electrical YAMAHA VX110 2005 Owner's Manual

7-37
E
–+ELECSTARTING SYSTEM
BATTERY
Refer to “ELECTRICAL” in Chapter 3.
WIRING CONNECTIONS
1. Check:
Wiring connections
Poor connections →
Properly connect.
FUSES
1. Check:
Fuses
Broken →
Replace.
NOTE:
The 3 A fuse is for the remote control unit
(Deluxe model only).
The 10 A fuse is for the main and fuel pump
relay and the electronic control throttle valve
relay.
The 20 A fuse is for main and fuel pump relay.
The 30 A fuse is for the main relay.
Fuse ratings:
3 A, 10 A, 20 A, 30 A
START SWITCH
1. Check:
Continuity
Out of specification →
Replace.
Start switch continuity
(natural color coupler)
Clip PositionLeads
Red Brown
Installed Free
Push
Removed Free
Push
ProCarManuals.com

7-44
E
–+ELECCHARGING SYSTEM
FUSE
Refer to “STARTING SYSTEM”.
BATTERY
Refer to “ELECTRICAL” in Chapter 3.
LIGHTING COIL
Refer to “IGNITION SYSTEM”.
RECTIFIER/REGULATOR
Refer to “IGNITION SYSTEM”.
ProCarManuals.com

7-50
E
–+ELECINDICATION SYSTEM
FUSE
Refer to “STARTING SYSTEM”.
BATTERY
Refer to “ELECTRICAL” in Chapter 3.
MAIN AND FUEL PUMP RELAY
Refer to “IGNITION SYSTEM”.
ECM
Refer to “IGNITION SYSTEM”.
ENGINE TEMPERATURE SENSOR
Refer to “IGNITION SYSTEM”.
THERMOSWITCH (ENGINE)
Refer to “IGNITION SYSTEM”.
THERMOSWITCH (EXHAUST)
Refer to “IGNITION SYSTEM”.
REMOTE CONTROL UNIT
(DELUXE MODEL ONLY)
Refer to “REMOTE CONTROL SYS-
TEM (DELUXE MODEL ONLY)”.
BUZZER
1. Check:
Buzzer
Buzzer does not sound → Replace.
Checking steps:
Connect the battery (12 V) to the buzzer
coupler as shown.
Battery positive terminal →
Red (R) terminal 1
Battery negative terminal →
Black (B) terminal 2
ProCarManuals.com

9-6
E
TRBL
ANLS
TROUBLE ANALYSIS
JET PUMP UNIT
Duct 6
Impeller 6
Intake grate 6
Bearings 6
Water inlet hose 6
Bilge hose 6
Bilge strainer 3
Bilge hose joint 6
ELECTRICAL
Ignition system, fuel control system
Pickup coils 7
ECM 7
Ignition coils 7
Slant detection switch 7
Engine stop switch 7
Engine shut-off switch 7
Spark plugs 3
Main and fuel pump relay 7
Electronic control throttle
valve relay7
Thermoswitch 7
Sensor assembly 7
Engine temperature
sensor7
Throttle body assembly
(throttle position sensor)7
Accelerator position
sensor7
Cam position sensor 7 Trouble mode Check elements
ENGINE WILL NOT START
HARD STARTING
ROUGH IDLING
HIGH IDLING
ENGINE STALLS
POOR ACCELERATION
ENGINE WILL NOT STOP
POOR PERFORMANCE
LIMITED ENGINE SPEED
OVERHEATING
LOW OIL PRESSURE
LOOSE STEERING
BILGE INCREASE
IRREGULAR WARNING INDICATION
POOR BATTERY CHARGING
Relative partReference
chapter
ProCarManuals.com