transmission oil ASTON MARTIN DB AR1 Q 2003 Owners Guide

B - Controls
1-B-11 External Temperature Display - Press the trip button briefly to display the
external temperature. Whilst the external temperature is displayed, press
and hold the button to change between °C and °F readouts. Briefly press the
button again to return to the trip display.
Gearshift Indicator (centre top)
Indicates the current gearshift mode on DB AR1 fitted
with 'Touchtronic' transmission. 'A' indicates Automatic
mode. A number 1-5 indicates the current gear selected
when in Touchtronic mode.
Speedometer (centre right)
Indicates the vehicle speed in miles per hour and/or kilometres per hour.
Also houses the odometer recording the total distance travelled by the
vehicle.
Oil Pressure Gauge (top right)
The oil pressure gauge is graduated in bar (1 bar 14.7 psi). Normal oil
pressure at medium engine revs should be in the range 3-6 bar.
Engine Coolant Temperture Gauge (bottom right)
In temperate climates, normal coolant temperature is indicated with the
needle to the left of the 'N' position, but coolant temperature will vary
(within the range 92 - 105°C) dependent on ambient temperature and
driving conditions.

C - Driving
1-C-6
Warning Light Indications at Ignition On
As the ignition is switched on, the DB AR1 electronic control units each
complete a self check to ensure correct operation. During these checks, the
warning lights on the instrument panel will illuminate as follows:
• Bulb Check - All warning lamps illuminate for about three seconds as a
bulb check. (The Sport and Transmission Fail lamps are not illuminated
on manual transmission vehicles).
• The Ignition and Oil Pressure warning lights illuminate until the engine
starts.
• The Check Engine light will illuminate during the engine management
self-check and will extinguish when the starter button is pressed.
• The Seat Belt warning light illuminates and a gong sounds for six seconds
if the driver's seat belt is not fastened. On fastening the seat belt, the gong
immediately ceases. The warning lamp extinguishes at the end of the six
second warning period.
• The ABS and Traction Control warning lights illuminate and extinguish
if the system self checks are satisfactory.
• The Brake warning light will illuminate and extinguish if the brake fluid
level is within specification.
• The SRS Airbag warning light will illuminate and extinguish if the SRS
Airbag control system check is satisfactory.
Only the handbrake (parking brake) warning light should stay on after the
engine has started and is running correctly. The handbrake warning light will
extinguish as the handbrake is fully released.
Note: Other Information lights may remain on (e.g. Main Beam Warning or Low
Screen Wash) dependant on the vehicle state and switch settings at the time.

F - Owner Maintenance
1-F-39
Fuse Lists
Passenger Footwell Fusebox - Right Hand
F1 5A Passive Anti-Theft Module
F2 20A Cigar Lighter
F3 10A Diagnostic Sockets, Radio, Air Conditioning, Driver's
Door Mirror and Window
F4 5A Seat Switches and Heaters
F5 10A Indicator Flasher
F6 10A Ignition Coils 1-6
F7 10A Interior Lamp Cluster
F8 10A Ignition Coils 7-12
F9 20A RHS Seat Heater Relay, RHS Seat Module
F10 10A Dimmer, Passive Anti-Theft Module, Radio
F11 10A Door Mirrors
F12 5A Diagnostic Sockets
F13 25A Not used
F14 10A Hazard Flasher Unit
F15 20A Wiper Logic Module and Wiper Stalk
F16 30A ABS Control Unit
F17 20A Wiper Motor, Logic Module and Wiper Stalk
F18 30A ABS Control Unit
F19 10A Air Conditioning LH Blower Motor
F20 5A Gearshift Interlock Module, Traction Control Switch,
Interior, Map & Courtesy Lamps
F21 10A Air Conditioning RH Blower Motor
F22 10A Powertrain and Transmission control Modules - Keep
Alive Memory

F - Owner Maintenance
1-F-58
Storing the Car - Recommendations
Note: These recommendations apply to new and pre-owned cars either in
Dealer or customer ownership.
When ever the car is not in use always cover the car with it's fabric cover.
If the vehicle is not to be used for periods up to six months it should be stored
in a dry, well ventilated building.
Drive the car for a sufficient distance to warm the oil in the engine, torque
convertor, transmission and final drive unit; this ensures complete lubrication
of the internal components.
Check the engine coolant level. Top up if necessary with the correct
antifreeze/water solution.
In order to take the weight off the tyres, raise the car with a jack and place
supports under the front and rear suspension.
If the vehicle is not raised from the ground, increase the tyre pressures to 3.4
bar 340 kpa 50 psi. Cover the tyres to exclude any light. Rotate the wheels
1/4 turn every month to avoid tyre flat spots.
The battery should be removed and cleaned. Fully charge the battery on a
trickle charger and recharge once a month.
Once a month
Reconnect the battery and ventilate the storage area. Start and run the
engine until fully warmed up. Check that there are no fluid leaks. Check
and correct the tyre pressures if necessary.
Run the Air Conditioning system to keep the internal parts of the Air
Conditioning system lubricated.

