lock PONTIAC G8 2008 Repair Manual

Filling the Tank
{CAUTION
Fuel vapor burns violently and
a fuel re can cause bad
injuries. To help avoid injuries
to you and others, read and
follow all the instructions on
the pump island. Turn off your
engine when you are refueling.
Do not smoke if you are near
fuel or refueling your vehicle.
Do not use cellular phones.
Keep sparks, ames, and
smoking materials away from
fuel. Do not leave the fuel pump
unattended when refueling your
vehicle. This is against the law
in some places. Do not re-enter
the vehicle while pumping fuel.
Keep children away from the
fuel pump; never let children
pump fuel.The fuel cap is located behind a
hinged fuel door on the driver side
of the vehicle.
To open the fuel door the vehicle
must be unlocked. Push on the rear
edge of the door to open.
When reinstalling the cap, turn it
clockwise until it clicks, otherwise
the Malfunction Indicator Lamp may
turn on. SeeMalfunction Indicator
Lamp on page 4-18.
{CAUTION
Fuel can spray out on you if
you open the fuel cap too
quickly. If you spill fuel and
then something ignites it, you
could be badly burned. This
spray can happen if your tank
is nearly full, and is more likely
in hot weather. Open the fuel
cap slowly and wait for any
hiss noise to stop. Then
unscrew the cap all the way.
Be careful not to spill fuel. Do not
top off or overll the tank and
wait a few seconds after you have
nished pumping before removing
the nozzle. Clean fuel from painted
surfaces as soon as possible.
SeeExterior Cleaning on page 9-94.
When replacing the fuel cap,
turn it clockwise until it clicks.
Make sure the cap is fully installed.
Driving and Operating 8-35
2008 - Pontiac G8 Owner Manual

Vehicle Service
and Care
Service
Service...............................9-2
Accessories and
Modications.....................9-3
California Proposition 65
Warning............................9-3
California Perchlorate
Materials Requirements.....9-3
Doing Your Own
Service Work....................9-4
Adding Equipment to the
Outside of the Vehicle......9-4
Owner Checks
Owner Checks....................9-5
Hood Release.....................9-5
Engine Compartment
Overview...........................9-6
Engine Oil..........................9-8
Engine Oil Life System.....9-10
Engine Air Cleaner/Filter. . .9-11
Automatic Transmission
Fluid................................9-13
Engine Coolant.................9-13
Radiator Pressure Cap......9-15
Engine Overheating...........9-16
Cooling System.................9-17
Power Steering Fluid.........9-21
Windshield Washer Fluid. . .9-22
Windshield Wiper Blade
Replacement...................9-23
Brakes..............................9-24
Battery..............................9-26
Headlamp Aiming
Headlamp Aiming..............9-27
Bulb Replacement
Bulb Replacement.............9-29
Halogen Bulbs..................9-29
Headlamps and Parking
Lamps.............................9-29
Taillamps..........................9-31
Replacement Bulbs...........9-32
Electrical System
Add-On Electrical
Equipment.......................9-32
Headlamp Wiring..............9-33
Windshield Wiper Fuses. . . .9-33
Power Windows and
Other Power Options. . . . . . .9-33
Instrument Panel Fuse
Block...............................9-33
Engine Compartment
Fuse Block......................9-35
Rear Compartment Fuse
Block...............................9-38
Tires
Tires.................................9-39
Tire Sidewall Labeling. . . . . . .9-40
Tire Terminology and
Denitions.......................9-43
Ination - Tire Pressure. . . .9-46
High-Speed Operation. . . . . . .9-48
Tire Pressure Monitor
System............................9-49
Tire Pressure Monitor
Operation........................9-51
Tire Inspection and
Rotation..........................9-54
When It Is Time for
New Tires.......................9-56
Buying New Tires.............9-56
Different Size Tires and
Wheels............................9-58
Vehicle Service and Care 9-1
2008 - Pontiac G8 Owner Manual

Uniform Tire Quality
Grading...........................9-59
Wheel Alignment and Tire
Balance...........................9-60
Wheel Replacement..........9-61
Tire Chains.......................9-62
Tire Changing
If a Tire Goes Flat............9-62
Tire Sealant and
Compressor Kit
(V8 Engine)
.....................9-64
Changing a Flat Tire
(V6 Engine).....................9-71
Removing the Spare Tire
and Tools........................9-72
Removing the Flat Tire
and Installing the
Spare Tire
.......................9-73
Storing a Flat or Spare
Tire and Tools.................9-78
Compact Spare Tire..........9-79
Jump Starting
Jump Starting...................9-80
Towing
Towing Your Vehicle.........9-84
Shift Lock Manual
Release...........................9-84
Recreational Vehicle
Towing............................9-85
Towing a Trailer................9-85
Appearance Care
Interior Cleaning................9-91
Exterior Cleaning..............9-94
Sheet Metal Damage........9-98
Finish Damage..................9-98
Underbody Maintenance. . . .9-98
Chemical Paint Spotting. . . .9-98
Vehicle Care/Appearance
Materials.........................9-99
Service
For service and parts needs, visit
your dealer/retailer. You will receive
genuine GM parts and GM-trained
and supported service people.
Genuine GM parts have one
of these marks:
9-2 Vehicle Service and Care
2008 - Pontiac G8 Owner Manual

