cooling MERCEDES-BENZ C CLASS COUPE 2003 User Guide

257
Practical hints
What to do if …
Display
Possible cause
Suggested solution
B
COOLANT
CHECK LEVEL
The coolant level is too low.

Add coolant (
page 229).

If you have to add coolant frequently,
have the cooling system checked by
an authorized Mercedes-Benz Cen-
ter.
Warning!
G
Do not spill antifreeze on hot engine parts.
Antifreeze contains ethylene glycol which
may burn if it comes into contact with hot
engine parts. You can be seriously burned.
!Do not ignore the low engine coolant
level warning. Extended driving with
the message and symbol displayed
may cause serious engine damage not
covered by the Mercedes-Benz Limited
Warranty.
Do not drive without sufficient amount
of coolant in the cooling system. The
engine will overheat, causing major en-
gine damage.

259
Practical hints
What to do if …
Display
Possible cause
Suggested solution
Ï
COOLANT
STOP, ENGINE OFF!
The poly-V-belt could be broken.

Stop immediately and check the
poly-V-belt.
If it is broken:

Do not continue to drive. Otherwise
the engine will overheat due to an in-
operative water pump which may re-
sult in damage to the engine. Notify
an authorized Mercedes-Benz
Center.
If it is intact:

Do not continue to drive the vehicle
with this message displayed. Doing
so could result in serious engine
damage that is not covered by the
Mercedes-Benz Limited Warranty.
COOLANT
VISIT WORKSHOP!
The cooling fan for the coolant is malfunc-
tioning.

Observe the coolant temperature
gauge.

Have the fan replaced as soon as
possible.

317
Technical data
Fuels, coolants, lubricants etc.
Fuels, coolants, lubricants etc.
Capacities Vehicle components and their respective
lubricants must match. Therefore use only
brands tested and recommended by us. Please refer to the Factory Approved Ser-
vice Products pamphlet, or inquire at your
Mercedes-Benz Center.
Model
Capacity
Fuels, coolants, lubricants etc.
Engine with oil filter
C 230 Kompressor
C320
5.8 US qt (5.5 l)
7.9 US qt (7.5 l)
Recommended engine oils
Automatic transmission
8.5 US qt (8.0 l)
MB Automatic Transmission Oil
1
1MB part no. 001 989 21 03 10Manual transmission
1.3 US qt (1.2 l)
MB Manual Transmission Oil
2
2MB part no. 001 989 26 03 10Rear axle
1.2 US qt (1.1 l)
Hypoid gear oil SAE 85 W 90
Power steering
approx. 1.1 US qt (1.0 l)
MB Power Steering Fluid (Pentosin CHF 11S)
Front wheel hubs
approx. 2.1 oz (60 g) each
High temperature roller bearing grease
Brake system
0.5 US qt (0.5 l)
MB Brake Fluid (DOT 4+)
Cooling system
C 230 Kompressor
C320
approx. 8.5 US qt (8.0 l)
approx. 10.5 US qt (10.0 l)
MB 325.0 Anticorrosion/Antifreeze Agent

321
Technical data
Fuels, coolants, lubricants etc.
Gasoline additives
A major concern among engine manufac-
turers is carbon build-up caused by gaso-
line. Mercedes-Benz recommends only the
use of quality gasoline containing additives
that prevent the build up of carbon depos-
its.
After an extended period of using fuels
without such additives, carbon deposits
can build up especially on the intake valves
and in the combustion area, leading to en-
gine performance problems such as:

Warm-up hesitation


Unstable idle


Knocking/pinging


Misfire


Power loss
Do not blend any specific fuel additives
with fuel. This only results in unnecessary
cost and may be harmful to engine opera-
tion.
Damage or malfunctions resulting from
poor fuel quality or from blending specific
fuel additives are not covered by the
Mercedes-Benz Limited Warranty.
Coolants
The engine coolant is a mixture of water
and anticorrosion/antifreeze, which pro-
vides:

Corrosion protection


Freeze protection


Boiling protection (by increasing the
boiling point)
The cooling system was filled at the factory
with a coolant providing freeze protection
to approximately -22°F (-30°C) and corro-
sion protection.
If the antifreeze mixture is effective to
-22°F (-30°C), the boiling point of the cool-
ant in the pressurized cooling system is
reached at approximately 266°F (130°C).
The coolant solution must be used
year-round to provide the necessary corro-
sion protection and increase boil over pro-
tection. You should have it replaced every
15 years or 150 000 miles (250 000 km),
whichever comes first.

