engine MITSUBISHI COLT 2008 (in English) Owners Manual

8-28 Maintenance
8
Rear window wiper blades
The rear window wiper uses a wiper arm and wiper blade
designed specially for that wipe r. If replacement becomes nec-
essary, please consult a MITSUBISHI MOTORS Authorized
Service Point or another specialist.General maintenance
E01002700113
Fuel, engine coolant, o il and exhaust gas leakage
Look under the body of your vehicle to check for fuel, engine
coolant, oil and exhaust gas leaks.
Exterior and interior lamp operation
Operate the combination lamp sw itch to check that all lamps
are functioning properly.
If the lamps do not illuminate, the probable cause is a blown
fuse or defective lamp bulb. Check the fuses first. If there is no
blown fuses, check the lamp bulbs.
For information regarding th e inspection and replacement of
the fuses and the lamp bulbs, refer to “Fuses” on page 8-30 and
“Replacement of lamp bu lbs” on page 8-40.
If the fuses and bulbs are all OK, we recommend you to have
your vehicle checked and repaired.
WARNING!
● If you see a suspicious fuel leak or if you smell fuel,
do not operate the vehicle; we recommend you to
call for assistance.

Maintenance8-29
8
Meter, gauge and indicator/warning lamps
operation
Run the engine to check the op eration of all meters, gauges,
and indicator/warning lamps.
If there is anything wrong, we recommend you to have your
vehicle inspected.
Hinges and latches lubrication
Check all latches and hinges, and lubricate if necessary by first
cleaning and then appl ying multipurpose grease.
For cold and snow weather
E01002800172
Ventilation slots
The ventilation slots in front of the windscreen should be
brushed clear after a heavy snowfall so that the operation of the
heating and ventilation systems will not be impaired.
Weatherstripping
To prevent freezing of the weatherstripping on the doors, bon-
net, etc., they should be treated with silicone grease or spray.
Additional equipment
It is a good idea to carry a shovel or a short-handled spade in
the vehicle during the winter so that you can clear away snow
if you get stranded. A small hand-brush for sweeping snow off
the vehicle and a plastic scraper for the windscreen and rear
window are also useful.

Maintenance8-33
8
No. Symbol Electrical systemCapacity
1 Ignition switch 40 A
2 Electric window system 40 A
3 Radiator fan 40 A
4 Automated manual transmission 40 A
5 Demister 30 A
6 Heated seat 30 A
7 Diesel 30 A
8 Heater 40 A
9 Radio 10 A
10 Room lamp 10 A
11 Heated door mirror 7.5 A
12 Electronic control module 7.5 A
13 Windscreen wiper20 A
14 Tail lamp (right) 7.5 A
15 Tail lamp (left) 7.5 A
16 Engine 20 A
17 Fuel pump 15 A
18 Horn 10 A
19 Headlamp high beam (left) 10 A 20 Headlamp high beam (right) 10 A
21 Diesel 7.5 A
22 Diesel 15 A
23 Outside rear-view mirrors 7.5 A
24 Rear fog lamp 7.5 A
25 Accessory socket 15 A
26 Rear window wiper 15 A
27 Sunroof 20 A
28 Accessory socket 15 A
29 — ——
30 — ——
31 Hazard warning flasher 10 A
32 — ——
33 Door locks 15 A
34 Front fog lamps 15 A
35 Headlamp low beam (left) 10 A
36 Headlamp low beam (right) 10 A
37 Reversing lamp 7.5 A
38 Engine control 7.5 A
No. Symbol Electrical systemCapacity

9
Specifications
Vehicle labeling . . . . . . . . . . . . . . . . . . . . . . . . . . .9- 2
Vehicle dimensions . . . . . . . . . . . . . . . . . . . . . . . .9- 6
Vehicle performance . . . . . . . . . . . . . . . . . . . . . . .9- 8
Vehicle weight . . . . . . . . . . . . . . . . . . . . . . . . . . . .9- 9
Engine specifications . . . . . . . . . . . . . . . . . . . . . . .9- 12
Transmission specifications . . . . . . . . . . . . . . . . . .9- 13
Electrical system . . . . . . . . . . . . . . . . . . . . . . . . . .9- 14
Tyres and wheels . . . . . . . . . . . . . . . . . . . . . . . . . .9- 15
Other specifications . . . . . . . . . . . . . . . . . . . . . . . .9- 16
Fuel consumption . . . . . . . . . . . . . . . . . . . . . . . . . .9- 17
Notes regarding diesel fuel . . . . . . . . . . . . . . . . . .9- 20
Capacities . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9- 21

Specifications9-3
9
The plate shows model code, engine model, transmission
model and body colour code, etc.
Please use this number when ordering replacement parts.Vehicle identification number plate
(RHD vehicles only)
This is stamped on the number plate riveted to the left front
corner of the instrument panel pad. It is visible from outside the
vehicle through the windscreen.
1- Model code
2- Engine model code,
Exterior code
3- Transmission model code
4- Approval number
5- Chassis number
6- Maximum gross vehicle weight
7- Body colour code, Interior code,
Option code
8- Gross combination weight
9- Maximum axle weight (Front)
10- Maximum axle weight (Rear)

9-4 Specifications
9
Engine number
The engine number is stamped on the engine cylinder block as
shown in the illustration.
Petrol-powered vehicles
1100 models
*: Front of the vehicle
1300 models, 1500 models (Except for vehicles with
turbocharger)
1500 models (Vehicles with turbocharger)