Accessories and
Modications
When non-dealer/non-retailer
accessories are added to your
vehicle they can affect your vehicle’s
performance and safety, including
such things as, airbags, braking,
stability, ride and handling,
emissions systems, aerodynamics,
durability, and electronic systems
like antilock brakes, traction control
and stability control. Some of
these accessories could even cause
malfunction or damage not
covered by warranty.
GM Accessories are designed to
complement and function with other
systems on your vehicle. Your
GM dealer/retailer can accessorize
your vehicle using genuine GM
Accessories. When you go to yourGM dealer/retailer and ask for GM
Accessories, you will know that
GM-trained and supported service
technicians will perform the
work using genuine GM
Accessories.
Also, seeAdding Equipment to Your
Airbag-Equipped Vehicle on
page 1-30.
California Proposition 65
Warning
Most motor vehicles, including this
one, contain and/or emit chemicals
known to the State of California
to cause cancer and birth defects or
other reproductive harm. Engine
exhaust, many parts and systems
(including some inside the vehicle),
many uids, and some component
wear by-products contain and/or
emit these chemicals.
California Perchlorate
Materials Requirements
Certain types of automotive
applications, such as airbag
initiators, seat belt pretensioners,
and lithium batteries contained
in remote keyless entry transmitters,
may contain perchlorate materials.
Special handling may be necessary.
For additional information, see
www.dtsc.ca.gov/hazardouswaste/
perchlorate.
Vehicle Service and Care 9-3
2008 - Pontiac G8 Owner Manual

Engine Compartment Overview
When you open the hood, this is what you will see:A. Engine Compartment Fuse
Block. See Engine Compartment
Fuse Block on page 9-35 .
B. Coolant Reservoir and Dipstick. See Cooling System on
page 9-17 .
C. Engine Oil Fill Cap. See “When to Add Engine Oil” under Engine
Oil on page 9-8 .
D. Engine Oil Dipstick (Out of View). See “Checking Engine Oil” under
Engine Oil on page 9-8 .
E. Brake Master Cylinder Reservoir. See “Brake Fluid” under Brakes
on page 9-24 .
F. Power Steering Reservoir. See Power Steering Fluid on
page 9-21 .
G. Engine Air Cleaner/Filter. See Engine Air Cleaner/Filter
on page 9-11 .
H. Windshield Washer Fluid Reservoir. See Windshield
Washer Fluid on page 9-22 .
I. Radiator Pressure Cap. See Cooling System on page 9-17 .
V6 Engine
9-6 Vehicle Service and Care
2008 - Pontiac G8 Owner Manual

A. Engine Compartment FuseBlock. See Engine Compartment
Fuse Block on page 9-35 .
B. Coolant Reservoir and Dipstick. See Cooling System on
page 9-17 .
C. Engine Oil Dipstick. See “Checking Engine Oil” under
Engine Oil on page 9-8 .
D. Engine Oil Fill Cap. See “When to Add Oil” under Engine Oil on
page 9-8 .
E. Power Steering Reservoir. See Power Steering Fluid on
page 9-21 .
F. Brake Master Cylinder Reservoir. See “Brake Fluid” under Brakes
on page 9-24 .
G. Engine Air Cleaner/Filter. See Engine Air Cleaner/Filter on
page 9-11 .
H. Windshield Washer Fluid Reservoir. See Windshield
Washer Fluid on page 9-22 .
I. Radiator Pressure Cap. See Cooling System on page 9-17 .
V8 Engine
Vehicle Service and Care 9-7
2008 - Pontiac G8 Owner Manual