322 Technical dataFuels, coolants, lubricants etc.Coolant system design and coolant used
stipulate the replacement interval. The
above replacement interval is only applica-
ble if MB 325.0 anticorrosion/antifreeze
solution or other Mercedes-Benz approved
products of equal specification (see Facto-
ry Approved Service Products pamphlet)
are used to renew the coolant concentra-
tion or bring it back up to the proper level.
To provide important corrosion protection,
the solution must be at least 45% anticor-
rosion/antifreeze (equivalent to freeze
protection to approx. - 22°F [-30°C]). If
you use a solution that is more than 55%
anticorrosion/antifreeze (freeze protec-
tion to approx. - 49°F [-45°C]), the engine
temperature will increase due to the lower
heat transfer capability of the solution.
Therefore, do not use more than this
amount of anticorrosion/antifreeze.If the coolant level is low, water and
MB 325.0 anticorrosion/antifreeze should
be used to bring it up to the proper level
(have cooling system checked for signs of
leakage). Please make sure that the mix-
ture is in accordance with label instruc-
tions.
The water in the cooling system must meet
minimum requirements, which are usually
satisfied by normal drinking water. If you
are not sure about the water quality, con-
sult your authorized Mercedes-Benz
Center.
Anticorrosion/antifreeze
Your vehicle contains a number of alumi-
num parts. The use of aluminum compo-
nents in motor vehicle engines
necessitates that anticorrosion/antifreeze
coolant used in such engines be specifical-
ly formulated to protect the aluminum
parts. (Failure to use such anticorro-
sion/antifreeze coolant will result in a sig-
nificantly shortened service life.)
Therefore, the following product is strongly
recommended for use in your vehicle:
Mercedes-Benz 325.0 Anticorrosion/Anti-
freeze agent.
Before the start of the winter season (or
once a year in hot southern regions), you
should have the anticorrosion/antifreeze
concentration checked. The coolant is also
regularly checked each time you bring your
vehicle to your authorized Mercedes-Benz
Center for service.

333
Index
A
ABS 23, 73, 327
ABS control 74
Malfunction indicator lamp 247
Messages in display 253
Warning lamp 247
Accelerator position, automatic transmis- sion 137
Accident In case of 50
Activating Air conditioning (cooling) 148, 157
Air recirculation mode 146, 154
Anti-theft alarm system 78
Automatic climate control 151
Central locking (control system) 122
Climate control 143
Defrost 146, 154
Easy-entry/exit feature 123
ESP 77
Exterior headlamps 47
Exterior lamps 97
Hazard warning flasher 99
Headlamps 47
High beams 99
Ignition 31 Immobilizer 53, 78
Rear fog lamp 97
Rear window defroster 147, 156
Residual heat 158
Seat heater* 92
Tow-away alarm 79
Windshield wipers 48
Adding Coolant 230
Engine oil 228
Additional turn signals 280
Adjustable air outlets, rear passenger com- partment 149, 158
Adjusting 32 Air distribution 145, 153
Air volume 145, 153
Backrest tilt 33, 35
Exterior rear view mirror 40
Head restraint height 33, 35, 37
Head restraint tilt 34, 35
Head restraints 37
Inside rear view mirror 39
Instrument cluster illumination 102
Manual seat 33
Mirrors 39
Rear seat head restraints 36 Seat cushion tilt 33, 35
Seat fore and aft adjustment 33, 34
Seat height 33, 35
Seats 32
Steering column height 39
Steering column length 39
Steering wheel 37
Air conditioner (cooling) Turning off 148, 157
Turning on 148, 157
Air conditioner refrigerant 319
Air distribution Adjusting 145, 153
Air outlets, rear passenger compartment Adjustable 149, 158
Air pressure see Tire inflation pressure 234
Air recirculation mode 146, 154 Activating 146, 154
Deactivating 147, 155
Air volume Adjusting 145, 153
AIRBAG OFF indicator lamp 251
Airbags 57 BabySmart
TM airbag deactivation
system 327
BabySmartTM deactivation system 67

