belt MITSUBISHI 3000GT 1996 2.G Workshop Manual

Downloaded from www.Manualslib.com manuals search engine GENERAL - Diode Location17
DIODE LOCATION
Name
Diode (ABS circuit) <Up to 1995 models>
Diode (MFI circuit)
Diode (Seat belt warning circuit)Symbol
Name
SymbolA
Diode (Theft-alarm circuit)C
BDiode (4WS fluid level warning light circuit)D
C
Diode (ABS circuit)
,’ i’16FOO24
I \T19F013400002703
/
f(MFI c?uit)Y16FO251
236FOO16
1 TSB Revision

Downloaded from www.Manualslib.com manuals search engine 32GENERAL - How to Diaanose
CHECKING CABLES AND WIRES1. Check connections for looseness, rust and stains.
2.Check terminals and wires for corrosion by battery electro-
lyte, etc.
3.Check terminals and wires for open circuit or impending
open circuit.4. Check wire insulation and coating for damage, cracks
and degrading.
5.Check conductive parts of terminals for contact with other
metallic parts (vehicle body and other parts).6. Check grounding parts to verify that there is complete
continuity between attaching bolt(s) and vehicle body.7. Check for incorrect wiring.
8.Check that wirings are so clamped as to prevent contact
with sharp corners of the vehicle body, etc. or hot parts(exhaust manifold, pipe, etc.).
9.Check that wirings are clamped firmly to secure enough
clearance from the fan pulley, fan belt and other rotating
or moving parts.
10. Check that the wirings between the fixed parts such as
the vehicle body and the vibrating parts such as the engine
are made with adequate allowance for vibrations.
HANDLING ON-VEHICLE BATTERY
When checking or servicing does not require power from the
on-vehicle battery, be sure to disconnect the cable from thebattery
(-) terminal. This is to prevent problems that could
be caused by a short circuit. Disconnect the (-) terminal first
and reconnect it last.
Caution1. Before connecting or disconnecting the negative
cable, be sure to turn off the ignition switch and the
lighting switch.
(If this is not done, there is the possibility of semicon-
ductor parts being damaged.)
2.After completion of the work steps [when the battery’s
negative (-)
terminal is connected], warm up the engineand allow it to idle for approximately five minutes
under the conditions described below, in order to sta-
bilize the engine control conditions, and then checkto be sure that the idling is satisfactory.
Engine coolant temperature:
85-95°C (185-203°F)
Lights, electric fans, accessories: OFF
Transaxle: neutral position
(A/T models: “N” or “P”)
Steering wheel: neutral (center) position
1 TSB Revision

Downloaded from www.Manualslib.com manuals search engine 50CONFIGURATION DIAGRAMS - Dash Panel
DASH PANEL
Connector
symbol
C
01thru
45
NOTE*I: 1992 models
*2: Up to 1995 models
c-01c-02
c-o.3
c-04x
C-06X
c-07x
C-08c-09
C-l 0
C-l 1
c-12
Body wiring harness (LH)
and front wiring harness combination
Body wiring harness (LH)
and front wiring harness combination
Body wiring harness (LH)
and front wiring harness combination
Door lock power relay 1
Defogger relay
Power window relay
Diode (for seat belt warning circuit)
Diode (for seat belt warning circuit)
Column switch
Column switch
Diode (for theft-alarm circuit)c-13
c-14
C-l 5
C-l 6
C-l 7
C-l 8
C-l 9c-20
c-21c-22
C-23
C-24
/ i
i
.m
/\\
LJ
Accelerator pedal switch*’
Control wiring harness and instrument panel
wiring harness combination
Body wiring harness (LH) and instrument panel
wiring harness combination
Air conditioning control panel
Air conditioning control panel
Air conditioning switch
Blower switch
Heater control panel illumination light
Blend air damper control motor
Mode selection damper control motor
Power transistor (for full-auto air conditioning
circuit)
Blower resistor
I TSB Revision