Checking Coolant
The coolant reservoir and dipstick is
located in the engine compartment
on the passenger side of the vehicle.
SeeEngine Compartment Overview
on page 9-6for more information
on location.
1. Turn off the ignition.
2. Turn the coolant dipstick
cap one-eighth of a turn
counterclockwise and slowly
pull the dipstick straight up.3. When the engine is cold, the
coolant level should be at or
above the Min mark on the
dipstick.
After the vehicle has been driven
and the engine is at normal
operating temperature, the level
should be somewhere between
half full and the Max mark.
4. If the coolant level is correct,
replace the dipstick and turn
the cap one-eighth of a
turn clockwise.
Adding Coolant
If you need more coolant, add the
proper DEX-COOL
®coolant mixture
at the coolant reservoir, but only
when the engine is cool. If the
coolant reservoir is empty, a special
ll procedure is necessary. See
Engine Overheating on page 9-16
for instructions on “How to Add
Coolant to the Cooling System.”
{CAUTION
You can be burned if you spill
coolant on hot engine parts.
Coolant contains ethylene
glycol, and it will burn if the
engine parts are hot enough.
Do not spill coolant on a hot
engine.
When replacing the coolant reservoir
cap, make sure it is hand-tight
and fully seated.
Radiator Pressure Cap
Notice:The radiator cap on your
vehicle is a pressure-type cap
and must be tightly installed
to prevent coolant loss and
possible engine damage from
overheating. Be sure the cap is
properly closed.
SeeEngine Compartment Overview
on page 9-6for more information
on location.
Vehicle Service and Care 9-15
2008 - Pontiac G8 Owner Manual

Notice:In cold weather, water
can freeze and crack the engine,
radiator, heater core and other
parts. Use the recommended
coolant and the proper coolant
mixture.
{CAUTION
You can be burned if you spill
coolant on hot engine parts.
Coolant contains ethylene
glycol and it will burn if the
engine parts are hot enough.
Do not spill coolant on a hot
engine.
1. Check the engine coolant
reservoir (A) level and, if
required, top with coolant. See
Engine Coolant on page 9-13.2. Locate the radiator pressure
cap (B).
{CAUTION
Steam and scalding liquids
from a hot cooling system can
blow out and burn you badly.
They are under pressure, and if
you turn the radiator pressure
cap — even a little — they can
(Continued)
CAUTION (Continued)
come out at high speed. Never
turn the cap when the cooling
system, including the radiator
pressure cap, is hot. Wait for
the cooling system and radiator
pressure cap to cool if you ever
have to turn the pressure cap.
3. Cover the cap with a thick
cloth and turn it slowly
counterclockwise and remove.
4. If there is no coolant or the level
is low, slowly ll the system
through the radiator pressure cap
opening with a 50/50 mixture
of clean, drinkable water and
a DEX-COOL
®coolant until full.
Wait 30 seconds for coolant
to settle and top off if the
level drops.
Do not spill coolant on the
accessory drive belts.
If a spill occurs, rinse the belt
with fresh water.
9-20 Vehicle Service and Care
2008 - Pontiac G8 Owner Manual

5. Start the engine.
6. With the engine idling, top off the
coolant through the radiator
pressure cap opening until full.
Wait 30 seconds for the
coolant to settle and top off, if
the level drops.
7. Once the system is full, put the
radiator pressure cap back on
by turning clockwise.
8. Turn off the ignition.
9. Check the coolant level in the
reservoir and ll it until the
level is at the top of the dipstick.Power Steering Fluid
Power Steering Fluid Level
Power steering uid is used in
all vehicles.
Check the level after the vehicle has
been driven for at least twenty
minutes so the uid is warm.
How to Check Power Steering
Fluid
To check the power steering uid,
do the following:
1. Turn the key off and let the
engine compartment cool down.
2. The power steering uid reservoir
is located on the driver side
toward the front of the engine
compartment. SeeEngine
Compartment Overview on
page 9-6.3. Wipe the cap and the top of the
reservoir clean.
V6 Engine
Vehicle Service and Care 9-21
2008 - Pontiac G8 Owner Manual

4. Turn the cap counterclockwise
and pull it straight up.
5. When the engine is hot, the level
should be at the hot MAX level.
When the engine is cold, the
uid level should be between
MIN and MAX on the dipstick.
6. Replace the cap.
Adding Power Steering Fluid
To determine what kind of uid
to use, seeRecommended Fluids
and Lubricants on page 11-12.
Always use the proper uid. Failure
to use the proper uid can cause
leaks and damage hoses and seals.
1. Turn the ignition to LOCK/OFF.
2. Top off with power steering
uid. Do not overll the reservoir.
3. Push the cap straight down
and turn clockwise to tighten.
Windshield Washer Fluid
What to Use
When you need windshield washer
uid, be sure to read the
manufacturer’s instructions before
use. If you will be operating
your vehicle in an area where the
temperature may fall below freezing,
use a uid that has sufficient
protection against freezing.
Adding Washer Fluid
Open the cap with the washer
symbol on it. Add washer uid
until the tank is full. SeeEngine
Compartment Overview on page 9-6
for reservoir location. V8 Engine
9-22 Vehicle Service and Care
2008 - Pontiac G8 Owner Manual