MERCEDES-BENZ CLK COUPE 2004 Owners Manual

378 Practical advice
Battery
!
Only use battery chargers with a maximum
ch arging voltage of 14.8 V. 6
Charge the battery.
Observe the notes inthe operating
instructions foryour battery charge r.
6 Refit the charge d battery.
To do so, follow the steps described
under "Removing the battery" in the
re ve rse order.
! Always conne ctthe battery in the order de-
scribed below. Never swap the terminal clamps.
You could otherwise damage the vehicle's elec-
tronics.
6 Switch off all electrical consumers.
6 Connect the positive terminal and
secure the cover.
6 Connect the negative terminal. 6
Connect the breather hose.
Make sure that the battery is fitted with
a stopper opposite the breather hose.
i If the power supply tothe battery has been
interrupted (e. g.it has been reconnected), you
must carry out the following tasks:
! Set the clock (= page 121)
! Rese tthe side win dows ( =page 180) Cha
rging and fitting the battery G
Risk of inju ry Never charge th
ebattery when it is fitted in
the vehicle. Youco uld otherwise dam age
the vehicle's electronics .Only charge the
battery ina well ventilated area. During the
ch arg ingp roce ss, gas esmay escapeand
generate minor explosi ons which could in-
jure you and oth ers or cause paint damage
or acid corrosion to the vehic le. G
Risk of acid burns During the charging process, there is a risk
of acid burns due to the gases escaping
from th ebattery. Do not lean over the bat-
tery while the engine is being jump-started. Connecting the
battery 209en_d2.boo Seite
378 Dienstag, 25. Mai 2004 7:26 19

379
Practical advice
Jump-starting
If the battery is discharged, the engine can
be started from another vehicle using jump
leads. Forim proved accessibility, your ve-
hicle has been fitted with a positive and
negative contact in the eng ine compart-
ment.
Please note:
! Jump-starting must only be performed
when the engine and catalytic convert-
er are cold.
! Do not start the engine if the battery
has frozen. Let th ebattery thaw out
fir st.
! Jump-starting may only be performed
from batteries with the sam enominal
vol tage.
! Use jump leads for jump -starti ng.You
can obtain further information from a
qualified speci alistw orkshop, e.g. a
Mercedes-Benz Service Centre. !
Avoid repeated and lengthy starting
at tem pts.
Never start the vehicle using a rapid battery
charger.
6 Make sure thatthe two vehicles do not
touch.
6 Switch off all electri cal consumers. 1
Positive terminal of donor battery
2 Positive contact of your vehicle
3 Negative terminal of your vehicle
4 Negative contact of donor battery
6 Open the red cap on positi vecontact
2 of your vehicl e. Jump-starting
G
Risk ofacid burns Do not lean over the battery while the en-
gine is being jump-started.
G
Risk of explosion Avoid cr
eating sparks. Keep naked flames
away from the battery and do not smoke in
it s vi cini ty.
Comply with safety precautions and special
protective measures when handling batter-
ies ( =
page 375). ==209en_d2.boo Seite
379 Dienstag, 25. Mai 2004 7:26 19

380 Practical advice
Jump-starting
6
Connect positive terminal 1to posi-
ti ve conta ct2 on your vehicle using
the jump lead. Start with the donor bat-
ter y.
6 Run the donor vehicle's engine at idling
speed.
6 Connect negative terminal 4of the
donor battery to negative contact 3of
your vehicle using the jump lead. Start
wi th the donor battery.
6 Start the engine.
6 You can now switch electrical consum-
ers back on. Do not under any circum-
stances switch on the lights. 6
First undo the jump leads from nega-
tive terminals 3and 4of the batter-
ies, and then from positi veterminals
1 and 2.
6 Have the battery checked at aqualified
specialist workshop, e.g. a Mercedes-
Benz Service Centre. 209en_d2.boo Seite
380 Dienstag, 25. Mai 2004 7:26 19