G - Specifications
1-G-12
Recommended Fluids
Engine oil (Initial fill) Mobil 1 0w-40 Europe (0w-30 USA)
Engine oil API SJ/CF, ACEA A3/B3 OR ILSAC GF2
Mobil 1 recommended
Engine coolant 60% water, 40% Havoline OAT
Do not mix OAT with glycol based antifreeze
Manual gearbox oil Texaco 1863, Transam 7045, Mobil ATF or
Dexron III
Auto transmission fluid Esso LT 71141
Final drive oil Shell spirax super 90 TS or Mobilube SHC LS
Brake/Clutch fluid Mobil Universal Brake Fluid
Power steering fluid Mobil ATF or Dexron III
A/C refrigerant R134A (HFC134A)
Engine Oil
Synthetic oils must conform to API SJ/CF standards. Preferably with ACEA
A3/B3 and ILSAC GF2. The chart below gives oil grades for average ambient
temperatures and applies to both mineral and synthetic oils.
Caution: To achieve the desired high performance of synthetic lubricants, do not mix
with mineral oils.

2-A-5
A - Service Schedules
Pre-delivery Inspection (PDI)
Before you receive your DB AR1, it will undergo a comprehensive pre-
delivery inspection at the Dealer's premises to ensure that it meets Aston
Martin's quality standards. The following checks will be made:
Levels and Leaks
Engine oil
Power steering oil
Brake Fluid
Clutch fluid (manual only)
Engine coolant level
Engine coolant specific gravity
Windscreen washer fluid
Fuel system
Gearbox oil/Auto transmission fluid
Rear axle oil - Differential
Battery
Mechanical Functions
Auto transmission
Selection and P & N functions
Manual gear selection
Clutch operation (manual only)
Throttle pedal operation
Parking brake operation
Steering column adjustment and lock
operation
Seat adjuster rails
Bonnet (Hood) release and catch
Door operation and locks
Storage compartments
Rear view mirror
Wheels and Tyres
Road wheel nuts
Tyre pressures
Front wheel tracking
Electrical Checks
Battery condition
Heated windscreen
Windscreen washers
Windscreen wipers
Air-conditioning controls
Gauges and warning lights
Radio/Cassette/CD player
Navigation (where fitted)
All speakers
Electric aerial
Inertia switch
Window mechanisms
Side and headlights (main and dip)
Front fog lights
Rear fog lights (where fitted)
Hazard warning lights
Instrument illumination and dimmer
Air conditioning panel illumination
Auto Trans. PRNDL illumination
Horns
Interior/map lights
Cigar lighter
Seat adjustment - all functions
Door mirror adjustments
Reset clock (if necessary)
Door / boot courtesy lights
Central locking system
Filler flap lock operation
Seat belt operation
Seat belt warning system
Security system / Remote control
Clutch pedal start inhibit
Interrogate DTC codes (not N.
America)
Record battery open-circuit voltage

2-A-7
A - Service Schedules
Service Schedules
The following service schedules are recommended for DB AR1. The schedules may
be modified if necessary. Please consult your Aston Martin Dealer for details of any
service schedule updates.
Road Test Evaluation
1000mls 7500mls 15000mls
1500km 12000km 24000km
3 months 6 months 12 months
x x x Pre-Maintenance Road Test Evaluation
Fluids Filters and Leaks Checks
1000mls 7500mls 15000mls
1500km 12000km 24000km
3 months 6 months 12 months
x x x Renew the engine oil
x x x Renew the engine oil filter
x x x Check for engine oil leaks
- - x Renew the air cleaner elements
x x x Check auto transmission for leaks
x x x Check man. gearbox for leaks.
Top-up if necessary
- - x Renew rear axle oil
x - - Check / top-up rear axle oil
- x - Check rear axle for leaks, top up if necessary
- - 30000 Renew engine coolant - check S.Gravity
x x x Check/top-up engine coolant
x x x Check cooling and heating systems for leaks
- - 60000 Renew fuel filters
x x x Check for fuel leaks
Every 2 years 30,000 miles Renew brake fluid
x x x Check / top-up brake fluid reservoir
x x x Check / top-up clutch fluid reservoir
x x x Check / top-up power steering reservoir
x x x Check power steering system for leaks
x x x Check brake hoses, pipes and unions for leaks
x x x Check suspension dampers for leaks
x x x Top-up windscreen washer reservoir
x x x Check exhaust system for leaks
x x x Check air conditioning system for leaks

Index
5-A-5
Seat Belt Fastening 1-A-14
Seat Belt Pretensioner 1-A-15
Securing a Child Seat (ALR System) 1-A-15
Special Warnings - Child Safety Restraints 1-A-19
Warnings 1-A-16
Seat Controls 1-A-12
Seat Heater 1-B-19
Security System
Arming the Alarm 1-E-4
Disarming the Alarm 1-E-4
Full Alarm Activation 1-E-5
Operation 1-E-3
Panic Alarm 1-E-5
Passive Anti-Theft System (PATs) 1-E-7
System Protection 1-E-4
Unlocking the Car 1-E-4
Security Systems 1-E-2
Servicing Precautions 1-F-2
Dangerous Substances 1-F-5
Engine Oils 1-F-5
Fuel Tank Filling 1-F-5
Protecting The Environment 1-F-5
Side and Headlight Switching 1-B-13
Side Repeaters 1-F-48
Specifications
Body 1-G-2
Brakes 1-G-5
Dimensions and Weights 1-G-9
Engine 1-G-2
Engine Oil 1-G-12
Final Drive 1-G-4
Interior Features 1-G-7
Lights 1-G-8
Performance 1-G-2
Recommended Fluids 1-G-12
Steering 1-G-4
Suspension 1-G-5
Transmission - Automatic 1-G-4
Transmission - Manual 1-G-4
Wheels and Tyres 1-G-6
Winter Tyre Pressure 1-G-6
Speedometer 1-B-11
Steering Column Controls 1-B-14
Steering Wheel 1-A-10
Rake 1-A-10