Peugeot Expert 2004 User Guide

16 -
19-07-2004
Quick reference guide
OPENING THE BONNET
From inside: pull the control located
on the right, under the fascia.
From outside: lift the catch, raise
the bonnet and secure the strut to
hold the bonnet open. When the warning
light comes on you
have enough fuel left
to drive
approximately
30 miles (50 km) .
:
54
FILLING THE FUEL TANK
The tank must be illed with the
engine off .
F Insert the key, then turn it to the
left.
F Remove the cap.
A label indicates the type of fuel to
be used.
The capacity of the tank is
approximately 80 litres.
Low fuel level warning light
:
55
Cruise control enables the vehicle to
maintain a steady speed programmed
by the driver, regardless of the road
characteristics and without the driver
having to touch the accelerator or
brake pedals.
To be stored, the vehicle speed must
be higher than approximately 25 mph
(40 km/h) or 40 mph (60 km/h)
(according to engine), with at least
fourth gear engaged.
CRUISE CONTROL
Operation
F Press switch A. The indicator light
comes on.
You can store a speed.
F Press switch A again to switch
the system off. The indicator light
is switched off.
Do not use the cruise control on
slippery roads or in heavy trafic.
:
65

12 -
19-07-2004
13
-
19-07-2004
Quick reference guide
HEATING / AIR CONDITIONING
: 36
Air conditioning
On/Off Air recirculation
Air distribution
Rear screen and/or
mirrors demisting
Air low Temperature

14 -
19-07-2004
15
-
19-07-2004
Quick reference guide
Press Function
1 Increase volume.
2 Decrease volume.
3 Selection of the previous stored station (radio) - Selection of t he previous CD (CD changer).
4 Selection of the next stored station (radio) - Selection of the next CD (CD changer).
5 Automatic search of lower frequencies (radio) - Selection of the pre vious track (CD/CD changer).
6 Automatic search of higher frequencies (radio) - Selection of the n ext track (CD/CD changer).
7 Change of source (radio/CD/CD changer).
8 Mute; restoring of the sound by pressing any button.
AUDIO RD1

14 -
19-07-2004
15
-
19-07-2004
Quick reference guide
ButtonFunction
A ON/VOL Press: audio equipment on/off. Rotation: volume adjustment.
B 5
Ejection of the CD.
C RDS RDS function on/off.
Press for more than 2 seconds: regional following mode on/off.
D TA Trafic information priority on/off.
Press for more than 2 seconds: PTY function on/off.
E AUDIO Selection of adjustment of the bass, treble, loudness and sou nd distribution.
F 5Increase the setting of the functions associated with button
E .
G 6Decrease the setting of the functions associated with button
E .
H 4Automatic search of higher frequencies.
Selection of the next CD track.
I MAN Manual/automatic operation of button H and J.
J 3Automatic search of lower frequencies.
Selection of the previous CD track.
K Selection of the radio. Selection of the FM1, FM2, FM3, AM wa
vebands.
Press for more than 2 seconds: automatic storing of the stations (au tostore).
L Selection of the CD changer.
Press for more than 2 seconds: random play.
M Selection of the CD.
Press for more than 2 seconds: random play.
1 to 6 1 2 3 4 5 6 Selection of the stored station.
Press for more than 2 seconds: storing of a station.
Selection of a disc in the CD changer.
:
24