381
Practical advice
Towing
Comply with national regulations when
towing.
Having the vehicle carried away on a trans-
porter or trailer is pre ferable to towing it
away. We recommend the use of a rigid
towbar if towing is nec essary.
You may on lytow the vehicle a maximum
of 50 km. A maximum towing speed of
50 km /hmust not be exceeded. i
Deactivate the automatic locking while driv-
in gfunction when towi ng. You could otherwise
beco me locked out when pushi ngortowing the
vehicle.
! Vehicles wit hautomatic transmission
must not be tow-started.
! If th eengine does not start, try jump-
starting it ( =page 379).
! If the vehicle does not start after
jump-starting, have it towed to a quali-
fied specialist work shop, e.g. to a
Mercedes-Benz Service Centre.
! If the vehicle is to be towed for a longer
distance, only tow it with the rear axle
raised. !
If the vehicle has suffere dtransmission
damage, only tow it with the propeller
shaft disconnected.
! Before tow ing the vehicle, make sure
the battery isconnected and charged.
Otherwise, you will not be able to
switch on the ignition and will have
no steering and braki ngassistance.
! Shift the transmission to position N. Opening the front cover
The fixing points for the bolt-on towing eye
are located in the bumpers. They are locat-
ed under the cover on the right-hand side
when
viewed in the direction of travel both
at the front and the rear.
! Only secure the tow cable or towbar to the
towing eye.The vehicle could otherwi sebe
damaged. Towing
G
Risk of accident Tow the vehicle using a rigid
towbar if:
! the engine will not start
! there is a malfunction in the power sup-
ply or the vehicle's electrical sy stem
There is no power assistance for the steer-
ing when the engine is not running. Signifi-
ca ntly greater force is then needed to steer
the vehicle and to brake.
When towing or tow-starting another vehi-
cle, its weight should not be greater than the
permissible gross weight of your ve hicle. Po
ints to bear in mind Fitting the towing eye209en_d2.boo Seite
381 Dienstag, 25. Mai 2004 7:26 19

382 Practical advice
Towing
1 Front cover
6 Press back cover 1on the arrow.
6 Remove cover 1from the opening. Do
not pull the cover away. Opening the rear cover
Standard vehicles
2 Rea r co ver
6 Press back co ver2 on the arrow.
6 Remove cover 2from the opening. Do
not pull the cover away. AMG vehicles
3 To prise off the cover
6 Prise off the cover from below 3with
a tool such as a screwdriver.
6 Remove the cover from the opening.
Do not pull the cover away. P 88.20-2238-31 neu
P 88.20-2239-31 neu P 88.20-
2441-31 209en_d2.boo Seite
382 Dienstag, 25. Mai 2004 7:26 19

383
Practical advice
Towing Securing the towing eye
6
Remove the towing eye and the wheel
wrench from the vehicle tool kit
(= page 276).
6 Screw in the towing eye clockw ise to
the stop.
6 Insert the wheel wrench handle into the
towing eye and tighten. Removing the towing eye
6
Remove the wheel wrench from the ve-
hicle to olkit.
6 Insert the wheel wrench handle into the
towing eye and turn the wheel wrench
anti-clockwise.
6 Unscrew the to wing eye.
6 Insert the top of cover 1byits tab in
the front bumper and press the bottom
of the cover inuntil it engages.
or St
andard vehicles:
6 Insert the bottom of cover 2by its tab
in the rear bumper and press the top of
the cover in until it engages.
or
AMG veh icles:
4 To fit the cover
6 Hook the cover in the rear bumper on
the right-hand side and slide it fully
over to the right (direction of arrow) 4.
6 Apply light pressure on the left-hand
side of the cover.
6 Put the towing eye and the wheel
wrench back into the vehicle tool kit. !
Theengine must not be running ifyo ua re
towing the vehicle with the front axle raised. Ap-
pli ca tion of the brakes by ESP would otherwise
da ma ge the braking sy stem on the rear axle be-
yond repair. Vehicles with manua
l transmission
6 Switch on the ignition (key inposition 2
in the ignition lock).
6 Make sure that no gear is engaged. P 88.20-2440-31 Towing the vehicle209en_d2.boo Seite
383 Dienstag, 25. Mai 2004 7:26 19

