RENAULT KANGOO 2013 X61 / 2.G Lighting Workshop Manual

8Electrical equipment
V1 MR-376-X76-80D000$TOC.mif
V1
80D
"The repair procedures given by the manufacturer in this document are based on the
technical specifications current when it was prepared.
The procedures may be modified as a result of changes introduced by the
manufacturer in the production of the various component units and accessories from
which his vehicles are constructed."
V1
All rights reserved by Renault s.a.s.
Edition Anglaise
Copying or translating, in part or in full, of this document or use of the service part
reference numbering system is forbidden without the prior written authority of
Renault s.a.s.
© Renault s.a.s. 2013
LIGHTING
UCH
Vdiag No.: 0F
Fault finding – Introduction 80D - 2
Fault finding – Role of components 80D - 4
Fault finding – Operating diagram 80D - 5
Fault finding – Function 80D - 11
Fault finding – Configuration 80D - 13
Fault finding – Conformity check 80D - 14
Fault finding – Status summary table 80D - 15
Fault finding – Interpretation of statuses 80D - 16
Fault finding – Command summary table 80D - 20
Fault finding – Interpretation of commands 80D - 21
Fault finding – Customer complaints 80D - 26
Fault finding – Fault Finding Chart 80D - 27

80D-2V1 MR-376-X76-80D000$010.mif
80D
UCH
Vdiag No.: 0F
1. SCOPE OF THIS DOCUMENT
This document presents the fault finding method applicable to all computers with the following specifications:
2. PREREQUISITES FOR FAULT FINDING
Documentation type
Fault finding procedures (this manual):
– Assisted fault finding (integrated into the diagnostic tool), Dialogys.
Wiring Diagrams:
– Visu-Schéma.
Type of diagnostic tools
–CLIP
Special tooling required
*VLL — Very Long LifeVehicle(s): KANGOO VLL*
Function concerned: LIGHTINGName of computer: UCH
Vdiag No.:
0F
Special tooling required:
Diagnostic tool
Multimeter
Elé. 1622Bornier
Elé. 1681Universal bornier
UCH_V0F_PRELI
LIGHTING
Fault finding – Introduction

80D-3V1 MR-376-X76-80D000$010.mif
LIGHTING
Fault finding – Introduction80D
UCH
Vdiag No.: 0F
If the information obtained by the diagnostic tool requires the electrical continuity to be checked, connect
bornier Elé. 1622 or universal bornier Elé. 1681.
3. SAFETY INSTRUCTIONS
The safety instructions must be followed at all times when working on components, to avoid damage or injury:
– check the battery voltage to avoid incorrect operation of computer functions,
– use the appropriate toolsWARNING:
– All checks using bornier Elé. 1622 or Elé. 1681 must be performed with the battery disconnected.
– The bornier is only designed to be used with a multimeter. Never supply the test points with 12 V.

80D-4V1 MR-376-X76-80D000$020.mif
80D
UCH
Vdiag No.: 0F
Side lights:
The side lights are switched on directly using the lighting stalk, via the passenger compartment fuse and relay box.
This function lights all the side lights (front and rear) as well as the number plate lighting.
Dipped beam headlights:
The dipped beam headlights are switched on directly using the lighting stalk, via the passenger compartment fuse
and relay box.
This function lights only the two bulbs providing the dipped headlights function.
Main beam headlights:
The main beam headlights are switched on directly using the lighting stalk, via the passenger compartment fuse and
relay box.
This function lights only the two bulbs providing the main beam headlights function.
Rear fog light:
The rear fog light is switched on directly using the lighting stalk, via the passenger compartment fuse and relay box.
This function lights only the rear fog lights.
Hazard warning lights:
The "hazard warning lights illumination request" signal from the hazard warning lights switch is sent to the UCH,
which controls the hazard warning lights.
This function lights only the hazard warning lights. The UCH also manages the illumination of the hazard warning
lights in the event of impact detection.
Indicators:
The "left-hand or right-hand indicators illumination request" signal initiated by the driver using the lighting stalk is
sent to the UCH, which controls the left-hand and right-hand indicators.
LIGHTING
Fault finding – Role of components

80D-5V1 MR-376-X76-80D000$030.mif
80D
UCH
Vdiag No.: 0F
Indicator lights
• List of system components and associated component codes:
• Indicator lights diagram645Passenger compartment electrical control unit
260Passenger compartment fuse box and relay
125Hazard warning lights switch
172Rear right-hand light
173Rear left-hand light
255Front right-hand indicator light
256Front left-hand indicator light
267Right-hand repeater
268Left-hand repeater
209Lighting stalk
LIGHTING
Fault finding – Operating diagram

80D-6V1 MR-376-X76-80D000$030.mif
LIGHTING
Fault finding – Operating diagram80D
UCH
Vdiag No.: 0F
Side lights
• List of system components and associated component codes:
• Side lights diagram645Passenger compartment electrical control unit
260Passenger compartment fuse box and relay
166Right-hand number plate light
167Left-hand number plate light
172Rear right-hand light
173Rear left-hand light
184Right-hand side light
185Left hand side lights
209Lighting stalk
247Instrument panel

80D-7V1 MR-376-X76-80D000$030.mif
LIGHTING
Fault finding – Operating diagram80D
UCH
Vdiag No.: 0F
Main beam headlights
• List of system components and associated component codes:
• Main beam headlights diagram226Right hand headlight
227Left hand headlight
247Instrument panel
260Passenger compartment fuse box and relay
209Lighting stalk

80D-8V1 MR-376-X76-80D000$030.mif
LIGHTING
Fault finding – Operating diagram80D
UCH
Vdiag No.: 0F
Dipped headlights
• List of system components and associated component codes:
• Dipped beam headlights diagram260Passenger compartment fuse box and relay
226Right hand headlight
227Left hand headlight
247Instrument panel
537Left headlight corrective motor
538Right headlight corrective motor
209Lighting stalk

80D-9V1 MR-376-X76-80D000$030.mif
LIGHTING
Fault finding – Operating diagram80D
UCH
Vdiag No.: 0F
Front fog lights
• List of system components and associated component codes:
• Front fog lights diagram260Passenger compartment fuse box and relay
176Right-hand front fog light
177Left-hand front fog light
231Front fog relay
247Instrument panel
209Lighting stalk

80D-10V1 MR-376-X76-80D000$030.mif
LIGHTING
Fault finding – Operating diagram80D
UCH
Vdiag No.: 0F
Rear fog light
• List of system components and associated component codes:
• Rear fog light diagram260Passenger compartment fuse box and relay
173Rear left-hand light
247Instrument panel
209Lighting stalk