18 -
19-07-2004
19
-
19-07-2004
Instruments and controls
PETROL-DIESEL MANUAL GEARBOX INSTRUMENT PANELS
1 - Front fog lamps indicator light.
2 - Rear fog lamp indicator light.
3 - Clock.
4 - Left direction indicator.
5 - Engine oil pressure warning
light.
6 - Central STOP warning light.
7 - Handbrake, low brake fluid
level and electronic brake force
distribution warning light.
8 - Right direction indicator.
9 - Speedometer. 10 -
Main beam headlamps indicator
light.
11 - Dipped beam headlamps
indicator light.
12 - Coolant temperature indicator.
13 - Coolant maximum temperature
warning light.
14 - Service indicator and total / trip
distance recorder.
15 - Trip recorder zero reset and
total / trip distance recorder
display button.
16 - Low coolant level warning light. 17 -
Engine autodiagnostics warning
light.
18 - Seat belt not fastened warning
light*.
19 - Front and side air bags warning
light.
20 - Water in diesel filter warning
light*.
21 - Anti-lock brake system (ABS)
warning light.
22 - Front brake pad wear warning
light.
23 - Diesel engine pre-heat warning
light.
24 - Battery charge warning light.
25 - Clock adjustment button.
26 - Fuel level indicator.
27 - Low fuel level warning light.
* According to country.

18 -
19-07-2004
19
-
19-07-2004
Instruments and controls
INSTRUMENTS AND
CONTROLS
A permanently lit warning light
or one lashing, with the engine
running, indicates an operating
fault of the unit concerned. The
illumination of certain warning
lights may be accompanied by
an audible signal. Do not ignore
this warning: consult a PEUGEOT
dealer as soon as possible.
If the central STOP warning light
comes on when you are driving,
stop your vehicle immediately,
where it is safe to do so.
Central STOP warning
light
Linked to the «engine oil pressure»,
«coolant temperature and low level»,
«handbrake», «low brake luid level»
and «electronic braking system fault»
warning lights.
You must stop if the light lashes
with the engine running.
Consult a PEUGEOT dealer. Engine oil pressure and
temperature warning
light
Linked to the central STOP warning
light.
You must stop.
This warning light indicates one of
the following:
- insuficient oil pressure,
- a lack of oil in the lubrication circuit. Top up the level.
- an oil temperature which is too high. The warning light is accompanied
by an audible signal. To lower
the oil temperature, reduce your
speed.
Consult a PEUGEOT dealer.
Low coolant level
warning light
Linked to the central STOP warning
light.
You must stop.
Wait for the engine to cool before
topping up the level.
The cooling circuit is pressurised.
In the event of breakdown and to
prevent any risk of burns , unscrew
the cap to the irst notch to allow the
pressure to drop.
When the pressure has dropped,
remove the cap and top up the level.
Consult a PEUGEOT dealer. Battery charge warning
light
This indicates one of the following:
- faulty operation of the charging circuit,
- slack battery or starter terminals,
- a cut or slack alternator belt,
- an alternator failure.
Consult a PEUGEOT dealer. Handbrake, low brake
luid level and Electronic
Brake Force Distribution
fault warning light
Linked to the central STOP warning
light.
This indicates one of the following:
- that the handbrake is applied or not fully released,
- an excessive drop in brake luid level (if the warning light remains
on even when the handbrake is
released),
- a fault in the Electronic Brake Force Distribution, if lit at the same
time as the ABS warning light.
You must stop.
Consult a PEUGEOT dealer.

20 -
19-07-2004
21
-
19-07-2004
Instruments and controls
Front brake pad wear
warning light
For your safety, have the four front
brake pads replaced as soon as the
warning light comes on. Anti-lock braking system
(ABS) warning light
This comes on for
3 seconds each time the
ignition is switched on.
If the warning light remains on or
comes on above 8 mph (12 km/h),
this indicates an ABS malfunction.
However, the vehicle retains
conventional servo-assisted braking.
Lighting of this warning light is
accompanied by an audible signal.
Consult a PEUGEOT dealer.
Engine diagnostics
warning light
This comes on each time
the ignition is switched
on. If it comes on with
the engine running, this indicates
incorrect operation of the injection,
ignition or emission control system.
There is a risk of damage to the
catalytic converter (petrol engine
only). Consult a PEUGEOT dealer. Seat belt not fastened
warning light*
When the ignition is switched on, this
indicator light comes on if the driver
has not fastened his seat belt. Diesel engine pre-heat
warning light
Wait until the warning light goes out
before starting the engine.
If the temperature is high enough,
the warning light comes on for less
than one second. You can start the
engine without waiting. Front and side air bags
warning light
The light will come on for a few
seconds when the ignition is
switched on.
With the engine running, illumination
of this warning light indicates a fault
in the air bags.
Consult a PEUGEOT dealer.
Low fuel level
warning light
When this light irst comes on,
you have enough fuel left to drive
approximately 30 miles (50 km)
(The tank capacity is approximately
80 litres).
Water in diesel ilter
indicator light*

