ignition BMW MOTORRAD F 650 CS 2003 Rider's Manual (in English)

3
53
Starting – Riding – Parking
Removing motorcycle
from side stand
d Warning:
Make sure the side stand is fully
retracted before you ride off.
– Riding with the side (prop) stand extended represents
a safety risk.
 Turn the ignition key to the “R” or “ON” position (
b9)
– Handlebars unlocked  Both feet on the ground, no
weight on the motorcycle
 Hold the left handlebar grip
with your left hand
 Keep your right hand on the
right handlebar grip and the
handbrake lever
 Slowly raise the motorcycle to
the upright position and keep
it balanced
 Sit on the motorcycle and use your left foot to retract the
side stand
Side stand
10K14bkg2.book Seite 53 Montag, 15. September 2003 5:30 17

3
56
Starting – Riding – ParkingSwitch on the ignition– Kill switch3 in the run
position
U
 Ignition switch 1 in the ON
position
 Wait until the warning light for
coolant temperature (
b7)
stops flashing
In an emergency only:
 Move kill switch 3 to position
V
– The electronic engine man-
agement, fuel pump and
starter motor electrical cir-
cuits are de-energised
Fully retract the side stand
L Note:
If the side stand is extended
and a gear engaged, you can-
not start the motorcycle.
Select neutral– Neutral indicator light 2
green
k ON
L Note:
Engine does not start:
– Move the gear lever to the
k
position or disengage the
clutch
Engine stops when first gear is
engaged:
– Fully retract the side stand; if
necessary, consult the trou-
bleshooting chart (
b Mainte-
nance Instructions, Chapter 2)
Before you start
12
10K1403g2.fm Seite 56 Montag, 29. September 2003 4:15 16

3
57
Starting – Riding – Parking
Starting Press starter button4 (max.
5 seconds) and do not release it
until the engine is running
smoothly
 Do not turn the throttle twistgrip
when starting the engine.
L Note:
After releasing the starter button if
the engine does not start, wait at
least 5 seconds before pressing
the starter button again.
After switching off the ignition,
wait 3 seconds before switching it
on again.
e Attention:
If you attempt to start the engine
when the battery is flat, you will
hear the relay chattering. Further
attempts will damage the starter
relay and starter motor.
Before trying again: recharge the
battery.
L Note:
At ambient temperatures below
0 °C (32°F), pull the lever to disen-
gage the clutch when starting the
engine.
e Attention:
Do not allow the engine to idle
unnecessarily or for prolonged
periods of time – risk of over-
heating or fire. Ride away im-
mediately after starting the en-
gine.
Avoid high engine speeds after
a cold start.
4 Starting
3
10K14bkg2.book Seite 57 Montag, 15. September 2003 5:30 17

3
58
Starting – Riding – Parking
ABS check– ABS warning light 1
(
b 64-68)
Coolant temperatureWarning light 2 j (red) flashes
for approx. 3 seconds after you
switch on the ignition.
The electronic engine manage-
ment system initialises itself
during this period.
e Attention:
If the coolant temperature
warning light
j comes on, stop
the engine and allow it to cool
down.
Check coolant level in the
expansion tank (
b42).
If the expansion tank is full, but
the warning light remains on, or
if coolant consumption is exces-
sive, consult a specialist work-
shop, preferably an authorised
BMW motorcycle dealer.
Telltale and warning lights
12
10K14bkg2.book Seite 58 Montag, 15. September 2003 5:30 17

3
65
Starting – Riding – Parking
d Warning:
Do not operate high-power
radio equipment on the mo-
torcycle. There is a slight risk
of it affecting operation of the
ABS.
ABS checkAutomatic activation when you
switch on the ignition.
Warning light 1 comes on.
ABS self-diagnosis
When you start the engine and
pull away:
– Warning light 1 goes out to
indicate that ABS is opera-
tional
OEOptional extra
Anti-lock braking system (ABS)OE
1
10K14bkg2.book Seite 65 Montag, 15. September 2003 5:30 17

3
68
Starting – Riding – Parking
ABS is out of action:
– at speeds below 6 km/h / 3.73 mph (12 km/h /
7.46 mph – if brake lever/
pedal was operated before-
hand)
– when the ignition is switched off
– if the battery is defective or
flat (indicated by ABS warning
light)
– if there is a fault in the ABS
system (
b66)
 The brakes remain fully operational, though without
the reserves of safety
afforded by ABS.
OEOptional extra
d Warning:
If there is a fault in the ABS sys-
tem – as indicated by warning
light 1 – the reserves of safety
normally afforded by ABS are
not available until the defect has
been put right.
There is a risk of dropping the
motorcycle if the brakes are ap-
plied too hard and the wheels
lock or the rear wheel lifts clear
of the ground as a result of a
high level of front tyre adhesion.
The ABS system shuts down au-
tomatically if you ride for approx.
10 seconds with only one wheel
in contact with the ground.
Anti-lock braking system (ABS)OE
1
10K14bkg2.book Seite 68 Montag, 15. September 2003 5:30 17