9-12 Specifications
9Engine specifications
E01100601363
Item
Petrol-powered vehiclesDiesel-powered vehicles
1100 models1300 models
1500 models
1.5L DI-D
50kW (68PS)1.5L DI-D
70kW (95PS)Except for vehi- cles with
turbochargerVehicles with turbocharger
Engine type Three-cylinder,
in line, water cooled four-
cycle, double
overhead cam- shaft Four-cylinder, in
line, water
cooled four-
cycle, double
overhead cam- shaft Four-cylinder, in
line, water
cooled four-
cycle, double
overhead cam- shaft Four-cylinder, in
line, water
cooled four-
cycle, double
overhead cam-
shaft with inter- cooler and
turbocharger Three-cylinder, in line, water
cooled four-cycle, double overhead camshaft
with intercooler and turbo- charger
Engine model
Total displacement
Bore
Stroke
Compression ratio 134910
1,124 cc
75.0 mm
84.8 mm 10.5 135930
1,332 cc
75.0 mm
75.4 mm 10.5 135950
1,499 cc
75.0 mm
84.8 mm 10.5 4G15
1,468 cc
75.5 mm
82.0 mm 9.0 639939
1,493 cc
83.0 mm
92.0 mm 18.0
Valve clearanceIntake 0.18 - 0.26 mm (cold) Automatically
Exhaust0.26 - 0.34 mm (cold) Automatically
Firing order1-3-2 1-3-4-2 —
Maximum output (EEC
net)55 kW/
6,000 r/min 70 kW/
6,000 r/min 80 kW/
6,000 r/min 110 kW/
6,000 r/min 50 kW/
4,000 r/min 70 kW/
4,000 r/min
Maximum torque (EEC
net) 100 Nm/
4,000 r/min 125 Nm/
4,000 r/min 145 Nm/
4,000 r/min 210 Nm/
3,500 r/min 160 Nm/
1,600 r/min 210 Nm/
1,800 r/min

9-22 Specifications
9
*1: Except for vehicles with turbocharger*2: Vehicles with turbocharger
No.ItemQuantityLubricants
1Washer fluid5.16 litres—
2Engine oil
1100 modelsOil pan 3.0 litres
Refer to page 8-7
Oil filter 0.2 litre
1300 models,
1500 models*1
Oil pan 4.0 litres
Oil filter 0.2 litre
1500 models*2
Oil pan 3.3 litres
Oil filter 0.3 litre
Oil cooler 0.1 litre
3Brake fluid As requiredBrake fluid DOT 4 +
Clutch fluid
4
Engine coolant
[includes 0.6 litre in the reserve
tank]1100 models 4.2 litres
High-quality ethylene glycol based coolant
1300 models, 1500 models*14.6 litres
1500 models*26.0 litres
5Manual transmission oil/ Automated manual transmission oil 1.75 litres DiaQueen WIDE GEAR OIL G-1 or
Castrol/Burmach gear oil BOT 328 (or exact equivalents)
6Refrigerant (air conditioning) 410 - 450 gHFC-134a

Specifications9-23
9
Diesel-powered vehicles
No.ItemQuantityLubricants
1Washer fluid 5.16 litres—
2Engine oilOil pan 5.2 litres
Refer to page 8-7
Oil filter 0.3 litre
3Brake fluid
As requiredBrake fluid DOT 4 +
Clutch fluid
4Engine coolant [includes 0.95 litre in the reserve tank] 6.6 litres High-quality ethylene glycol based coolant
5Manual transmission oil1.75 litresDiaQueen WIDE GEAR OIL G-1 or
Castrol/Burmach gear oil BOT 328 (or exact equivalents)
6Refrigerant (air conditioning) 410 - 450 gHFC-134a
LHD RHD

Alphabetical index1
A
Accessory socket 5-60
Accessory (Installation) 5
Active stability control system (ASC) 4-42Indicator lamp 4-44
Additional equipment 8-29
Air bag 2-47
Air conditioning Automatic air conditioning 5-13
Important operation tips for the air conditioning 5-22
Air purifier 5-23
Antenna 5-59
Anti-lock brake system (ABS) 4-36 Warning lamp 4-38
Audio Error codes 5-54
Handling of compact discs 5-56
LW/MW/FM electronic tuning radio with CD player 5-24
Steering wheel remote control switch 5-52
Automated manual transmission 4-25 Oil 9-21
Automatic air conditioning 5-13
B
Battery 8-15 Charge warning lamp 3-12
Discharged battery (Emergency starting) 6-2
Specification 9-14 Bonnet 8-4
Brake
Anti-lock brake 4-36
Braking 4-35
Fluid 8-14, 9-21
Parking brake 4-6
Parking brake lever stroke 8-24
Power brakes 4-35
Warning lamp 3-9
Bulb capacity 8-41
C
Capacities 9-21
Cargo loads 4-45
Catalytic converter 8-3
Central door locks 1-9
Changing a fuse 8-35
Charge warning lamp 3-12
Chassis number 9-2
Check engine warning lamp 3-11
Child restraint 2-31
Child-protection rear doors 1-13
Cleaning Exterior of your vehicle 7-4
Genuine leather 7-3
Interior of your vehicle 7-3
Plastic, vinyl leather, etc 7-3
Clutch Fluid 8-14