Downloaded from www.Manualslib.com manuals search engine /
id
CONFIGURATION DIAGRAMS - Instrument Panel and Floor Console55
D-13
D-14
D-15
\D-17
D-46
D-23
D-24
D-29
D-30
D-31
D-32
D-33
D-34
D-35
D-36
D-37
D-38
D-39
D-40
D-41
/
id, D-42
D:2736fO18100004269
D-26
D-25*’
Active aero switch <Hatchback>
Accessory socket
Accessory socket
Auto-cruise main switch
Seatbelt warning buzzer
Radio
Radio
Radio
Rear wiper and washer switch <Hatchback>Active exhaust
switch*;!
Remote-control mirror switch
Rheostat
Instrument panel wiring harness -and body
wiring harness (LH) combination
Instrument panel wiring harness and body
wiring harness (LH) combination
D-43
D-44
D-45
D-46
D-47
D-48
D-49
D-50
D-51
D-52
D-53
Instrument panel wiring harness and body
wiring harness (LH) combination
Instrument panel wiring harness and adapter
wiring harness combination
Instrument panel wiring harness and front wiring
harness combination
Telephone cableRadio or body wiring harness and radio sub
wiring harness combination
Top switch <Convertible>
Instrument panel wiring harness and body
wiring harness (LH) combination <Convertible>
Parking switch <Convertible>
Chime*3
Body wiring harness (LH) and header wiring
harness combination*3
Body wiring harness (LH) and header wiring
harness combination*3
TSB Revision

Downloaded from www.Manualslib.com manuals search engine 56CONFIGURATION DIAGRAMS - Interior
INTERIOR
E-07E-08
E-06
‘-OfI/l--c
E-04
\
II/E-27
E-30
1E-25 1 E-i4 / E:22/E-21 1
E-29
E-28
NOTEE-26 E-39
*2 E-23 EJJ, +4 ,520*I: From 1993 models
l *: From 1994 models
E-01
E-02
E-03
E-04
E-05
E-06
E-07
E-08
E-09
E-10
E-11
E-l 2
E-13Body wiring harness (RH) and door wiring
harness (RH) combination
Vanity mirror illumination light (LH)
Door mirror (RH)
Door speaker (RH)
Dome lightPower window sub switch
Vanity mirror illumination light (RH)
Power window motor (RH)
Door light (RH)Door key cylinder unlock switch (RH)
Door lock actuator (RH)ABS control unit
ABS resistor
-=zAWD>*~
E-14
E-15
E-16
E-17
E-18
E-19
E-20
E-21
E-22
E-23
E-24
E-25
E-26
E-27
Front seat belt solenoid (RH)
Door switch (RH)
ABS rear speed sensor (RH)
Light automatic shut-OFF unit
Rear intermittent wiper relay
ABS rear speed sensor (LH)
Front seat belt solenoid (LH)
Door switch (LH)
Door lock actuator (LH)
Door key cylinder unlock switch (LH)Front seat belt switch (RH)
Door light (LH)Front seat belt switch (LH)
Power seat assembly
ITSBionI

Downloaded from www.Manualslib.com manuals search engine 61
i
CIRCUIT
DlAG.RAMS
CONTENTSActive Aero Circuit.........................
428Active Exhaust System Circuit..............
370
Anti-lock Braking System (ABS) Circuit......322
Auto-cruise Control Circuit..................380
Back-up Light...........................54-85
Buzzer Circuit.............................208
Car Telephone Circuit......................435
Central Door Locking Circuit................222
Charging System..........................16-3
Cigarette Lighter Circuit.................54-120
Cooling Circuit.............................176
Defogger Circuit........................54-193Dome Light, Foot Light and Ignition Key
Cylinder Illumination Light................54-72
Door Light and Luggage Compartment
Light...................................54-81
ELC-4 A/T Circuit..........................186
Electronic Control Suspension (ECS) Circuit . . 352
Fog Light Circuit.........................
54-58
Full Auto Air Conditioning’ Circuit............272Glove Box Light, Vanity Mirror
Light and Inspection Light Circuit..........
54-84
Headlight...............................
54-40
Heater Circuit.............................,239
Horn..................................54-116
How to Read Circuit Diagrams..............
62
Ignition System.........................16-32
Manual Air Conditioning Circuit.............242
Meter and Gauges Circuit...............54-12
MFI Circuit................................84
Power Distribution Circuit...................68
Power Seat Circuit....:...................416
Power Window Circuit.....................212
Radio and Tape Player................54-124
Rear. Wiper and Washer Circuit............318
Remote Controlled Mirror Circuit...........320
Starting System.........................16-20
Stop Light.............................54-98
Sunroof Circuit.............................442
Supplemental Restraint System (SRS)
Circuit....................................374
Taillight, Parking/Side Marker Light and
License Plate Light Circuit................54-64
Tension-reducer Type Seat Belt Circuit......423
Theft-alarm System....................54-206
Top Stack Circuit.........................438
Turn-signal Light and Hazard Light.......54-90
Windshield Wiper and Washer Circuit........316
I
LiI