337
Index
Cockpit 20, 327
Cockpit management and data system
(COMAND*) 328
Collapsible tire 328
COMAND* 328
COMAND* see separate operating instructions
Combination switch 99 High beam flasher 48, 99
Turn signals 47
Windshield wipers 48
Consumer information 325
Control and operation of radio transmitters 222
Control system 105, 328 AUDIO menu 110
Convenience submenu 123
Display digital speedometer 110
Functions 106, 109
Instrument cluster submenu 116
Lighting submenu 119
Malfunction memory menu 112
Menus 108, 109, 329
Multifunction display 105
Multifunction steering wheel 106
NAV menu 112 Selecting radio system 111
Settings menu 114
Standard display menu 110
Submenus 107, 109
TEL* menu 126
Trip computer menu 125
Vehicle submenu 122
Convenience submenu 123 Activating easy-entry/exit feature 123
Setting key dependency 124
Setting parking position for exterior rear view mirror 124
Coolant 229, 321 Adding 230
Anticorrosion/antifreeze quantity 322
Capacities 317
Checking level 229
Messages in display 257, 258
Temperature 223
Temperature gauge 102
Warning lamp 258
Coolant level Checking 225, 229
Cruise control 189, 328 Canceling 190
Driving downhill 190 Driving uphill 190
Fine adjustment 191
Saving current speed 190
Setting speeds 191
Cruise control lever 189
Cup holder Cleaning 243
In front seat armrest 196
Customer Assistance Center (CAC) 327
D
Daytime running lamp mode 98 Setting 119
Deactivating Air conditioning (cooling) 148
Air recirculation mode 147, 155
Alarm 79
Anti-theft alarm system 79
Automatic climate control 151
Central locking (control system) 122
Climate control 143
Cruise control 190
Defrost 146, 154
Engine with the key 53
ESP 76
Exterior lamps 97
Exterior lamps delayed shut-off 120

344 IndexMalfunctionDisplaying 113
Malfunction memory 112 Calling up 112
Manual headlamp mode 97
Manual operations Fuel filler flap 277
Interior lighting control 100
Locking the vehicle 275
Sliding/pop-up roof 278
Unlocking the driver’s door 274
Unlocking the trunk lid 275
Unlocking transmission selector lever 277
Manual seat Adjusting 33
Adjusting backrest tilt 33
Adjusting head restraint height 33
Adjusting head restraint tilt 34
Adjusting seat cushion tilt 33
Adjusting seat height 33
Front seat head restraints 90
Seat fore and aft adjustment 33
Manual transmission 130 Shifting into reverse 131
Starting with 44 MAXCOOL maximum cooling 154
MB Tex upholstery
Cleaning 244
Mechanical key 274, 275
Memory function 93, 329 Recalling positions from memory 94
Storing exterior rear view mirror park-ing positions 95
Storing key dependent settings 94
Menus 106 AUDIO 110
Control system 329
In control system 108, 109
Malfunction memory 112
NAV 112
Settings menu 114
Standard display 110
Submenus 107
TEL* 126
Trip computer 125
Microphone Hands-free microphone 26
Miles/kilometers in speedometer Setting 117 Mirrors
Adjusting 39
Automatic antiglare for rear view mirror 138
Exterior rear view mirror 40
Exterior rear view mirror parking posi- tions 124
Inside rear view mirror 39
Storing exterior rear view mirror park- ing position 95
MON 225
MON (Motor Octane Number) 329
Mph or km/h in speedometer 117
Multifunction display 105, 329 Selecting language 118
Standard display 109
Multifunction display messages ABS 253
BAS 254
Battery 270
Brake fluid 256
Brake pads 256
Check engine 250
Coolant 258
Coolant level 257
Display 270