384 Practical advice
TowingVehicles with automati
ctransmission*
6 Switch on the ignition (key in position 2
in the ignition lock ).
6 Move the selector lever to N.
! Do not tow the vehicle further than 50 km.
Do not exceed a towing spe edof 50 km /h,ot h-
erw ise the trans mission could be damag ed.
Only tow the ve hicle with the rear axl e
raised if:
! you need to tow the vehicle for a longer
distance
! the transmission has been damaged
Instead of raising the rear axle, the propel-
ler shaft to the driven axl ecan be removed. Points to bea
rin mi nd:
! Vehicles with automatic transmission*
must not be tow-started.
! The battery must be connected.
! The engine and the catalytic converter
must be cold.
! Avoid repea ted or lengthy attempts to
start the engine. Vehicles with
manual transmission
6 Switch on the ignition (key in position 2
in the ignition lock).
6 Make sure that no gear isengaged.
6 Tow the vehicle to set it in motion, or al-
low it to roll.
6 Engage a suit able gear and gradually
release the clutch. Do not depress the
accelerator.
! The engine is started. The towing
eyes can be used to pull the ve-
hic leonto a trailer or transporter for trans-
po rting purposes.
Make su rethat no gea ris engag ed. On ve-
hicles with automatic transmission*, the
selector lever must be in position N
! Lash the vehicle securely ,and only by the
wheels or wheel rim s.
Your vehicle could otherwise be damaged. Tow-starting the vehicle
(emer
gencyengine start) Tr
an sporting thev ehicle 209en_d2.boo Seite
384 Dienstag, 25. Mai 2004 7:26 19

385
Practical advice
Fuses
The electrical fuses in your vehicle inter-
rupt the power supply to the equipment in
the event of a malfunction. This prevents
damage to the rest of the on-board
electri cs.
The following are available for changing
fuses ( =page 385):
! Fuse allocation chart
! Spare fuses
! Fuse extractor !
Only use fuses wi th thespec ifie d amperage
fo r the system inques tion, and which have been
ap proved for Mercede s-Be nz.Electrical parts or
sys tems could otherwise bedamaged.
Do not attempt to repair or bridge faul tyfuses.
Have the cause traced and recti fied at a qualified
specialist workshop, e.g. a Mercedes-Benz Serv-
ic e Centre.
The electrical fuses are located in different
fus eboxes:
! Main fuse box onthe left of the dash-
boa rd (
=page 386).
! Fuse box in the engine compartment
on the left (
=page 386).
! Fuse box in the boot on the left
(
= page 387). Fuse allocation chart
The fuse allocation chart is located in the
cover of the main fuse box on the dash-
board (
=page 386) .The amperage of the
fuses is also given there. Spare fuses
Spare fuses can be found in the vehicle
tool kit (=
page 276). Fuse extractor
Coupé
The fuse extractor can be found in the cov-
er of the fuse box
inthe boot (
=page 387).
Cabriolet
The fuse extractor can be found in the ve-
hicle tool kit ( =pa ge 276). Fuses
G
Riskof fire Only use fuses with the speci
fied amperage
for the system in question, and which have
be en approved for Mercedes-Be nz.Other-
wise, a short-circuit could occur, which
could cause afire. Changing fuses209en_d2.boo Seite
385 Dienstag, 25. Mai 2004 7:26 19

386 Practical advice
Fuses
The main fuse box is located behind the
light switch on the dashboard.
1 Cover Opening
6
Open the driver's door.
6 Insert a screwdri ver, or a similar tool
(arrow ).
6 Prise off cover 1with a sc rewdriver or
a similar implement.
6 Pull cover 1outwards. Closing
6
Hook on cover 1at the front.
6 Fold in cover 1until it engages.
The fuse box islocated in the engine com-
partment on the left-hand side. Opening
2 Cover
3 Rotary catch
4 Retainer 6
Turn rotary catches 3onequarter
turn ant i-cl ockwise.
6 Lift cover 2at the back, guide it side-
ways out of retainer 4and remove it
for wa rds.
5 Fuse box cover
6 Clamps Main fuse box
P 54
.15-2328-31 neu Fus
eboxinthe engine compartment P 54.15-2326-31 neu P 54.15-2325-31 neu209en_d2.boo Seite
386 Dienstag, 25. Mai 2004 7:26 19

387
Practical advice
Fuses
6 Rem ove any moisture from the fuse
box using a dry cloth.
6 Loosen clamps 6and swing fuse box
cover 5upwards. Clos
ing
6 Place the cover on fuse box 5. Make
sure that the rubber seal fits correctly
and the cover fits correctly on the box.
6 Press cover 5and secure it with
clam ps6.
6 Guide the cover into the retainer.
6 Turn the rotary catches one quarter
turn clockwise. The fuse box is located in the boot behind
the left-hand side panel. Open
ing
Illustratio ntake n from a Coupé
1 Trim
2 Coupé: cover
3 Coupé: fuse extractor 6
Remove trim 1.
6 Remove cover 2. Closi
ng
6 Rep lace co ver2.
6 Press on trim 1. Fuse box in
theb oot P 54.15-2327-31 neu209en_d2.boo Seite
387 Dienstag, 25. Mai 2004 7:26 19