Downloaded from www.Manualslib.com manuals search engine CIRCUIT DIAGRAMS - Power Distribution Circuit
POWER DISTRIBUTION CIRCUIT (UP TO 1993 MODELS) (CONTINUED)
$TEDQL’
G-W5W-B
G-W
[Beg; COMBINATION
G-W
J/Bs(c-69)
.AIR CONDITIONINGSEAT BELT.HIGH MOUNTEDCONTROL PANELSOLENOIDTug;T-ALARM
.GLOVE BOX1
STOP LIGHT.THEFT-ALARM1.STOP LIGHT,I~~~tjINATIONHORN RELAY1
BEb. 6
1
Et$:EE CONTROL
IOD ORSTORAGECONNECTOR
I._....[\i#yINATION
4~;;;""""
.LICENSE
PLATE LIGHT
.RADIO AND TAPE.REAR~~!&"""0"
.RHEOSTAT.VANITY MIRRORILLUMINATION
LIGHTPLAYER
.DOOR LOCKPOWER RELAY 1.DOOR LOCKPOWER RELAY 2.MOTOR ANTENNACONTROL UNIT
_- .__.. --
r
_.._.
.ACTIVE AERO
. @%!A
CONTROL UNIT
NATION.AIR CONDITIONING
,DOME LIGHT
CONTROL UNIT
-DOOR LIGHT
Y245~i6~"~~BT
E~;;;;~NIC
SUSPENSION
CONTROL UNIT
.ENGINECONTROL MODULE.ETACS UNIT.FOOT LIGHT
i
'ESE!
.LIGHT AUTOMATICSHUT-OFF UNIT
ILLl
.LUGGAGE
LIGt
fP;bfiRTMENT
.KEYLESS ENTRY
.RADIO AND
CONTROL UNIT
TAPE PLAYER.SPARE CONNECTOR
(
WIRELESS8%PHoNE
).TRANSAXLECONTROL MODULE
(A-13X) (c-sa) ic-ss) (c-70)
mj fl pjq p&qHROlMOOBA
I
TSB Revision

Downloaded from www.Manualslib.com manuals search engine CIRCUIT DIAGRAMS - Power Distribution Circuit
POWER DISTRIBUTION CIRCUIT (1994 MODELS) (CONTINUED)
,ij ’
G-W
G-W
J/B
5W-B
G-W
[Pgfi; COMBINATION
.AIR CONDITIONINGSEAT BELT.HIGH MOUNTEDCONTROL PANELSOLENOIDT'#;;T-ALARMSTOP LIGHT.GLOVE BOX.THEFT-ALARM.STOP LIGHT.ILJ&INATION
HORN RELAY
MULTI-
RE"""
AMPLIFIER
2B-Y*
+-IOD ORSTORAGE43WFE CONTROLCONNECTOR
S;SRTDIAGNOSIS
.STARTER MOTOR
~3%""
LIGHI~~~l&INATION
dM&CT'ON
.LICENSEPLATE LIGHT.RADIO AND TAPE PLAYER.REARCOMBINATION
LIGHT
.RHEOSTAT.VANITY MIRRORILLUMINATIONLIGHT
*fi;;~yL~CK
'i&fEyLgCK
.MOTOR ANTENNACONTROL UNIT
$#~~NATION
*DATA LINKCONNECTOR.DOME LIGHT.DOOR LIGHT*TRANSAXLECONTROL MODULE
.KEYLESS ENTRYCONTROL UNIT,LIGHT AUTOMATICSHUT-OFF UNIT.LUGGAGECOMPARTMENTLIGHT.RADIO ANDTAPE PLAYER.SPARE CONNECTOR
i ~~~@i~wE I
E~;LE;[~NIC
SUSPENSION
CONTROL UNIT
.ENGINE\ UN11/
CONTROL MODULE
HROlMOlBA
TSB Revision

