fuel AUDI A4 2000 B5 / 1.G AFC Engine On Board Diagnostic Multiport Fuel Injection Workshop Manual

Continued next page
Pa
ge 101 of 366 On Board Dia
gnostic
(OBD
) - Multi
port Fuel In
jection
(MFI
)
11/22/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.FU01.01.1

01-75


Engine Control Module
(ECM) -J192- faulty

- Replace and code engine control module page 01
-265
erase DTC
memory and test drive check DTC memory
Note:
The malfunction "P0337 / 16721" is set at an engine speed between 25 RPM and 400 RPM as soon as no crankshaft sensor
signal is recognized for longer than 3 sec.
Pa
ge 102 of 366 On Board Dia
gnostic
(OBD
) - Multi
port Fuel In
jection
(MFI
)
11/22/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.FU01.01.1

01-76

Output on GST and/or on
VAG 1551 scan tool Possible malfunction cause

Malfunction repair
P0401 / 16785
Exhaust Gas Recirculation
Flow Insufficient Detected EGR system vacuum hose kinked or fallen
off

- Check vacuum hoses

Malfunction cause found: Yes
No

- Erase DTC memory, test drive and
after test drive, check DTC memory
again
MIL Status:
MIL lights up after 2 Trips Leak in a vacuum hose of the EGR system
(e.g. cracked, worn though, etc.)

- Check vacuum hoses for leaks

Malfunction cause found: Yes
No

- Erase DTC memory, test drive and
after test drive, check DTC memory
again

Vacuum hose between EGR vacuum
regulator solenoid valve -N18- and mechanical
EGR valve plugged

- Check vacuum hoses for
obstructions
For troubleshooting
Display group 017
Malfunction cause found: Yes
No
Continued next page

- Erase DTC memory, test drive and
after test drive, check DTC memory
again
Pa
ge 103 of 366 On Board Dia
gnostic
(OBD
) - Multi
port Fuel In
jection
(MFI
)
11/22/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.FU01.01.1

01-77


EGR vacuum regulator solenoid valve -N18- sticks
in closed position

- Check EGR vacuum regulator solenoid valve -N18-
page 24
-67


Malfunction cause found: Yes
No

- Erase DTC memory, test drive and after test drive, check
DTC memory again

EGR valve sticks in closed position

- Check mechanical EGR valve page 24
-70

Malfunction cause found: Yes


- Erase DTC memory, test drive and after test drive, check
DTC memory again
Notes:

Recognition condition for the malfunction "P0401 / 16785" (mech. valve continuously closed) is a coolant temperature over
72 C (162 F), an open idle switch, a throttle angle less than 42.5 , a vehicle speed between 70 km/h and 105 km/h (44
and 66 mph), an EGR duty cycle greater than 50%, an engine speed between 1500 RPM and 3300 RPM and an engine
load between 23% and 60%. If all these conditions are fulfilled and the EGR temperature signal is less than 50 C (122
F) for longer than 34 sec, the malfunction "P0401 / 16785" is set.
Pa
ge 104 of 366 On Board Dia
gnostic
(OBD
) - Multi
port Fuel In
jection
(MFI
)
11/22/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.FU01.01.1

01-78

Output on GST and/or on
VAG 1551 scan tool Possible malfunction cause

Malfunction repair
P0402 / 16786
Exhaust Gas Recirculation
Flow Excessive Detected Vacuum line incorrectly connected
and/or hose connections transposed

- Check EGR system vacuum hose
according to vacuum plan page 24
-111


Malfunction cause found: Yes
No

- Erase DTC memory, test drive and after
test drive, check DTC memory again DTC
memory
MIL Status:
MIL lights up after 2 Trips EGR vacuum regulator solenoid
valve -N18- stuck in open position

- Check EGR vacuum regulator solenoid
valve -N18- page 24
-67


Malfunction cause found: Yes
No

- Erase DTC memory, test drive and after
test drive, check DTC memory again DTC
memory

EGR valve leaks or is stuck in
open position

- Check mechanical EGR valve page 24
-
70

For troubleshooting Display
group 017
Malfunction cause found: Yes


- Erase DTC memory, test drive and after
test drive, check DTC memory again
Notes:
Pa
ge 105 of 366 On Board Dia
gnostic
(OBD
) - Multi
port Fuel In
jection
(MFI
)
11/22/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.FU01.01.1

The malfunction "16786" (mech. valve continuously open) is set if after a cold start (-12 C to 30 C (10 to 86 F) coolant
temperature) the EGR temperature is greater than 50 C (122 F) at a coolant temperature of 35 C (95 F).
Pa
ge 106 of 366 On Board Dia
gnostic
(OBD
) - Multi
port Fuel In
jection
(MFI
)
11/22/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.FU01.01.1

01-79

Output on GST and/or on
VAG 1551 scan tool Possible malfunction cause

Malfunction repair
P0422 / 16806
Main Catalyst Efficiency
Below Threshold (Bank 1) Are other malfunctions stored in the DTC
memory?

