARNING SWITCH .............................. S-l 07
PCV VALVE ................................................
POWER BRAKE UNIT ‘;--=I;;
..................................
POWER DOOR LOCK SYSTEM ................... S-23
DOOR LOCK CONTROL.. ...................... S-26
DOOR LOCK SWITCH.. .......................... S-26
DOOR LOCK TIMER AND RELAY.. ....... S-26
POWER STEERING.. .................................... N-23
POWER STEERING FLUID .......................... N-27
POWER STEERING OIL PUMP.. ................. N-37
POWER STEERING PRESSURE SWITCH . . F-l 73
POWER WINDOW SYSTEM.. .......................
S-27
MAIN POWER WINDOW SWITCH.. .......
S-31
POWER WINDOW MOTOR.. ..................
S-32
POWER WINDOW SUB-SWITCH ........... S-32
PRESSURE REGULATOR (FUEL). ............. F-l 29 . . . . . . . . , . . . . . , . RADIATOR CAP .............................................
E-7
RADIATOR GRILLE,
I
LOWER GRILLE MOLDING ....................... S-51 fl
RADIATOR THERMOSWITCH ...................... E-17 t
REAR AXLE ................................................. M-10
REAR BRAKE (DISC) ................................... P-23
REAR BRAKE (DRUM) ................................. P-28
REAR BUMPER ............................................ s-40
REAR COMBINATION LIGHT.. ....
REAR CROSSMEMBER ............................... R-29
REAR DOOR ................................................ S-l 5
REAR DOOR LOCK AND OPENER.. .
REAR FINISHER ........................................... s-52
REAR HATCH ............................................... s-20
REAR HATCH LOCK AND OPENER.. ......... S-22
REAR SHOCK ABSORBER AND SPRING.. R-21
REAR SIDE MARKER LIGHT ....................... T-48
REAR SIDE WINDOW REGULATOR AND . . . . . . . . .
AI .,.n
INDEX
Q
QUARTER WINDOW GLASS . . . . . . . . . . . . ..a........ S-62
R
RADIATOR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
kiLA33 ........................................................ a-- I I
REAR SPEAKER ........................................... T-99
REAR SPOILER ............................................ s-41
REAR STABILIZER.. ..................................... R-27
REAR SUSPENSION .................................... R-20
REAR WINDOW GLASS ............................... S-63
REAR WINDOW DEFROSTER.. .................... T-74
REAR WINDOW DEFROSTER SWITCH ....... T-77
REAR WIPER AND WASHER ...................... S-74
REAR WASHER MOTOF
REAR WIPER AND WASHER SWITCH . . S-77
REAR WIPER MOTOR ............................ s-77
RELEASE BEARING (CLUTCH). . . . . . . . . . ..s..... H-17 I . . . . . . . . ...*. .*......*..
SEAT BELT.. ........................................ S-100,102
BUCKLE SWITCH.. ............................... S-l 02
SEAT ........................................................... s-110
SEPARATOR (FUEL) .................................. F-l 40
SHUTTER VALVE ACTUATOR (VICS) ........ F-l 18
SLIDING SUNROOF ..................................... S-80
MOTOR ASSEMBLY ............................... S-81
SUNROOF RELAY.. ................................ S-82
SUNROOF SWITCH.. .............................. S-82
SOLENOID VALVE
(PRESSURE REGULATOR CONTROL) .... F-135
SOLENOID VALVE (PURGE CONTROL). .. F-140
SOLENOID VALVE (VICS) .......................... F-l 18
SPARK PLUGS ............................................ G-18
-II__

Z-Gl-4 Reading Wiring Diagrams
System circuit diagram/connector diagram
l These show the circuits for each system, from the power supply to the ground. The power supply side
is on the upper part of the page, the ground side on the lower part. The diagrams describe circuits with
the ignition switch off.
Below is an explanation of the various points in the diagram.
) Indicates operating conditions for switches.
The prefix letter indicates the system in which
:he connector is used.
JB: Joint box connections
X : Common connectors
A : Charging system/starting system
connectors
B : Engine control system connectors
C : Gauge control system connectors
D : Wiper system connectors
E : Lighting system connectors
F : Signal system connectors
G : Air-conditioning system connectors
H : Transmission control system
connectors
I : Interior lamp system connectors
J : Audio/radio connectors
K : Power window/power door lock system
connectors
L : Remote control mirror system
connectors
M : Sliding sunroof system connectors
N : Power steering/4-wheel steering
system connectors
0 : Anti-lock brake system connectors
P : Power seat/seat heater system
connectors
Cl : Auto cruise control system connectors
R : Auto adjusting suspension system
connectors
S : Passive shoulder belt control/air bag
system connectors
T : Others
Y : Ground connector
- .
1

\\‘
IGNITION SYSTEM l ENGINE CONTROL 9 harness ground is represented differently
:han a unit ground.
Types of grounds Symbol
Harness
I
-
-
-
-
‘“G:
si-
P
7:’
.I
I
I
.i
-
-
-
f
9
Tiii
zs
LL
<Gii
Y
a
EE
-