Lighting of this warning
light indicates the presence
of water in the diesel ilter.
For the indirect injection Diesel
engine, bleed the circuit at the ilter.
For the direct injection Diesel
engines, consult a PEUGEOT dealer
as soon as possible.
There is a risk of damage to the
injection system.
* According to country. Fuel gauge
Each time the engine is started, the
warning light comes on for a few
seconds and the needle moves to
test the operation of the gauge.

20 -
19-07-2004
21
-
19-07-2004
Instruments and controls
Front brake pad wear
warning light
For your safety, have the four front
brake pads replaced as soon as the
warning light comes on. Anti-lock braking system
(ABS) warning light
This comes on for
3 seconds each time the
ignition is switched on.
If the warning light remains on or
comes on above 8 mph (12 km/h),
this indicates an ABS malfunction.
However, the vehicle retains
conventional servo-assisted braking.
Lighting of this warning light is
accompanied by an audible signal.
Consult a PEUGEOT dealer.
Engine diagnostics
warning light
This comes on each time
the ignition is switched
on. If it comes on with
the engine running, this indicates
incorrect operation of the injection,
ignition or emission control system.
There is a risk of damage to the
catalytic converter (petrol engine
only). Consult a PEUGEOT dealer. Seat belt not fastened
warning light*
When the ignition is switched on, this
indicator light comes on if the driver
has not fastened his seat belt. Diesel engine pre-heat
warning light
Wait until the warning light goes out
before starting the engine.
If the temperature is high enough,
the warning light comes on for less
than one second. You can start the
engine without waiting. Front and side air bags
warning light
The light will come on for a few
seconds when the ignition is
switched on.
With the engine running, illumination
of this warning light indicates a fault
in the air bags.
Consult a PEUGEOT dealer.
Low fuel level
warning light
When this light irst comes on,
you have enough fuel left to drive
approximately 30 miles (50 km)
(The tank capacity is approximately
80 litres).
Water in diesel ilter
indicator light*

Lighting of this warning
light indicates the presence
of water in the diesel ilter.
For the indirect injection Diesel
engine, bleed the circuit at the ilter.
For the direct injection Diesel
engines, consult a PEUGEOT dealer
as soon as possible.
There is a risk of damage to the
injection system.
* According to country. Fuel gauge
Each time the engine is started, the
warning light comes on for a few
seconds and the needle moves to
test the operation of the gauge.

20 -
19-07-2004
21
-
19-07-2004
Instruments and controls
Coolant temperature indicator
- needle in zone
(A), the temperature
is correct,
- needle in zone (B), the temperature
is too high. The central STOP
warning light lashes.
You must stop.
Consult a PEUGEOT dealer.
Instrument panel display
After switching on the ignition, two
functions are shown in succession:
- service indicator (see corresponding section),
- total distance recorder (see corresponding section).
Note : it displays the total and trip
distances for 30 seconds when the
ignition is switched off, on opening
the driver’s door, as well as on
locking and unlocking the vehicle.

20 -
19-07-2004
21
-
19-07-2004
Instruments and controls
Coolant temperature indicator
- needle in zone
(A), the temperature
is correct,
- needle in zone (B), the temperature
is too high. The central STOP
warning light lashes.
You must stop.
Consult a PEUGEOT dealer.
Instrument panel display
After switching on the ignition, two
functions are shown in succession:
- service indicator (see corresponding section),
- total distance recorder (see corresponding section).
Note : it displays the total and trip
distances for 30 seconds when the
ignition is switched off, on opening
the driver’s door, as well as on
locking and unlocking the vehicle.