No

Yes

- First correct these malfunctions
according to Diagnostic Trouble Code
(DTC) table.
MIL Status:
MIL lights up after 2 Trips Malfunction cause found: Yes
No

- Erase DTC memory, test drive and
after test drive, check DTC memory
again

Bank 1 Three Way Catalytic Converter
(TWC) chemically or thermally aged or
mechanically destroyed

- Replace Three Way Catalytic
Converter (TWC) Bank 1
For troubleshooting
Display groups 035, 036,
044
Malfunction cause found: Yes


- Erase DTC memory, test drive and
after test drive, check DTC memory
again
Note:

With the help of the Oxygen Sensor Probe in front of and behind the Three Way Catalytic Converter (TWC), the rate of
Three Way Catalytic Converter (TWC) deterioration is determined using the Three Way Catalytic Converter (TWC) oxygen
storage capability.
Pa
ge 107 of 366 On Board Dia
gnostic
(OBD
) - Multi
port Fuel In
jection
(MFI
)
11/22/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.FU01.01.1

01-80

Output on GST and/or on
VAG 1551 scan tool Possible malfunction cause

Malfunction repair
P0432 / 16816
Main Catalyst Efficiency
Below Threshold (Bank 2) Are other malfunctions stored in the DTC
memory?

No

Yes

- First repair these malfunctions
according to Diagnostic Trouble Code
(DTC) table.
MIL Status:
MIL lights up after 2 Trips Malfunction cause found: Yes
No

- Erase DTC memory, test drive and
after test drive, check DTC memory
again

Bank 2 Three Way Catalytic Converter
(TWC) chemically or thermally aged or
mechanically destroyed

- Replace Bank 2 Three Way
Catalytic Converter (TWC)
For troubleshooting
Display groups 035, 036,
044
Malfunction cause found: Yes


- Erase DTC memory, test drive and
after test drive, check DTC memory
again
Note:

With the help of the Oxygen Sensor Probe in front of and behind the Three Way Catalytic Converter (TWC), the rate of
Three Way Catalytic Converter (TWC) deterioration is determined using the Three Way Catalytic Converter (TWC) oxygen
storage capability.
Pa
ge 108 of 366 On Board Dia
gnostic
(OBD
) - Multi
port Fuel In
jection
(MFI
)
11/22/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.FU01.01.1

01-81

Output on GST and/or on
VAG 1551 scan tool Possible malfunction cause

Malfunction repair
P0440 / 16824
Evaporative Emission
Control System Malfunction Evaporative emissions system hoses
kinked or pinched

- Check hoses for correct fit

Malfunction cause found: Yes
No

- Erase DTC memory, test drive and
after test drive, check DTC memory
again
MIL Status:
MIL lights up after 2 Trips Leak in the EVAP system between
Intake manifold and EVAP canister
purge regulator valve -N80- or
EVAP canister purge regulator valve -
N80- and sensor for EVAP canister -
G172- or
Sensor for EVAP canister -G172- and
EVAP canister
- Check EVAP system for leaks

Malfunction cause found: Yes
No

- Erase DTC memory, test drive and
after test drive, check DTC memory
again
Pa
ge 109 of 366 On Board Dia
gnostic
(OBD
) - Multi
port Fuel In
jection
(MFI
)
11/22/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.FU01.01.1

01-82


EVAP canister purge regulator
valve -N80- sticks mechanically

- Check solenoid valve for Evaporative
Emission (EVAP) canister purge -N80- page 24
-58


Malfunction cause found: Yes
No
Continued next page

- Erase DTC memory, test drive and after test
drive, check DTC memory again
For troubleshooting
Display group 030
Sensor for EVAP canister -G172-
(differential pressure sensor) faulty

- Check Sensor for EVAP canister -G172-
(differential pressure sensor) page 24
-61


Malfunction cause found: Yes


- Erase DTC memory, test drive and after test
drive, check DTC memory again
Note:

With the help of the Sensor for EVAP canister -G172- (differential pressure sensor)the pressure is measured between the
Evaporative Emissions (EVAP) canister and solenoid valve for Evaporative Emission (EVAP) canister purge -N80- with
valve closed and open. If the difference in the two pressures is less than 4 mbar to 23 mbar (depending on air pressure),
the malfunction is set.
Pa
ge 110 of 366 On Board Dia
gnostic
(OBD
) - Multi
port Fuel In
jection
(MFI
)
11/22/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.FU01.01.1