4
69
Arrive safely
Know-how …In recent years, motorcycles’
technical design features have
become more and more
sophisticated.
Electronic engine management,
electronic ignition, the catalytic
converter or the use of four
valves per cylinder are clear
signs that far more than basic
technical knowledge may be
needed to solve certain prob-
lems. In addition, high-tech
materials are increasingly tak-
ing the place of conventional
ones, which again calls for thor-
ough and expert knowledge if
they are to be handled correctly
during repair work.
To be sure of achieving the nec-
essary standard, it is always
advisable to consult your
authorised BMW motorcycle
dealer.The authorised BMW motorcy-
cle dealer employs staff who
attend regular and comprehen-
sive training courses.
Authorised BMW motorcycle
dealers also receive all the cur-
rent technical information and
are therefore fully aware of the
latest developments.
… technical features …Authorised BMW motorcycle
dealers have the experience
and all the necessary facts at
their disposal when it comes to
solving problems quickly and
effectively. Workshops are
equipped with the latest techni-
cal facilities, for example the
special tools developed by
BMW, such as the
BMW diag-
nosis system and exhaust
emissions tester.
Reliability
10K14bkg2.book Seite 69 Montag, 15. September 2003 5:30 17

ii
78
Index
AAdjusting headlight beam throw, 44
Anti-lock braking system (ABS) Check, 65
Notes, 64
Self-diagnosis, 65
Troubleshooting, 66
BBrake fluid levelCheck, 32
Checking
front brake, 33
Brake system, checking, 30
Brake-fluid level Checking
rear brake, 34
CCatalytic converter, 51Safety instructions, 51
Checking brake pads, 31, 34
Checking brake pressure, 29
Clock, 6, 10
Clutch lever, 28
Clutch-lever play, adjusting, 28
Cockpit, 6
Coolant, 42, 43
Coolant level Check, 42
Correct loading, 41
EEmergency off (kill) switch for ignition, 13
Engine oil, 24
Engine oil pressure Warning light, 59
Environmental protection, 72
FFlashing turn indicator switch, 12
Flashing turn indicators Telltale lights, 7
Front brake Brake fluid level, 33
Fuel Octane number, 27
Fuel filler cap, 26
Fuel level Check, 26
Fuel tank capacity, 59
Fuse box, 5
GGearshifts, 60, 61
General view left side, 4
right side, 5
A – G
10K14bkg2.book Seite 78 Montag, 15. September 2003 5:30 17

ii
79
Index
HHandlebar levers, 28, 29Clutch lever, 28
Hazard warning flashers, 11
Headlight flasher, button, 12
Headlight setting RHD/LHD traffic, 44
High-beam/low-beam headlight switch, 12
IIgnition switch and steering lock,8,9
LLeft handlebar fitting, 12
LHD traffic
Headlight adjustment, 44
Loading, 41
MMotorcycle accessories, 74
NNeutral, 56 Telltale light, 7
Notes on safety General, 49, 50, 51
OOctane number, fuel, 27
Odometer, 6, 10
Oil filler neck, 24
Oil levelCheck, 24
Engine oil pressure, 59
PProp the motorcycle on its side
stand, 52
RRemoving motorcycle from side (prop) stand, 53
Rev. counter, 6
RHD traffic Headlight adjustment, 44
Rider’s equipment, 73
Right handlebar fitting, 13
Rims, 38, 39
Risk of fire, 50
Risk of overheating, 50, 57
Risk of poisoning, 49
H – R
10K14bkg2.book Seite 79 Montag, 15. September 2003 5:30 17

ii
80
Index
SSafety check, 21, 22
Safety instructionsCatalytic converter, 51
Safety instructions, braking, 62, 63
Seat, 14
Service worldwide, 71
Shock-absorber adjustment, 37
Softbag, 15, 16, 17
Softbag for stowage compartment, inserting/
securing, 15
Speedometer, 6
Spring preload, 36 Front wheel, 36
Starter pushbutton, 13
Starting, 57
Switch on the ignition, 56
TTank cap, 26
Telltale and warning lights, 6 ABS, 7, 58
Coolant temperature, 7, 58
Engine oil pressure, 7, 59
Flashing turn indicator, left, 7
High-beam headlight, 7
Low fuel level, 7, 59
Neutral, 7
Tread depth, tyres, 38
Tripmeter reset button, 6 Type plate, 5
Tyres
Running in, 55
Tread depth, 38
Tyre pressures, 39
WWarning lightLow fuel level, 59
Warning lights ABS, 7, 58
Coolant temperature, 7, 58
Engine oil pressure, 59
Low fuel level, 7
S – Z
10K14bkg2.book Seite 80 Montag, 15. September 2003 5:30 17