Downloaded from www.Manualslib.com manuals search engine 78CIRCUIT DIAGRAMS - Power Distribution Circuit
POWER DISTRIBUTION CIRCUIT (1995 MODELS) (CONTINUED)
F&J&C2TEDQC
Y
G-W
G-W
[W/; COMBINATION
G-W
5W-B
v,AIR CONDITIONINGSEAT BELT
CONTROL PANEL
SOLENOID
.RADIO AND TAPE PLAYER*REARCOMBINATION
LIGHT
.RHEOSTAT.VANITY MIRRORILLUMINATION
LIGHT
+AMPLIFIER
IOD ORSTORAGECONNECTOR
1
+W&T-ALARM.HIGH MOUNTEDSTOP LIGHT.THEFT-ALARM.STOP LIGHTHORN RELAYr
.ACTIVE AEROCONTROL UNIT'*AIR COMDITIONINGCONTROL UNIT4Mi8EU68FT$#~NATION
-_--
d
-
;L MODULE.ETACS UNIT.FOOT LIGHT.lGNITION KEYCYLINDER
ILLUMINATION
LIGHT
.KEYLESS ENTRYCONTROL UNIT
.DOME LIGHT.DOOR LIGHT.TRANSAXLECONTROL MODULE~~~~~$~~NIC
SUSPENSION
CONTROL UNIT
.LIGHT AUTOMATICSHUT-OFF UNIT.LUGGAGE
COMPARTMENT
LIGHT
*RADIO AND
TAPE PLAYER
(A-13X) (c-68) Fm) (c-70)
mi fg piq p&q
NOTE=:HATCHBACK
HROlM02BA
TSB Revision

Downloaded from www.Manualslib.com manuals search engine CIRCUIT DIAGRAMS - Power Distribution Circuit
POWER DISTRIBUTION CIRCUIT (FROM 1996 MODELS) (CONTINUED)
G-W5W-B
G-W
[owl;; COMBINATION
G-W
J/B
T-
AMPLIFIER
IOD ORSTORAGECONNECTOR
_-
@10A
+W&T-ALARM
.THEFT-ALARMHORN RELAY
.AIR CONDITIONINGSEAT BELT
CONTROL PANELSOLENOID
.GLOVE BOXILLUMINATION
LIGHT1
$@INATION.#3?YL~CK
4W'~CTION@iiyLgCK
.LICENSE.MOTOR ANTENNA
PLATE LIGHTCONTROL UNIT.RADIO AND TAPE PLAYER*REARfW&NATION
.RHEOSTAT*VANITY MIRROR
ILLUMINATION
LIGHT
.HIGH MOUNTEDSTOP LIGHT.STOP LIGHT
I
1
-----1
IR-k
1-----
--
--
2(c-70)
T
+I*ACTIVE AEROCONTROL UNIT'.ENGICONT
-_--
-_--
\
LJ
%L MODULE
,
*AIR COMDITIONING*ETACS UNITCONTROL UNIT.FOOT LIGHT
4i#@-%tiET.IGNITION KEYCYLINDER.&&NATIONILLUMINATION
LIGHT
.DATA LINK*KEYLESS ENTRYCONNECTORCONTROL UNIT*DOME LIGHT.LIGHT AUTOMATIC
*DOOR LIGHTSHUT-OFF UNIT.LUGGAGE.TRANSAXLECOMPARTMENT
CONTROL MODULELIGHT.RADIO ANDTAPE PLAYER
(A-1’IX) (c-68) ms) (c-70)
p&q fg mi [&I
NOTE2:HATCHBACK
IHROlM03BA
1 TSB Revision