MERCEDES-BENZ ML350 2008 W164 Owner's Manual

510 Technical data
Identification labels
1Certification label (on driver’s B-pillar)
The V
ehicle Identification Number (VIN)
can be found in the following locations:

on the certification label

embossed underneath the
passenger-side rear seat (
page 511)

on the lower edge of the windshield
(
page 511)
Example certification label (U.S. vehicles)
2Paintwork code
3VIN
Example certification label
(Canada vehicles)
2Paintwork code
3VIN
iData shown on certification label are for
illustration purpose only. These data are specific
to each vehicle and may vary from data shown in
the illustration. Refer to certification label on
vehicle for actual data specific to your vehicle.

511 Technical data
Identification labels
4Seat cushion
5Floor cover
6VIN
Fold the seat cushion4 forward
(
page 270).
Fold floor cover5 in direction of the
arrow.
The VIN6 is now visible.7Emission control information label,
includes both federal and California
certification exhaust emission
standards
8Engine number (engraved on engine)
9VIN (lower edge of windshield)
iWhen ordering parts, please specify vehicle
identification and engine numbers.

512 Technical data
Layout of poly-V-belt drive
ML 320 CDI
1Coolant pump
2Idler pulley
3Automatic belt tensioner
4Power steering pump
5Air conditioning compressor
6Crankshaft
7Idler pulley
8Generator (alternator)ML 350, ML 550
1Idler pulley
2Idler pulley
3Automatic belt tensioner
4Power steering pump
5Air conditioning compressor
6Crankshaft
7Coolant pump
8Generator (alternator)ML 63 AMG
1Idler pulley
2Idler pulley
3Idler pulley
4Automatic belt tensioner
5Power steering pump
6Air conditioning compressor
7Crankshaft
8Coolant pump
9Generator (alternator)

513 Technical data
Engine
Engine
ModelML 320 CDI (164.1221)
1The quoted data apply only to the standard vehicle. See an authorized Mercedes-Benz Light Truck Center for the corresponding data of all special bodies and special
equipment.
ML 350 (164.1861)
Engine642272
Mode of operationDiesel 4-stroke engine4-stroke engine, gasoline injection
No. of cylinders66
Bore3.27 in (83.00 mm)3.66 in (92.90 mm)
Stroke3.62 in (92.00 mm)3.38 in (86.00 mm)
Total piston displacement182 cu in (2987 cm3)213 cu in (3498 cm3)
Compression ratio17.7:110.7:1
Output acc. to SAE J 1349215 hp/4000 rpm
(160 kW/4000 rpm)268 hp/6000 rpm2
(200 kW/6000 rpm)
2Premium fuel required. Performance may vary with fuel octane rating.
Maximum torque acc. to SAE J 1349400 lb-ft/1600 - 2400 rpm
(543 Nm/1600 - 2400 rpm)258 lb-ft/2400 - 5000 rpm
(350 Nm/2400 - 5000 rpm)
Maximum engine speed4500 rpm6500 rpm
Firing order1-4-2-5-3-61-4-3-6-2-5
Poly-V-belt2 035 mm2 404 mm

514 Technical data
Engine
ModelML 550 (164.1751)
1All data preliminary. The quoted data apply only to the standard vehicle. See an authorized Mercedes-Benz Light Truck Center for the corresponding data of all special
bodies and special equipment.
ML 63 AMG (164.1772)
2The quoted data apply only to the standard vehicle. See an authorized Mercedes-Benz Light Truck Center for the corresponding data of all special bodies and special
equipment.
Engine273156
Mode of operation4-stroke engine, gasoline injection4-stroke engine, gasoline injection
No. of cylinders88
Bore3.86 in (98.00 mm)4.02 in (102.20 mm)
Stroke3.56 in (90.50 mm)3.72 in (94.60 mm)
Total piston displacement333.2 cu in (5461 cm3)378.8 cu in (6208 cm3)
Compression ratio10.7:111.3:1
Output acc. to SAE J 1349382 hp/6000 rpm3
(285 kW/6000 rpm)
3Premium fuel required. Performance may vary with fuel octane rating.
503 hp/6800 rpm3
(375 kW/6800 rpm)
Maximum torque acc. to SAE J 1349391 lb-ft/2800 - 4800 rpm
(530 Nm/2800 - 4800 rpm)465 lb-ft/5200 rpm
(630 Nm/5200 rpm)
Maximum engine speed6500 rpm7200 rpm
Firing order1-5-4-2-6-3-7-81-5-4-2-6-3-7-8
Poly-V-belt2 404 mm2 360 mm

515 Technical data
Rims and tires
Rims and tires
!Only use tires which have been tested and
approved by Mercedes-Benz. Tires approved by
Mercedes-Benz are developed to provide best
possible performance in conjunction with the
driving safety systems on your vehicle such as
ABS or ESP
®. Tires specially developed for your
vehicle and tested and approved by
Mercedes-Benz can be identified by finding the
following on the tire’s sidewall:

MO = Mercedes-Benz Original equipment
tires
AMG vehicles:
Does not apply to all approved tires on AMG
vehicles. For information on tested and
approved tires for AMG vehicles, contact an
authorized Mercedes-Benz Light Truck
Center.
Using tires other than those approved by
Mercedes-Benz may result in damage that is not
covered by the Mercedes-Benz Limited
Warranty.
!Using tires other than those approved by
Mercedes-Benz can have detrimental effects,
such as

poor handling characteristics

increased noise

increased fuel consumption
Moreover, tires and rims not approved by
Mercedes-Benz may, under load, exhibit dimen-
sional variations and different tire deformation
characteristics that could cause them to come
into contact with the vehicle body or axle parts.
Damage to the tires or the vehicle may be the
result.
iFurther information on tires and rims is
available at any authorized Mercedes-Benz Light
Truck Center. A placard with the recommended
tire inflation pressure is located on the driver’s
door B-pillar (
page 510). Some vehicles may
have supplemental tire inflation pressure infor-
mation for driving at high speeds (
page 358)
or for vehicle loads less than the maximum
loaded vehicle condition (
page 358). If such
information is provided, it can be found on the
placard located on the inside of the fuel filler
flap.The tire inflation pressure should be checked
regularly and should only be adjusted on cold
tires. Follow tire manufacturer’s maintenance
recommendation included with vehicle.
iThe following pages also list the approved
wheel rim and tire sizes for equipping your
vehicles with winter tires. Winter tires are not
available as standard or optional factory equip-
ment, but can be purchased from an authorized
Mercedes-Benz Light Truck Center.
Depending on vehicle model and the standard or
optional factory-equipped wheel rim/tire
configuration on your vehicle (Appearance
Package, Sport Package etc.), equipping your
vehicle with winter tires approved for your
vehicle model may also require the purchase of
two or four wheel rims of the recommended size
for use with these winter tires. See an authorized
Mercedes-Benz Light Truck Center for more
information.

516 Technical data
Rims and tires
Same size tires
ModelML 320 CDI
ML 350ML 320 CDI*
ML 350*ML 320 CDI (Sport Package*)
ML 350 (Sport Package*)
ML 550
Rims (light alloy)7.5 J x 17 H28Jx18H28Jx19H2
Wheel offset2.20 in (56 mm)2.36 in (60 mm)2.36 in (60 mm)
All-season tires1235/65 R17 104H M+S255/55 R18 105H M+S255/50 R19 107H XL (Extra Load) M+S
Winter tires1,2235/65 R17 104H M+S.255/55 R18 105H M+S.255/50 R19 107H XL (Extra Load) M+S.
All-terrain tires1,2-255/55 R18 105H M+S-
1Radial-ply tires2Not available as factory equipment.

517 Technical data
Rims and tires
ModelML 63 AMGML 63 AMG*ML 320 CDI (Sport Package*)
ML 350 (Sport Package*)
ML 550 (Sport Package*)
AMG rims (light alloy)9.5Jx19H210 J x 20 H28.5Jx19H2
Wheel offset1.81 in (46 mm)1.81 in (46 mm)2.28 in (58 mm)
All-season tires1 – –255/50 R19 107H XL (Extra Load) M+S
Summer tires1,2295/45 ZR19 109Y295/40 ZR20 106Y –
Winter tires1,3285/45 R19 107V M+S. –255/50 R19 107H XL (Extra Load) M+S.
1Radial-ply tires2Must not be used with snow chains.3Not available as factory equipment.

518 Technical data
Rims and tires
Spare wheel
ModelML 320 CDI
ML 350
ML 550ML 63 AMG
Rim4.0B x 18 H25.5 B x 19 H2
Wheel offset1.58 in (40 mm)0.51 in (13 mm)
Minispare tire1
1Must not be used with snow chains.
T 155/90 D18 113M
or
T 155/90 R18 113M –
Collapsible tire1 –185/65-19 104P
Recommended tire inflation pressure61 psi (4.2 bar)51 psi (3.5 bar)
!Please compare the recommended tire in-
flation pressure for your vehicle with the tire in-
flation pressure on the yellow label located on
the spare wheel rim.
If the tire inflation pressure on the yellow label
on the spare wheel rim differs from the values
given in this Operator’s Manual, inflate the col-
lapsible tire to the recommended tire inflation
pressure given on the yellow label on the spare
wheel rim.iPlease note that the tire inflation pressure of
the spare tire differs from the tire inflation pres-
sure of the road tires.

519 Technical data
Electrical system
Electrical system
ModelML 350ML 550ML 63 AMG
Generator (alternator)14 V/180 A14 V/180 A14 V/180 A
Starter motor12 V/1.4 kW12 V/1.7 kW12 V/2.1 kW
Battery12 V/70 Ah12 V/95 Ah12 V/95 Ah
Spark plugsBosch Y7MPP33NGK PLKR7A-1
1Contact an authorized Mercedes-Benz Light Truck Center.
Electrode gap0.031 in (0.8 mm)0.031 in (0.8 mm)0.039 in (1.0 mm)
Tightening torque15 – 19 lb-ft (20 – 25 Nm)15 – 19 lb-ft (20 – 25 Nm)15 – 22 lb-ft (20 – 30 Nm)
ModelML 320 CDI
Generator (alternator)14 V/180 A
Starter motor12 V/2.0 kW
Battery12 V/95 Ah